Ford F-150 Complaints

39,812 consumer complaints on file.

#11577493March 14, 2024
ENGINE, POWER TRAIN
low oil pressure flashing while driving with engine failure - no other issues just happened. Verified by mechanic March 2020
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11577374March 14, 2024
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, FORWARD COLLISION AVOIDANCE: WARNINGS, BACK OVER PREVENTION: WARNINGS
After a recurring dashboard alert to tell me that front sensors and rear braking were offline, I took the vehicle for warranty repair. The Ford dealer indicated that the repair would cost $519, because it was a wiring failure and not a failure in a part. According to the service advisor, the failure is a common failure that occurs at a tee where the wiring branches to a sensor just behind the rear bumper. He said that it is not covered by Ford's "bumper to bumper" warranty because it's a wiring failure and not a part failure (although the subject wiring harness does carry a Ford part number). Since my 2022 truck had only about 14,000 miles and had been lightly used (no off-road use), I balked at the notion that it should not be Ford's responsibility to replace the wiring harness. I paid only the diagnosis fee ($155) and took the truck home. On investigation, I found the harness and sensor wire he described to be easily accessible and easily damaged by any sort of road debris. I also found the wiring from the harness to the sensor to be unsupported, leading me to conclude that resonance due to normal road vibrations could have led to metal fatigue in the wire. It's my view that Ford's conclusion that this is normal wear and tear on a truck is ludicrous. I expressed this view in a letter to Ford's Consumer Relationship Center, but the response was simply to back the dealer's determination. They did provide the option to seek a second dealer opinion, but my concern is more about the long-term vulnerability as I am capable of repairing or replacing the harness myself. It's my conclusion that the joint should be shielded from road hazards and the wires to the sensors should be separately supported to reduce stress on the joint in the harness. My belief that this is a matter for NHTSB is based on the fact that the harness failure compromises rear emergency braking.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11577143March 13, 2024
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
While driving in the rain, my vehicle had a complete electrical failure. I could not accelerate or even turn the vehicle off. Because of this I could not move my vehicle off the highway. Fortunately I was not hit by the vehicle behind me, and was not in a turn. he Several warning lights came on. After being towed to a dealership, it was found that the factory windshield was leaking into the passenger side area where the Body Control Module (BCM) is housed. This flooded the unit and completely killed the truck. It was surprising to me that rain had the ability to completely render my truck useless. The manufacturer would not cover any repairs as they claimed windshield leaks were a maintenance issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11577189March 13, 2024
VISIBILITY/WIPER
Back-up camera is not clear , I can't clearly make out objects when backing, even after cleaning the lens. This has been like this as long as I have had the truck.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11577219March 13, 2024
POWER TRAIN, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
The contact owns a 2023 Ford F-150. The contact stated that while her husband was reversing down the driveway, the vehicle suddenly accelerated independently. Upon depressing the brake pedal, the brake pedal went to the floorboard and failed to bring the vehicle to a complete stop. As a result of the failure, the driver lost control of the vehicle, coming to a complete stop after striking a tree. The vehicle continued to accelerate, requiring the driver to turn off the engine. The air bags did not deploy. The blank warning light was illuminated. A Police report was not filed, and no injuries were reported. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 251.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11577216March 13, 2024
POWER TRAIN, POWER TRAIN:AUTOMATIC TRANSMISSION
As vehicle is downshifting there is sometimes a slight jerking or hard jerking associated when doing so. This happens a lot also when letting up off of the accelerator or slightly riding the accelerator for example is slow moving traffic. This is a significant jerking, not a smooth jerking when switching gears.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11576764March 12, 2024
EXTERIOR LIGHTING
The headlamps flicker when the steering wheel is turned at speeds of 1-45 miles per hour. The dealership claims that a software update will fix it, though the issue seems to be with the integrated circuits in the headlamp assembly. The issue has gotten worse over the last 3-4 months.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11576969March 12, 2024
POWER TRAIN
The contact owns a 2019 Ford F-150. The contact stated while driving the vehicle there was an abnormal sound coming from under the middle of the front driver’s side seat to the rear seat. The contact stated that it sounded as if something was loose and felt as if the engine was moving. The check engine warning light was briefly illuminated. The vehicle was taken to the dealer who stated the transmission needed to be diagnosed. The contact stated that the transmission was serviced several months prior to the failure by the dealer. The vehicle was not repaired due to the cost. The contact notified the manufacturer of the failure and was informed that the vehicle mileage was over the warranty coverage. The contact was then referred to the NHTSA Hotline. The failure mileage was approximately 72,200.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11576734March 11, 2024
UNKNOWN OR OTHER
We were sitting in a friends driveway with car running but not moving. My daughter opened the rear passenger door and there was a loud noise. It sounded like a gunshot. We finally figured out the sunroof had burst. It had left a huge hole in the sunroof and glass was everywhere. There was no warning for this and i have not driven the vehicle since the incident. (2 weeks ago) Had we been moving and had my wife, 12 year old daughter and her friend in the car this could of put a lot of people in danger.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11576557March 11, 2024
POWER TRAIN, POWER TRAIN:AUTOMATIC TRANSMISSION
The contact owns a 2013 Ford F-150. The contact stated that while her husband was driving at an undisclosed speed, the vehicle failed to shift out of 1st gear. The contact stated that the vehicle was stuck in 3rd gear. The wrench warning light and air bag warning light was illuminated. The contact stated that the entire dashboard screen was black. The contact stated her husband restarted the vehicle for the vehicle to return to normal operation. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the lead frame needed to be replaced. The vehicle was not repaired yet. The failure was related to NHTSA Campaign Number: 19V433000 (Power Train). The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline. The approximate failure mileage was 152,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11576487March 10, 2024
STRUCTURE:BODY, UNKNOWN OR OTHER
My 2020 ford truck driver side door locks freeze when temperatures get below freezing. When this happens the door does not open and when I open it from the inside the door doesn’t latch. I have to use a bungee cord to hold the door closed if I’m going to use the vehicle. Also the rest of the doors don’t lock when driving the vehicle. I believe other year ford trucks have had this issue and they also were recalled for a fix. I have had the truck to the dealer several times with no luck. The last time when the truck was under warranty they replaced the door lock actuator which didn’t help. I believe this is very much a safety issue and I shouldn’t even be driving this truck but I need it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11576345March 9, 2024
WHEELS, WHEELS:LUGS/NUTS/BOLTS/STUDS
ATTEMPTED TO MOUNT MY SPARE TIRE AND THE METAL COVERING ON MY LUGNUTS HAD EXPANDED CAUSING ME TO BE UNABLE TO REMOVE THE FLAT TIRE. DONE SOME RESEARCH AND DISCOVERED THIS TO BE A COMMON OCCURANCE ON MY 2013 F150. THI ISSUE W/FORD NEEDS TO BE RESOVELD TO PREVENT ANY FURTHURE DIFFILCULTIES. NEEDS TO BE A SOLID LUGNUT TO REPLACE THOSE THAT HAVE THE METAL SKIN COVERING THE LUGNUT. THANKS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11576412March 9, 2024
POWER TRAIN
I know there has been a lot of reported issues with Ford's 10R80 transmission. At 73,000 miles my wrench light came on due to a powertrain issue. When the wrench light came on it wasn't shifting correct and it was slipping thankfully I was in my neighborhood and not on the highway. I used my mechanical breakdown insurance and my transmission was replaced with a brand new one. At 75,000 miles roughly 2,000 miles on the new transmission that was installed by Mac Haik's Southway Ford in San Antonio Texas the transmission popped while driving on [XXX]. When the popping happened I was unable to accelerate since it didn't want to shift properly. I had to stop at a gas station and the transmission was leaking fluid after the pop. I then got the truck back to Mac Haik's Southway Ford since the transmission is under warranty. When the transmission popped on the highway and not wanting to shift properly was a serious safety concern. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11576132March 8, 2024
POWER TRAIN
I own a 2013 Ford F-150. On numerous occasions while driving at any speeds, 40-70;MPH, the vehicle downshifted from 6th, 5th, and 4th to 1st gear, and cease to come to a halt. . The check engine and wrench warning lights illuminated. I would have to turn the truck off and restart to get out of the middle of the road. I would at times have to do this every few miles in order to make it to my destination. The check engine wrench warning light remained illuminated at times and other times would not, and the transmission failed to shift out of 1st gear. This would only happen periodically at 1st, then started happening on a regular basis I took to Ford dealership and got repairs done. At which time I Questioned if there were any recalls and they stated the recall repairs had already been fulfilled on my vehicle, therefore all costs involved are my responsibility. I paid the repair charges in full of approximately 2000$. Upon researching the recalls which started in 2019 NHTSA Campaign Number: 19V433000 (Power Train) or 19V075000 (Power Train). And also seeing documentation in reference to these campaigns that when some of the vehicles were repaired that the broken parts were not all removed from inventory therefore the original recall repairs were made with faulty parts. I then proceeded to phone the Ford dealership back and was pretty adamant that I should be reimbursed for the second repairs as it sounds like same issue of 2019 recall. I was denied my request and was informed to call Ford customer service for reimbursement. As of this date no reimbursement has been made. The failure mileage was approximately 136K
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11576181March 8, 2024
ENGINE
The contact owns a 2014 Ford F-150. The contact stated that upon starting the vehicle, there was an abnormal grinding sound coming from the vehicle. There was no warning light illuminated. The vehicle was taken to an independent mechanic and was diagnosed with a defective cam phaser. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11576188March 8, 2024
POWER TRAIN
The contact owns a 2012 Ford F-150. The contact stated that while driving at an undisclosed speed, the vehicle suddenly downshifted and hesitated while depressing the accelerator pedal. There was no warning light illuminated. The contact would restart the vehicle to reset the vehicle. The vehicle was taken to a local dealer where a diagnostic test was performed. The mechanic linked the failure to NHTSA Campaign Number: 19V075000 (Power Train) but stated that the vehicle was not included in the recall. The manufacturer was also notified of the failure and the contact was referred to the NTHSA Hotline for assistance. The vehicle was not repaired. The failure mileage was approximately 75,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11576199March 8, 2024
POWER TRAIN, POWER TRAIN:AUTOMATIC TRANSMISSION
The contact owns a 2019 Ford F-150. The contact stated while driving 70 MPH, the transmission was shifting gear erroneously. The contact stated that the transmission shifted from 10th gear to 3rd gear and then to 6th gear. The contact stated that the vehicle was bucking while driving. The contact pulled over and there was an unknown warning light illuminated. The vehicle was taken to an independent mechanic, who informed the contact that the transmission needed to be replaced. The vehicle was taken to the local dealer, where it was diagnosed that the transmission needed to be replaced. The vehicle was not repaired. The vehicle was taken to another local dealer, Szott Ford (8800 E Holly Rd., Holly, MI 48442). The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 156,000. The VIN was not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11576217March 8, 2024
POWER TRAIN
A common transmission failure on these trucks is the lead frame. My truck threw two codes related to the input speed sensor failing which resulted in $2,200 in repairs on a truck with 24,500 miles. This is a common issue that is unresolved and could cause accidents, injury, or death due to truck spontaneously going into limp mode.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11576250March 8, 2024
POWER TRAIN:AUTOMATIC TRANSMISSION
The contact owns a 2018 Ford F-150. The contact stated while driving at an undisclosed speed, he heard an abnormal rattling sound coming from underneath the vehicle. No warning lights were illuminated. The vehicle was taken to the dealer, who was unable to determine the cause of the failure. The vehicle was not repaired. The vehicle was then taken to an independent mechanic, who diagnosed a failure with the flywheel. The contact was informed that the flywheel was cracked. The vehicle was not repaired. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 36,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11576263March 8, 2024
POWER TRAIN
The contact owns a 2013 Ford F-150. The contact stated that while driving at an undisclosed speed, the vehicle suddenly jerked, after which the vehicle lost significant motive power. The contact was able to pull to the shoulder of the roadway, where the vehicle failed to shift out of first gear. The check engine warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the leadframe. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 19V433000 (Power Train), but the VIN was not included. The failure mileage was 150,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150