Chevrolet Tahoe Complaints (2004)

467 consumer complaints on file.

#11764617September 16, 2026
STEERING, ELECTRICAL SYSTEM, SERVICE BRAKES
My brakes locked up with steering wheel and cause me to go off the road it’s very unsafe and there should be recall immediately
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11676048July 24, 2025
SEAT BELTS
UNKNOWN
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11534962July 28, 2023
POWER TRAIN
My Tahoe has the New Process 246GM transfer case. They have a known issue called pump rub where the pump is to close to the magnesium shell, and rubs pin holes in the shell which causes fluid to dissipate over time causing the transfer case to run dry burning it up. I've had a mechanic check it out and there was no fluid in the case, and now I have a transfer case that's burned up. I've called a transmission shop, and they told me it was a common issue. I would like for general motors to correct this issue
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11518661April 24, 2023
SERVICE BRAKES, HYDRAULIC
The contact's spouse owns a 2004 Chevrolet Tahoe. The contact stated while driving approximately 35 MPH, the brake pedal was depressed and remained extended to the floorboard. The contact engaged the parking brake to bring the vehicle to a complete stop. The vehicle was driven to the residence and parked. Additionally, the contact stated that while parked, the brake pedal was depressed, and brake fluid was squirting onto the ground from underneath the front of the vehicle. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 190,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11482582September 2, 2022
SERVICE BRAKES, HYDRAULIC
The contact owns a 2004 Chevrolet Tahoe. The contact stated that while driving at an undisclosed speed, the brakes failed to stop the vehicle immediately while the brake pedal was being depressed. The vehicle was taken to the dealer where it was diagnosed that the failure was related to NHTSA Campaign Number: 04V045000 (Service Brakes, Hydraulic) however, the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 150,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11459100March 31, 2022
SERVICE BRAKES, HYDRAULIC
The contact owns a 2004 Chevrolet Tahoe. The contact stated that while inspecting the coils under the hood, he noticed that the master cylinder brake lines were leaking. The vehicle was taken to an independent mechanic who diagnosed that the master cylinder brake lines needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 183,500. The VIN was unavailable.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11341775July 28, 2020
ENGINE, UNKNOWN OR OTHER
MY2004 CHEVY TAHOE LT WAS MOVING WHEN THE REAR VIEW MIRROR FELL OFF THE WINDSHIELD. ALSO THE EXHAUST MANIFOLD BOLTS HAVE BROKEN OFF WHICH CAUSE BAD GAS MILEAGE AND SLOW TAKE OFFS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11327456June 5, 2020
SERVICE BRAKES, ELECTRICAL SYSTEM, STEERING
THERE IS A RECALL #04004. "BRAKE HYDRO-BOOST RELIEF VALVE" BUT MY VIN# IS NOT ON THE LIST. OVER 64,000 VEHICLES WERE AFFECTED AND THERE IS A "#1" ON THE MOUNTING SURFACE. ALL OF THE UNITS DETECTED A MACHINING ERROR IN THE RELIEF BORE CAVITY FOR MODULES PRODUCED FROM A MACHINE IDENTIFIED AS "FADAL #1" THIS CAN AND HAS CAUSED MY 2004 CHEVROLET TAHOE TO HAVE NO POWER ASSIST WITH MY STEERING AND NO POWER BRAKES. I HAVE FOUND MYSELF HOLDING TWO FEET ON THE BRAKE PEDAL AT A RED LIGHT. AND CAN NOT OPERATE IN SMALL SPACES SUCH AS PARKING GARAGES AND CERTAIN PARKING STALLS. I WANTED TO KNOW IF THERE IS SOMETHING MORE THAT I CAN DO IN REGARDS TO THIS PARTICULAR RECALL AND FIND OUT IF THERE IS SOME MISTAKE AS FAR AS MY VIN# NOT BEING RECOGNIZED BUT YET EXPERIENCING THE SAME PROBLEMS. MY VEHICLE HAS BECOME INOPERABLE FOR THAT IT IS UNSAFE TO DRIVE WITH THE NO POWER ASSIST AND COULD CAUSE A MAJOR ACCIDENT...I WANT TO SEE ABOUT RECEIVING SOME AID IN ALL THIS. THIS HAS BEEN A ISSUE SINCE AUGUST OF 2019. IT HAS CAUSED ME TO LOSE WORK FOR A LACK OF TRANSPORTATION. MY CREDIT HAS FALLEN BEHIND BECAUSE OF NOT BEING ABLE TO MAKE IT TO WORK AND SPENDING MY SAVINGS ON TRYING TO GUESS AT WHAT IS WRONG WITH IT. FOR IT IS MY ONLY VEHICLE. NOW THAT THE COVID-19 IS HERE IS A DOUBLE WHAMY! IN DIRE STRAITS - CALI LOVIN MY 4X4 - [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11327461June 5, 2020
SERVICE BRAKES, VEHICLE SPEED CONTROL, STEERING
THIS IS IN REFERENCE TO COMPLAINT # 11327456 THE ADDRESS AND THE MPH ARE INCORRECT. PLEASE SEE FORM ATTACHED TO THIS COMPLAINT # AFFECTED PARTS: STEERING, BRAKES, ELECTRICAL, ELEC, STABILITY CONTROL AND SPEED CONTROL THIS SITE WOULDN'T LET ME CHECK MORE THAN 3. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11319447March 27, 2020
SERVICE BRAKES
BRAKES NOT WORKING WHEN PRESSED CAUSED AN ACCIDENT
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11271234October 26, 2019
FUEL/PROPULSION SYSTEM
THE TAHOE USED AS OUR VOLUNTEER FIRE DEPARTMENT MEDICAL TRUCK WAS SPEWING FUEL FROM ABOVE THE GAS TANK. WE DROPPED THE TANK AND FOUND THE LINES ON THE TOP OF THE FUEL TANK RUSTED SEVERELY TO THE POINT OF FAILURE. IT WAS FIRST NOTICED ON A MEDICAL RUN WITH THE ENGINE IDLING.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11252648September 1, 2019
ELECTRICAL SYSTEM
THE MAIN ENGINE WIRING HARNESS WAS FULL OF CONDENSATE AND CORRODED. THE VEHICLE WOULD JUST SHUT OFF WHILE DRIVING. TOOK MULTIPLE TRIPS TO THE MECHANIC SHOP FOR THEM TO BE ABLE TO DUPLICATE AND CORRECT THE ISSUE. ONLINE RESEARCH SHOWS MANY TAHOE OWNERS EXPERIENCING THE SAME ISSUES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11192145March 28, 2019
ENGINE
TL* THE CONTACT OWNS A 2004 CHEVROLET TAHOE. THE CONTACT STATED THAT TEN MINUTES AFTER THE VEHICLE WAS PARKED, IT CAUGHT FIRE. THE FIRE DEPARTMENT WAS CALLED AND EXTINGUISHED THE FIRE. THE CONTACT WAS UNSURE AS TO WHERE THE FIRE ORIGINATED. A FIRE REPORT WAS FILED. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO A TOW FACILITY. IT WAS UNKNOWN YET IF THE VEHICLE WAS DESTROYED. THE VEHICLE WAS NOT DIAGNOSED. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11164195December 31, 2018
SERVICE BRAKES
TL* THE CONTACT OWNS A 2004 CHEVROLET TAHOE. THE CONTACT STATED THAT THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD WHEN IT WAS DEPRESSED. ALSO, "STABILITY SYSTEM DISABLED- SERVICE BRAKE SYSTEM" FLASHED ON THE INSTRUMENT PANEL. THE CONTACT HAD TO APPLY FORCE TO THE BRAKE PEDAL TO MANEUVER THE VEHICLE OUT OF A DRIVE-THRU AREA OF A BUSINESS ESTABLISHMENT. THE CONTACT TURNED OFF AND RESTARTED THE VEHICLE. THE VEHICLE WAS PARKED AT THE CONTACT'S RESIDENCE DUE TO THE FAILURE. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V045000 (SERVICE BRAKES, HYDRAULIC). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11156890December 7, 2018
ENGINE
THE REAR MAIN DEAL WENT BAD IN ALMOST ALL OF THE TRUCKS AND SUVS WITH A 4.8L OR 5.3L ENGINE IN THEM WHERE THE POUR OIL EVERYWHERE AND THIS COULD BE CONSIDERED AN EPA VIOLATION AND A FIRE HAZARD IT NEEDS TO BE RECALLED ASAP SO WE CAN SAVE LIVES AND SAVE THE ENVIRONMENT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11141452October 19, 2018
SERVICE BRAKES
DRIVING DOWN THE ROAD AROUND 25 TO 30 MPH AND A KID RAN OUT BETWEEN TWO CARS AND I SLAMMED ON THE BRAKES AND THEY PARTIALLY FAILED. THE TRUCK EVENTUALLY STOPPED, BUT IMMEDIATELY GOT A BRAKE FAILURE WARNING AND I HAD TO HOLD THE PEDDLE TO THE WALL TO STOP THE REMAINING MILE OR SO HOME. I GET HOME AND LOOK UNDER THE DRIVERS DOOR TO INVESTIGATE A PUDDLE AND I SEE SMOKE WHERE THE RUPTURED BRAKE LINE HAD BEEN SPRAYING BRAKE FLUID ON THE CATALYTIC CONVERTER. THOUGHT FOR SURE THE TRUCK WAS GOING TO CATCH ON FIRE. THE BRAKES WERE JUST SERVICED, PADS AND ROTORS A YEAR OR SO AGO, SO I HAD NO CLUE THE LINES WERE BAD. JUST GOT HOME TO SEARCH ON THIS AND SEE THAT THE NHTSA HAS BEEN INVESTIGATING THIS, BUT NOT MUCH HAS HAPPENED WITH THIS SINCE 2014. VERY DISTRESSING. SEEMS THE ONLY THING THAT HAS BEEN DONE IS GM IS OFFERING THE REPLACEMENT LINES FOR SALE, BUT NO MENTION THAT THE DEALERS WANT $2,000 OR MORE TO INSTALL THEM?? I AM VERY THANKFUL THAT THIS KID IS STILL ALIVE AND WE BOTH DID NOT HAVE TO ENDURE A DEATH DUE TO THE CLOSE CALL. HOWEVER, I'M EXTREMELY DISTURBED THAT THIS IS A KNOWN ISSUE WITH MILLIONS OF THESE TRUCKS ON THE ROAD AND NOTHING IS BEING DONE WITH THIS TICKING TIME BOMB. EVERY SINGLE SUCH AFFECTED TRUCK WILL EVENTUALLY RUN INTO THE SAME ISSUE, AND PEOPLE ARE GOING TO GET KILLED. GM IS CLEARLY NOT ADDRESSING THIS OR EVEN WARNING PEOPLE OF THE HIDDEN PROBLEM. WHY WON'T YOU GUYS DO ANYTHING ABOUT THIS BIG PROBLEM? YOU'VE KNOW ABOUT THIS FOR 4 YEARS AND NOTHINGS BEEN DONE? I'M SHOCKED, THAT GM HAS BEEN ABLE TO AVOID ALL RESPONSIBILITY DUE TO A MFRS DEFECT BY USING CHEAP AND INFERIOR PRODUCTS THAT DO NOT HOLD UP IN THE NORTHERN CLIMATES. COATED BRAKE LINES SHOULD BE MANDATED!!! JUST CAME BACK FROM THE NEXT PAGE TO QUALIFY: NO CRASH - BY ABOUT 1 FOOT. NO FIRE - VERY LUCKY. NO INJURY/FATALITY - THIS VERY CLOSE! I WOULD LIKE A CALL BACK.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11115053August 1, 2018
SERVICE BRAKES
COMPLETE BRAKE FAILURE PEDAL STRAIGHT TO THE FLOOR MAIN BRAKE LINE MIDWAY OF THE TRUCK COMPLETELY BLEW APART MY SON JUST DROVE 2 HOURS PULLED IN THE DRIVEWAY I WENT TO MOVE HIS CAR THANK GOODNESS PUT THE BRAKE PEDAL TO THE FLOOR AND FLUID WAS EVERYWHERE I HAVE READ THAT THIS PROBLEM IS A 1 + 1,000 ON CHEVY TRUCKS HOWEVER I HAVE PURCHASED A CHEVY 2005 TAHOE 1 YEAR DIFFERENCE AND THIS WEEKEND THE SAME EXACT THING HAPPENED TRAVELING BACK FROM A WEEKEND AWAY AND COMPLETE BRAKE LINE FAILURE BRAKE LINE COMPLETELY BUSTED HALFWAY DOWN AND FLUID EVERYWHERE SO I GUESS I AM TOO IN 2000 SEEMS A LITTLE COINCIDENTAL I AM IN OHIO AND I HAVE READ ABOUT THE SALT BRINE AND EVERYTHING HOWEVER I HAVE ONE OF THE CLEANEST TRUCKS AROUND WE ARE DETAIL FREAKS EVERY ONE OF OUR CARS IS TAKEN CARE OF SOMETHING IS DEFINITELY WRONG WITH THESE YEARS OF TAHOES AND IT'S GOING TO KILL SOMEBODY ONCE AGAIN WE WERE ON A TWO-HOUR TRIP HOME STOP TO USE THE BATHROOM THE NEXT TIME WE HIT THE BRAKES THEY WERE TOTALLY GONE HAD TO USE EMERGENCY BRAKE TO STOP AND PULL OVER WE FEEL THE DIVINE INTERVENTION ON BOTH INCIDENCES AND ARE BLESSED THAT SOMEONE WAS LOOKING OUT FOR US AND IT SURE WASN'T CHEVY
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11093804May 14, 2018
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2004 CHEVROLET TAHOE. THE CONTACT STATED THAT THE ELECTRICAL SYSTEM IN THE VEHICLE STOPPED WORKING WITHOUT WARNING, WHICH CAUSED THE BATTERY TO DIE. THE CONTACT REPLACED THE BATTERY MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO AN UNKNOWN DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 183,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11089017April 19, 2018
UNKNOWN OR OTHER
WHILE RUNNING THE AC WHILE DRIVING OR STOPPED, THE AC TEMPERATURE WOULD AUTOMATICALLY SWITCH TO WARM AIR. THIS IS WITH THE AC BUTTON PUSH ON WITH THE UNIT WORKING PROPERLY. IF YOU SHUT THE CAR OFF AND BACK ON AGAIN IT WOULD RESET AND WORK AGAIN. BUT SHORTY AFTER IT WOULD DO IT AGAIN AND AGAIN
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11048477November 26, 2017
SERVICE BRAKES
BRAKE LINE RUSTED. LOST FLUID AND BRAKES WHILE DRIVING. HAVE BEEN DRIVING FOR 53 YEARS. NEVER HAD THIS HAPPEN WITH ANY OTHER VEHICLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Tahoe