Ford F-250 Complaints

11,199 consumer complaints on file.

#10426658September 21, 2011
STEERING
TL* THE CONTACT OWNS A 2006 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING 70 MPH OVER SMALL ROAD BUMPS, HE LOST CONTROL OF THE STEERING. THE VEHICLE BEGAN TO VIOLENTLY SHAKE UNTIL THE CONTACT STOPPED THE VEHICLE. THE FAILURE RECURRED WHENEVER THE CONTACT DROVE OVER ROAD BUMPS AT HIGHWAY SPEEDS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE FAILURE WAS A COMMON OCCURRENCE. THE STEERING LINKAGES AND STEERING DAMPENER WERE REPAIRED. THE FAILURE RECURRED ONCE FOLLOWING REPAIRS. THE FAILURE MILEAGE WAS 43,200. UPDATED 10/13/11 *BF UPDATED 01/12/12
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10426426September 20, 2011
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING
TL* THE CONTACT OWNS A 1997 FORD F-250. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER FOR REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE STORAGE: TANK ASSEMBLY: MOUNTING). THE CONTACT WAS INFORMED THAT THE RECALL REPAIRS COULD NOT BE PERFORMED BECAUSE THE RUSTED FUEL TANK STRAPS CAUSED FRICTION AND CREATED A HOLE IN THE FUEL TANK AND CAUSED FUEL TO LEAK. THE TANK WAS NOT COVERED IN THE RECALL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 77,989 AND THE CURRENT MILEAGE WAS 77,944. UPDATED 10/14/11 *BF THE COSNSUMER WAS ALSO INFORMED HE MUST PAY FOR A RUSTED FILLER NECK AT A COST OF $ 319.52.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10426540September 20, 2011
ELECTRICAL SYSTEM, POWER TRAIN
TRUCK BEGAN BLOWING FUSE #45, RESULTING IN A LOSS OF INSTRUMENTS AND NO THROTTLE ACTIVATION AVAILABLE. SEEMS TO OCCUR MOST OFTEN WHEN TURNING LEFT, AND/OR WHEN SHIFTING FROM PARK OR REVERSE INTO DRIVE, OR DRIVE INTO REVERSE OR PARK. HAS RESULTED IN A LOSS OF POWER IN ALL OF THE ABOVE SITUATIONS, WITH THE ENGINE ONLY IDLING. IF THIS OCCURS WHILE HEADING UPHILL, VEHICLE WILL NOT MOVE. INTERNET SEARCH REVEALS THIS SEEMS TO BE A FAIRLY COMMON PROBLEM, AND IS DUE TO INSULATION BEING RUBBED OFF PART OF THE WIRING HARNESS THAT RUNS THROUGH THE STEERING COLUMN. SAME RESEARCH INDICATES FORD CHANGED THE ROUTING OF THE WIRING HARNESS IN LATE 2003. I BELIEVE THIS SITUATION SHOULD BE REPAIRED FREE OF CHARGE BY FORD. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10425995September 19, 2011
ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 2003 FORD F-250 SUPERDUTY. THE CONTACT WAS DRIVING 40 MPH WHEN THE VEHICLE STALLED AND FAILED TO RESTART. THE VEHICLE WAS TOWED TO THE DEALER BUT WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 108,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10427254September 19, 2011
ENGINE AND ENGINE COOLING
WHILE TRAVELING ON VACATION WITH A TRAVEL TRAILER IN TOW, THE TEMPERATURE GAUGE ON OUR 2006 FORD-F-250 (WITH A 5.4 LITER ENGINE) INDICATED THE ENGINE WAS OVERHEATING. AFTER STOPPING SEVERAL TIMES ON THE BERM OF AN INTERSTATE, THERE WAS NO INDICATION THAT THE ENGINE WAS HOT. SINCE WE WERE TRAVELING ON A HOLIDAY, THE TRUCK WAS FIRST TAKEN TO A PEP BOYS LOCATION WHERE THEIR EVALUATION SHOWED THERE WAS NO SIGN OF OVERHEATING. WE WERE ADVISED OF A SERVICE BULLETIN ISSUED ON THIS VEHICLE STATING THAT IT MIGHT EXHIBIT FALSE OVERHEATING. SO, WE CONTINUED OUR TRIP. TRUCK CONTINUED TO DISPLAY FALSE READINGS AND THE ENGINE STARTED TO DERATE. AT THIS TIME, WE HAD TO HAVE THE TRUCK TOWED TO A FORD DEALERSHIP, WHERE THEY INSTALLED AN UPDATED COOLANT CROSSOVER TUBE AND THERMOSTAT HOUSING TO CORRECT THE PROBLEM OF FALSE OVERHEATING. THIS WORK WAS DONE (PARTS & LABOR) AT A COST TO US OF $645.67 AFTER AAA DISCOUNT. THE COST TO US WAS A SURPRISE, AS THE DEALERSHIP WAS AWARE OF THE PROBLEM AND KNEW EXACTLY WHAT WAS NEEDED TO BE DONE TO RECTIFY IT. WE WERE TOLD THAT THIS KNOWN PROBLEM WAS A SERVICE BULLETIN NOT A RECALL BECAUSE IT IS NOT CONSIDERED A SAFETY ISSUE. HOWEVER, IT WAS VERY MUCH A SAFETY ISSUE FOR US AS WE WERE COMPELLED TO STOP SEVERAL TIMES ON THE SIDE OF A BUSY INTERSTATE BEFORE HAVING TO REQUEST THAT THE PICKUP AND TRAVEL TRAILER BE TOWED TO A SAFE LOCATION.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10426291September 19, 2011
FUEL SYSTEM, DIESEL
THE DEF TANK CONTINUES TO THROW A CHECK ENGINE LIGHT WARNING. ACCORDING TO THE DEALER FORD KNOWS ABOUT THE PROBLEM AND THERE IS NO CURRENT FIX TO THE ISSUE. MY DEF TANK WAS REPLACED WITH A UNIT OFF ANOTHER VEHICLE ON THE LOT AND WAS TOLD THAT I COULD BE LEFT STRANDED IF THE LIGHT CONTINUES TO STAY ON. SAN TAN FORD HAD NO FIX FOR THE PROBLEM UNTIL FORD RELEASE A FIX AND ACCORDING TO THE SERVICE MANAGER THERE ARE 120 PEOPLE WAITING FOR TANKS. HOW CAN FORD CONTINUE TO SELL THESE F250'S IF THE DEF TANKS ARE NOT WORKING AND LEAVE THE VEHICLE OUT OF WORKING ORDER. THIS IS A SERIOUS SAFETY ISSUE IF THE VEHICLE DISABLES ITSELF AT ANYTIME DUE TO THIS PROBLEM! THERE NEEDS TO BE SOME PRESSURE PUT ON FORD TO GET THESE VEHICLES IN WORKING ORDER AND PEOPLE SHOULD BE MADE AWARE OF THIS PROBLEM IF THEY ARE SPENDING OVER $50,000 ON A NEW VEHICLE THAT MAY AT ANYTIME STOP WORKING WITH NO FIX AVAILABLE. NEED TO RECALL ASAP, PEOPLE ALL OVER THE FORUMS ARE COMPLAINING OF THE ISSUE AND REMOVING THESE POLLUTION EQUIPMENT TO HAVE THEIR VEHICLES WORKING CORRECTLY. NOT GOOD BUSINESS FORD! *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10426295September 19, 2011
SUSPENSION, STEERING
WHEN DRIVING HIGHWAY SPEEDS I NEVER KNOW WHEN THE FRONT END IS GOING TO VIOLENTLY SHAKE SO BAD THAT I CAN'T SEE OUT THE REAR VIEW MIRRORS TO EVEN KNOW WHO IS AROUND ME WHEN MY TRUCK IS COMPLETELY OUT OF CONTROL. I CAN'T BELIEVE SOMEONE HAS NOT DIED YET! IT'S NOT IF, BUT WHEN. A JOINT IN THE ROAD, POT HOLE, OR JUST A PAVEMENT IRREGULARITY CAUSES IT, BUT I NEVER KNOW WHEN. I'VE ASKED SERVICE AND SALES TECHS AT BOTH PHIL LONG FORD/LITTLETON, CO AND LAKEWOOD FORD/LAKEWOOD, CO AND RECEIVED THE SAME LINE OF CRAP, THAT I'M THE FIRST PERSON WHO EVER MENTIONED IT. CHECK MY TIRE PRESSURE IS WHAT I'M TOLD. ALL I HAD TO DO WAS GOOGLE THE PROBLEM AND I FOUND A SEEMINGLY ENDLESS LIST OF COMPLAINTS OF THE EXACT SAME PROBLEM. THIS SITE WAS ALREADY AWARE OF THE PROBLEM BECAUSE WHEN I WENT TO SELECT THE "FAILED COMPONENTS", STEERING WAS ALREADY HIGHLIGHTED. THIS IS A $50,000 TRUCK I'M AFRAID TO DO THE SPEED LIMIT IN. LOADED OR UNLOADED, PULLING A TRAILER OR NOT, THE PROBLEM CAN PRESENT ITSELF. HOW MANY COMPLAINTS OR DEATHS DOES IT TAKE BEFORE FORD IS HELD RESPONSIBLE FOR THIS DEFECT? *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10425848September 17, 2011
FUEL SYSTEM, GASOLINE
STALLS OUT AFTER HOT RUN AND WONT RESTART UNTIL COOLS DOWN AND SOMETIMES AFTER COOL DOWN IT WONT START WITHOUT USING ASTARTER FLUID.STARTS STALLING AROUND 60 MPH.THIS IS A 6.0 DIESEL TRUCK.HAS STOPPED RUNNING RUNNING DOWN THE ROAD AFTER YOU LET OFF GAS PEDAL.HAVE NOTIFIED FORD OF THIS PROBLEM AND FOUND THAT THERE WAS A RECALL ON THIS TRUCK.WAS TOLD THAT THERE IS NOT A RECALL BY FORD WHEN I CALLED THEM. *TT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10425534September 15, 2011
STEERING, SERVICE BRAKES, HYDRAULIC, SUSPENSION
SHIMMY- THE SHIMMY PROBLEM THAT OCCURS IN THE 4X4 F250 SHOULD STILL BE A SIGNIFICANT ISSUE FOR THOSE OF US THAT STILL OWN THESE TRUCKS. THE DEALER TRIED THE TIRE INFLATION STORY WITH ME, BUT THAT DID NOT CORRECT THE PROBLEM. ROAD RACING SPORT CARS FOR MANY YEARS I KNOW THAT ONE POUND CAN MAKE A DIFFERENCE IN HANDLING AND I MADE SURE THAT THE TIRES WERE INFLATED CORRECTLY. THEN THEY TOLD ME THAT FORD SENT THEM A NEW SET OF ALIGNMENT SPECS. WELL AS WE ALL KNOW NOW THAT DID NOT FIX IT EITHER. THEN THEY TOLD ME THAT THE TIRES BEING CUPPED WAS CAUSING THE SHIMMY, MY RESPONSE TO THAT WAS THAT IT WAS THE SHIMMY CAUSING THE TIRES TO CUP NOT THE TIRES BEING CUPPED CAUSING THE SHIMMY, ALTHOUGH THE WORSE THE CUPPING, THE WORSE THE SHIMMY. AFTER INSISTING ON NEW TIRES AND THEN THE NEW LINE UP SPECS, WE TRIED IT AGAIN. THEN 960 MILES LATER AND ONLY ROAD DRIVING THE SAME CUPPING WAS HAPPENING AGAIN. THEN IT WAS THE DAMPENER AND ATTACH POINT THAT WAS THE PROBLEM. THEN 2 YEARS LATER CAME THE LETTER ABOUT DECELERATING AND APPLYING THE BRAKES AND THEN ABOUT 45 MPH IT SHOULD FIX IT. I GUESS THAT WOULD BE OK UNTIL YOUR GOING DOWN THE INTERSTATE AT 70 MPH WITH AN 18 WHEELER BEHIND YOU GOING 70 MPH. WOULD IT BE OK AFTER WHAT COULD BE A SERIOUS AND POSSIBLY FATAL ACCIDENT THAT I COULD PULL OUT MY LETTER THAT I GOT FROM FORD AND TELL EVERYONE, SORRY BUT I DRIVE A FORD. *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10425566September 15, 2011
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 1997 FORD F-250 HD. WHILE DRIVING APPROXIMATELY 40 MPH, THE CONTACT HEARD A LOUD NOISE COMING FROM OUTSIDE OF THE VEHICLE AND ALSO SMELLED A SLIGHT BURNING ODOR. UPON REACHING THE DESTINATION THE CONTACT NOTICED BOTH FUEL TANK STRAPS WERE FRACTURED WHICH WERE SUPPORTING THE FRONT FUEL TANK. THE VEHICLE WAS EQUIPPED WITH A DUAL FUEL TANK. AS A RESULT OF THE DRAGGING OF THE FRONT FUEL TANK, THERE WAS DAMAGE WHICH CAUSED A LARGE FUEL LEAK. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10425588September 15, 2011
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING
TL* THE CONTACT OWNS A 1997 FORD F-250. THE CONTACT STATED THAT THE FUEL TANK WAS RUSTED, WHICH CAUSED A FUEL LEAK. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING) BUT DID NOT WANT TO MOUNT A RUSTED TANK. NEITHER THE DEALER NOR MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 138,048. UPDATED 1/20/12 *CN THE CONSUMER STATED THE GAS TANK WAS LEAKING, DUE TO RUSTED MOUNTED STRAPS. UPDATED 02/01/12
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10425637September 15, 2011
POWER TRAIN:AUTOMATIC TRANSMISSION, ENGINE AND ENGINE COOLING:ENGINE
TRUCK STALLS WHEN SHIFTING FROM 2ND TO 3RD GEAR, WHEN PULLING ON TO HIGHWAY. *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10425394September 14, 2011
ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 2006 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, HE NOTICED THAT THE VEHICLE WAS OVERHEATING. AFTER PULLING OVER HE NOTICED THAT THERE WAS SMOKE COMING FROM THE ENGINE AND THAT THERE WAS NO COOLANT IN THE RESERVOIR. THE VEHICLE WAS NOT INSPECTED BY A DEALER NOR REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED HIM THAT THE VEHICLE WOULD HAVE TO BE DIAGNOSED AT A DEALER BEFORE GOING ANY FURTHER. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 89,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10425476September 14, 2011
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 1997 FORD F-250. THE CONTACT STATED THAT THE VEHICLE WAS PARKED WHEN SHE SMELLED A FUEL ODOR. UPON EXAMINING THE VEHICLE, THE CONTACT NOTICED THAT THE FUEL TANK WAS LEAKING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE CONTACT WAS INFORMED THAT THE STRAPS WHICH HELD THE FUEL TANK IN PLACE CORRODED THROUGH THE FUEL TANK. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING). THE FAILURE MILEAGE WAS 71,506.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10425237September 13, 2011
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 1999 FORD F-250 SD. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 30 MPH HE HEARD A LOUD NOISE. HE NOTICED THAT THE FUEL TANK DETACHED FROM THE VEHICLE AND BOTH STRAPS WERE CORRODED. THERE WAS NO FUEL SPILLING OUT OF THE VEHICLE ONCE THE TANK FELL OFF. THE VEHICLE WAS NOT INSPECTED BY A DEALER NOR WAS IT REPAIRED. THE MANUFACTURER WAS CONTACTED AND ADVISED HIM THAT THERE WERE NO RECALLS ON HIS VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 161,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10425288September 13, 2011
POWER TRAIN
POWER TRAIN HAD REAR MAIN SEAL FAILURE AROUND THIS DATE. POWER TRAIN HAS ANOTHER FAILURE AND LEAK IN SEPTEMBER OF THE SAME YEAR WHICH FORD WILL NO LONGER FIX. VEHICLE HAS LESS THAN 100,000 MILES AND ONLY APPROX 81,000 WHEN THE POWER TRAIN BEGAN TO HAVE PROBLEMS. THIS VEHICLE HAS SEVERAL OTHER ISSUES WHICH FORD WILL NOT ADDRESS. THE CUSTOMER ASSISTANCE CENTER AND THE COMPANY REP WILL ONLY OFFER HALF OFF ON REPAIRS WHICH THEY CLAIM THEY ARE NOT RESPONSIBLE FOR AND WILL NOT ACKNOWLEDGE THE PAST OR OTHER CURRENT PROBLEMS THE VEHICLE IS HAVING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10424761September 12, 2011
SUSPENSION, STEERING
DURING HIGHWAY SPEEDS AND YOU HIT A SET OF BUMPS OR A SINGLE BUMP MY TRUCK WILL VIOLENTLY SHAKE AT THE FRONT END. IT FEELS LIKE THE WHOLE FRONT END OF THE TRUCK IS COMING APART! FORD WILL NOT ADMIT ANYTHING IS WRONG.. THERE ARE COUNTLESS ENTRIES ABOUT THIS ALL OVER THE WEB.. IS SOMEBODY GOING TO DO SOMETHING?? *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10424752September 12, 2011
ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 2003 FORD F-250. WHILE DRIVING 55 MPH, THE CONTACT HEARD A LOUD THUMP AND BEGAN TO SMELL GASOLINE FUMES ENTERING THE VEHICLE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO DIAGNOSED THE VEHICLE WITH A BLOWN SPARK PLUG. THE DEALER WAS UNAWARE OF THE FAILURE AND ADVISED HIM TO BRING THE VEHICLE IN FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS AWARE OF THE FAILURE. NO REPAIRS WERE PERFORMED. THE CURRENT AND FAILURE MILEAGES WERE 75,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10425046September 12, 2011
FUEL SYSTEM, GASOLINE
TL*THE CONTACT OWNS A 1999 FORD F250. WHILE DRIVING 5 MPH, BOTH STRAPS FOR THE FUEL TANK FRACTURED, CAUSING THE FUEL TANK TO DETACH FROM THE VEHICLE. IN DOING SO, THE BRAKE LINES WERE FRACTURED. BOTH THE FUEL TANK AND THE BRAKE LINES BEGAN LEAKING FLUIDS. THE VEHICLE WAS TOWED TO A LOCAL SERVICE STATION WHERE THE FUEL STRAPS, REAR MAIN BRAKE LINE AND THE FUEL SENDING UNIT WERE REPLACED. THE DEALER AND THE MANUFACTURER WERE CONTACTED AND STATED THERE WERE NO RECALLS FOR THE FAILURE AND OFFERED NO FURTHER ASSISTANCE. THE FAILURE MILEAGE WAS 113,665.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10424288September 8, 2011
STEERING
TL* THE CONTACT OWNS A 2011 FORD F-250 SD. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 35 TO 45 MPH THE VEHICLE WOULD DRIFT FROM LEFT TO RIGHT WITHOUT ANY WARNING. THE VEHICLE WAS NOT INSPECTED BY A DEALER NOR HAD IT BEEN REPAIRED. THE DEALER WAS CONTACTED AND ADVISED HIM THAT THEY WERE NOT AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 13,000. THE VIN WAS UNAVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250