Ford F-150 Complaints

39,812 consumer complaints on file.

#11666530June 12, 2025
SUSPENSION, UNKNOWN OR OTHER
I went for an oil change, tire rotation, etc at the dealer on 6/9/25 and was told that my frame had rust damage/holes and would not pass inspection this coming December. Went to Ziebart on 6/11/25 and they confirmed multiple hole/rust damage on frame which needed repair. They were perplexed as no problem was seen at my last yearly check of the rust protection in July of 2024. Also, no mention of a potential problem was found at my last vehicle inspection in December of 2024. How does this kind of damage occur in 6 months? I'm reading on-line that this is an issue with Ford F-150s, but no recall?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666545June 12, 2025
ENGINE
The contact owns a 2018 Ford F-150. The contact stated that while the vehicle was being serviced at an unknown location, the contact was informed that the cam phasers and timing chain were defective. Additionally, the contact stated that the engine made an abnormal sound upon starting the vehicle. There was no warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed that the engine needed to be replaced. The vehicle was not repaired. The contact related the failure to Ford Campaign Number: 21N03. The manufacturer was made aware of the failure but no assistance was provided. The failure mileage was approximately 69,500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666550June 12, 2025
POWER TRAIN, BACK OVER PREVENTION, ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER
The contact owns a 2018 Ford F-150. The contact stated that the vehicle was making an abnormal revving sound and other unknown sounds while the accelerator pedal was depressed. Additionally, the contact stated that the door and A/C and heating system actuator had failed. The contact stated that the rearview was inoperable. There was no warning light illuminated. The vehicle was taken to an independent mechanic, where it was determined that the turbo, the air compressor and the 4-Wheel Drive system needed to be replaced. The contact stated that the actuator was unrepairable and was rigged by the mechanic. The vehicle was repaired; however, the failure recurred. The local dealer was not contacted. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 100,003.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666554June 12, 2025
ENGINE
The contact owns a 2020 Ford F-150. The contact stated that upon starting the vehicle, there was an abnormal rattling sound coming from the engine, followed by a rough idle. There was no warning light illuminated. The vehicle was taken to a local dealer, where it was diagnosed that the cam phasers had failed and needed to be replaced. The vehicle was not repaired. The contact related to the failure to Ford Campaign Number: 21B10. No further information was available. The failure mileage was approximately 100,800.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666559June 12, 2025
POWER TRAIN:AUTOMATIC TRANSMISSION
The contact owns a 2016 Ford F-150. The contact stated that while driving at undisclosed highway speeds, the vehicle stalled after the transmission shifted to the sixth gear. The contact stated that upon restarting the vehicle, the vehicle operated as needed; however, the failure recurred while accelerating and shifting to the sixth gear. The vehicle was taken to the local dealer. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was 79,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666569June 12, 2025
ENGINE, POWER TRAIN
What component or system failed or malfunctioned, and is it available for inspection upon request? VCT Cam Phasers x4 How was your safety or the safety of others put at risk? This is a major engine component that provides power to the vehicle. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes at two separate locations this has been a persistent issue. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Yes I discovered upon this issue when I purchased this vehicle through Enterprise Car sales
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666587June 12, 2025
ELECTRICAL SYSTEM
See attached document for complaint.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666633June 12, 2025
STRUCTURE
The contact owns a 2016 Ford F-150. The contact stated that upon opening the front passenger's side door, the contact noticed that water had leaked into the interior of the door panel through the rubber seal. There was no warning light illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 128,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666549June 12, 2025
POWER TRAIN
Transmission failure Transmission slips between 4th and 7th gears Yes its available for inspection Yes its been diagnosed by FORD No there were no warning lamps or messages, just noticed the shifting problem and took it in.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666458June 12, 2025
ENGINE
My truck falls in the recall for the valve failures and they finally have parts to do the test but there is tons of documents and articles saying Ford agreed with NHTSA to provide a 10 year 150k warranty to people who fall in this recall. per you guys investigation EA23007 under 24N12. When I talked to Ford and the dealer they say that's not a number. Just on principle this is crazy. I bought my truck thinking well atleast Ford is taking care of people on this. After reading the states summary saying Ford would provide that.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666207June 11, 2025
SEATS
Driver seat cushion. Vehicle has 1300 miles on it. moved seat forward and the seat bottom is crooked which is very uncomfortable to drive now as it causes low back pain and is not good for a person like myself with lumbar fusion. Your left leg has no seating area other than your left leg is off the cushion and between door panel seat is probably 15 degrees to right from being centered. Tried to move seat forward and back and up and down with no results. Took back to dealer 6-10-2025 they supposedly looked at the seat track and see nothing wrong with it, without removing seat you would not be able to tell what is defective which dealer didn't do. Compared seat to 2025 model seat is straight. Reading the internet seems to be a manufacturing defect with seats on Ford F150. Can provide vehicle for inspection.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666230June 11, 2025
SERVICE BRAKES, HYDRAULIC
The contact owns a 2019 Ford F-150. The contact stated that while operating the vehicle, the check engine warning light was illuminated. The vehicle was taken to the local mechanic who diagnosed that the brake fluid hose had ruptured while rubbing on the steering column. The contact was advised that the brake fluid hose needed to be replaced. The manufacturer was notified of the failure, but no assistance was offered. The vehicle was not yet repaired. The failure mileage was 118,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666284June 11, 2025
VEHICLE SPEED CONTROL, POWER TRAIN
The contact owns a 2018 Ford F-150. The contact stated that while at a four-way stop, the accelerator pedal was depressed; however, the vehicle failed to respond as needed. The contact stated that the engine revved up, but the vehicle failed to respond. The brake pedal was released, and the vehicle lunged forward, almost causing a crash. The contact stated that the vehicle was jerking while driving at various speeds. There were no warning lights illuminated. The vehicle was taken to the local dealer where it was diagnosed with transmission failure. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The approximate failure mileage was 162,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666319June 11, 2025
VISIBILITY:GLASS, SIDE/REAR
The contact owns a 2015 Ford F-150. The contact stated while the driving at an undisclosed speed, there was an abnormal sound coming from the rear sliding glass. The contact stated that the rear sliding glass frame had fractured. The fractured frame caused the rear sliding glass to push out from the frame. Additionally, the contact stated that due to the failure, water was entering into the rear of the vehicle. The dealer was made aware of the failure and provided the contact with the cost for the diagnostic test. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 50,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666332June 11, 2025
POWER TRAIN
The contact owns a 2013 Ford F-150. The contact stated that while driving on the highway at 45 MPH, the transmission unexpectedly downshifted from high gear to a low gear. The contact stated that the “Service Vehicle Soon” warning light illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed, and the contact was advised that the transmission lead frame was faulty and needed to be replaced. The vehicle was not repaired. The contact referenced Customer Satisfaction Program: 19N01; as a possible cause for the failure. The manufacturer was notified of the failure. The approximate failure mileage was 118,408.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666381June 11, 2025
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
The contact owns a 2017 Ford F-150. The contact stated that while the vehicle was parked, the rear passenger’s side door became inoperable. The contact stated that the rear door would not function properly, and the contact was unable to open the door. The vehicle was taken to the dealer, where it was diagnosed that the rear door cable had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for further assistance. The failure mileage was approximately 70,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666382June 11, 2025
ENGINE
During cold start and sometimes during a warm start the engine rattles. Took to local mechanic and the cam phasers and timing chain are bad. Truck was not covered on recall of newer engines. Truck just went over 100,000 miles outside of the recall. Mechanic said if the timing chain was to come disconnected the truck will stop running and cause heavy damage to the engine.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666388June 11, 2025
ENGINE
In November, dealership sends out a tech to perform a PCM Recall on my truck. 110,000 miles and never had a problem with it. After recall, check engine light comes on after less than 10 miles of driving. Tech returns, runs his program and says maybe this will fix it. Less than 200 miles of driving, check engine light comes on again. Third attempt with tech, runs program, says there is nothing he can do. Dealership says there is nothing they can do except run diagnostics for a fee. Contact Ford corporate, they give the same nothing they can do except run diagnostics for a fee. I refuse. No problems at all with my truck until they performed the PCM recall issued by Ford. Just so happens this problem is being reported on Reddit app by several other Ford owners, but “there’s nothing Ford can do.”
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666409June 11, 2025
SERVICE BRAKES
The passenger side front brake overheated while driving at highway speed. We stopped the truck after smelling the burning odor. The rotor was blue and radiating heat. The driver's side appears normal. Inspection revealed the lower caliper piston was stuck. The piston boot was removed and significant corrosion was found. Truck has 60,000 miles. We are the original owners.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666327June 11, 2025
TIRES
The contact owns a 2025 Ford F-150 equipped with Hankook Tires, Tire Line: Dynapro A/T 2, Tire Size: 275/60/R20, DOT Number: (N/A). The contact stated that upon inspection, it was discovered that the rear passenger’s side tire had a 3/4-inch sized tread separation. A replacement tire was installed. The contact later discovered that the same failure had occurred with the front passenger’s side tire. The cause of the failures were not yet determined. The manufacturer and local dealer were notified of the failure. The failure mileage was 5,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150