Ford F-250 Complaints

11,199 consumer complaints on file.

#10442482January 5, 2012
POWER TRAIN
TL* THE CONTACT OWNS A 2011 FORD F-250. THE CONTACT STATED THAT HE SHIFTED INTO DRIVE FROM REVERSE AND THE VEHICLE CONTINUED TO DRIVE IN REVERSE. THE CONTACT SHUT THE VEHICLE OFF AND IT OPERATED AS NORMAL UPON RESTART. THE FAILURE RECURRED APPROXIMATELY ONE YEAR LATER AND THE CONTACT CRASHED INTO A MAILBOX. NO INJURIES WERE REPORTED. IN ADDITION, THE CONTACT STATED THAT THE VEHICLE WOULD INTERMITTENTLY BEGIN ACCELERATING FROM STOPS IN FIFTH GEAR WHEN THE VEHICLE WAS SUPPOSED TO BE IN FIRST GEAR. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 1,700.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10442352January 4, 2012
ENGINE AND ENGINE COOLING
THIS VEHICLE SINCE THE LAST PCM UPDATE WHEN IT GOES INTO "CLEAN EXHAUST FILTER" MODE WILL SHOOT OUT HEAVY SMOKE FOR 2 MILES. THIS IS AN ENVIRONMENTAL POLLUTION AND ALSO A SAFETY HAZARD FOR DRIVERS BEHIND THE VEHICLE. THIS PROBLEM HAS BEEN ONGOING FOR MONTHS. DEALER STATES IT IS"NORMAL". *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10442346January 4, 2012
ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THE FUMES ENTER THE CABIN AND MAKE THE VEHICLE OCCUPANTS DIZZY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT THE BOLTS FOR THE ENGINE MANIFOLD CORRODED AND FRACTURED. THE DEALER STATED THAT THIS WAS A KNOWN FAILURE BECAUSE THE BOLTS WERE METAL AND THE FRAME WAS ALUMINUM. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 55,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10442378January 4, 2012
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING, FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWN A 1999 FORD F-250. THE CONTACT STATED THAT THE FUEL TANK STRAPS CORRODED AND CREATED A HOLE IN THE FUEL TANK. FUEL BEGAN TO LEAK AS A RESULT OF THE FAILURE. THE CONTACT RECEIVED A RECALL NOTICE ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 99V093001 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY), BUT THE DEALER WOULD NOT PERFORM THE REPAIRS DUE TO THE FUEL TANK LEAK. THE FAILURE MILEAGE WAS 160,000. UPDATED 02/09/12*LJ THE CONSUMER STATED FORD REPLACED TANK WHICH CAUSED STRAP FAUILRE. UPDATED 02/13/12
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10442409January 4, 2012
STEERING
TL* THE CONTACT OWNS A 2005 FORD F-250. WHILE DRIVING APPROXIMATELY 65 MPH, THE CONTACT DROVE OVER A BUMP AND THE VEHICLE BEGAN TO IMMEDIATELY VIBRATE VIOLENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHERE BOTH FRONT TIE ROD ENDS WERE REPLACED. THE CONTACT ALSO RECENTLY RECEIVED AN ADVISORY NOTIFICATION LETTER FROM THE MANUFACTURER IN REGARDS TO STEERING WHEEL AND FRONT END VIBRATIONS WHEN DRIVING OVER BUMPY ROAD SURFACES. THE MANUFACTURER ADVISED OWNERS TO MAINTAIN PROPER TIRE INFLATION. THE MANUFACTURER WAS NOTIFIED AND MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 20.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10442277January 3, 2012
ENGINE AND ENGINE COOLING
RADIATOR HAS FAILED FOUR TIMES. THE FOURTH TIME IT FAILED IT WAS OUT OF WARRANTY. FORD REFUSES TO ACKNOWLEDGE THE DEFECT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10441942December 31, 2011
FUEL SYSTEM, DIESEL
THE TRUCK STALLED AND SKIPPED ON THE INTERSTATE ALMOST CAUSING A COLLISION ON I 85. ACCORDING TO THE TECH THE FUEL INJECTION CONTROL MODULE GOES BAD IN ALMOST EVERY FORD F250 6.0 DIESEL ENGINE WHEN YOU HIT THIS MILEAGE. NOT SURE HOW WE CONTINUE TO GIVE FORD A PASS ON THIS COMMON ISSUE. *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10441724December 30, 2011
ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A OWNS A 2006 FORD F-250. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED DIFFICULTY ACCELERATING AT ALL SPEEDS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT ALL OF THE SPARK PLUGS FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 128,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10441780December 30, 2011
SUSPENSION
TL* THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT WAS DRIVING 60 MPH OVER A ROAD BUMP WHEN THE VEHICLE BEGAN TO SHAKE VIOLENTLY. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR A DIAGNOSTIC TEST BUT THE DEALER WAS UNABLE TO DEFECT THE CAUSES OF THE FAILURE. THE MANUFACTURER SUGGESTED ADDING FRONT DAMPERS TO THE VEHICLE BUT THE VEHICLE WAS ALREADY EQUIPPED WITH STOCK DAMPERS THAT DID NOT NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS CONCERNED WITH THE POSSIBILITY OF LOSING CONTROL OF THE VEHICLE WHEN THE FAILURE OCCURRED. THE FAILURE MILEAGE WAS 62,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10441772December 30, 2011
TIRES, TIRES:TREAD/BELT
TL* THE CONTACT OWNS A 2002 FORD F250 WITH DEFINITY DAKOTA A/T TIRES, SIZE LT 265/75R16, DOT NUMBER: UTW8PA91108. THE CONTACT WAS DRIVING 70 MPH WHEN THE TREAD SEPARATED FROM THE FRONT PASSENGER TIRE. THE CONTACT MERGED TO THE SHOULDER WHERE HE CHANGED THE TIRE AND INSTALLED THE SPARE. THERE WERE NO ROAD HAZARDS THAT COULD POSSIBLY HAVE CONTRIBUTED TO THE FAILURE. THE TIRE WAS TAKEN TO A LOCAL TIRE MERCHANT WHO RE-INSTALLED A NEW TIRE. A MONTH LATER WHILE DRIVING 70 MPH, THE FRONT DRIVER AND THE REAR PASSENGER SIDE TIRES EXPERIENCED TREAD SEPARATION, CAUSING DAMAGE TO THE FRONT DRIVER SIDE UNDER CARRIAGE. THE SPARE TIRE WAS INSTALLED O BOTH FAILED TIRES. THE TIRES WERE NOT INSPECTED FRO THE CAUSE OF THE FAILURE AND THE MANUFACTURER OF WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 160,000 AND THE CURRENT MILEAGE WAS 183,000. THE FAILURE MILEAGE OF THE TIRE WAS 15,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10441814December 30, 2011
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 1990 FORD F-250. THE CONTACT STATED THAT A DAYS AFTER SWITCHING ONE OF THE FUEL TANKS, FUEL STARTED TO SPEW OUT OF THE FILLER NECK. THE CONTACT STATED THAT ONCE THE CAP WAS RELEASE AND THE ENGINE WAS TURNED OFF, THE FUEL SPILL COULD BE STOPPED. THE VEHICLE WAS TOWED TO THE DEALER WHO DIAGNOSED THAT THE RETURN VALVE WAS STUCK BETWEEN THE TANKS, WHICH CAUSED FUEL TO ENTER THE SECOND TANK AND OVERFLOW. AS A RESULT THE FUEL PUMP FAILURE, THE JUMPER AND THE ROLL-OVER VALVES NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 93V125000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY). THE VEHICLE WAS REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 116,105.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10441407December 27, 2011
STEERING, SUSPENSION
AFTER "SHUTTER" INCIDENT (THIS HAS OCCURRED SINCE PURCHASED NEW) VEHICLE STEERING WOULD NO TURN TO THE LEFT. AFTER REPEATED ATTEMPTS A FULL RIGHT TURN THEN FAST FORCED LEFT TURN A POP/ CRACK OCCURRED WHICH THEN ALLOWED RESTRICTED LEFT TURN. STEERING LOCKED SEVERAL MORE TIMES WHILE TRYING TO SAFELY EXIT THE HIGHWAY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10441424December 27, 2011
STEERING, SUSPENSION
I WAS TRAVELING 70 MPH ON A 3 LANE INTERSTATE, IN THE LEFT LANE. I WENT OVER A BRIDGE EXPANSION JOINT AND THE TRUCK STARTED SHAKING VIOLENTLY AND WOULD NOT STOP UNTIL I PULLED OVER TO THE SHOULDER. I CHECKED TO SEE WHAT MAY HAVE CAUSED THE SHAKING AND FOUND NO VISIBLE DAMAGE, AND SO PROCEEDED WITHOUT ANY FURTHER ISSUES. THE VEHICLE IS STOCK WITH PROPER TIRES, SUFFICIENT TREAD, AND WERE INFLATED TO WITHIN 2 TO 3 POUNDS OF FORDS RECOMMENDED TIRE INFLATION (I CHECKED THE NEXT DAY). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10441257December 26, 2011
ELECTRICAL SYSTEM
THE VEHICLE LOST POWER AT APPROX. 65MPH ENGINE WENT INTO IDLE MODE WITHOUT ANY WARNING. I WAS ABLE TO AVOID OTHER VEHICLES ON THE INTERSTATE AND COASTED TO A STOP . THE ENGINE REMAINED IN IDLE MODE AND WHEN THE ACCELERATOR WAS PRESSED THE ENGINE DID NOT INCREASE IN RPMS. I TURNED THE OFF THE ENGINE AND WHEN TRYING TO RESTART IN TURNED OVER, BUT WOULD NOT FIRE UP. AFTER A COUPLE OF TRIES IT FINALLY STARTED AND I DROVE HOME. THE SECOND INCIDENT OCCURRED ON DEC.26TH 2011. THE TRUCK WAS DRIVEN TO THE STORE WITHOUT ANY PROBLEMS AFTER RETURNING AND TRYING TO START IT UP THE ENGINE WOULD NOT FIRE. FINALLY AFTER A COUPLE OF TRIES IT FINALLY STARTED AND I DROVE APPROX. TWO MILES , PULLED INTO THE DRIVEWAY AND IT WENT INTO IDLE MODE AGAIN. I TURNED THE ENGINE OFF BUT IT WILL NOW NOT RESTART. I WILL HAVE TO GET IT TOWED TO A REPAIR SHOP, THIS COULD HAVE HAD VERY SERIOUS CONSEQUENCES . THE INTERSTATE TRAFFIC WAS LITE AND I WAS ABLE TO SWITCH LANES EVEN THOUGH I WAS COASTING WITHOUT POWER WITH THE ENGINE IDLING. A COUPLE OF VEHICLES HAD TO HIT THE BRAKES AS I MOVED OVER. IF I HAD COME TO A STOP IN THE MIDDLE OF THE INTERSTATE WITHOUT POWER IT COULD HAVE EASILY RESULTED IN A MAJOR ACCIDENT. WITH THE POTENTIAL LOSS OF LIFE OR SERIOUS INJURY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10441144December 24, 2011
SUSPENSION, STEERING
MY 2005 F250 SUPER DUTY PICKUP TRUCK VIBRATES VIOLENTLY WHEN I CROSS A BUMP IN THE ROAD AT 65 MPH OR HIGHER. THIS IS VERY DANGEROUS BECAUSE IT IS BOUNCING SO MUCH THAT THE STEERING AND BRAKES DO NOT WORK PROPERLY. SO FAR THIS HAS ONLY HAPPENED DURING TRAVELING ON A STRAIT STRETCH. IF IT WHERE ON A CURVE, IT WOULD BE IMPOSSIBLE TO STEER. SOMETIMES IT VIBRATES INTO THE OTHER LANE. IT IS VERY SCARY. FORD ISSUED A SERVICE NOTICE NOVEMBER 2011 STATING TIRE INFLATION IS THE PROBLEM. THIS IS NOT THE PROBLEM AS THE TIRES ARE INFLATED PROPERLY. I HAVE TAKEN THE TRUCK TO THE DEALER AND THEY ALIGNED THE FRONT END BUT THAT DIDN'T HELP. FORD NEEDS TO FIND A FIX FOR THIS PROBLEM AND ISSUE A RECALL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10441049December 22, 2011
FUEL SYSTEM, GASOLINE, ENGINE AND ENGINE COOLING:ENGINE:DIESEL
EGR AND OIL COOLER BROKEN WITH UNDER 53,000 MILES AND ONLY TWO MONTHS AFTER PURCHASING FROM DEALER. FORD REFUSES TO ACCEPT RESPONSIBILITY EVEN THOUGH THEY SUED THE ENGINE MAKER NAVISTAR (INTERNATIONAL) FOR A DEFECTIVE ENGINE AND WON. FORD REFUSES TO HELP A FIRST TIME AND NOW LAST TIME CUSTOMER. PLEASE RECALL THESE 6.0 DIESEL ENGINES . ENOUGH IS ENOUGH *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10440829December 21, 2011
STEERING
TL* THE CONTACT OWNS A 2006 FORD F250. THE CONTACT STATED THAT THE STEERING WHEEL AND THE FRONT END OF THE VEHICLE WOULD VIBRATE EXCESSIVELY WHEN TRAVELING OVER A ROAD OR SPEED BUMP. THE DEALER WAS CONTACTED AND THEY ADVISED THE CONTACT THAT THE AIR PRESSURE IN THE TIRES CAUSED THE VEHICLE TO VIBRATE. THE CONTACT RECEIVED A MANUFACTURER'S RECALL NOTICE CONCERNING THE VIBRATION, BUT THE MANUFACTURER WOULD NOT REPAIR THE VEHICLE STATING THAT THE VEHICLE HAD BEEN ALTERED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 2,000 AND THE CURRENT MILEAGE WAS 39,000. KMJ
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10440358December 19, 2011
FUEL SYSTEM, GASOLINE
WHILE DRIVING WITH FUEL LEVEL BETWEEN 1/8 AND 1/4 TANK, TRUCK SHUT DOWN COMPLETELY. THE "50 MILES TO EMPTY" INDICATOR HAD ILLUMINATED APPROX. 2 MILES BEFORE FAILURE. HAD TRUCK TOWED TO DEALER AND WAS FORCED TO PAY APPROX. $250 FOR DIAGNOSTIC AND TOW. DEALER COORDINATED WITH FORD CORPORATE AND DETERMINED I DROVE TRUCK UNTIL FUEL WAS EMPTY. APPROX. 4 WEEKS LATER, TRUCK SHUT DOWN AGAIN. DEALER EXPLAINED I WOULD HAVE TO "PLACE A BET" THAT THE FUEL INDICATOR SENSOR WAS "OUT OF TOLERANCE." THEY WOULD HAVE TO REMOVE FUEL TANK AND CHECK SENSOR. PER TECH, IF SENSOR WAS WITHIN TOLERANCE, I WOULD HAVE TO PAY THE ENTIRE BILL. I TOLD THEM TO GO AHEAD AND PERFORM THE CHECK. SENSOR WAS IN FACT OUT OF TOLERANCE AND WAS INDICATING MORE FUEL THAN WAS ACTUALLY IN THE TANK. SENSOR WAS REPLACED AND THE DEALER, NOT FORD, REFUNDED THE ORIGINAL AMOUNT OF REPAIR. LAST FORD I WILL PURCHASE. GM/CHEVY WILL BE MY NEXT DIESEL PURCHASE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10440312December 18, 2011
SUSPENSION
WHILE DRIVING ON THE HIGHWAY AT SPEEDS IN THE 60'S I WENT OVER THE SEEM OF A BRIDGE. THE TRUCK VIBRATED SO WILDLY THAT I GRABBED THE WHEEL WITH BOTH HANDS, HIT THE BRAKES HARD AND PRAYED. ITS AN AWFUL FEELING. I DON'T LET ANYBODY DRIVE THIS TRUCK ON THE HIGHWAY. IT HAS HAPPENED TO ME MORE TIMES THAN NOT. I CHECK THE TIRE PRESSURE REGULARLY. THIS TRUCK SHOULD BE RE-CALLED. ITS A VERY DANGEROUS SITUATION. IT'S NOT A SHIMMY. ITS VERY VIOLENT. IF ANYBODY WANTS PROOF I WILL GLADLY TAKE THEM FOR A RIDE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10440155December 16, 2011
EQUIPMENT ADAPTIVE/MOBILITY, ENGINE AND ENGINE COOLING, FUEL SYSTEM, GASOLINE
DRIVING THROUGH A FARM FIELD AND SOMETHING HIT THE OIL PAN AND CRACKED IT WITH A HAIR LINE FRACTURE, 1/8 INCH, AND OIL LEAKING. NO VISABLE DAMAGE OR MARKING UNTIL PULLED FROM TRUCK, EVEN THAN NO MARKS BUT A SLIGHT DENT IN PLASTIC. NO OTHER VISABLE DAMAGE ANYWERE ELSE UNDER TRUCK. ASKED IF ALL OIL PANS ARE PLASTIC AND I WAS TOLD BY DEALER, YES. THIS IS A TRUCK DESIGNED TO FOR OFF ROAD HEAVY DUTY WORK. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250