Ford F-150 Complaints

39,812 consumer complaints on file.

#11596362June 25, 2024
POWER TRAIN
Vehicle geared down without warning, several occasions it would stay geared down on an interstate. I would have to pull over to get it to perform properly. Took it in to the local Ford dealership for repair and it cost me $7000 to replace transmission, immediately afterwards it continued gearing down which happened to be an issue with the power control module. I know the 2014 have been recalled with the same issues, and feel the 2015 should probably also be included in the recall.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11596370June 25, 2024
POWER TRAIN, SERVICE BRAKES, AIR:ANTILOCK:ABS WARNING LIGHT
The contact owns a 2013 Ford F-150. The contact stated while driving 70 MPH with the cruise control activated, the transmission suddenly downshifted from 6th to 1st gear. There was no warning light illuminated. The contact pulled over into the Emergency Lane, turned off the vehicle, and had the vehicle towed to an independent mechanic. The independent mechanic diagnosed that the final drive assembly, including, the spider gears and rear axles were blown due to the ABS system being damaged due to the transmission slightly detaching when the downshift occurred. The final drive assembly was replaced; however, the transmission only shifted from 1st to 2nd gear before downshifting back to 1st gear while making a loud grinding sound. The mechanic diagnosed that the transmission needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure and confirmed that the VIN was not included in a recall. The contact was referred to the NHTSA Hotline to report the failure. The failure mileage was 157,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11596374June 25, 2024
ENGINE, VEHICLE SPEED CONTROL
When traveling on road and want to speed up to get on freeway, change lanes, or simple speed up I lose power shift and it goes from 6 to 4 or 3 in gears and I can't accelerate which has almost caused many accidents. The check engine signal will only blink right when it's happening and loose speed and the AC air flow will get warm until it corrects itself after I either slow down or shut truck off completely. But always happens when you accelerate at any time.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11596377June 25, 2024
ENGINE AND ENGINE COOLING, POWER TRAIN
The contact owns a 2018 Ford F-150. The contact stated while starting the vehicle, the vehicle made an abnormal cracking sound. The vehicle was taken to the dealer, where the contact was informed that the vehicle was operating as designed because the sound was a characteristic of the engine cowling. The contact stated while driving at various speeds, the vehicle lost motive power. The contact was able to pull to the side of the road. The contact was able to restart the vehicle and continued driving. The low oil pressure warning light was illuminated. The vehicle was taken to the dealer, where the cam shafts, the timing belt, the oil pump, and other unknown parts were replaced. Additionally, the contact stated while driving at various speeds, the vehicle experienced unexpected hard downshifts and the rear wheels locked up. The contact stated that the failure occurred intermittently. The contact was able to continue driving. The vehicle was taken to the dealer, where an unknown computer reprogramming was performed; however, the failure persisted. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 50,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11596379June 25, 2024
POWER TRAIN
March 2024 I went to Pep Boys to assist and replace Spark Plugs and Coils because of a Random Misfire Code. Sometime during April 2024 my F-150 began to randomly shift while driving, down shift, jerk surge like it wants to take-off accelerating, and jump to a random gear 6, 8, 4, and back to 7 and automatically switch to limp mode. I took my truck to a performance shop they recommended software updates and suspected transmission. After the updates, I took my F-150 to Firestone because it started throwing P0420 and P0430 Codes. Firestone did a diagnostic and airflow test, recommended New Catalytic Converters. However, the Truck still Jerks and shifts erratically to gears and downshifts to lower gears while driving. After coming to a complete stop, the truck is slow to accelerate as it feels like the rear axle is locked, then jerks and stalls like it is turned off. after 2-3 seconds it surges to next gear and downshifts again. I called Ford and several of the local service departments to inspect my F-150 and each one tells me that I have to leave my truck with them for 3 weeks because they are behind. I asked if they provide loaners and they all said no. On 19 June 2024 I called Ford Motor Co. to complain, and they contacted the same local Ford Service Centers on my behalf to see if they could help to book an appointment. Unfortunately, there wasn't anything they could do to help because the service managers at 3 different locations said they are backed up and if I wanted their help, I would need to get in line by leaving my truck with them and expect a 3 week delay. I have a 2018 Ford F-150 5.0L 4x4 Sport Edition, I can switch the Truck to Manual Mode and it drives fine, therefore I know that my Transmision is still in good working order. However, in Automatic, Sport or Econo mode my truck has the erratic, rough idling, random gear shifts and sluggish acceleration at complete stops.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11596380June 25, 2024
POWER TRAIN
The contact owns a 2015 Ford F-150. The contact stated that on several occasions while driving at various speeds, the vehicle unintendedly downshifted to a lower gear. The contact observed a vibration coming from underneath the middle of the vehicle. On other occasions, while driving at slow speeds, the vehicle began jerking slightly to moderately. The vehicle was taken to the residence. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 60,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11596384June 25, 2024
POWER TRAIN
I was driving down the road at 70 mph and my 10R80 transmission rapidly downshifted to 1st gear. This is on top of the erratic shifting and driveline vibration from the CDF clutches which ford said tough luck on getting repaired/warrantied after they announced they fixed with a redesign, but also after being told "nothing is wrong" until after the warranty has gone out.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11596390June 25, 2024
POWER TRAIN
On [XXX] i was traveling on [XXX] coming home from Nashville, TN the cruise control was set at approx 75mph, my truck was in 10th gear. I suddenly heard a loud clunk , looked at the instrument cluster and the gear indicator showed i was in 3rd gear, I promptly pulled over and stopped to inspect for any type of damage. There was none so i proceeded to a nearby exit and gas station, put the truck in park, shut it off for a more thorough inspection. Nothing was found so i cautiously proceeded the remaining 75 miles to my home, i have not had that issue again, yet. 2019 Ford F150 , 85,000 miles. One owner vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11596401June 25, 2024
STEERING
The contact owns a 2017 Ford F-150. The contact stated that while driving at an undisclosed speed, the steering wheel became abnormally stiff, making it difficult to maneuver the vehicle. No warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with electronic power steering failure. The vehicle was being repaired. The contact related the failure to an unknown recall. The manufacturer was made aware of the failure but confirmed that the vehicle was not included in a recall. The failure mileage was 97,215.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11596408June 25, 2024
POWER TRAIN
The contact owns a 2015 Ford F-150. The contact stated while attempting to drive from a complete stop, the RPMs were significantly high, but the vehicle hesitated to respond while depressing the accelerator pedal. Additionally, the contact stated while driving at high speeds, the vehicle experienced unexpected downshifts to first gear. The power train warning light and the check engine warning light were illuminated. The vehicle was taken to an independent mechanic, where the transmission was replaced; however, the failure persisted. The dealer was contacted and informed the contact that the VIN was not included in a recall; therefore, he would be charged a fee for the diagnostic test and repair. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 82,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11596410June 25, 2024
POWER TRAIN
The contact owns a 2019 Ford F-150. The contact stated that while her husband was driving 60 MPH, the transmission inadvertently downshifted to first gear, causing the vehicle to come to a complete stop. The transmission then inadvertently upshifted back to fifth and sixth gears. No warning light was illuminated. The vehicle was taken to two independent mechanics and the dealer, where it was determined that the transmission needed to be replaced. The vehicle was not repaired and remained at the dealer. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 128,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11596420June 25, 2024
SERVICE BRAKES
I was driving my 2014 F150 truck with 5.0L engine when Brake fluid level low light came on. I tested the brakes and the pedal was soft and went almost to the floor. I added brake fluid and within 5 miles it leaked out. I had the truck towed to my parents home near where I broke down. Confirmed that master cylinder leaked fluid into brake booster. I can see there was a recall for 2014 F150 3.5L engine for this issue. Called dealer and Ford corporate and was told it did not affect 5.0. Problem is exact to recall and I believe the issue affects more vehicles than listed by Ford. Ford directed me to file complaint with NHTSA.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11596426June 25, 2024
UNKNOWN OR OTHER
Nothing wrong
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11596436June 25, 2024
LATCHES/LOCKS/LINKAGES
The contact owns a 2013 Ford F-150. The contact stated the rear passenger’s side door failed to latch close or lock as intended. The contact used excessive force on the latch to open the rear passenger’s side door. There was no warning light illuminated. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 100,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11596440June 25, 2024
POWER TRAIN
Transmission has hard shifts especially at low rpms and at times when at a complete stop, truck shifts to neutral during acceleration. Also when slowing down for a top light and not coming to a complete stop, transmission makes clunking noises while downshifting.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11596441June 25, 2024
FUEL SYSTEM, GASOLINE
The contact owns a 2018 Ford F-150. The contact stated that on several occasions while stopped at a red light, the EcoBoost feature activated, and the vehicle lunged forward during acceleration. There were no warning lights illuminated. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 94,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11596443June 25, 2024
POWER TRAIN
The contact owns a 2013 Ford F-150. The contact stated while stationary at a red traffic light, the vehicle unexpectedly shifted to third gear. There were no warning lights illuminated. The vehicle was taken to an independent mechanic where the vehicle was repaired. The contact related the failure to an unknown recall. The manufacturer was made aware of the failure and confirmed that the VIN was not under recall. The failure mileage was approximately 145,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11596445June 25, 2024
POWER TRAIN
The contact owns a 2020 Ford F-150. The contact stated while driving at various speeds, the transmission experienced hard shifting and fluttering while shifting from 3rd to 4th gear. The cause of the failure was not yet determined. The vehicle was not repaired. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The failure mileage was 130,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11596462June 25, 2024
POWER TRAIN
Hard transmission shifting and hesitation. It puts the driver and others in danger from the hard shifting and unexpected shifting and hesitation when shifting.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11596468June 25, 2024
ENGINE, POWER TRAIN
Camshaft phaser failure. We had code P051B which led to sensor replacement. Shortly after cold start engine rattle. Suspect was cam/phaser from web investigating. At 50k miles this should be covered. Ford wants $6,000 to change VCT, Timing belt & faulty cam phasers. Ford acknowledged in 2021 their fault, but this was never issued as recall. We never got ANY letter from Ford. For people like us that have low miles, ONLY get oil changes at Ford regularly, should not be punished for bad installed parts. Camshaft phasers need to be recalled.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150