Ford F-150 Complaints

39,812 consumer complaints on file.

#11597918July 1, 2024
POWER TRAIN, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, FORWARD COLLISION AVOIDANCE: WARNINGS
My wife was driving about 40 mph and the emergency collision alarm came on causing the vehicle to abruptly try to stop. San alarm went off in the dash indicating an imminent crash causing my wife to almost lose control of the vehicle. There was no vehicle in front of us and none in the opposing lane or behind us to trigger this response. My wife speculated maybe a bird flew across in front of us but I dodn,t see that. it was very alarming and almost caused her to lose control of the vehicle. I had this happen to me driving alone at about 40 mph. The only difference , there was a vehicle in front of m E but I was not close enough to trigger this safety alarm. The vehicle in front of me was not stopped and I was not close enough to trigger this response. I was at least4 or 5 car lengths away doing 40 mph. and they were traveling about the same speed. No rapid approach issue...
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11597923July 1, 2024
POWER TRAIN, ENGINE
The contact's wife owns a 2016 Ford F-150. The contact stated while driving 75-80 MPH, the transmission unexpectedly downshifted from 6th gear to 3rd gear. The power train warning light was illuminated. The contact shifted to neutral(N) and pulled to the side of the road. The contact turned off and restarted the vehicle, and the vehicle operated as needed while driving. The contact stated that the failure recurred several times while driving. The vehicle was taken to an unknown dealer several times; however, the failure could not be duplicated. The contact stated that while at a complete stop, the transmission failed to shift from third gear to first gear. The contact was able to continue driving. Additionally, the contact stated while attempting to drive from a complete stop, the accelerator pedal was depressed, but the vehicle failed to respond. The contact depressed the accelerator pedal until the engine revved to 80 MPH, and the vehicle responded, but then failed to exceed 5 MPH. The contact pulled to the side of the road. The vehicle was towed to another dealer, where the transmission control module and the crankshaft pressure sensor were replaced. The vehicle was repaired, and the contact was provided a two year warranty for the TCM. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 138,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11597933July 1, 2024
POWER TRAIN
The contact owns a 2012 Ford F-150. The contact stated that while driving 20–70 MPH, the transmission unexpectedly downshifted to first gear. While at a stop, the vehicle shut off. The contact pulled over and restarted the vehicle. The contact stated that the instrument cluster had gone blank several times. The wrench symbol was displayed. The vehicle was taken to the local dealer, but the vehicle was not diagnosed or repaired. The vehicle was taken to an independent mechanic, who was unable to duplicate the failure. The mechanic performed a tune-up. The vehicle was taken to a transmission specialist, who stated that the failure was related to the computer sensor. The contact stated that the failure was related to NHTSA Campaign Number: 24V444000 (Power Train). The manufacturer was contacted, and opened a case and referred the contact to the NHTSA Hotline. The failure mileage was approximately 325,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11597979July 1, 2024
POWER TRAIN, ENGINE
The contact owns a 2016 Ford F-150. The contact stated that while driving on six occasions at various speeds, an "acceleration warning" message appeared and the transmission and check engine warning lights illuminated. Additionally, the vehicle lost motive power and failed to accelerate as intended. The vehicle was steered to the side of the road and restarted. The vehicle was taken to a dealer where it was diagnosed; however, the dealer was unable to replicate the failure. The manufacturer was notified of the failure. The failure mileage was 49,532.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11598006July 1, 2024
POWER TRAIN
The contact owns a 2018 Ford F-150. The contact stated that while driving at an undisclosed speed, the transmission upshifted from first gear to tenth gear. There were no warning lights illuminated. The vehicle was taken to a transmission specialist, who determined that the first and third gears were chattering, the third and fifth gear upshifts had a flare, the eighth and ninth gears had a flare, and when shifting to tenth gear, the transmission shifted to neutral, and then downshifted to first gear before shifting to tenth gear. The manufacturer was contacted and referred the contact to the NHTA Hotline for assistance. The failure mileage was approximately 68,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11598020July 1, 2024
POWER TRAIN, VEHICLE SPEED CONTROL, ENGINE
In 2022, while behind the wheel of my 2015 F150, I would be driving down the highway (70+ mph) and the transmission would suddenly downshift to 1st gear, then jump to 3rd, and then back down to first gear, all over the place. This happened on several occasions. It was erratic, I experienced sudden changes in speed, sudden and frightening revving of the engine (especially on the highway) and on several occasions I had to make sudden changes to my driving to ensure my safety as well as the safety of others on the road. After I was able to pull over and turn my truck off, the truck would either not turn back on or take a while to be able to turn on. I had no warning that the transmission was about to shift gears and only noticed a check engine light after the incident had occurred. After taking my truck to a transmission shop and they did not find an issue with the transmission (it worked correctly while they test drove it), I took it to a Ford Dealership where I was told there was a fault with the CAM Shaft sensors. After a $3,000 repair to fix the issue, I recently found Ford has Recalled 2014 F-150s for issues that sound identical to what I was experiencing in my 2015 F-150.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11598024July 1, 2024
POWER TRAIN
The contact owns a 2013 Ford F-150. The contact stated while driving 70 MPH, the transmission unexpectedly downshifted and the vehicle slid sideways. The contact believed that the failure was associated with NHTSA Campaign Number: 19V433000 (Power Train). The vehicle was taken to a dealer where it was diagnosed that an unknown part needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 195,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11598054July 1, 2024
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
The contact owns a 2014 Ford F-150. The contact stated that while the vehicle was parked and attempting to reverse, the contact became aware that the rear-view camera was not functioning as intended. The contact stated that the failure was intermittent. The vehicle was not diagnosed or repaired by an independent mechanic or the local dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 59,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11598062July 1, 2024
FUEL SYSTEM, GASOLINE
The contact owned a 2016 Ford F-150. The contact stated while driving 40 MPH, smoke was coming from the rear passenger window with no warning lights illuminated. The contact pulled over and exited the vehicle safely and noticed that the rear of the vehicle caught on fire. The local fire department was able to extinguish the fire. The cause of the fire was undisclosed, but the fire marshal's report was provided to the contact. The contact suffered from smoke inhalation for a few days but did not seek medical attention. A police report was not filed. The vehicle was towed to the local towing facility and later picked up by the contact's insurance agency for investigation. The dealer was not contacted, and the vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 152,000. The VIN was not available.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11598078July 1, 2024
POWER TRAIN
While driving vehicle slows down/loses power. Dash reads "see manual". Started happening a few days ago. Took to mechanic today and they stated this is a known issue from Ford transmissions, I should inquire about a recall as the parts are backordered three weeks and the costs is a substantial amount. Recall only covers 2014 not 2015, from what I am reading the same issue happening to my 2015.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11598083July 1, 2024
POWER TRAIN, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
While I was driving on the highway at 70 miles an hour with adaptive cruise control on the transmission unexpectedly down shifted gears causing me to almost crash. Once I got off the highway at a stop light the truck wouldn’t shift into first gear for ten minutes. Once it finally was able to shift gears I barely made it to my destination and the truck would not shift into reverse. Now it won’t go over 30 miles an hour because it’s unable to shift to the higher gears. My family was in the truck at the time and fortunately no one was hurt but it was too close of a call. I have the truck at a local ford dealer now and they are looking at it now but said it could cost be 6k which I cannot afford to pay. I don’t know what I am going to do. I don’t have a vehicle to drive and now I am stuck without a vehicle to drive my family around.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11597999July 1, 2024
UNKNOWN OR OTHER
I bought my 2023 F150 August 31 2023 and a few days later with just 600 miles on it the air conditioner quit working. We were traveling and turned it off for a couple hours and when turned back on it worked. Called the salesman and he said there have other incidences. Today 7/01/24 it happened again, and opening the hood I saw that the air conditioning lines were frozen. If this issue with fan not blowing when needing the defroster there could be safety issues driving in freezing precipitation. Dealer could not replicate so said there was no problem. There were no warning lights with regard to this problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11597786June 30, 2024
AIR BAGS, SERVICE BRAKES
My emergency brake doesn't work and light is on,and air bags did not deploy when I was hit from behind.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11597796June 30, 2024
POWER TRAIN
Transmission shifted from 6 to 5 at 60 miles per hour. Truck has 60 thousand one owner miles on truck. Dealership had not heard of 6 to 5. No warning lights or messages. Has not been inspected. Very conserved for safety when this happened.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11597817June 30, 2024
UNKNOWN OR OTHER, ELECTRICAL SYSTEM
My truck is brand new. The A/C lines and evaporator coil are freezing up when using the A/C, resulting in no air flow out of the vents in the cabin. I checked forums online and this has been a common problem with my vehicle yet Ford has filed no recall to fix it. Dealership states it’s a faulty temp sensor in the evaporator. Ford refuses to pay for the fix under the vehicle manufacturer warranty because no warning lights are displayed on your dash.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11597839June 30, 2024
POWER TRAIN
Transmission went to 1st gear to 7th gear and stalled out almost caused an accident. Called Ford customer service about the problem after realizing it's an ongoing problem with 2018 Ford F150 5.0 Gasoline engine. I honestly believe a factory recall needs to be before someone loses their life.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11597843June 30, 2024
ELECTRICAL SYSTEM, POWER TRAIN
Twice now in the past 2 weeks I was accelerating from a stop when soon after my truck shifts from 4th to 5th, it’ll slam back down into 2nd gear. Both times my rpms spike, obviously, and my tires briefly screech. Then the truck just shift back up and seems completely normal. There was zero indication of any issues prior to either of these incidents. One of the times, I had my wife and two toddlers in the truck. It was lucky I didn’t lose control either of the times. From the forms that I’ve read, it sounds like I have a faulty transmission range sensor or may need a software update. I have not yet had a dealership officially diagnose my vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11597789June 30, 2024
VEHICLE SPEED CONTROL, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
After starting the vehicle at a motel in the morning, and backing out of the parking spot, I put the vehicle in drive and gave it a little bit of gas (wheel cranked to the left to finish turning out of the spot), and the vehicle rapidly accelerated across the parking lot. I hit the brakes and the vehicle stopped accelerating. I looked down to see the cruise control set to 15 Mph and crossed out (disengaged due to brake engagement). I never set the cruise control at that speed. To the best of my knowledge I never bumped any cruise control buttons that morning. To the best of my knowledge a software glitch caused cruise control to set and engage, from a stop, to an unsafe speed considering the circumstances.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11597700June 29, 2024
POWER TRAIN, VEHICLE SPEED CONTROL
Vehicle is exhibiting issues consistent with the recalled lead frame part on previous year models, despite my 2016 having the same transmission as they do. Truck will randomly downshift into first at slower speeds causing engine to rev very high and not want to shift into next gear. Often times it will get “stuck” in 3rd gear even when coming to a complete stop and leaving a stop in 3rd still. On one occasion the truck shuddered and began to decelerate even as the accelerator was being pressed on the highway causing a significant safety issue, I had to put in neutral and restart the truck while still driving to regain forward mobility of the vehicle. When these things occur typically a little gear wrench symbol will appear on the dash and on one occasion has raised a check engine light with code P0720.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11597701June 29, 2024
POWER TRAIN
I was driving on the highway at 75 mph when the vehicle went into limp mode. All gauges on the cluster stopped working, the odometer readout became dashes, the wrench icon flashed on the gauge cluster, there was no throttle response, and the transmission was stuck in third gear. I experienced a down shift from 6th gear to 3rd while coasting from from the left lane to the right shoulder. No DTCs were registered. I turned the vehicle off and back on and drive it the remaining mile to my house. It happened again a few days later with my children in the car. I had a scan tool with me and the vehicle registered a P0720 code for the output shaft sensor. Again I was able to coast to the side of the road with no throttle response.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150