Ford F-250 Complaints

11,199 consumer complaints on file.

#10244234October 2, 2008
STRUCTURE
TL*THE CONTACT OWNS A 2005 FORD F-250 SD. THE CONTACT NOTICED CORROSION AND RUST AT THE LOWER REGION OF ALL FOUR WELDED DOOR SEAMS. IN ADDITION, THE TAILGATE'S LOWER INNER/OUTER SKIN WELD SEAM PANEL WAS SEPARATING, RUSTED, AND CORRODED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, BUT THERE WERE NO RESOLUTIONS. THE FAILURE MILEAGE WAS 38,200 AND CURRENT MILEAGE WAS 39,500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10244143October 1, 2008
STEERING
THE POWER STEERING PUMP PULLEY POPPED OFF THE PUMP SHAFT AFTER A BLOWOUT OF THE LEFT FRONT TIRE ON MY 2002 FORD F250 DIESEL PICKUP TRUCK. THE PULLEY APPEARS TO BE PRESSED ONTO THE PUMP SHAFT. I SUSPECT A PIECE OF TIRE TREAD HIT THE PULLEY OR EXCESS STRESS CAUSED BY THE BLOWOUT CAUSED IT TO POP OFF THE SHAFT. THE RESULT IS AN IMMEDIATE LOSS OF STEERING. I AM INTERESTED IN KNOWING IF THIS HAS HAPPENED IN OTHER SIMILAR VEHICLES. THANK YOU, THOMAS HUEBNER *TR
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10243840September 29, 2008
SUSPENSION:FRONT, STEERING, SUSPENSION
WE HAVE CONTINUOUS ISSUES WITH THE SHIMMY AND UNCONTROLLABLE SHAKE IN THE FRONT END OF OUR 2005 F250 SUPER DUTY (GAS). AT SPEEDS OF 55 AND HIGHER, THE TRUCK WILL SHAKE UNCONTROLLABLY OFF THE ROAD AT THE SLIGHTEST UNEVEN OR BUMP IN THE ROAD. WE HAVE TAKEN IT TO DEALERSHIPS NUMEROUS TIMES AND THE ONLY THING THEY HAVE DONE IS TO REPLACE THE DAMPER ASSEMBLY ON JUNE 6TH. PROBLEM STILL EXISTS AND SEEMS TO BE MORE ERRATIC AND FREQUENT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10243494September 26, 2008
STEERING, SUSPENSION
FRONT END SHAKES VIOLENTLY AFTER HITTING POT HOLES OR BUMPS IN THE ROAD. TO THE POINT WHERE A COLLISION IS HIGHLY POSSIBLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10243427September 25, 2008
ENGINE AND ENGINE COOLING:ENGINE
TL*THE CONTACT OWNS A 2003 FORD F250 SUPER DUTY. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE BEGAN TO MAKING A HISSING NOISE. THE CONTACT PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD AND THE HISSING STOPPED. HE LOOKED UNDER THE HOOD, RESTARTED THE VEHICLE, AND NOTICED THAT THE NUMBER 4 SPARK PLUG BLEW OUT OF THE ENGINE HEAD WITH A FAILED COIL. THE VEHICLE WAS TAKEN TO A DEALER AND THEY STATED THAT A NEW ENGINE WAS NEEDED. THE CURRENT MILEAGE WAS 102,300 AND FAILURE MILEAGE WAS 101,999.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10243184September 23, 2008
STEERING
TL*THE CONTACT OWNS A 2006 FORD F-250. WHILE DRIVING 63 MPH, THE VEHICLE STRUCK A SMALL DIP IN THE ROAD. THE STEERING BEGAN TO SHAKE VIOLENTLY AND THE CONTACT LOST CONTROL. THE VEHICLE WILL NOT BE REPAIRED BECAUSE THE CONTACT WANTS THE VEHICLE REPLACED. THE MANUFACTURER STATED THAT THEY WERE AWARE OF THE FAILURE; HOWEVER, ADVISED HIM TO FOLLOW THE TSB INSTRUCTION TO REPAIR THE FAILURE. THE FAILURE MILEAGE WAS 51,000 AND CURRENT MILEAGE WAS 65,000.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10242987September 20, 2008
ENGINE AND ENGINE COOLING:COOLING SYSTEM, ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
VEHICLE HAS A OIL COOLER AND EGR COOLER DEFECT. COMMON PROBLEM BY MANY F250 OWNERS. FORD IS AWARE OF THE PROBLEM AND HAS ISSUED A SUPERSEDED PART NUMBER FOR THE OIL COOLER, EGR COOLER IS UNCHANGED. WHEN THESE COMPONENTS FAIL IT CAUSES THE VEHICLE TO OVERHEATS WHEN TOWING A LOAD AND CAN CONSUME SEVERAL GALLONS OF COOLANT. IT'S A SAFETY CONCERN DUE IN PART THAT IF A VEHICLE OVERHEATS AND SHUTS OFF WHILE TOWING A HEAVY LOAD THE VEHICLE WILL LOSE BRAKING POWER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10242969September 19, 2008
ENGINE AND ENGINE COOLING
2002 FORD F-250 PICKUP WITH A 5.4 LITRE ENGINE. SPARK PLUGS KEEP BLOWING OUT OF THE ENGINE. THE FORD SERVICE DEPARTMENT TELLS ME THEY SEE THIS OFTEN AND THEN PRESENT ME WITH A $400.00 BILL EACH TIME A SPARK PLUG BLOWS LOOSE. I'VE RECENTLY LEARNED THAT THIS CAN ALSO RESULT IN AN ENGINE FIRE BECAUSE THE COMPRESSED GAS AND AIR MIXTURE ARE BEING BLOWN THROUGH THE SPARK PLUG HOLE, WHILE THE LOOSE PLUG CONTINUES TO FIRE NEARBY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10242803September 18, 2008
SERVICE BRAKES, HYDRAULIC, STEERING
I EXPERIENCED A LEAK IN THE POWER STEERING HOSE FROM THE POWERSTEERING PUMP TO THE HYDRABOOST ON MY 2002 FORD F250 WHILE DRIVING IN THE MOUNTAINS PULLING A 30FT. 5TH WHEEL TRAILER. I HAD TO USE 1 GALLON OF FLUID TO RETURN 90 MILES. ACCORDING TO ANOTHER MECHANIC, THIS IS A COMMON FAILURE AND IS DUE TO POOR DESIGN AND ENGINEERING THIS HOSE IS CARRIED BY THE LOCAL DEALER AND THEY INDICATED THAT IT HAS A HIGH FAILURE RATE. THIS FAILURE RESULTS IN LOSS OF POWERSTEERING AND POWER BRAKES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10242651September 17, 2008
VEHICLE SPEED CONTROL
TL*THE CONTACT OWNS A 2004 FORD F250 SUPERDUTY. WHILE IDLING AT A RED LIGHT, THE VEHICLE UNINTENTIONALLY ACCELERATED. CURRENTLY, THE VEHICLE CONSTANTLY ACCELERATES ON ITS OWN. THE VEHICLE HAS NOT BEEN DIAGNOSED BY A MECHANIC OR DEALER AT THIS TIME. THE CURRENT MILEAGE WAS 92,000 AND FAILURE MILEAGE WAS 90,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10242682September 17, 2008
ENGINE AND ENGINE COOLING
MY 2000 F-250 V-10 PICKUP HAS ONLY 53K MILES. IT SUDDENLY STARTED RUNNING VERY ROUGH THIS WEEK. I TOOK IT TO THREE SHOPS AND PAID FOR DIAGNOSTICS. ALL THREE GAVE ME DIFFERENT REPORTS STATING THAT THE ENGINE IS BLOWN. I CALLED THE DEALER AND FOMOCO IN DETROIT. I WAS TOLD THAT I AM UP THE CREEK...LITERALLY. THE REPAIR IS TOO COSTLY FOR ME AND I CAN'T AFFORD A NEW TRUCK AS THIS PILE COST ME ALMOST 18K INCLUDING FINANCE CHARGES. MY WARRANTY WAS UP LAST YEAR AS I BOUGHT THE 100K EXT WARR. I GOOGLED THE V-10 F-250 AND FOUND MANY COMPLAINTS INVOLVING COIL PACK PROBLEMS AS THE ROOT OF THIS ENGINE'S BLOWING. THE COIL PACKS ARE NOT THE PROBLEM, BUT INDEED CAUSE FOR US CONSUMERS TO GO TO THE DEALER WHERE THEY BILK THOUSANDS OUT OF US SINCE THESE ENGINES BLOW VERY EASILY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10242499September 16, 2008
ENGINE AND ENGINE COOLING
ON SUNDAY, AUGUST 14, 2008 I WAS DRIVING MY 2001 FORD F-250 WITH A 5.4 LITER ENGINE AND I HEARD A LOUD POP WHICH WAS FOLLOWED BY A LOSS OF POWER AND A NOISE THAT SOUNDED LIKE A LARGE EXHAUST LEAK. WHEN I OPENED THE HOOD I NOTICED ONE OF THE SPARK PLUGS HAD BLOWN OUT OF THE HEAD AND HAD BROKEN THE COIL, RIPPED THE SPARK PLUG BOOT AND STRIPPED THE HEAD. THIS IS THE SECOND TIME IN 1 1/2 YEARS THAT I HAVE HAD A SPARK PLUG BLOW OUT OF THE HEAD. (THESE WERE TWO DIFFERENT SPARK PLUGS). THIS IS A COSTLY REPAIR AND MANY OTHERS HAVE HAD THE SAME PROBLEM. I CONTACTED FORD AND THEY TOLD ME THERE WAS NOTHING THEY COULD DO TO HELP ME AND THEN TRIED TO SELL ME A NEW VEHICLE INSTEAD OF FIXING THE ONE I HAVE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10242370September 16, 2008
SUSPENSION:FRONT, SUSPENSION:REAR
WHEN TRAVELING OVER MILDLY ROUGH ROADS AT SPEED (45 AND ABOVE) THE TRUCK STARTS SHAKING AND THE STEERING WHEEL OSCILLATES TO THE POINT WHERE IT IS HARD TO HOLD ON TO IT. THE ONLY WAY TO STOP THE SHAKING IS TO STEER TO THE LEFT OR RIGHT ABRUPTLY OR SLOW TO 30 MPH OR LESS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10242438September 16, 2008
ELECTRICAL SYSTEM, POWER TRAIN, STEERING, STRUCTURE
TL*THE CONTACT OWNS A 2001 FORD F-250 SD. WHEN THE GEAR SHIFTER IS USED, IT CAUSES THE ACCELERATOR PEDAL FUSE TO BLOW. SMOKE APPEARED OUT OF THE STEERING COLUMN. THE CONTACT BELIEVES THAT THE FAILURE WAS DUE TO BURNED WIRES AND ALL OF THE ISSUES WERE CONNECTED TO THE STEERING COLUMN ELECTRICAL SYSTEM. HE BELIEVES THAT THE WIRES WERE BURNED IN THE STEERING COLUMN. THE TOW PACKAGE BURNED AND THE RIGHT TURN SIGNAL AND BRAKE LIGHTS NO LONGER WORK. ALL OF THE DOORS APPEARED TO BE SHORT AND DO NOT CLOSE OR OPEN PROPERLY. IN ADDITION, THE OVERDRIVE FAILED ON THE STEERING COLUMN. WHEN THE CONTACT PRESSES THE BUTTON, NOTHING HAPPENS. THE DEALER STATED THAT THE VEHICLE WAS NOT UNDER WARRANTY AND DOES NOT HAVE ANY SAFETY RECALLS THAT APPLY TO THE VIN. THE CONTACT WOULD BE RESPONSIBLE FOR THE REPAIR COSTS. THE FAILURE MILEAGE WAS 142,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10242069September 13, 2008
SEAT BELTS
SEAT BELT ON DRIVER SIDE WILL NOT LATCH EVERY TIME. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10241882September 11, 2008
SUSPENSION, STEERING
TL*THE CONTACT OWNS A 2006 FORD F-250 SD. WHILE DRIVING APPROXIMATELY 70 MPH OVER RAILROAD TRACKS, THE SUSPENSION AND STEERING WHEEL SHIMMIED SEVERELY. THERE WERE NO WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, BUT WAS NOT DIAGNOSED BY A TECHNICIAN. THE VEHICLE WAS NOT REPAIRED. RECENTLY, THE STEERING WHEEL GEAR BOX FAILED. CURRENTLY, THE VEHICLE IS UNABLE TO BE DRIVEN AND STILL HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 70,000 AND CURRENT MILEAGE WAS 78,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10241663September 10, 2008
SUSPENSION:FRONT, STEERING
I HAVE AN 06 F250. WHILE DRIVING AT APPROX. 40-45 SINCE I VE HAD THE TRUCK NEW I HAVE HAD MAJOR WOBBLE. YESTERDAY ON THE INTERSTATE I WAS DRIVING MY FAMILY BACK FROM DISNEYLAND AND HIT A POTHOLE AROUND 70MPH. THE TRUCK SHOOK OUT OF CONTROL IT WAS ALL I COULD DO TO GET THE TRUCK TO THE SHOULDER. I HAVE TAKEN THE TRUCK IN SEVERAL TIMES AND HAVE BEEN TOLD NO PROBLEMS. PLEASE DO SOMETHING BEFORE SOMEONE GETS KILLED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10241698September 10, 2008
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
TL*THE CONTACT OWNS A 2002 FORD F-250 SUPER DUTY. THE CONTACT STATED THAT THE BOLTS ON THE EXHAUST MANIFOLD SNAPPED OFF ON THREE DIFFERENT OCCASIONS. THE FAILURE WAS BROUGHT TO HIS ATTENTION BY HIS MECHANIC DURING ROUTINE MAINTENANCE. THE DEALER AND MANUFACTURER HAVE NOT BEEN NOTIFIED BECAUSE THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE VEHICLE HAS NOT YET BEEN REPAIRED. THE CURRENT MILEAGE WAS APPROXIMATELY 79,000 AND FAILURE MILEAGE WAS APPROXIMATELY 30,000. UPDATED 10/20/08. *LJ UPDATED 10/20/08. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10241782September 10, 2008
STEERING
2006 FORD F250 SHAKES VIOLENTLY WHEN HITTING A BUMP ON HIGHWAY. THIS IS A VERY DANGEROUS SITUATION. THE SHAKING IS SO VIOLENT THAT IT CAUSES YOU TO TEMPORARILY LOOSE CONTROL UNTIL YOU GET THE VEHICLE STOPPED. FORD IS AWARE OF THE PROBLEM AND ISSUED A TECHNICAL SERVICE BULLETIN. HOWEVER, IT REQUIRES SEVERAL TRIPS TO THE DEALER. AFTER REPLACING THE DAMPENER ON THE FRONT END IT QUIT. THE SHAKING IS STARTING AGAIN AFTER ONLY 10,000 MILES. THIS IS DANGEROUS AND FORD NEEDS TO ADDRESS IT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10241434September 9, 2008
SUSPENSION:FRONT
DRIVING ON HIGHWAY AT SPEEDS OF 65 MPH, GOING OVER A BUMP ON THE ROAD, THE FRONT END STARTS SHAKING VERY BAD UNTIL YOU GET BELOW 40 MPH, IT IS ALL YOU CAN DO TO KEEP IT UNDER CONTROL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250