Ford F-150 Complaints

39,812 consumer complaints on file.

#11633370December 31, 2024
VISIBILITY/WIPER
Rear Window/Glass spontaneously shattered. Loud Noise as it shattered entirely. No apparent cause while driving in parking lot with no bystanders.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11633451December 31, 2024
POWER TRAIN
MY SONS 2020 FORD F150 FELT LIKE IT WAS LOSING POWER. AS I TURNED ONTO HIGHWAY. THE TRUCK SHIFTED FROM THE FIRST GEAR TO SECOND GEAR SMOOTHLY, ASTHE TRUCK SHIFTED FROM 2-3 , THE TRUCK REVED AND DID NOT ENGAGE INTO 3RD GEAR. I LET OFF THE GAS, THINKING IT WILL CATCH THE NEXT GEAR AND CONTINUE TO INCREASE SPEED. BUT IT DID NOT, IT AGAIN REVED AND DID NOT ENGAGE INTO 3RD GEAR. NOW THE TRAFFIC WAS FLYING PAST ME, I PRESSED THE ACCELATOR TO THE FLOOR IN AN ATTEMPT TO AVOID AN ACCIDENT AND NOT BE REARENDED. AFTER SEVERAL SECONDS, THE TRANSISSION ENGAGED AND THE TRUCK BEGAN TO MOVE FORWARD AT A SLOW PACE. THIS IS WHEN I NOTICED ON MY FORDPASS APP, SAYING POWETRAIN MALFUNCTION/REDUCED POWER. I WAS ABLE TO GET THE TRUCK TO THE CLOSEST GAS STATION, WHERE I SHUT THE TRUCK OFF. AFTER SEVERAL MINUTES, I RESTARTED THE TRUCK AND DROVE THE TRUCK TO WORK WITH NO ISSUES. THE NEXT DAY, I TOOK THE TRUCK TO A LOCAL TRANSMISSION SHOP. WHERE THEY INDICATED THE TRANSMISSION WAS SHOT AND NEEDED TO BE REPLACED OR REBUILT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11633459December 31, 2024
VISIBILITY/WIPER, UNKNOWN OR OTHER
Windshield wipers stop working for minutes at a time. Then work and pause off an on half way up the Windshield. The tailgate won't stay up. It will drop open all on its own when driving even when it's locked.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11633145December 30, 2024
ELECTRICAL SYSTEM, ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER
today while driving, my instrument cluster that houses my speed, range, and drivers assistance information went black. i looked up the issue and i am not the only one with this issue. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11633177December 30, 2024
POWER TRAIN:AUTOMATIC TRANSMISSION
The contact owns a 2020 Ford F-150. The contact stated that while driving at an undisclosed speed and attempting to accelerate the vehicle briefly lost motive power before slamming into gear. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the transmission. The vehicle was repaired, but the failure reoccurred 2 additional times. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA hotline for assistance. The VIN was not available. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11633205December 30, 2024
POWER TRAIN
The contact owns a 2014 Ford F-150. The contact stated while driving 55 MPH and approaching a stop, the transmission shifted into third gear. The contact stated that while stopped, parked, or while driving at various speeds, the transmission would unexpectedly shift up or down to third gear. The “WRENCH Symbol” and seat belt warning lights were illuminated. The local dealer was contacted, and the vehicle was taken to the dealer where it was diagnosed and repaired under NHTSA Campaign Number: 24V444000 (Power Train); however, the failure persisted. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 130,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11633214December 30, 2024
ENGINE, WHEELS
My 2017 F150 is 7 years old with 80K mileage. Engine problem: Cold start ticking/tapping/rattle noise. Ford claimed it sent a letter in 2021 but I never received. Googled and found there are large amount of the same complaints on 2017-2020 F150 with 3.5L EcoBoost engine. The Cam Phaser / VCT Units will fail. Vehicles may not restart after auto-start-stop. Ford issued Customer Satisfaction Program 21N03 and Technical Service Bulletin TSB23-2143. Those measures are not enough. Ford should recall all 2017-2020 F150 with 3.5L Ecoboost built before Nov 30, 2019. Lug nuts at wheels: Ford used cheap two-piece nuts. All the nuts were swollen in Dec 2024 and could not be removed by myself. I had to drive my F150 to Quick Lane and paid $140 to get all the nuts replaced with one-piece nuts. An employee of Quick Lane told me Ford used cheap two-piece nuts for long time, and it's a common issue on some Ford vehicles. Image if a tire is flat on highway while the nuts are swollen and the flat tire can not be changed! Ford should recall all vehicles using the cheap two-piece nuts. I still keep the old nuts as an evidence.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11633219December 30, 2024
POWER TRAIN
The contact owns a 2018 Ford F-150. The contact stated while driving at various speeds, the transmission was slipping and banging into gear. No warning lights were illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed, and the contact was informed that the transmission was faulty and needed to be rebuilt or replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 63,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11633235December 30, 2024
UNKNOWN OR OTHER
Incredible load white noise from all speakers, unable to stop without turning truck off. Volume controls do nothing, turning off all radios and accessories does not stop it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11633029December 30, 2024
UNKNOWN OR OTHER
The under carriage splash gaurd keeps tearing off and hangs down. This is a widely known issue and presents a fire hazard and road hazard.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11633280December 30, 2024
SERVICE BRAKES, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
I was traveling 47 mph and suddenly the parking brake was activated, causing the car to brake instantly. Luckily, no one was behind me and luckily it did not cause an accident. There were no lights on the dashboard. I took it to the Ford dealer to have it inspected and they gave me an appointment for 8 days later and let me go home knowing that I could not drive it since I almost caused an accident.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11633073December 30, 2024
EXTERIOR LIGHTING
The contact owns a 2022 Ford F-150. The contact stated that the driver’s side daytime running headlight was flickering while driving. The contact stated that the passenger’s side headlight was dim and the driver’s side fog light failed to operate as needed. The dealer was notified about the failure and related the failure to NHTSA Campaign Number: 23V802000 (Exterior Lighting); however, the VIN was not included. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 56,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11632927December 29, 2024
ENGINE
There has been a continuous oil leak from the oil pan since the vehicle was first purchased from the dealer. The manufacturer is aware of this issue and has issued a TSB for all vehicles from the Kansas and Detroit plants that are affected by a defective oil pan. The manufacturer is refusing to issue a recall despite the issue being wide spread and the dealership reporting that if left unfixed, the issue could result in loss of steering and could cause a serious accident. The vehicle has been inspected by the dealership and instructions were given to contact the customer support center for the manufacturer. The manufacturer admitted to knowing about the defect and still refuses to issue a recall.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11632858December 28, 2024
UNKNOWN OR OTHER, ENGINE
I was instructed to take my truck in for a recall of a sudden downshift issue with the transmissions molded leaf frame. I had told the ford representative that i was experiencing similar symptoms with my vehicle. and some symptoms that were even of even greater risks to me where when coming to a complete stop my vehicle would fail to gain proper speed facing oncoming traffic!! Also i had told the representative that due to those issues i also had the computer re-programmed previously to try to resolve the issue before becoming aware of the recall... i also had purchased an engine and transmission harness from a ford dealer prior to the recall as well, All for which i have not been re-compensated for..after becoming aware of the recall did i understand that the issue lied in the transmissions molded leaf frame which has not been repaired...no actions were taken to remedy my vehicle and i was upset and unsatisfied with the entire process!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11632868December 28, 2024
UNKNOWN OR OTHER
Sunroof rails broke for the second time, and the sunroof will not close on the drivers side. This problem is putting extra pressure on the glass since it isn’t seated properly. Water also leaks in during rain storms and has caused electrical issues. I can now only drive this $95,000 vehicle in good weather.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11632659December 27, 2024
BACK OVER PREVENTION
The contact owns a 2018 Ford F-150. The contact stated while reversing, the back-over prevention camera did not function as intended. The contact stated that the back-over prevention camera displayed a black screen. The contact stated that due to the failure, the vehicle lightly tapped a nearby pole. The contact stated that very little damage was done to the vehicle. The vehicle was taken to the dealer where it was diagnosed with a failed APIM module. The contact was informed that the APIM module needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline and report the failure. The failure mileage was approximately 102,500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11632680December 27, 2024
FUEL/PROPULSION SYSTEM
The metal fuel line from the canister up to the high press fuel rail developed a crack and ruptured without warning. The vehicle was unsafe to drive because it poured a significant amount of gasoline onto the ground when the fuel pump came on. The vehicle was towed to the dealer for repair. The fuel line was inspected by the dealer's technician, rupture was confirmed and both fuel supply and return lines were replaced. After repair was performed, the dealer service representative showed me the fuel line that was replaced.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11632688December 27, 2024
POWER TRAIN:AUTOMATIC TRANSMISSION
The contact owns a 2013 Ford F-150. The contact stated while driving at various speeds, the instrument cluster became inoperable and the vehicle lost drive power while the RPMs were significantly high. The contact stated that the vehicle failed to exceed an unidentified low speed. The power train warning light was illuminated. The contact stated that he pulled to the side of the road on some occasions. The contact stated that the failure had progressively worsened, and the vehicle no longer responded as needed upon turning off and restarting the vehicle. Additionally, the contact stated that the vehicle made an abnormal clunking sound while shifting into gears. The check engine warning light was illuminated. The contact related the failure to NHTSA Campaign Number: 19V075000(Power Train); however, the VIN was not included. The dealer was notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 138,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11632731December 27, 2024
ENGINE, POWER TRAIN
The contact owns a 2014 Ford F-150. The contact received notification of NHTSA Campaign Number: 24V444000 (Power Train). The contact stated that while driving at approximately 35 MPH exiting the highway, the vehicle lost power and stalled. The oil pressure warning light illuminated. The vehicle was steered to the side of the road and inspected. The vehicle was restarted and the failure persisted. The vehicle was taken to the residence but stalled multiple times on the way. Additionally, the contact stated a couple of days later the contact stated that he observed a knocking noise emanating from the engine compartment. The vehicle was then towed to a dealer where it was diagnosed that that the rods were knocking and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11632744December 27, 2024
POWER TRAIN
The contact owns a 2018 Ford F-150. The contact stated while driving 70 MPH, the transmission overheated. There was no warning light illuminated. There was smoke inside the cabin and bed cover. There was an abnormally high-pitched sound detected while driving. While reversing, there was an abnormal sound detected. The vehicle was taken to the local dealer, where it was diagnosed that there was transmission fluid on the exhaust. The dealer removed two quarts of transmission fluid. The vehicle was repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 97,178.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150