Ford F-250 Complaints

11,199 consumer complaints on file.

#10226531May 2, 2008
SUSPENSION
FRONT END SHIMMIES REALLY BAD WHEN BRAKING ABOVE 50 MPH. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10226427May 1, 2008
STEERING, SUSPENSION:FRONT
AT ABOUT 45 TO 55MPH TRUCK SOMETIMES DEVELOPS A LIGHT SHIMMY IN THE FRONT END. IT OCCASIONALLY BECOMES VERY SEVERE FEELING LIKE THE WHOLE FRONT SUSPENSION IS ABOUT TO COME APART. IT IS ESPECIALLY PREVALENT WHEN THERE IS A SLIGHT LEFT PRESSURE ON THE STEERING WHEEL, LIKE WHEN CHANGING LANES. SLOWING WILL ELIMINATE THE BOUNCE, BUT IT IS DIFFICULT TO SLOW QUICKLY WHEN THE FRONT END IS BOUNCING AND SEVERELY VIBRATING. IT CAUSES A NEAR TOTAL LOSS OF CONTROL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10226339April 30, 2008
SUSPENSION
MY FORD F-250 SUPERDUTY DIESEL OCCASIONALLY SHAKES EXTREMELY VIOLENTLY WITH TEMPORARY COMPLETE LOSS OF VEHICLE CONTROL WHEN DRIVING AT HIGHER SPEEDS AND CROSSING UNEVEN OBSTACLES SUCH AS BRIDGE GAPS AND SMALL ROAD DEVIATIONS. THE VEHICLE FEELS TO SHAKE VIOLENTLY IN THE FRONT END AND INHIBITS STEERING. THE SHAKE IS EXTREMELY VIOLENT IN NATURE WITH OSCILLATING LARGE AMPLITUDE DEFLECTIONS IN EACH WHEEL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10226008April 29, 2008
POWER TRAIN:DRIVELINE
TL*THE CONTACT OWNS A 2006 FORD F-250 SD. WHILE DRIVING BETWEEN 45-70 MPH, THE ENTIRE VEHICLE SHAKES VIOLENTLY. THE VEHICLE WAS TAKEN TO THE DEALER FOUR DIFFERENT TIMES FOR THIS FAILURE, BUT IT WAS UNABLE TO BE REPAIRED. THE CONTACT TRADED THE VEHICLE IN AT A LOSS. THE FAILURE MILEAGE WAS 4,806.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10226024April 29, 2008
SERVICE BRAKES, HYDRAULIC
THERE IS A BRAKE LINE TO THE REAR WHEELS LOCATED ROUGHLY ABOVE THE DIFFERENTIAL. THAT LINE IS IN CLOSE PROXIMITY TO ANOTHER CABLE (MAYBE THE EMERGENCY BRAKE CABLE) AND THE BRAKE LINE AND CABLE ARE RUBBING TOGETHER. THE BRAKE LINE IS VERY WORN IN THAT AREA FROM CONTACT WITH THE CABLE. IT LOOKS TO BE WORN TO A POINT THAT WOULD BE VERY CLOSE TO THE "CORE"OF THE BRAKE LINE. OF COURSE EXCESS PRESSURE OR FURTHER WEAR COULD CAUSE A FAILURE OF THAT LINE AND THEREFORE LOSS OF REAR BRAKING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10226058April 29, 2008
ENGINE AND ENGINE COOLING
RECENTLY FOUR GOSHEN VANS AND / OR BUSES HAVE CAUGHT FIRE AND COMPLETELY BURNED UP. IN THREE CASES THE BUSES / VANS WERE PARKED AND EITHER JUST SHUT OFF OR PARKED AND IDLING WHEN SMOKE WAS DISCOVERED AND THEN THE FIRE STARTED. IN EACH CASE THE VEHICLE BURNED UP IN MINUTES (7 MINUTES IN ONE CASE). SOME OF THESE VEHICLES ARE USED TO TRANSPORT DISABLED CLIENTS SO THESE ARE VERY SERIOUS INCIDENTS WHICH COULD LEAD TO DEATH OR INJURY. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10225869April 28, 2008
ELECTRICAL SYSTEM
1994 FORD F250 CAUGHT FIRE IN DALLAS TX. ALTERNATOR CONNECTOR CAUGHT FIRE AND BURNED WHILE DRIVING ON THE FREEWAY. WIRES MELTED, ALTERNATOR CONNECTOR MELTED. TRUCK IS STILL DOWN WIRING HARNESS TO ALTERNATOR NOT AVAILABLE. OLD PARTS ARE AVAILABLE. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10225772April 26, 2008
SUSPENSION:REAR
I WAS DOING SOME REPAIR WORK ON MY FORD F-250 AND DECIDED TO LOOK AROUND THE UNDERSIDE. I WAS STUNNED TO SEE THAT 2 OUT OF 4 LEAVES OF THE LEFT REAR SPRING HAD BROKEN OFF NEAR THE U BOLT. THE PROBLEM WAS NOT EVIDENT WHILE DRIVING BECAUSE I HAVE NOT PUT ANYTHING HEAVY IN THE TRUCK. I ONLY FOUND THE PROBLEM BECAUSE I WAS PREPARING FOR A LONG TRIP WITH A HEAVY TRAILER. THE TRUCK WAS AT MY FORD DEALER THE WEEK BEFORE AND THEY DID NOT NOTICE THE BROKEN SPRING. WHILE SHOPPING FOR A REPLACEMENT SPRING, I WAS AMAZED HOW MANY STORES MADE COMMENTS LIKE "WE SELL A LOT OF THESE". I CALLED THE FORD CUSTOMER SERVICE LINE TO ASK THEM TO PAY FOR THE REPAIRS AND THEY CLAIMED THAT THEY DO NOT GET ANY REPORTS OF BROKEN SPRINGS. I AM A DEGREED MECHANICAL ENGINEER AND AM REASONABLY FAMILIAR WITH THE DESIGN OF SPRINGS. I FIRMLY BELIEVE THAT NO SPRING SHOULD EVER FAIL UNDER NORMAL USE. HAD THE SPRING FAILED WHILE I WAS ON THE ROAD, I WOULD HAVE LOST CONTROL OF THE TRUCK. MY INFORMAL DATA COLLECTION TELLS ME THAT MOST OF THE FAILURES HAPPEN AFTER THE WARRANTY EXPIRES. IT APPEARS THAT FORD HAS NO WAY TO KNOW ABOUT REPAIRS MADE BY NON-FORD SHOPS. GIVEN THAT THE PRICE DIFFERENCE FOR THE REPAIR IS SUBSTANTIAL, IT WOULD BE REASONABLE TO SUGGEST THE MOST OF THE REPAIRS ARE MADE OUTSIDE OF FORD. THE CUSTOMER SERVICE REP WAS NOT INTERESTED IN THE SAFETY ASPECT AND TOLD ME THERE WAS NO OTHER WAY TO CONTACT ANYONE ELSE IN THE COMPANY. IN MY BEST ENGINEERING JUDGMENT, THE SPRING FAILED DUE TO FATIGUE. THE PROBLEM IS MUCH LARGER THAN FORD REALIZES. AND ALL OF THE VEHICLES WITH THESE SPRINGS ARE GETTING OLDER EVERY DAY. I WAS NOT KILLED OR INJURED BY THIS DEFECT ONLY BECAUSE OF MY ENGINEERING AND MECHANICAL ABILITIES ENABLED ME TO SEE AND FIX IT BEFORE IT FAILED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10225457April 23, 2008
SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT, SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT, SUSPENSION:REAR
TL*THE CONTACT OWNS A 2000 FORD F-250 SD. WHILE THE VEHICLE WAS RECEIVING AN OIL CHANGE, THE MECHANIC DISCOVERED THAT BOTH LOWER AND UPPER BALL JOINTS NEEDED TO BE REPLACED. THE REAR END COVER WAS RUSTED. THE CURRENT MILEAGE WAS 36,931 AND FAILURE MILEAGE WAS 36,923.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10225357April 22, 2008
SUSPENSION:FRONT
WHEN TRAVELING AT HIGHWAY SPEEDS A DEFECT OR UNEVEN PORTION IN THE ROADWAY SUCH AS A POTHOLE OR BUMP OR AN EXPANSION JOINT ON AN OVERPASS CAN CAUSE THE FRONT END TO START SHIMMYING UNCONTROLLABLY. THE VEHICLE HAS TO BE SLOWED OR EVEN STOPPED TO MAKE THE SHIMMY STOP WHICH IS A DANGEROUS SITUATION ON A MULTILANE HIGHWAY. THIS HAS OCCURRED TWO TIMES IN THE PAST 3 MONTHS, I MUST STRESS THAT THE SHAKING IS QUITE VIOLENT AND FRIGHTENING. I HAVE BEEN RESEARCHING THIS ON THE INTERNET AND HAVE FOUND THAT MANY PEOPLE HAVE THIS SAME COMPLAINT WITH NO APPARENT FIX FOR THE PROBLEM. IF THIS IS SO THEN I WILL BE TRADING THIS VEHICLE IN FOR ANOTHER BECAUSE THIS IS AN UNACCEPTABLE CONDITION. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10225313April 21, 2008
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
I WAS DRIVING ON HWY 59 SOUTH TO HOME WHEN A SPARK PLUG BLEW OUT OF MY 2003 F-250 WITH 5.4 MOTOR. NUMBER 3 PASSENGER SPARK PLUG BLEW OUT, TRUCK ONLY HAS 53,000 MILES ON IT. TRUCK WAS TOWED TO DEALERSHIP AND THEY ACTED LIKE THEY NEVER HEARD OF SUCH BUT THAT THEY HAD A KIT TO FIX IT. COST TO FIX WAS $454.36, THEN THE TOLD ME NO WARRANTY ON THE FIX. PLUS TOW BILL OF $149.00 FORD MOTOR COMPANY KNOWS OF THIS DEFECT AND REFUSES TO DO ANYTHING! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10225314April 21, 2008
SUSPENSION:FRONT
VIOLENT FRONT END SHAKE AFTER HITTING SMALL POT HOLES OR BUMPS AT ANY SPEED, COMPLETE LOSS OF CONTROL OF TRUCK UNTIL COMING TO STOP. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10225319April 21, 2008
SUSPENSION:FRONT:STABILIZER BAR
THIS MORNING I WAS DRIVING MY 2005 F250 4X4 ABOUT 40 MPH WHEN IT STARTED A DEATH WOBBLE. I HAD TO PULL OVER AND CAME TO A COMPLETE STOP. I LOOKED AT THE TIRES TO DETERMINE IF I LOST A BALANCE WEIGHT. I THEN PROCEEDED ABOUT A HALF MILE AND STOPPED AT A LOCAL STORE. WHEN I LEFT THE DEATH WOBBLE STARTED AGAIN. I KEEP THE TRUCK BELOW 40MPH AND HEADED TO THE STORE WHERE I PURCHASED MY TIRES. IT HAPPENED AGAIN AS I WAS ENTERING THE FREEWAY. I AGAIN HAD TO STOP AND PULL OVER. I KEEP THE TRUCK BELOW 40MPH AND ARRIVED AT THE TIRE STORE WHERE THEY BALANCED THE FRONT TIRES. WHEN I LEFT I AGAIN ENTERED THE FREEWAY AND THE "DEATH WOBBLE" STARTED AGAIN. I KEEP THE TRUCK BELOW 40MPH AND USED SURFACE STREETS TO GET TO THE FORD DEALERSHIP WHERE I PURCHASED MY TRUCK. I WILL HAVE THE RESULTS TOMORROW AFTER OVER $700 WORTH OF REPAIRS. IF I WAS TOWING MY FIFTH WHEEL I THINK THERE WOULD HAVE BEEN A BAD TRAFFIC ACCIDENT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10225006April 19, 2008
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
I HAVE A 1999 FORD F250 WITH A TRITON 5.4L V8 ENGINE. IN MARCH OF THIS YEAR IT BLEW OUT A SPARK PLUG FROM THE CYLINDER HEAD. AFTER RESEARCHING THIS I'VE FOUND IT TO BE A COMMON PROBLEM WITH THESE ENGINES. THIS COULD HAVE BEEN DISASTROUS DUE TO THE FUEL VAPOR THAT WAS COMING FROM THE EXPOSED CYLINDER. THE SMELL OF GAS IN THE CAB WAS SUBSTANTIAL. I HAD TO REPLACE THE ENGINE AT A COST OF $4521. IT IS JUST A MATTER OF TIME BEFORE SOME ONE GETS HURT OR WORSE FROM A FIRE CAUSED BY THIS PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10225014April 19, 2008
STEERING, SUSPENSION
MY FORD F250 SD 2005 HAS A VIOLENT UNCONTROLLABLE SHAKING IN THE FRONT END. THIS PROBLEM HAS BECOME MORE FREQUENT AS THE TRUCK GETS OLDER. WHEN THIS HAPPENS I HAVE TO PULL OVER AND STOP. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10225019April 19, 2008
SUSPENSION:REAR
I HAVE A FORD SUPER DUTY TRUCK THAT EXHIBITS WHAT HAS BEEN NAMED THE DEATH WOBBLE AS WELL AS THE 40-50 MPH REAR END BOUNCE OR SHAKE. NEW TIRES, SHOCKS, BRAKES, ETC HAVE NOT CORRECTED THIS ISSUE. I'VE READ ONLINE WHERE MANY OTHERS EXPERIENCE THIS SAME ISSUE AND MANY HAVE BEEN TOLD BY FORD THAT THEY HAVE TO LIVE WITH THIS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10224926April 18, 2008
TIRES:TREAD/BELT
TL*THE CONTACT OWNS A 2000 FORD F250. THE CONTACT OWNS A TIRE BUSINESS AND HAS HAD TEN NANKANG MUDSTAR RADIAL TIRES, SIZE 305/70R16 (NA) RETURNED BY CUSTOMERS. THE TIRES ARE COMING APART WITH VERY LOW MILEAGES. THE CONTACT SPOKE WITH THE MANUFACTURER AND WAS INFORMED THAT THEY WOULD ASSIST. AS OF APRIL 18, 2008, THE MANUFACTURER HAS NOT ASSISTED. THE CONTACT HAS ALL THE RECORDS FOR EACH TIRE THAT WAS REPLACED. NO OTHER VEHICLE OR DEALER INFORMATION WAS AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10224927April 18, 2008
VEHICLE SPEED CONTROL:CRUISE CONTROL
TL*THE CONTACT OWNS A 1993 FORD F250. THE VEHICLE WAS TAKEN TO THE DEALER FOR THE RECALL REPAIR REGARDING THE VEHICLE SPEED CONTROL: CRUISE CONTROL. THE DEALER DISCONNECTED THE CRUISE CONTROL ON OCTOBER 17, 2007 AND INFORMED THE CONTACT THAT THE REPLACEMENT PART WAS NOT YET AVAILABLE. THERE HAD BEEN NO FAILURE TO DATE. THE RECALL NUMBER AND PURCHASE DATE WERE UNKNOWN. THE CURRENT MILEAGE WAS 180,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10224936April 18, 2008
ELECTRICAL SYSTEM:WIRING
TL*THE CONTACT OWNS A 2004 FORD F250. WHILE DRIVING ON TWO SEPARATE OCCASIONS, THE VEHICLE SHUT OFF WITHOUT WARNING. THE VEHICLE RESTARTED APPROXIMATELY TEN MINUTES LATER AND HAD TO BE TOWED. NHTSA CAMPAIGN ID NUMBER 05V270000 (ELECTRICAL SYSTEM:WIRING) WAS REFERENCED. THE VEHICLE WAS DIAGNOSED BY A MECHANIC. THE SPEED AND FUEL SYSTEM WERE UNKNOWN. THE CURRENT MILEAGE WAS 27,150 AND FAILURE MILEAGE WAS 27,140. UPDATED 5/19/08 *CN UPDATED 05/19/08
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10224803April 17, 2008
ENGINE AND ENGINE COOLING
ON MY WAY TO WORK, I HAD JUST EXITED THE EXPRESS WAY, WHEN I HEARD A LOUD (BANG) THAT WAS FOLLOWED BY A LOUD CONSTANT SOUND. I HAD BEEN TOLD ABOUT THIS PROBLEM WITH THE F-250 SUPER DUTY WITH THE 5.4 V-8 ENGINE SO I KNEW WHAT HAD HAPPENED. I ENDED UP HAVING TO DRIVE MY TRUCK 35 MILES HOME BECAUSE I HAD NO OTHER WAY HOME. THIS PROBLEM IS SO COMMON THAT MY LOCAL AUTO PARTS SUPPLIER CARRIES A REPAIR KIT ON THE SHELF IN THE SMALL TOWN OF DUNDEE MICH. THE REPAIR KIT CAME COMPLETE WITH THE CORRECT TAP, REPAIR COIL, INSERTION TOOL AND SPARK PLUG. I ALSO HAD TO REPLACE THE IGNITION COIL BECAUSE IT WAS BLOWN INTO SMALL PIECES. THE TRUCK RAN FINE AT FIRST BUT NOW IT HAS ALMOST NO POWER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250