Ford Bronco Sport Complaints (2022)

347 consumer complaints on file.

#11757998August 19, 2026
ENGINE, FUEL/PROPULSION SYSTEM
My vehicle is subject to NHTSA Recall 25V467 / Ford Recall 25S76 for a fuel injector that may crack and leak fuel into the engine compartment, creating a risk of fire. The recall was issued in July 2025 and remains open more than a year later. Ford has provided an interim PCM software update intended to detect a leaking injector and mitigate the fire risk, but this does not replace the defective fuel injectors and the recall remains open. Ford states that a final remedy is still being developed / is not currently available for my vehicle. I am concerned about the length of time this safety defect has remained without an available permanent repair. The vehicle continues to be operated while subject to a known fuel-leak and underhood-fire risk, and I do not have the ability to have the defective components permanently repaired despite the recall having been open since July 2025. I am requesting that NHTSA review the delay in Ford providing the final remedy for Recall 25V467. The vehicle is available for inspection upon request. I have not experienced a fuel leak, fire, crash, or injury at this time.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11757631August 18, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The vehicle was taken to the dealer, and the contact was informed that the part to do the recall repair was unavailable. The contact was advised to take the vehicle to the dealer if the vehicle experienced the failure. The manufacturer was contacted. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11757551August 17, 2026
Carry Handle, Shell, Base
Locking device to secure car seat to the base broke, on this REPLACEMENT infant car seat. Graco Case #49771285, 10/19/25 (I no longer have pictures or videos of defective car seat, Graco should have them on file. The infant seat was returned to Graco QA, the Graco replaced it with current defective car seat on 10/24/25). Current Graco infant car seat Case # 5195437 with Reference # 520230003. I have pictures of this one. In addition, our daughter gave us her back up car seat to use with her son, the one we bought the above car seats for. This SSME & 3rd infant car seat had the SAME DEFECT! We asked Graco to RECALL these seats. They said they don’t make them any longer. We requested a recall again and said we would also be submitting a report of defect to NHTSA, this is it. We are concerned for the safety of thousands of infants nationwide that are still using these infant car seats. PLEASE follow up with Graco AND recall these infant car seats. Thank you from a concerned grandparent.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11757469August 17, 2026
POWER TRAIN
Both the valve included in Ford's TSB 24-2185 and the clutch pack included in TSB 26-2328 both defaulted in the vehicle, causing debris and metal shavings to accumulate in the RDU which resulted in pitting of the gears and parts. This has resulted in a complete RDU replacement. The vehicle has only 65,700 miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756393August 12, 2026
POWER TRAIN, ENGINE, UNKNOWN OR OTHER
Oil pump solenoid has been replaced 3 times and the vehicle is under 100,000 miles. There is a low oil light illuminates on dash board in addition to acceleration lose and a white smoke coming from under the hood and the back end of the vehicle. The 6th or 7th time this happened the Bronco had to be towed. There were many more problems included in this tow, powertrain failure, engine misfire, loss of power, crackling, popping sound from under the hood.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756077August 10, 2026
POWER TRAIN
I am reporting a safety concern involving the transmission in my 2022 Ford Bronco Sport equipped with the 1.5L engine and 8-speed automatic transmission (8F35). I purchased this vehicle new in May 2022 with approximately 6 miles on it. At approximately 83,000 miles, the vehicle displayed a “Powertrain Malfunction/Reduced Power” warning through FordPass. The notification stated that a transmission clutch had not applied within the expected amount of time and warned that I may experience limited functionality, including unavailable gears. I took the vehicle to an authorized Ford dealership, All Star Ford Denham Springs, for diagnosis. On August 4, 2026, the dealership informed me in writing that the vehicle has an internal transmission failure and metal in the transmission fluid. The technician determined that the transmission requires complete replacement. I was subsequently quoted approximately $13,000 for the repair. I am concerned that an internal transmission failure of this nature could result in reduced propulsion, unavailable gears, abnormal shifting, or loss of vehicle mobility. Which it did in the middle of a airline hwy in baton rouge, La I am requesting that NHTSA review this failure and determine whether similar transmission/clutch failures are occurring in other 2022 Ford Bronco Sport vehicles equipped with the 8F35 transmission and whether this represents a broader safety defect. Ford has previously issued Customer Satisfaction Program 22B38 involving certain 2022 Bronco Sport vehicles equipped with the 8F35 transmission. That program described a manufacturing issue involving a transmission clutch component and a potential long-term durability concern. I understand that my vehicle has not been confirmed to be included in that program, and I am not claiming that it caused my failure. I am providing this information because of the similarity to the clutch-related warning and subsequent internal transmission failure diagnosed in my vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11755823August 10, 2026
POWER TRAIN, FUEL/PROPULSION SYSTEM, ELECTRICAL SYSTEM
I am reporting a safety concern involving the transmission in my 2022 Ford Bronco Sport equipped with the 1.5L engine and 8-speed automatic transmission (8F35). I purchased this vehicle new in May 2022 with approximately 6 miles on it. At approximately 83,000 miles, the vehicle displayed a “Powertrain Malfunction/Reduced Power” warning through FordPass. The notification stated that a transmission clutch had not applied within the expected amount of time and warned that I may experience limited functionality, including unavailable gears. I took the vehicle to an authorized Ford dealership, All Star Ford Denham Springs, for diagnosis. On August 4, 2026, the dealership informed me in writing that the vehicle has an internal transmission failure and metal in the transmission fluid. The technician determined that the transmission requires complete replacement. I was subsequently quoted approximately $13,000 for the repair. I am concerned that an internal transmission failure of this nature could result in reduced propulsion, unavailable gears, abnormal shifting, or loss of vehicle mobility, particularly if the failure occurs while the vehicle is being driven. Thus being it did fail in the middle of a highway with the gas pedal no longer working. The car was then towed to the dealership and would not even go into neutral to remove the car from the trailer I am requesting that NHTSA review this failure and determine whether similar transmission/clutch failures are occurring in other 2022 Ford Bronco Sport vehicles equipped with the 8F35 transmission and whether this represents a broader safety defect. Ford has previously issued Customer Satisfaction Program 22B38 involving certain 2022 Bronco Sport vehicles equipped with the 8F35 transmission. That program described a manufacturing issue involving a transmission clutch component and a potential long-term durability concern. I understand that my vehicle has not been confirmed to be included in that program
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11755073August 5, 2026
SEAT BELTS, AIR BAGS, SUSPENSION
TRANSACTION FRAUD & SYSTEM BYPASS:The vehicle was purchased from an authorized franchise dealer in January 2026. Following an investigation, it was discovered that the dealership's finance desk executed a "split-paperwork" scheme to override an automated delivery compliance hold. The dealership utilized my actual 2.0L Badlands VIN on banking documents, but electronically transmitted a completely different, lower-trim 1.5L engine VIN to my insurer (USAA) to issue a clean delivery binder. This intentional data manipulation was used to knowingly bypass active safety recall alerts.SUMMARY OF INCIDENT:In March 2026, while traveling on [XXX], the front suspension suffered an unexplained, catastrophic failure, resulting in an immediate, total loss of steering control. The vehicle veered off the roadway and impacted a concrete barrier at high velocity. The mechanics of this failure exactly mirror the structural anomalies detailed in federal NHTSA Recall 26V340000 (Ford Recall 26S36) regarding lower control arm ball joint separation.CRITICAL RESTRAINT SYSTEM FAILURE:During the high-velocity impact, the primary occupant safety restraint systems completely failed to perform. The driver’s side seatbelt failed to lock, and zero front or side airbags deployed. This total safety mechanism failure directly resulted in a severe Traumatic Brain Injury (TBI) and permanent new-onset seizures, confirmed via clinical EEG by the Veterans Affairs (VA) hospital and currently managed via Keppra 3x/day.FORENSIC EVIDENCE PRESERVATION:High-definition video evidence exists, captured 10 days prior to the crash, documenting the seatbelt retractor in a pre-existing state of mechanical failure (dangling/failing to recoil). The vehicle has undergone only minor exterior cosmetic repairs; the failed suspension components, broken seatbelt modules, and un-deployed airbag sensors remain fully intact and forensically preserved as physical evidence inside my garage for immediate federal safety ins INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATI
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11754903August 5, 2026
FUEL/PROPULSION SYSTEM
has been 1 year since recall was initiated for the fuel cap crack with no recourse. we do not feel safe waiting longer for this fix and would request compensation from ford to sell the car.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11754386August 3, 2026
FUEL/PROPULSION SYSTEM
There have been no issues, however it has been a year with no parts available and this sounds like a major potential safety concern if it could start a fire.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11753718July 30, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the “Service Engine” warning light was intermittently illuminated. The contact stated that the dealer had previously replaced a rubber hose on the vehicle to prevent a fire. The dealer was contacted about the recall repair and confirmed that the part to do the recall repair was not yet available. The manufacturer was made aware of the issue. The failure mileage was approximately 37,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11753350July 28, 2026
POWER TRAIN, LANE DEPARTURE: BLIND SPOT DETECTION, ELECTRICAL SYSTEM
I've had a Blindspot warning light alert, told by dealership this is an electrical issue, after a web search, I see this is a common and known issue for Ford, yet no recall has been issued. I also have another know, common powertrain issue with my rear differential. The vehicle makes noise when turning, unstable when driving. The vehicle is less than 5yrs old and under 60k miles. Both issues are safety issues and could cause an electrical fires or vehicle stalling. I am scheduled for a 2nd inspection on 7/31 and hopefully repair.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11753070July 27, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that exhaust fumes were entering the cabin of the vehicle. The contact stated that the dealer had previously installed a fuel injector tube behind the front driver's side wheel. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure but confirmed that parts were not yet available. The failure mileage was approximately 68,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11752443July 23, 2026
ENGINE
Vehicle developed a hum when accelerating on July 5, 2026. Made an appointment with the dealership to have it diagnosed. They could not get me in until July 16, 2026. On July 15, 2026, the vehicle went into limp mode and had to be driven at an unsafe speed to the dealership to diagnose and repair the issue. There are 81,000 miles on the vehicle. The issue turned out to be a cracked catalytic converter. The catalytic converter had previous been replaced in August 2025 due to the same issue at 67,000 miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11752441July 23, 2026
POWER TRAIN
Vehicle was parked in a parking lot. When starting the vehicle and trying to put it into reverse, it would not backup. Vehicle had to be towed to the dealership. The transmission had gears stripped and was due to a failure of the shift module of the vehicle. The vehicle had under 67,000 miles on it. There were no issues with the shift module or transmission up until this point.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11751855July 21, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline). The local dealer was contacted and confirmed that parts were not yet available for the recall repair. The dealer informed the contact that the manufacturer would notify vehicle owners whenever the part became available. The manufacturer was not contacted. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11751493July 20, 2026
POWER TRAIN
The contact owns a 2022 Ford Bronco Sport. While the contact’s daughter was driving at an undisclosed speed, there was a loud popping sound coming from the vehicle and the check engine warning light illuminated. After parking the vehicle, the contact discovered that the vehicle failed to reverse. The vehicle was towed to the local dealer who diagnosed the vehicle and determined that the transmission clutch had failed and there were metal fragments inside the transmission. The contact was informed that the transmission needed to be replaced. The transmission was replaced, and the vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 76,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11750242July 14, 2026
ENGINE, FUEL/PROPULSION SYSTEM
The catalyic converter is no longer working and showing check engine lights. There is no fix for this issue yet. I cannot get my registration which was due last month.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11750071July 13, 2026
ENGINE
I have replaced the water pump THREE times on this Bronco Sport. It has been every 18 months or about every 20,000 miles. I made the report in March of 2025, never heard anything. Making another report now as it is currently in the shop getting the water pump replaced for the THIRD TIME!!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11749196July 8, 2026
UNKNOWN OR OTHER
All my husband purchases is mainly Fords and he has for over 20 years. The last 3 Fords we have purchases from years 2019-2025 have had the same issues. My husband had a 2019 Ford Escape that broke down on us in the mountains. Had to have transmission replaced twice before 100,000 miles. Then he got a 2020 escape and same thing plus a motor replaced..now I have a 2022 bronco sport outer banks and they claim I need transmission replaced and rear end differential. I was quoted $15,000. That is almost as much as my car is worth. I am outside the "warranty" window. The dealership was rude about it because we didnt purchase our Ford with them directly stating they are loyal to their customers who purchase with them first. We have been loyal to ford for so long and now losing faith! I can in no way possible afford that much money! I bought it because I thought it was the safe option for my daughter and for me taking her to school. This car is not safe to drive at all! I had to drive it home from dealership because I cant afford to fix it and now I am without. How am I suppose to drive my kid to school in something that is shaking and grinding like that? This is not the first ford we have had to do it but we remain loyal!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Bronco Sport