BMW · Model Report
Showing safety data for the 2022 model year only.
BMW has issued Service Information Bulletin SIB 66 13 23 for 2022 X3 and X4 models equipped with Driving Assistant Professional. This bulletin addresses issues like 'Camera calibration failed' and 'KAFAS camera: Field of view permanently faulty' caused by KAFAS camera hood deformation due to heat.
BMW has issued Service Information Bulletin SIB 66 13 23 to address KAFAS camera hood deformation in certain 2022-2024 BMW X3 and X4 models equipped with 5AU Driving Assistant Professional. This issue can lead to various Check Control messages and restricted driver assistance functions.
BMW TSB SIB 51 09 25 addresses issues with the tailgate on 2022-2024 BMW X3 models, including difficulty opening/closing, unintended opening, and warning messages. The problem is often caused by corrosion on the tailgate latch due to pressure washing.
BMW has issued Service Information Bulletin SIB 66 13 23 for 2022 BMW X3 vehicles equipped with Driving Assistant Professional, addressing issues with restricted driver assistance functions due to KAFAS camera hood deformation. This TSB outlines the diagnosis and repair for fault codes like 800AC4…
BMW has issued a manufacturer communication regarding a condition where 2022-2023 BMW vehicles may experience no audio playback from the radio, navigation, or telephony systems, including a loss of system sounds like PDC and turn indicators.
BMW has issued a Technical Service Bulletin (TSB 10235200) for 2021-2023 BMW X3, X5, X7, and 5 Series models regarding dim or discolored LED daytime running lights. This TSB provides guidance for diagnosing and resolving the exterior lighting problem.
This manufacturer communication provides technical information regarding the BMW Gear Selector Switch (GWS) system for 2021-2023 BMW models. It details the components and function of the GWS, which integrates control electronics and sensors for gearshift lever position.
A manufacturer communication addresses a cracking sound from the B-pillar(s) in 2021-2023 BMW X3 and X4 models, typically heard while driving at speeds of 10 mph and above.
BMW has issued a Technical Service Bulletin (NHTSA ID 10235179) for a howling or whistling noise from under certain 2021-2023 BMW models. This noise typically occurs at 30-37 mph after a cold start when temperatures are 32°F or lower, affecting the engine and cooling system.
A manufacturer communication addresses instances where 2021-2023 BMW vehicles display an incorrect GPS location, affecting the 'Nav Map' and reported 'coordinates'. Owners should consult their dealership for diagnosis and resolution.
Some 2021-2022 BMW models, including the X3, 840i, M8, M850i, and X4, may develop visible white spots on the edge of the central information display (CID). This manufacturer communication details the cause and resolution for this issue.
BMW has issued Manufacturer Communication 10230735 to address customer concerns regarding uneven ambient lighting emission, such as bright spots or dark spots, on the door trim panels of certain 2021-2023 X-Series vehicles.
2022 BMW X3 M40i. The Driver Assistance system appears to activate normally after startup with no warning or indication that a fault is present. However, within approximately 3–5 minutes of driving, a Check Control message appears stating “Driver Assistance limited. Camera vision.” The vehicle then identifies affected systems including Pedestrian Warning, Frontal Collision Warning, Side Collision Warning, Automatic Lane Change, Active Blind Spot Detection, and Steering Assistant. A separate message states that Active Cruise Control is reduced and there may be no brake intervention for stationary vehicles. The safety concern is that the system can appear active and available before the warning appears, even though at least some driver-assistance functions may already not be operating. Before the warning was displayed, I observed that Steering Assistant/lane-keeping did not intervene and I crossed out of my lane without steering correction or a lane-departure warning. There was no prior warning that the camera-based system was malfunctioning. I cannot confirm whether the other affected safety functions were operational during this interval. A BMW dealer inspected the vehicle and physically found the KAFAS camera hood/trim warped from heat. The warped component was removed and shown to me, and the dealer ordered a replacement. BMW has issued SIB 66 13 23 addressing KAFAS camera hood deformation on affected vehicles. Fault memory also contained KAFAS codes 800ABF, 800ABE, and 800AC4 for camera field-of-view disturbance and calibration failure. This creates a potential safety defect because the driver may reasonably believe lane-keeping and other camera-based safety systems are functioning until the vehicle detects the failure several minutes later. The vehicle/component can be made available for inspection
No injuries · No fire · No crash
- Customer Reports: ac not cooling, stopped cooling yesterday while on the highway, approved evac and recharge if needed Caused by Leaking a/c hose from compressor to condenser Tech: CHRISTOPHER ARCHER (F88) Installed 64 53 9 868 421 : B1-Pressure hose assy c Installed 64 53 9 284 018 : B1BIMIRRZN-Gasket ring Confirmed concern. Performed vehicle
No injuries · No fire · No crash
belt tensioner failed while on highway without warning, leading to complete shutdown of the engine. Car had to be towed for repair. Complete disintegration of the timing belt, the car only had 51,000 miles. Expensive repair
No injuries · No fire · No crash
The contact owns a 2022 BMW X3. The contact stated that while driving at an undisclosed speed in hot weather, the air conditioner failed to operate as intended. The vehicle was taken to the dealer, where it was determined that the air conditioner line was rubbing against a pulley, presenting a fire hazard. The contact was informed that the air conditioner hose needed to be replaced. The manufacturer was made aware of the failure. The failure mileage was approximately 52,000.
No injuries · No fire · No crash
On June 23, 2026 around 3:30pm, we were driving 70 mph on an interstate (I40) and the panoramic sunroof spontaneously shattered on our BMW X3. We were not struck by anything and there was no inclement weather or extreme heat. The sunshade was pulled so we were not hit by the glass, but we were very much in danger. My baby was in the backseat and he would have had glass all over him. We had to pull over on the highway and had to arrange for another car to take us home.
No injuries · No fire · No crash