Ford F-250 Complaints

11,199 consumer complaints on file.

#10438947December 7, 2011
STEERING, SUSPENSION
UPON HITTING A BUMP AT 30 TO 40 MPH , STEERING VEERS FROM SIDE TO SIDE, ALSO KNOWN AS THE "DEATH WOBBLE"VERY UNSETTLING TO SAY THE LEAST,AFTER SOME RESEARCH ONLINE I WAS SHOCKED TO SEE THAT OTHER FORD 4X4 OWNERS HAVE THE SAME THING. I FOUND A COMPANY THAT SAYS THE STEERING GEOMETRY IS WRONG AND HAVE A FIX, WC MOTORSPORTS (508-203-9450)THIS SHOULD NOT BE HAPPENING , MY TRUCK HAS UNDER 40,000 MILES AND I AM AFRAID TO DRIVE IT. IT IS OBVIOUS THAT SOMETHING IS WRONG AND FORD HAS BEEN IGNORING FOR YEARS. WHAT DO I DO ?DO YOU WANT TO BUY IT? [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10438758December 6, 2011
STEERING, SUSPENSION
WHILE DRIVING OVER A SET OF RAILROAD TRACKS, ALMOST LOST CONTROL OF VEHICLE. TOOK IT TO FORD GARAGE, THEY TEST DROVE IT. REPLACE STEERING BOX. TWO YEARS LATER. STEERING PUMP BROKE, AND THE NEW STEERING BOX BROKE, WHILE DRIVING. VEHICLE IS PARKED, AND WILL REMAIN PARKED. DROVE THE VEHICLE LAST WEEK AND EXPERIENCED THE SAME INCIDENT. COULD NOT TURN THE STEERING WHEEL. TURNED TO THE LEFT, WHEN I TRIED TO TURN TO THE RIGHT, IT WOULD NOT TURN. WAS DRIVING AT ABOUT 40MPH. WENT OFF THE ROAD. IT CONTINUES TO ACT THE SAME. THIS WOULD BE A GREAT VEHICLE TO TEST. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10438760December 6, 2011
STEERING
TL* THE CONTACT OWNS A 2006 FORD F-250 SD. WHILE DRIVING APPROXIMATELY 30 MPH, THE CONTACT DROVE OVER AN UNEVEN ROAD SURFACE AND THE STEERING WHEEL BEGAN TO SHIMMY, CAUSING THE VEHICLE TO MERGE INTO ANOTHER LANE. THE FAILURE WOULD RECUR WHEN ATTEMPTING A TURN AND USUALLY WHEN DRIVING BETWEEN 30-60 MPH. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTICS. THE CONTACT REFERENCED A CONCURRENT INVESTIGATION OF THE FAILURE UNDER NHTSA ACTION NUMBER: EA08007 (SUSPENSION:FRONT) THAT COULD POSSIBLY HAVE BEEN RELATED TO THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 65,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10438809December 6, 2011
SERVICE BRAKES, HYDRAULIC
REAR BRAKE BACKING PLATES RUSTED OUT. QUICK SEARCH ON THE INTERNET REVEALED THAT THIS IS A COMMON PROBLEM ON 2000-2008 FORD TRUCKS. PARKING BRAKE COMPONENTS ARE MOUNTED TO BACKING PLATE. LOSS OF PARKING BRAKES AND POSSIBLE DAMAGE TO REAR ABS IF THE PARKING BRAKE COMPONENTS SEPARATE FROM MOUNTS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10438592December 5, 2011
SUSPENSION
I JUST RECEIVED FROM FORD ANOTHER NOTICE ABOUT THE OUT OF CONTROL SHIMMING THAT TAKES PLACE CONCERNING THE 2005 F- 250 . FORD HAS DOES NOTHING TO CORRECT THIS PROBLEM OTHER THAN TO BLOW SMOKE AT EVERYONE ABOUT THE TIRE PRESSURE. SINCE I BOUGHT THIS UNIT NEW, THE TIRE HAVE ALWAYS BEEN CORRECTED TO THE PROPER AMOUNT OR THE CORRECT TIRES BEEN REPLACED. STILL THIS ISSUE TAKES PLACE . ITS AN UNBELIEVABLE TERRIFYING SHAKING THAT TAKES PLACE , AND ONLY STOPS WHEN THE TRUCK GETS TO ABOUT 20-25 MILES AN HOUR. THIS OCCURRED MOST RECENTLY, LAST THAT A CAR FOLLOWING ME , PULLED ME OVER TO TELL ME HOW IT LOOKED FROM THE REAR, TO THE POINT THE PERSON BEHIND ME WAS FEARFUL FOR THEIR SAFETY AS WELL. I REFUSE TO LET ANY MEMBER OF THE FAMILY DRIVE THIS TRUCK ,OTHER THAN MYSELF. THERE IS CERTAINLY MORE TO THIS ISSUE THAN WHAT FORD IS MAKING OUT TO BE AND ALL FORD WANTS TO DO IS BLOW SMOKE AT US ABOUT THE TIRE PRESSURE. I'VE TRIED TO SELL THIS UNIT TO NO AVAIL, AS THE DEALERS DON'T WANT TO TOUCH THIS UNIT AND OTHERS HAVE CHECKED ON LINE TO HAVE FOUND OUT ABOUT IT AND ASKED ME ABOUT IT , AND WANTING TO BE HONEST I TOLD THEM ABOUT IT. SO NOW I HAVE A TRUCK THAT I CAN'T EVEN SELL AT A DEEP DISCOUNT. THANKS FORD. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10438088December 2, 2011
VISIBILITY
TL* THE CONTACT OWNS A 2009 FORD F-250. THE CONTACT STATED THAT WHEN THE SUN SHINED ON THE WINDSHIELD, IT WOULD EMIT A GLARE OF RANGING COLORS. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING WHERE THE TECHNICIAN WAS UNABLE TO DIAGNOSE A FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 5,300.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10437820November 30, 2011
TIRES:TREAD/BELT, TIRES
TIRE SEPARATION. *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10437885November 30, 2011
ELECTRICAL SYSTEM:WIRING
TL* THE CONTACT OWNS A 2005 FORD F-250 SD. WHILE PARKED, THE CONTACT ATTEMPTED TO START THE VEHICLE BUT THE VEHICLE WOULD NOT START. THE VEHICLE WAS INSPECTED BY A MECHANIC AND A DIAGNOSTIC TEST WAS PERFORMED. THE MECHANIC STATED THERE WAS A FAILURE WITH THE FUEL INJECTOR CONTROL MODULE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 05V270000 (ELECTRICAL SYSTEM:WIRING) BUT WAS ADVISED BY THE MANUFACTURER THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 100,000. UPDATED 01/24/12*LJ UPDATED 01/25/12
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10437886November 30, 2011
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2004 FORD-250 SD. THE CONTACT WAS DRIVING 65 MPH WHEN THE ENGINE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE DEALER CONFIRMED THAT THE FUEL INJECTOR MODULE NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED THAT THE VEHICLE DID NOT QUAILFY FOR REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER : 05V270000(ELECTRICAL SYSTEM:WIRING). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 92,000 AND THE CURRENT MILEAGE WAS 120,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10437471November 28, 2011
ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 2010 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE VEHICLE DECELERATED TO 20 MPH. A SENSOR BEGAN TO ILLUMINATE, INDICATING THAT THE VEHICLE WAS CLEANING ITS EXHAUST. THE CONTACT ALSO STATED THAT THE VEHICLE DECELERATED DURING THIS FAILURE AND BEGAN TO AGAIN ACCELERATE ONCE THE SENSOR TURNED OFF. THE FAILURE RECURRED ON MORE THAN ONE OCCASION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS OPERATING AS NORMAL. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 42,600.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10437474November 28, 2011
STRUCTURE:BODY, POWER TRAIN:AUTOMATIC TRANSMISSION
VEHICLE HAS 7.3 LITER DIESEL ENGINE AND THE FORD 4R100 AUTOMATIC TRANSMISSION AND 4 WHEEL DRIVE. TRANSMISSION FAILED AT ABOUT 88,000 MILES DESPITE PROPER SERVICING SINCE NEW. IT WOULD INTERMITTENTLY STOP SHIFTING IN NORMAL USE AND BEGAN TO SLIP BADLY. ONLY SECOND GEAR WAS STILL WORKING WHEN I GOT IT TO THE DEALER THE NEXT DAY. THE TRANSMISSION WAS REPLACED AT MY EXPENSE ($3500+). THE REPLACEMENT TRANSMISSION FAILED IN A SIMILAR WAY AT ABOUT 135,000 MILES DESPITE BEING SERVICED AS REQUIRED BY THE DEALER. THEY ARE UNABLE TO OBTAIN A VALVE BODY FOR THIS TROUBLESOME ASSEMBLY AND IT HAS BEEN AT THE DEALER FOR NEARLY TWO WEEKS. THIS MODEL OF TRANSMISSION IS DEFECTIVE AND DANGEROUS ESPECIALLY IF YOU ARE TOWING AND LOSE ENGINE BRAKING DUE TO THE TRANSMISSION FAILING. FORD NO LONGER USES THIS TRANSMISSION AS IT HAS A HIGH FAILURE RATE. THE BODY HAS RUSTED THROUGH AT ONE OF THE CAB CORNERS AND OVER BOTH REAR WHEEL WELLS. FORD REPAIRED THE RUST THROUGH ONCE UNDER WARRANTY BUT THE RUST THROUGHS CONTINUE AND HAVE A NEGATIVE EFFECT ON THE INTEGRITY OF THE VEHICLE STRUCTURE AND PROTECTION OF IT'S OCCUPANTS IN THE EVENT OF A CRASH. A RUSTED BODY WOULD NOT PROTECT OCCUPANTS AS WELL AS AN AN UNRUSTED ONE. *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10437224November 24, 2011
STEERING, SUSPENSION
I WAS TRAVELING ON THE FREEWAY AT 60 MPH. THE VEHICLE WENT INTO A VIOLENT SHAKING AFTER GOING OVER AN UNEVEN ROAD SURFACE. THE VEHICLE JUMPED A HALF LANE OVER AND I HAD LOST CONTROL UNTIL MY SPEED WAS REDUCED. AT THAT TIME I WAS AFRAID OF SLAMMING ON THE BRAKES AND LOSING MORE CONTROL OR POSSIBLY FLIPPING OVER. NOW THIS VIOLENT SHAKING OCCURS EVERY TIME I HIT A POT HOLE OR ANY UNEVEN SURFACE AT 55 TO 60 MPH. I HAVE TAKEN MY VEHICLE TO FORD SERVICE AND THEY CAN NOT FIND ANY PROBLEM THAT WOULD CAUSE THE VIOLENT SHAKING. AFTER DOING SOME RESEARCH I FOUND A VIDEO OF THIS ON YOU TUBE AS "F-250 DEATH WOBBLE". THIS VIDEO SAYS IT ALL AND IS BASED ON A STOCK ORIGINAL EQUIPMENT F-250 SUPER DUTY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10436892November 23, 2011
ENGINE AND ENGINE COOLING
LEAKING RADIATOR HOSES CAUSING LOSS OF COOLANT FROM ENGINE. LEAK IS A HAZARD TO ENVIRONMENT AND WILDLIFE THAT MAY COME IN CONTACT WITH ETHYLENE GLYCOL. DEALER INDICATES A DESIGN ISSUE EXISTS WITH RADIATOR HOSE O-RINGS AND FORD HAS REDESIGNED THE HOSES TO USE DOUBLE O-RINGS VS. THE CURRENT SINGLE O-RING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10436535November 21, 2011
ENGINE AND ENGINE COOLING
TL*THE CONTACT OWNS A 2002 FORD F250 SD. WHILE DRIVING APPROXIMATELY 50 MPH, THE CONTACT HEARD A LOUD NOISE OUTSIDE OF THE VEHICLE AND SUDDENLY THERE WAS A REDUCTION IN THE ENGINE POWER. THE CONTACT MANEUVERED TO THE SIDE OF THE ROAD AND THEN RESUMED CAUTIOUSLY TO THE RESIDENCE. UPON REACHING THE DESTINATION THE VEHICLE WAS INSPECTED. THE CONTACT DETECTED ONE OF THE SPARK PLUGS EXPLODED FROM THE HEAD. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 142,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10436553November 21, 2011
FUEL SYSTEM, GASOLINE
I WAS DRIVING MY 1989 FORD F250 THAT I RECENTLY PURCHASED ON NOVEMBER 14TH 2011 AND WHEN I GOT HOME I SMELLED GASOLINE, UPON FURTHER INVESTIGATION I SAW FUEL RUNNING OUT OF THE FRONT FUEL TANK FILLER NECK PAST THE GAS CAP. I WAS USING THE REAR TANK AT THE TIME. I WENT ONLINE TO SEE IF ANYONE ELSE HAD ENCOUNTERED THIS PROBLEM AND FOUND THAT THERE WAS ACTUALLY A SAFETY RECALL ISSUED ON THIS PROBLEM FOR THIS TRUCK. I LOOKED UP THE VIN ON FORDS' WEBSITE AND IT SAID THERE WERE NO RECALLS ASSOCIATED WITH MY TRUCK, MY THOUGHT WAS THAT IT WAS PROBABLY BECAUSE IT WAS SO OLD IT WAS NO LONGER IN THEIR DATABASE. I CALLED MACE FORD IN TERRE HAUTE AND SPOKE WITH LANDIS IN THE SERVICE DEPARTMENT ON 21 NOVEMBER 2011 HE CHECKED AND SAID THERE WASN'T ANYTHING THEY COULD DO AND REFERRED MY TO THE FORD CUSTOMER SERVICE NUMBER WHICH I CALLED AND SPOKE TO [XXX] ALSO ON 21 NOVEMBER 2011, HE ALSO TOLD ME IT WAS NOT LISTED AND CHECKED WITH HIS SUPERVISOR'S AND THEY SAID IT DID NOT APPLY TO MY TRUCK. WHAT I DON'T UNDERSTAND IS MY TRUCK MEETS ALL OF THE CRITERIA THAT I CAN FIND LISTED IN THE FORD SAFETY RECALL NUMBER 91S39. IT IS A 1989 FORD F250 WITH DUAL FUEL TANKS AND ACCORDING TO THE DOOR PLATE IT WAS MANUFACTURED IN APRIL OF 1989. CAN YOU HELP ? THE SYMPTOMS ARE ACTUALLY AS DETAILED IN THE RECALL, THE BEING THAT FUEL IS FORCED FROM ONE FUEL TANK INTO ANOTHER OVERFLOWING THE TANK. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10435979November 15, 2011
ENGINE AND ENGINE COOLING
WHILE ON VACATION TRUCK STARTED LOSING POWER THEN STARTED BLOWING COOLANT FROM THE EXHAUST PIPE. CALLED AAA HAD TRUCK TOWED TO FORD DEALERSHIP WHERE THEY TOLD ME TRUCK HAD BAD EGR COOLER. NOT ONLY THAT BUT MY TRUCK WAS 8 MONTHS OUT OF WARRANTY. DEALERSHIP REPAIRED TRUCK, COST WAS OVER $2,500. NOT ONLY DID I HAVE TO TRAVEL 2 HOURS TO PICK MY TRUCK UP 3 DAYS LATER AFTER REPAIR, BUT FOUND ONLINE THEY ARE A LOT OF 6.0 POWER STROKE CUSTOMERS HAVING SAME ISSUE. I CONTACTED FORD WITH NO RESOLUTION, EVEN ASKED THE REPRESENTATIVE IF SHE COULD LOOK UP SOME OF THE SAME WEBSITES THAT I HAD, SHE REPLIED NO DUE TO RESTRICTION AT WORK. I THEN OFFERED TO EMAIL THE COMPLAINTS OF OTHERS TO THEM WHICH I WAS TOLD NO. I WAS TOLD MY NAME AND INFORMATION WOULD BE SAVED INCASE THERE WAS EVER A RECALL. THIS IS OBVIOUSLY A DEFECT WITH THIS ENGINE AND NEEDS TO BE ADDRESSED, AND CUSTOMERS REIMBURSED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10435978November 15, 2011
SUSPENSION, STEERING
BETWEEN SPEEDS OF 40-65MPH TRUCK WILL GO INTO "DEATH WOBBLE" AFTER HITTING A POTHOLE, ROUGH SPOT IN ROAD, OR DIPS ( EX. OVER PASSES, BRIDGES). TRUCK WILL SHAKE VIOLENTLY TO THE LEFT AND RIGHT ALMOST CAUSING A WRECK. ONCE THIS HAPPENS I HAVE TO LET OFF GAS APPLY BRAKE SLOWLY TILL TRUCK STOPS THE SHAKING. TRAFFIC BEHIND ME HAS TO BRAKE, ALMOST CAUSING ACCIDENTS, NOT TO MENTION HOW HARD IT IS TO CONTROL THE TRUCK WHEN THIS HAPPENS. I HAVE ALMOST HAD A WRECK EVERY TIME THIS HAD OCCURRED. FIRST STARTED WHEN I BOUGHT THE TRUCK IN FEB. 2010 WITH 52,500 MILES. STILL HAPPENS TO THIS DAY AFTER REPLACING FRONT END PARTS, TRUCK NOW HAS 68K MILES. I'VE RESEARCHED ONLINE AND THIS SEEMS TO BE AN ISSUE LOTS OF PEOPLE ARE HAVING, NOT TO MENTION IT IS ONGOING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10435519November 14, 2011
SUSPENSION, STEERING
DRIVING ALONG AT ABOUT 45 MPH, HIT A ROUGH PATCH OF PAVEMENT AND THE FRONT END OF THE TRUCK BEGAN TO BOUNCE AND THE STEERING WHEEL BEGAN TO OSCILLATE BACK AND FORTH, ALTHOUGH THE TRUCK DID NOT GO LEFT OR RIGHT FROM THE LINE OF TRAVEL. AFTER SLOWING DOWN THE TRUCK CAME BACK UNDER MY CONTROL, BOUNCE AND OSCILLATION STOPPED. THIS HAS HAPPENED NUMEROUS TIMES (WEEKLY), WITH THE ORIGINAL TIRES AND WITH REPLACEMENT TIRES. I HAVE HAD THE FRONT END ALIGNED AND TIRES BALANCED. I CHECK THE AIR PRESSURE WEEKLY. ALL OF THIS HAD NO AFFECT ON THE OSCILLATIONS. I WOULD DRIVE OVER THE SAME AREAS DAILY ANDCOULD CONTINUE TO REPEAT WHAT HAD HAPPENED BY DRIVING THE SAME SPEED OVER THE SAME PIECE OF BAD PAVEMENT. IT IS NO WORSE OR BETTER THAN WHEN IT FIRST HAPPENED. BUT HAVING MY WIFE DRIVE THE TRUCK AND HAVE THE SAME ISSUE CONCERNED ME. I DID RESEARCH THAT LED ME TO FIND OUT THAT THIS IS A PROBLEM AFFECTS NUMEROUS F-250S AND TO YOUR WEBSITE. I WISH I HAD COMPLAINED ABOUT THIS WHEN IT BEGAN, BUT MY TRUCK WAS OUT OF WARRANTY AND I THOUGHT I WAS OUT OF LUCK (STILL MAY BE). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10435125November 10, 2011
FUEL SYSTEM, GASOLINE
WE WHERE HAULING CATTLE DOWN THE HIGHWAY AND LOST POWER AT 2500 RPMS THIS WAS EXTREMELY DANGEROUS TO BE ON A HIGHWAY GOING 55 MPH WITH A LOAD OF CATTLE AND WITH NO WARNING THE TRUCK LOST POWER. WE TOOK THE TRUCK INTO THE FORD DEALERSHIP AND ARE NOW HAVING THE HIGH PRESSURE FUEL INJECTOR PUMP REPLACED. THE CAB OF THE TRUCK HAS TO BE TAKEN OFF TO WORK ON THIS PUMP IT WILL BE AT LEAST 18 HOURS OF LABOR. FORD HAS REDESIGNED THE NEWER MOTORS SO THAT THE HIGH PRESSURE FUEL INJECTOR PUMP IS NOW IN THE FRONT OF THE MOTOR. I REALLY THINK THIS SHOULD BE A RECALL BEFORE MORE PEOPLE HAVE THIS HAPPEN TO THEM PLEASE LOOK INTO THIS... *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10435129November 10, 2011
ELECTRICAL SYSTEM, ENGINE AND ENGINE COOLING
DRIVING DOWN THE HIGHWAY AND THE TRUCK PICKED UP SPEED BY ITSELF UNTIL IT REACHED 95 MPH THEN THE ENGINE BOGGED DOWN REPEATLY,THEN I SHUT THE ENGINE DOWN AND RESTARTED IT AND IT WORKED OK UNTIL EVENING THEN THE TRUCK FAILED TO START AND THE STARTER KEPT TURNING WITHOUT ME TOUCHING THE KEY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250