Alfa Romeo Stelvio Complaints (2019)

36 consumer complaints on file.

#11759159August 24, 2026
VEHICLE SPEED CONTROL, ENGINE, FUEL/PROPULSION SYSTEM
I'm driving and all of a sudden - while I'm on the highway - a service engine pops up on the dashboard, and my car looses all power and drive ability. I immediately loose any gas/drive ability to accelerate or maintain legal speeds. I read about the recent recall with the fuel system and it's exactly what my car is experiencing, but somehow my VIN is both telling me that my car has a recall at one place, and then doesn't have a recall at another. It's confusing and I"m not sure what the database issue is because my car is experiencing the same exact feul system problem is that I"m reading on line for recall of my car's year.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11759200August 24, 2026
ELECTRICAL SYSTEM
1. COMPONENT FAILED & INSPECTION: The transmission ground strap (uninsulated, bare braided copper cable) completely corroded/severed from environmental decay. This open ground circuit forced high engine-cranking currents into secondary low-voltage paths, causing an extreme thermal surge that melted and shorted out the main engine compartment wiring harness. Both failed components are preserved by the owner and are available for forensic inspection upon request. 2. SAFETY RISK: This manufacturing flaw causes a severe thermal fire hazard and an instantaneous, catastrophic loss of all vehicle propulsion, power steering, braking assist, and lighting systems while operating on public roadways. This abrupt deactivation threatens occupant safety and surrounding traffic by risking high-speed highway collisions or engine bay fires without warning. 3. CONFIRMATION: The exact failure cascade was formally diagnosed, itemized, and verified by Maranello Alfa Romeo of [XXX] ([XXX]) under a repair estimate of $7,203.10. 4. INSPECTIONS: Formally inspected by factory-certified technicians at the local authorized dealership center. No insurance, police, or outside authority investigations have occurred yet, as the car was towed immediately to avoid an active open highway fire. 5. SYMPTOMS & WARNINGS: There were absolutely no warning lamps, messages, check engine lights, or symptoms prior to the incident. Failure occurred instantly on XXX. The vulnerability was hidden from plain sight until the primary ground pathway severed completely during engine startup. 6. MANUFACTURER KNOWLEDGE: Alfa Romeo engineering has recognized this danger on 2017-early 2023 models, releasing a redesigned, fully sheathed/insulated ground cable (Part No. 68648999AA) to prevent this environmental decay. The consumer was never proactively notified of this critical safety vulnerability INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11755638August 8, 2026
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM, ENGINE
There were no warning lights prior to driving and the vehicle stopping on the highway 2 times. Now the warning lights is constant and referencing the recall from 09/2025. Still no remedy for the recall. Mopar and the Alfa Romeo dealership have not contacted me regarding fixing the problem. A class action lawsuit needs to be filed
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11748560July 6, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2019 Alfa Romeo Stelvio. The contact stated that while driving approximately 45 MPH, the vehicle suddenly stalled. On another occasion, the vehicle stalled while in a parking lot. The fuel warning light, the auto-stop warning light, and the traction control warning light were illuminated. The vehicle was initially towed to a relative's residence and later towed to a local dealer, where an unknown repair was performed; however, the stalling failure recurred. The vehicle was then taken to an independent mechanic, who diagnosed the failure as a faulty fuel module requiring replacement. The vehicle was not repaired. The manufacturer was contacted, but offered no financial assistance and advised the contact not to drive the vehicle. The contact confirmed that the remedy part for NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline) was not yet available. The failure mileage was approximately 43,250.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11745893June 23, 2026
VEHICLE SPEED CONTROL, ENGINE
The vehicle randomly has a yellow A! error code, then it loses power while driving, when going up a hill, sometimes barely makes it. No mechanics can figure this out and its a topic of complaints amongst numerous forums regarding this vehicle. Why isn't there a recall on this?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11732816April 21, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2019 Alfa Romeo Stelvio. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving, the vehicle failed to exceed 60 MPH and the vehicle went into LIMP Mode. The vehicle was taken to the dealer, and the failure was associated with the recall and confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 95,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11729905April 8, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2019 Alfa Romeo Stelvio. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727879March 30, 2026
UNKNOWN OR OTHER
Subject: Formal Demand for Remedy – Safety Recall / 2019 Alfa Romeo Stelvio (VIN: [XXX] ) To Whom It May Concern, I am writing to formally demand immediate resolution regarding a serious safety recall affecting my 2019 Alfa Romeo Stelvio (VIN: [XXX] ). The recall, issued in September 2025, involves a defect in the fuel delivery module that may result in a loss of motive power. This defect presents a significant safety hazard, increasing the risk of a crash, injury, or worse. Despite the severity of this issue, I have not been provided with a remedy, repair timeline, or adequate alternative solution. It is unacceptable that I am expected to continue operating—or assume the risk of operating—a vehicle with a known safety defect and no available fix. This situation has caused ongoing concern, inconvenience, and diminished confidence in the safety and reliability of the vehicle. Given the lack of a timely and effective remedy, I am formally requesting that Alfa Romeo take one of the following actions immediately: Provide a permanent repair within a reasonable and clearly defined timeframe; OR Repurchase (buy back) the vehicle at fair market value; OR Provide a comparable replacement vehicle at no cost to me If this matter is not resolved promptly, I am prepared to pursue further action, including but not limited to filing additional complaints with the National Highway Traffic Safety Administration (NHTSA), seeking relief under applicable state lemon laws, and exploring other legal remedies available to me. Please treat this matter with the urgency it requires. I request a written response within 10 business days of receipt of this letter outlining the steps Alfa Romeo will take to resolve this issue. Thank you for your immediate attention to this serious safety concern. [XXX] and [XXX] [XXX] [XXX] or [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727913March 30, 2026
FUEL/PROPULSION SYSTEM
Despite the seriousness of the outstanding recall (25V-586), which Stellantis acknowledges can result in a sudden and complete loss of engine power at high speeds, Alfa Romeo/Stellantis have provided exactly zero updates in nearly 8 months since the recall was announced. In speaking with my dealer, I’ve learned that Alfa Romeo/Stellantis were initially providing vague estimates for when they expected a recall fix to be available but have since stopped providing information to the dealers altogether. The manufacturer’s behavior in the face of such a serious safety risk is alarming and leads me to question whether a fix is actually even under development or will ever be available. Without action or the threat of action by the government to force the manufacturer to comply with their obligations to vehicle owners I have no confidence that this serious safety issue will be satisfactorily addressed at all, much less in a timely manner.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11724128March 13, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2019 Alfa Romeo Stelvio. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11720152February 24, 2026
ENGINE, FUEL SYSTEM, GASOLINE
The contact owns a 2019 Alfa Romeo Stelvio. The contact stated that the check engine warning light was illuminated. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline). Additionally, the contact was unable to renew the registration due to the open recall. The local dealer was contacted and confirmed that parts for the recall repair were on back order. The vehicle was not diagnosed or repaired. The manufacturer was contacted and provided a reference number, but no additional assistance was provided. The failure mileage was approximately 93,400.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11717959February 14, 2026
FUEL/PROPULSION SYSTEM, VEHICLE SPEED CONTROL
While pulling out, vehicle decelerated as I was pressing the gas. Almost hit by another vehicle. Managed to avoid being hit and car still would not accelerate. Ultimately, pulling over at store and parking. Contacted manufacter because it was related to the recall, but they wasnt able to do anything about it. Im unable to drive it and im still paying for it. no remedies were offered
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11712161January 20, 2026
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
the vehicle has developed the exact symptoms described in the recall, including: Loss of power Check Engine Light Excessive oil consumption Electronic throttle control warnings / drivability issues My authorized dealer has confirmed that the recall is open but states parts are not available. This leaves me with an unsafe and unreliable vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709905January 9, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2019 Alfa Romeo Stelvio. The contact received notification of NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707627December 29, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2019 Alfa Romeo Stelvio. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed, but the vehicle failed to accelerate as intended, nearly causing a crash. The contact shifted to neutral(N), and the vehicle was pushed back to the nearby residence. The contact stated that a mobile independent mechanic diagnosed the vehicle at the residence. The dealer was made aware of the failure. In addition, the contact stated that several dealers were contacted, and the contact was informed that the parts were not available for an unknown repair. The contact received a recall notification NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the parts to do the recall repair were not available. The manufacturer was not made aware of the failure because the manufacturer's contact information was inoperable. The failure mileage was approximately 68,480.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11705307December 16, 2025
FUEL SYSTEM, GASOLINE, ENGINE
The contact owns a 2019 Alfa Romeo Stelvio. The contact stated that while driving at various speeds, the vehicle would hesitate upon depression of the accelerator pedal, and the check engine warning light would illuminate. The vehicle was taken to a dealer, where it was diagnosed with an EVAP system leak; however, the origin of the leak could not be determined. The contact stated that the vehicle later failed to start, and both the check engine and auto Start/Stop warning lights were illuminated. The vehicle was towed to an independent mechanic, where it was diagnosed with a defective fuel pump, and the fuel pump was replaced; however, the failure recurred a month later. The contact stated that the vehicle failed to start after multiple attempts. The contact left the vehicle and returned to the vehicle the following day. The contact managed to drive the vehicle to the residence. The vehicle was then taken back to the dealer, where an unknown repair was performed; however, the failure recurred two days later. The contact later received a recall notice for NHTSA Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The dealer was notified of the failure but refused to acknowledge the recall. The manufacturer had yet to be notified of the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle was not repaired. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702929December 4, 2025
ENGINE, FUEL SYSTEM, GASOLINE
The contact owns a 2019 Alfa Romeo Stelvio. The contact stated that the vehicle failed to drive forward. The vehicle was towed to the dealer, where the vehicle was diagnosed with a failed oil solenoid and battery failure. The contact was informed that the oil solenoid and battery needed to be replaced. The vehicle was repaired. The contact stated that the failure reoccurred a month later. The vehicle was towed back to the dealer. The contact was informed that the engine bolt needed to be cleaned, and the spark plugs needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The contact researched NHTSA Campaign Number: 25V586000 (Fuel system, Gasoline); however, the parts were unavailable for the recall repair. The dealer was made aware of the recall. In addition, the contact was without a vehicle because of the unrepaired recall. The contact stated that the dealer never mentioned the unrepaired recall and attempted to perform a temporary repair. The contact stated that whenever the check engine warning light illuminated on Alfa Romeo vehicles, the vehicle remained undrivable until the vehicle was repaired. The vehicle was undrivable and had been undriveable since June 2024. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 62,000. The VIN was unavailable.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702549December 2, 2025
EQUIPMENT
The contact owns a 2019 Alfa Romeo Stelvio. The contact stated that while driving at 50 MPH, the contact became aware of water entering the cabin of the vehicle from under the glove compartment on the passenger’s side. A dealer was contacted. The vehicle was taken to dealer where it was diagnosed and determined the electrical system needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 18V205000 (EQUIPMENT); however, the VIN was not included in the recall. The manufacturer was not notified of the failure. The failure mileage was 34,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699848November 17, 2025
FUEL/PROPULSION SYSTEM
Recall Issue Sep 09,2025 Manufacturer Recall Number93C NHTSA Recall Number25V-586 Recall StatusRecall Incomplete, remedy not yet available I would like to submit a compliant that it has been two months since the recall was issue and there still is no formal remedy provided.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698417November 9, 2025
ELECTRICAL SYSTEM
My car stopped and would not turn back on while in the middle lane of a busy highway. We were stopped on the highway >20min until police arrived to block the lanes so we could safely exit the vehicle and a tow truck could safely retrieve it. The ground strap underneath the vehicle that grounds the main engine harness was broken. As a result the electrical short resulted in burning/melting of several spots on the harness. There was no warning ahead of time and I’ve learned that this is a known issue. We are very lucky that this did not lead to a crash, injury or death.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Alfa Romeo Stelvio