Ford F-150 Complaints

39,812 consumer complaints on file.

#11634890January 8, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2021 Ford F-150. The contact stated while driving at an undisclosed speed, the contact that the engine coolant over temperature warning light illuminated. The vehicle was able to restart however, the failure recurred. The vehicle was taken to the dealer where it was diagnosed that the engine coolant system failed and needed to be repaired, The vehicle was not repaired. The manufacturer was made aware of the issue and referred the contact to the NHSTA Hotline for assistance. The approximate failure mileage was 65,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11634932January 8, 2025
STRUCTURE:BODY
Leaking sunroom. I cleaned tube's couple times and it is still happening. Ever time it's been raining my floor mat is soaking wet
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11634937January 8, 2025
POWER TRAIN
The Transmission failed. Before the mechanical light went on. As I was driving the vehicle it was having issues switching gears. And at times would loose power and then rev up and speed up. Loss of power and speeding up is a dangerous and frightening situation in a vehicle going at any speed and even more so while traveling on a highway. I had the vehicle towed to the nearest Ford dealership. In speaking with the service manager they recommended replacing the transmission due to the error codes that were produced in the computer. They stated that this was a common issue in this make and model and a replacement would be the best option to avoid future issues. And after researching the issue online there are many people having this same issue. It’s a $10,000 fix and FORD is aware of it and yet there still is no recall on the failure in these transmissions!! Error codes P2703; P2705; P0767
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11634951January 8, 2025
ELECTRICAL SYSTEM, STRUCTURE:BODY
On [XXX] I took the truck to Ford dealer after noticing the front floor passenger side carpet was wet and door locks and electronic tire pressure indicator failed to operate correctly. Ford service dept found a/c drain was letting water back into passenger compartment and caused body control module (bcm) failure. Bcm was replaced after 2 1/2 months in the service dept. Returned on 8/26/24, 9/18/24, and 10/22/24 for same water intrusion problem. Different repair done on 10/22/24 to remedy problem. Service dept contacted Ford national office and learned this was considered a design flaw by Ford. Expected a recall will be issued. Remedial treatment for mold was applied because I had been smelling a vinegar smell in the truck cab which is typical smell for presence of mold. This is the primary safety issue I believe exists, but failure of body control module could cause other safety problems. . No recall issued yet.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11634847January 8, 2025
POWER TRAIN
Transmission slipped from 4 to 1st while driving almost crashing my truck
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11634780January 8, 2025
FUEL/PROPULSION SYSTEM
Ford Motor Company has issued a safety recall, identified by letter NEF-107DG and recall number 24V-957, due to the potential failure of the CP4 fuel pump in certain vehicle models. The recall affects the following makes, models, and model years: FORD/F-250 SD (2020-2022), FORD/F-350 SD (2020-2022), FORD/F-450 SD (2020-2022), FORD/F-550 SD (2020-2022), FORD/F-600 SD (2020-2022), FORD/F-650 (2021-2022), and FORD/F-750 (2021-2022). This action addresses concerns that the CP4 pump may fail prematurely, potentially leading to engine stalling and increasing the risk of a crash. Notably, my 2021 Ford F-150 XLT with a 3.0L diesel engine is equipped with the same CP4 fuel pump as the models listed above. As such, it should logically be included in this recall to ensure consistent safety measures and address the risks associated with this known defect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11634575January 7, 2025
VEHICLE SPEED CONTROL
My 2014 F150 was recalled for a software patch pertaining to the lead frame in the transmission because the vehicle would abruptly downshift at any speed. After having the recall performed by a dealership, it continued to have the same issue. I was told by the Service Manager the lead frame was bad but the recall did not cover the repair. For my safety I had the repair done and it cost me $1869.64. I contacted NHTSA and was told the dealership would have to contact Ford Motor Company for a warranty code to cover the cost of the repair. Ford Motor Company said the dealership should pay for the repair up front then get reimbursed by Ford Motor Company. The dealership said only NGTSA can include the lead frame in the recall so I was responsible for the cost of the repair. As of this date (1/7/2025), I'm still out $1859.64. I have the lead frame that was removed from the truck and there are no obvious defects (cracks, buildups, etc) so the issue has to be with the control mechanism within the lead frame that the software patch should have corrected. Why has the recall not been upgraded to include replacing the lead frame?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11634632January 7, 2025
POWER TRAIN
The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (Power Train); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving out of the driveway, the vehicle jolted with a thud. The contact was able to be reversed. There was no warning light illuminated. The vehicle was then taken to the dealer for tire replacement and the contact was informed that the axle bolts on the driver’s and passenger’s side of the vehicle had fractured. The contact was informed that the axle bolts needed to be replaced. The manufacturer was not made aware of the issue. The failure mileage was approximately 30,000. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11634656January 7, 2025
ENGINE
Purchased Dec 4, 2019; followed maintenance requirements through BO Beukcman Quality Ford. Oil changes made IAW Ford guidelines every 5000 miles. Oil change was made Nov 23, 2023 at 49,504 miles. Just before next oil change noticed engine knocking on acceleration/deceleration with intermittent check engine light on. Oil changed at 54,226 miles (Aug 22, 2024). Condition mentioned to dealer. Dealer advised engine was consuming oil. There was no visible sign of leaks. Fix -- install new dip stick, reprogram the Powertrain Control Module (PCM). Rationale: Ford TSB 19-2365 Dec 5, 2019 quoted as follows: oil consumption "may be due to high intake manifold vacuum during some deceleration fuel shut off (DFSO) events resulting in oil being pulled into the combustion chamber from the crankcase, valve guides and positive crankcase ventilation (PCV)". Supposedly reprogramming would reduce engine vacuum during DFSO events (note: I noticed knocking on acceleration). At the dealership inquired why Ford did not advise customers of condition. They could not answer my question. My F-150 is a 5.0L V8 and was described by dealer as a Coyote engine. I asked if they had similar maintenance events like mine; answer - yes. I was disappointed; have owned previous F-150s and none "consumed" oil like this -- my previous truck had 150,000+ miles -- no oil burning. The dealer instructed me to bring the vehicle back every 1000 miles to check dipstick for consumption. Returned vehicle to dealer at 55,626 and 56,700 miles. On returns, consumption was noted; they topped off my oil with instruction to return again at 57,626 (current mileage 57,435 miles) This is inconvenient and poses a safety risk to me and perhaps others through engine degradation/failure especially while driving. Believe Ford owes the cunsumer a permanent engine fix. Vehicle is available for inspection NHTSA.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11634596January 7, 2025
SERVICE BRAKES, ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
I was driving around 35-40mph, slowing down, heading to a right hand turn lane. No vehicles in front of me. As I crossed over my lane into the turn lane my e-brake automatically came on and my pre collision braking light came on. No warning, nothing caused by me, and I have no clue how it happened. I had to physically pull the e-brake lever to release the brakes on a major road.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11634538January 7, 2025
LATCHES/LOCKS/LINKAGES
The contact owns a 2022 Ford F-150. The contact stated that on several occasions while the vehicle was parked during inclement weather, the driver’s side door failed to open. The contact stated that on one occasion while the vehicle was parked and attempting to exit the vehicle, the driver’s side door failed to open. The contact stated that after the vehicle had warmed up, the door opened as intended. The vehicle was taken to a dealer where it was diagnosed and determined that an unknown part needed to be replaced. The vehicle was repaired but the failure reoccurred. The manufacturer was notified of the failure. The failure mileage was approximately 42,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11634265January 6, 2025
VISIBILITY/WIPER
My F150 2016 rear glass shatter for no reason. it was parked in driveway and when I came out of morning.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11634275January 6, 2025
UNKNOWN OR OTHER
The transmission was up-shifting from 1st gear to 3rd, then from 6th gear to 8th, then from 8th gear to 10th gear without any increased gas pedal pressure. While at a stop sign and having my foot applied to the brake pedal, the transmission was jumping and jerking the truck forward to move! I had to put my foot harder on the brake pedal to keep the truck from moving into the intersection! I called the dealership and they advised me not to drive our truck, due to possible more damage to the transmission. The dealership told us that it might just be a programming/software issue, that a possible re-flashing of the transmission might be the issue. That the vehicle starts to learn how you drive? We were first charged a service fee to diagnose this transmission about $250.00. I was worried that I would rear end someone, due to this transmission trying to force me forward at every stop! While driving, it was doing a jerking motion that was very forceful. This should be a nationwide recall due to this transmission not responding correctly and possibly causing a serious vehicle accident, not by an operator error! Our mileage was at 48,203 miles when we took it to the dealership. The powertrain is for 5 years or 60,000 miles. We paid $3,520.00 + the $250.00 to diagnose. Ford paid $2,880.00 due to the low mileage and it just ran out of warranty. If you notice any unexplained jerking motion while driving get it checked out ASAP! Ask about Fords Customer Loyalty Score/Financial Assistance to help pay for this unexpected bill!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11634284January 6, 2025
ENGINE, VEHICLE SPEED CONTROL
The contact owns a 2013 Ford F-150. The contact stated while driving at 55 MPH the wrench symbol illuminated and the vehicle lost motive power and went into LIMP Mode. The contact coasted to the side of the road and turned off and restarted the vehicle and the vehicle returned to normal functionality. The failure occurred a total of three times; however, during the third failure, the check engine light illuminated. The vehicle was taken to the dealer who diagnosed the vehicle and determined that the output speed sensor module had failed and needed to be replaced. The dealer informed the contact of an undisclosed Customer Satisfaction Program however, the 10-year limitation had been exceeded. The vehicle had not been repaired. The manufacturer was made aware of the failure. The manufacturer transferred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 147,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11634307January 6, 2025
POWER TRAIN
Violent stutter switching into 3rd gear. Truck bogs down/flares in 5,7,8,9 gears. This could cause a major accident leading to a crash involving this vehicle and others.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11634333January 6, 2025
POWER TRAIN
The contact owns a 2013 Ford F-150. The contact stated while driving approximately 45 MPH, the transmission unexpectedly downshifted to first gear. No warning light was illuminated; however, the icons on the instrument panel became dark. The vehicle was taken to a dealer where it was diagnosed and determined that the lead frame wiring harness needed to be replaced. The contact researched and became aware of NHTSA Campaign Number: 19V433000 (Power Train); however, the VIN was not included. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 97,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11634395January 6, 2025
VISIBILITY:WINDSHIELD
The contact's son owns a 2016 Ford F-150. The contact stated that while her son was driving approximately 60 - 65 MPH with the defroster activated, the rear windshield started to crack. The driver drove the vehicle to the contact's residence and parked the vehicle. The dealer was contacted; however, the contact was prompted to leave a voicemail. The contact had not heard back from the dealer. The contact had made an appointment with a local glass replacement company. The vehicle had not been repaired. The manufacturer was made aware of the failure and referred the contact to the dealer to determine if the failure was caused by an impact before receiving assistance with the replacement. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 85,986.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11634435January 6, 2025
POWER TRAIN
10 SPEED AUTOMATIC TRANSMISSION (10R80) HARSH SHIFTING FROM 3 TO 4, CAUSING SLUGISH AND UNRELIABLE ACCELERATION. SUDDEN BANG INTO 4TH GEAR ALSO SLAMS OCCUPANTS INCLUDING DRIVER OFF SEATS. AAMCO OF EL CAJON, CA CONFRIMED AND CURRENTLY REBUILDING TRANSMISSION DUE TO FAILED VALVE BODY, EXCESSIVELY WARN FRICTION RINGS, SLIPPED CDF DRUM AND WARN TEETH INSIDE DRUM. SYMPTOMS WERE SUDDEN AND SEEMED TO BE WORSENED WITH COLDER WINTER MORNING. NO WARNING LIGHTS. VEHICLE ONLY HAS 59,000 MILES AND WAS DENIED WARRANTY DUE TO BEING OWNED LONGER THAN 6 YEARS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11634441January 6, 2025
POWER TRAIN, ENGINE, BACK OVER PREVENTION
The contact owns a 2017 Ford F-150. The contact stated that shortly after refueling the vehicle; while his wife was driving at a slow speed and merging onto the highway, the transmission failed to shift above 4th gear. In addition, the contact stated that the RMP had increased but the vehicle failed to accelerate as intended. No warning light was illuminated. The vehicle was towed to a local dealer where it was determined that there was failure with 2 wiring harnesses that required replacement. The vehicle was not repaired. Upon further investigation, the contact noticed that the rearview camera image occasionally failed to properly display an image. The manufacturer was made aware of the failure. The failure mileage was approximately 72,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11634447January 6, 2025
POWER TRAIN:AUTOMATIC TRANSMISSION
The contact owned a 2019 Ford F-150. The contact stated while driving at various speeds, the transmission was skipping between the 4th, 7th, and 8th gears. There was no warning light illuminated. The contact stated that while driving and depressing the accelerator pedal, the vehicle was jerking and lurching forward significantly. There was no warning light illuminated. The vehicle was taken to the dealer several times; however, the failure could not be replicated. The contact stated while accelerating from a complete stop and making a turn, the vehicle failed to respond as needed and rolled to a stop in the middle of the highway, nearly causing a crash. The contact turned off and restarted the vehicle several times, and the contact was able to drive to the dealer at a significantly slower speed. The dealer diagnosed the vehicle and determined that the transmission needed to be replaced. The vehicle was then taken to another dealer, Fort Mill Ford (801 Gold Hill Rd, Fort Mill, SC 29708), where the transmission was replaced. The vehicle was repaired. Additionally, the vehicle experienced cam phaser failure and was sold due to the repair cost. The manufacturer was notified of the failure. The failure mileage was approximately 40,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150