Ford F-250 Complaints

11,199 consumer complaints on file.

#10711970April 21, 2015
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 1999 FORD F-250 SD. THE CONTACT STATED THAT THE STRAPS FOR THE FUEL TANK WERE RUSTED ALL THE WAY THROUGH. THE CONTACT WAS MADE AWARE OF NHTSA CAMPAIGN NUMBER: 11V385000 (FUEL SYSTEM). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. HOWEVER, THE REFUSED TO PROVIDE ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE FAILURE MILEAGE WAS UNKNOWN....UPDATED 06/03/15 *BF UPDATED 7/7/2015*JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10706349April 17, 2015
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 1991 FORD F-250. AFTER REFUELING THE VEHICLE, FUEL STARTED LEAKING FROM THE FUEL TANK. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT WAS AWARE OF NHTSA CAMPAIGN NUMBER: 01I008000 (FUEL SYSTEM, GASOLINE) BUT THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 161,000. ..UPDATED 05/20/15 *BF THE CONSUMER HAS EXPERIENCED THE FUEL SWITCH OVER ISSUE AND WOULD LIKE TO BE ADDED TO THE RECALL. UPDATED 7/6/2015 *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10705798April 15, 2015
SUSPENSION
TL* THE CONTACT OWNS A 2011 FORD F-250. WHILE DRIVING 60 MPH OVER A BUMP IN THE ROAD, THE VEHICLE SHOOK UNCONTROLLABLY. THE CONTACT HAD TO SLOW THE VEHICLE DOWN TO 30 MPH TO REGAIN CONTROL. THE FAILURE WAS EXPERIENCED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE FRONT TIRES AND PERFORMED AN ALIGNMENT. IN ADDITION, THE FRONT SUSPENSION BARS WERE ALSO REPLACED; HOWEVER, THE FAILURE WAS NOT CORRECTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 40,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10705905April 15, 2015
STEERING
TL* THE CONTACT OWNS A 2011 FORD F-250. WHILE DRIVING 75 MPH, THE STEERING WHEEL WAS TURNED LEFT AND RIGHT, BUT THE WHEELS TURNED TO THE OPPOSITE DIRECTION. THE VEHICLE WAS TOWED TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE STEERING BOX FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 50,500. ...UPDATED 06/03/15 *BF UPDATED 7/7/2015*JS UPDATED 10/05/2017*CN
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10705650April 14, 2015
ENGINE, ELECTRICAL SYSTEM
NEAR THE END OF THE HIGHWAY I WAS SETTING THRU A LIGHT AND DECIDED TO ET FUEL. ONCE I REACHED THE TURN IN GOT TO THE PUMP ALL IS WELL. I WAS NOT TOWING OR HAULING ANYTHING THE DAY TEMPERATURE IS 66 DEGREES. I SET AT THE PUMP FOR A MINUTE ON THE PHONE AND THEN TURNED THE TRUCK OFF. PROCEEDED TO FILL UP AND THEN DEPART. I STARTED MY TRUCK REMOVED THE EMERGENCY BRAKE AT THE SAME TIME MY DASH INDICATOR LIGHTS ALL STARTED IN WITH HEIGHT EXHAUST TEMP HEIGHT OIL TEMP ALL SORTS OF OTHER LIGHTS ALONG WITH ENGINE SYSTEM START FAILURE. I PULLED AWAY FROM THE PUMP FOR SAFETY AND THEN SHUT IT OFF. THAT WAS IT NO START SAME WARNINGS. AFTER CALLING A WRECKER TWENTY MINUTES WENT BY AND I TRIED IT AGAIN AND IT STARTED WITH A SERVICE ENGINE LIGHT ON. NO DEALER COULD GET TO IT FOR TWO OR THREE DAYS SO I DROVE IT HOME TO SCHEDULE AN APPOINTMENT. HAD THIS HAPPENED SIX MILES EARLIER I WOULD HAVE BEEN IN A BAD SPOT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10705421April 13, 2015
ENGINE
I HAVE A 2012 FORD F250 KING RANCH 6.7 DIESEL. THE RADIATOR STARTED LEAKING SO I TOOK IT TO THE DEALERSHIP ONLY TO FIND OUT I NEEDED A NEW RADIATOR. SINCE MY BUMPER-TO-BUMPER WARRANTY RAN OUT AT 36K MILES THIS REPAIR WAS ON MY DIME. IN RESEARCHING ONLINE FORUMS AND SUCH, THERE HAVE BEEN KNOWN ISSUES WITH THE DIESEL RADIATOR AS FAR BACK AS 2008. THE ENTIRE PREMISE BEHIND A DIESEL ENGINE IS "COMPRESSION-IGNITION" IN WHICH FUEL IS IGNITED DUE TO COMPRESSED AIR AT APPROXIMATELY 1000 DEGREES F. THERE IS NO SCENARIO WHERE THE EITHER THE MANUFACTURER OF THE RADIATOR AND/OR FORD MOTOR COMPANY THEMSELVES SHOULD NOT BE REQUIRED TO FIX THIS FAULTY PART AT THEIR EXPENSE. THE REPAIR ESTIMATE WAS OVER $2,000 ON A VEHICLE LESS THAN 3 YEARS OLD. IN NO WAY SHOULD ANY NEW VEHICLE OWNER BE REQUIRED TO PAY FOR A NEW RADIATOR MUCH LESS FOR THE LABOR TO INSTALL IT AND THAT GOES DOUBLE FOR THE OWNER OF A DIESEL ENGINE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10705424April 13, 2015
STEERING
WHEN I TURNED OFF THE HIGHWAY THE STEERING WAS ALMOST STUCK- AS IF THE TRUCK HAD BEEN TURNED OFF. I MADE IT TO THE SIDE OF THE ROAD, TURNED IT OFF AND BACK ON AND THEN IT STEERED OK. THIS HAS HAPPENED TWICE BEFORE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10704582April 8, 2015
FUEL/PROPULSION SYSTEM, ENGINE, ELECTRICAL SYSTEM
WE PURCHASED THIS 2008 FORD F-250 SUPER DUTY NEW AT THE FORD STORE IN SAN LEANDRO, CA ON JULY 21, 2007 AND CONTINUE TO BE THE ORIGINAL OWNERS. THIS VEHICLE IS EQUIPPED WITH A 6.4 TURBO-DIESEL ENGINE. THIS VEHICLE IS SUBJECT TO TSB 07-26-2 (WIRING HARNESS DEFECT ON HPFP) ISSUED AUGUST 2007. ON THE MORNING OF MARCH 27, 2015, WHILE ACCELERATING ONTO A FREEWAY AND AT AN APPROXIMATE SPEED OF 50 MPH, THE ENGINE SHUT DOWN WITHOUT ANY WARNING. I LOST ALL ACCELERATION AND THE ENGINE DIED. BRAKING AND STEERING WERE ALSO DIMINISHED. I GOT LUCKY AND WAS ABLE TO AVOID A COLLISION AND COAST TO THE SIDE OF THE ROAD WHERE THE VEHICLE WOULD NOT RESTART. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP (BUD ADAMS - CASTRO VALLEY, CA; BAR#:228593 CAL#:66801). DIAGNOSIS REVEALED A SHORT IN THE WIRING OF THE HIGH PRESSURE FUEL PUMP GASKET WIRING HARNESS (THE SUBJECT OF TSB 07-26-2 WHEREIN FORD RECOGNIZED ON OR ABOUT AUGUST OF 2007 A PROBLEM WITH UNPROTECTED WIRING WITHIN THE HPFP WIRING HARNESS). REPAIRS WERE EXTREMELY COSTLY ($3,791.89 REDUCED TO $2,591.89) BUT MORE IMPORTANTLY THIS INSTANTANEOUS FAILURE WITHOUT WARNING IS GOING TO CAUSE AN ACCIDENT, INJURY OR DEATH; IT IS ONLY A MATTER OF TIME. I GOT LUCKY. I SEE OTHER COMPLAINANTS WHO HAD HOURS STUCK IN THE DESERT, SOMEONE WITH A LOAD OF CATTLE STUCK WITHOUT WARNING, THE LIST GOES ON. IN EACH REPORTED INSTANCE THE OPERATOR DESCRIBED AN IMMEDIATE LOSS OF POWER PLANT WITH NO WARNING. I URGE THE NTSB TO INVESTIGATE THESE UNPLANNED SHUT DOWNS OF THIS VEHICLE'S POWER PLANT. UNDER CERTAIN CIRCUMSTANCES THIS MAY LEAD TO LOSS OF CONTROL OF THE VEHICLE, COLLISION, INJURY AND POSSIBLY DEATH. FORD HAS KNOWN ABOUT THIS ISSUE SINCE AUGUST OF 2007 YET HAS NOT ISSUED A RECALL. SOME MAY SAY THIS IS DUE TO THE LARGE COSTS INVOLVED TO REMOVE AND REPLACE THE HPFP GASKET AND WIRING HARNESS (IN PART INVOLVING THE REMOVAL OF THE VEHICLE'S CAB). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10703883April 6, 2015
FUEL/PROPULSION SYSTEM
WHILE DRIVING THE MOUNTS THAT HOLD THE FUEL TANK FAILED CAUSING THE TANK TO FALL OFF AND DRAG ON THE ROAD, EVENTUALLY WEARING A HOLE IN THE TANK CAUSING THE FUEL TO LEAK OUT. OBVIOUSLY ONCE THE GAS RAN OUT THE VEHICLE WOULD NO LONGER OPERATE. WE WERE LUCKY THAT THERE WAS NO FIRE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10703992April 6, 2015
SERVICE BRAKES
WAS TOLD BY DEALER, REAR CALIPER WAS DRAGGING, I REPLACED REAR BRAKES AND IN THE PROCESS NOTICED BOTH BACK CALIPERS WERE DEFECTIVE AT 62000 MILES. ONE PISTON ON ONE SIDE WAS ATTACHED TO THE PAD AND CRACKED IN HALF. THE OTHER SIDE, BOTH PISTONS WERE BROKEN. AT SUCH A SHORT MILEAGE INTERVAL, CALIPERS SHOULD NOT BE DEFECTIVE AND DRAGGING ON THE ROTORS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10702688March 30, 2015
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2005 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE FAILED TO RESTART AND WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING ON TWO SEPARATE OCCASIONS. THE MECHANIC WAS UNABLE TO LOCATE A FAILURE ON EACH VISIT. THE VEHICLE WAS ALSO TAKEN TO THE DEALER WHO DISCOVERED THAT THE FAILURE WAS CONTRIBUTED TO THE FAULTY FUEL INJECTION CONTROL MODULE AND FUEL PUMP. THE VEHICLE WAS REPAIRED. THERE WAS A RECALL UNDER NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM) HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 138,576. MA 08/10/15 UPDATED 11/30/2015 *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10702689March 30, 2015
AIR BAGS, ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL (ESC)
WHEN U TURN ON PASSENGER SIDE AIR BAG THE RADIO DOES NOT WORK WHEN U TURN IT OFF THE TRACTION CONTROL LIGHT COMES ON AND ABS SYSTEM WARNING LIGHT COMES ON , THE BLUE TOOTH STOPPED WORKING ALL TOGETHER NO MATTER WHICH POSITION AIR PASS AIR BAG SWITCH IS IN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10702758March 30, 2015
ENGINE AND ENGINE COOLING, POWER TRAIN
RADIATOR FAILED AT 47,500 MILES. FORD REFUSES TO FIX. HAVE READ MULTIPLE INSTANCES OF DEFECTIVE RADIATORS FAILING FROM NEW TO 100,000 MILES. THIS WEBSITE LISTS COMPLAINTS AND AVERAGE MILEAGE. HTTP://REPAIRPAL.COM/COOLANT-LEAK-FROM-RADIATOR-931. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10702433March 29, 2015
ENGINE
WE OWN A 2009 FORD F250 SUPER DUTY 4X4, WITH LOW MILES (21478). THIS VEHICLE HAS RUN GREAT SINCE WE PURCHASED IT NEW. AS WE WERE DRIVING, THE ENGINE BEGAN TO RUN POORLY AND LOOSE POWER. THE ENGINE LIGHT THEN CAME ON. THE MECHANIC SCANNER THE ENGINE CODES P0012-P0018-P0022-P0341-P052D, INDICATING FAULTY CAM PHASERS AND TENSIONERS, AND THAT THE ENGINE WAS OUT OF TIME. THIS PICKUP HAS LOW MILEAGE AND ALL THE RECOMMENDED MAINTENANCE HAS ALWAYS BEEN DONE. THE FORD PARTS DEPARTMENT STATED THAT THEY KEEP THESE PARTS STOCKED BECAUSE IT IS A COMMON REPAIR ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10702141March 27, 2015
SEAT BELTS
TL*THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING AT A VARIOUS SPEEDS, THE FRONT PASSENGER, FRONT MIDDLE AND REAR MIDDLE SEAT BELTS FAILED TO BUCKLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 83,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10701967March 26, 2015
FUEL/PROPULSION SYSTEM
I WAS IN FLORIDA HAVING COFFEE AT THE PICNIC TABLE WHEN I NOTICED THE FUEL TANK WAS HANGING LOW. I WAS LUCKY TO CATCH IT BEFORE IT FELL OFF ON THE FREEWAY. I CAN SEND YOU A PICTURE. I UNDERSTAND THERE IS A RECALL ON OTHER FORD PICKUPS 150'S AND 250'S BUT NOT MY MODEL YEAR, MY YEAR TRUCK SHOULD BE INCLUDED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10701801March 25, 2015
FUEL/PROPULSION SYSTEM
THE HIGH PRESSURE FUEL PUMP FAILED. I HAVE TAKEN THE TRUCK TO TWO DIFFERENT DEALERSHIPS AND THEY HAVE SAID THE SAME THING. THEY ARE SAYING THAT IT IS A FUEL ISSUE BUT THE PUMP ON THE TRUCK ISN'T EQUIPPED WITH THE INCORRECT FUEL PUMP FOR THE DIESEL THAT IS SOLD IN THE US. I HAVE SPENT JUST ABOUT $2000.00 JUST FIGHTING THE WARRANTY COMPANY TO FIX THE TRUCK I DROVE FOR 10 DAYS BEFORE FAILING. THE TRUCK HAS BEEN IN THE SHOP LONGER THAN I HAVE HAD IT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10701349March 24, 2015
STEERING, SUSPENSION
THE TRUCK WENT INTO A WOBBLING FRONT WHEEL SITUATION WHEN I HIT AN IRREGULAR PAVEMENT STRETCH. IT HAS ALSO HAPPENED WHEN YOU GO OVER AN EXPANSION JOINT ON A BRIDGE OR HIT A BUMP OR POTHOLE AT FREEWAY SPEEDS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10701274March 23, 2015
ELECTRICAL SYSTEM
MY EGT SENSOR IN MY TRUCK WENT OUT THAT HAS TO DO WITH EMISSIONS THIS IS THE FIRST ONE I'VE HAD TO PAY FOR BUT THEY HAVE REPLACED ANOTHER BEFORE WARRANTY RAN OUT. THESE SENSORS ARE FAULTY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10695536March 20, 2015
ELECTRICAL SYSTEM
I WAS DRIVING MY SON TO SCHOOL AND AS I APPROACHED THE ENTRANCE TO THE SCHOOL THE ALARM CHIMED. I SLOWED DOWN ON A BUSY 4 LANE STREET TO TURN INTO THE SCHOOL PARKING LOT. AS I TRIED TO ACCELERATE THE TRUCK SHUT OFF LEAVING ME SITTING IN THE MIDDLE OF AN INTERSECTION WITH A 3 YEAR OLD IN THE BACKSEAT IN A CAR SEAT. I TRIED TO RESTART THE TRUCK BEFORE THE ONCOMING TRAFFIC REACHED US, TO NO AVAIL I GOT OUT AND STARTED TO PUSH THE TRUCK AND 2 PEDESTRIANS RAN ACROSS THE STREET TO STOP TRAFFIC AND HELP ME PUSH THE TRUCK OUT OF THE STREET SO WE WOULDN'T GET HIT. WHEN I CALLED FORD THEY SAID NOTHING COULD BE DONE TO GET THE TRUCK STARTED UNTIL THE EGT EXHAUST SENSOR WAS REPLACED AND THEY WERE ON BACK ORDER FOR 2 WEEKS. AFTER CALLING THE DEALERSHIP I PURCHASED THE TRUCK FROM (OUT OF STATE) THEY OFFERED TO OVERNIGHT ONE TO THE DEALERSHIP THAT WOULD REPAIR THE TRUCK. AFTER DISCUSSING THIS WITH SEVERAL MEMBERS OF THE LOCAL DEALERSHIP TEAM INCLUDING THE SERVICE MANAGER THEY MIRACULOUSLY FOUND A SENSOR IN A NEARBY TOWN TO REPLACE THE FOLLOWING DAY. WE EASILY COULD HAVE BEEN IN A SERIOUS ACCIDENT IF THE TRUCK WOULD HAVE STALLED WHILE ONCOMING TRAFFIC WERE CLOSER. THIS IS A SAFETY HAZARD AND NEEDS TO BE ADDRESSED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250