Ford F-150 Complaints

39,812 consumer complaints on file.

#11674940July 21, 2025
PARKING BRAKE, ENGINE, FUEL SYSTEM, GASOLINE
The contact owns a 2022 Ford F-150. The contact stated the parking brake was intermittently illuminated. The contact stated that the vehicle was shaking and vibrating abnormally while depressing the brake pedal. The contact stated that the VIN was included in NHTSA Campaign Number: 23V509000 (Parking Brake), which stated that the wiring harness needed to be replaced. The dealer determined that the failure was caused by the recall. The dealer also determined that the rotors needed to be replaced. The rotors were replaced. The contact stated that the rear brake rotors were replaced three times. The dealer informed the contact that the recall was considered completed and had not replaced the harness but secured the existing harness with a zip tie. The contact stated that approximately one year later, the parking brake light started to illuminate intermittently. The dealer was informed; however, the vehicle was not repaired. The contact stated that the check engine warning light illuminated while the fuel tank was full. The contact stated that the check engine warning light was intermittently illuminated. The vehicle was taken to a certified mechanic, who diagnosed that the knock sensor had failed and needed to be replaced. The vehicle was not repaired. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted. The manufacturer was made aware of the issue. The failure mileage was approximately 47,000. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674843July 20, 2025
POWER TRAIN
Our home is situated on a blind curve, and the speed limit is 55 mph. When pulling out onto the road, adequate acceleration is necessary to merge with the traffic flow. The truck initially accelerates as expected, then stops accelerating before suddenly jerking forward. Occasionally, it takes several seconds for the vehicle to accelerate, which creates a hazardous situation when approaching traffic is moving at 55 mph. It has not caused an accident yet but it has caused me to adjust my driving and times to use the truck. I use my wife's car (another Ford) most of the time. This hesitation and strange shifting poses safety risks for all road users. On 5/21/2025, I took the truck to Ford dealer, and on 5/30/2025, was informed that major work was required on the transmission and differential, estimated at $12,383.80. Seeking an alternative assessment due to financial considerations, I consulted a specialist who confirmed that the transmission and pinion bearings needed repair or replacement. The vehicle was returned to dealer on 6/4/2025 for differential repairs, completed on 6/13/2025 at a cost of $4,486.26. The transmission repair was not in the budget. Subsequent research indicated that the 10R80 transmission has a record of mechanical issues, service bulletins, recalls, and related legal matters. It appears likely that the jerky shifting of the transmission contributed to the failure of the pinion bearings. Although the truck is out of warranty and has 64,430 miles, given the safety concerns, I request that Ford review my case for assistance with the remaining transmission repairs, in light of documented issues with the 10R80. I request that Ford evaluate this request in consideration of customer satisfaction, public safety, and corporate responsibility. I know Ford is well aware of the problems as there are 474 other complaints on file. They need to step up and do the right thing before this causes serious injuries.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674848July 20, 2025
UNKNOWN OR OTHER
Back up camera does not work blank blue screen or freezes up or graney view can't see any possible hazards behind vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674871July 20, 2025
ENGINE, FUEL/PROPULSION SYSTEM, ELECTRICAL SYSTEM
Recall Action Soon Issue Since 07-11-2025 Low pressure fuel pump failure For More Information Telematics Generated Issue Recall Action Soon Issue Since 05-16-2025 Rear camera screen software update For More Information Telematics Generated Issue
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674683July 19, 2025
POWER TRAIN
The truck drops from sixth gear to fourth gear randomly while at high speeds. I took it in and they told me it was not covered by the recall that was done a couple years ago for this very same reason. I took it into five star Ford in Plano Texas. They told me that recall expired. I took it in then and they supposed changed out faulty parts.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674698July 19, 2025
STRUCTURE:BODY
Door Latch Freezing during cold winter months(every year) where temperatures drop below 32°F even after Ford Recall done on both front door latches. Inability to open door, then after door opened there is an Inability for door to latch until it warmed up.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674700July 19, 2025
POWER TRAIN, ELECTRICAL SYSTEM
Ford dealership Jack Kissee in Claremore, OK is telling me my truck is 6k miles out of warranty for Recall 19N01. I have owned my 2013 F150 for less than 2 years with no knowledge of any previous recalls or repairs needed by Ford. This has not been an ongoing issue and has only happened within the last 1,000 miles I have put on my truck. Wrench light and icon pop up on the dash and puts the truck into limp mode until I can get pulled over and get the truck shut off. Safety risk to everyone on the rode. Please let me know if there is a way this Recall 19N01 can be covered. Thank you.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674785July 19, 2025
STRUCTURE:BODY
This is an extended cab - 4 door - the rear doors are half doors with a a handle allowing entry and exit to and from the rear passenger seats. (It is not a crew cab 4 door). The doors LOCKED and the handles failed with a child in the rear seat. THe doors cannot be opened. The child and his mother had to climb over the center console to exit the vehicle. THe vehicle is at a mechanic who states no part are available to repair this faulty and unsafe door mechanism. Both rear doors are LOCKED. QUalified mechanic estimates the cost to rig a fix, in absence of any left door mechanism parts will be near or over $500.00. THe mechanic reports that the control cables from the handles to the door latch stretched and failed. If there had been a collision or engine fire, rear seated passengers would be trapped inside the vehicle. THIS NEEDS TO BE ADDRESSED and REPAIRED BY FORD.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674788July 19, 2025
ENGINE
I purchased this truck about a year ago. After two oil changes, the cam phasers began to rattle on startup. It has the 3.5l Ecoboost engine. This is a known problem and there have been tsb's but they come and go during short windows. The cam phasers were finally updated in 2021 but some people have paid thousands in and out of warranty, some multiple times before the issue is fixed. Ford says they are just a noise and do not cause any issues but the resale is directly effected whether private party or trade in (repair typically costs between $4-7500). Mine started making noise at 89,000 miles. Some people go years with the engine rattling and others have check engine lights and engine issues a shirt time after it begins. Ford knows it is a problem and the customer service sometimes will assist with the cost and other times they tell people to file a complaint here to finally get a recall going. The repair is in depth and typically requires the removal of the cab from the frame, making it likely that everything won't be reassembled correctly.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674795July 19, 2025
FUEL/PROPULSION SYSTEM, ENGINE, ELECTRICAL SYSTEM
2022 F-150 VIN: [XXX] ------------------------------------------------------------------------------------------------------------ Issue Since 07-11-2025 Low pressure fuel pump failure Recall Action Soon Issue Since 05-16-2025 Rear camera screen software update -------------------------------------------------------------------------------------------------------------- Issue Date 2025-06-13 Campaign 25S65/25V404 Description On your vehicle, in the event of unexpected 12V battery discharge, the front door electronic latches retain their last lockunlock status. If the driver or front passenger exit the front doors using the mechanical inside release handles, the doors may remain locked when they are closed. This may result in an unexpected lock-out condition for the driver and front passenger without the ability to immediately re-enter the vehicle. Safety Risk An occupant who remains inside a locked vehicle and unable to use an inside door release handle may be unable to be rapidly retrieved by a passenger who has exited the vehicle. This could increase the risk of injury in emergencies or hot weather. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674793July 19, 2025
POWER TRAIN, FORWARD COLLISION AVOIDANCE: WARNINGS
Issue Date 2025-06-13 Campaign 25S65/25V404 Description On your vehicle, in the event of unexpected 12V battery discharge, the front door electronic latches retain their last lockunlock status. If the driver or front passenger exit the front doors using the mechanical inside release handles, the doors may remain locked when they are closed. This may result in an unexpected lock-out condition for the driver and front passenger without the ability to immediately re-enter the vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674694July 19, 2025
STEERING
Trucks steering randomly goes out mainly when backing up or right after backing up and start to move forward.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674621July 18, 2025
ENGINE, POWER TRAIN
The contact owns a 2016 Ford F-150. The contact stated that while driving at an undisclosed speed, the transmission unexpectedly downshifted, with the check engine and transmission warning lights illuminated. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The approximate failure mileage was 119,845. The VIN was not provided.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674634July 18, 2025
ENGINE
The contact owns a 2018 Ford F-150. The contact stated while driving at an undisclosed speed, there was white smoke coming from the exhaust. In addition, the contact stated that the engine was running abnormally rough. No warning lights were illuminated. The vehicle was taken to the dealer where it was diagnosed with a blown head gasket and engine failure. The contact was informed that the engine needed to be replaced. The vehicle was being repaired. In addition, the contact was informed that the failure was due to an abnormal oil consumption. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 180,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674648July 18, 2025
ENGINE, FUEL/PROPULSION SYSTEM
In November of 2024, my truck was shaking, accelerating erratically, and felt like the transmission was slipping. The check engine light came on as well. I took it to the shop and after diagnosing that it was a misfire issue in cylinder 6, they replaced spark plugs, fuel injectors, and tried to switch out new coils. They found gasoline inside cylinder 6, and upon doing a compression test, it was well below 100%. The truck continued to have misfires in cylinder 6, ultimately leading to 0% compression in that cylinder after taking it back to the same authorship to diagnose. After researching online forums and technical bulletins, it’s clear this issue is not uncommon among 2.7L EcoBoost engines from this model year, suggesting a manufacturer defect. The cost to replace the engine (as now recommended) has been estimated at nearly $10,000. With the history of regular oil and maintenance by the previous owner and myself, I feel this is a manufacturing defect that could potentially cause harm to the driver and passengers.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674446July 18, 2025
ENGINE, POWER TRAIN, UNKNOWN OR OTHER
My 2017 Ford F-150 is experiencing an oil pan leak. F150 model is equipped with the 2.7L EcoBoost engine. This is a lack of RTV adhesion at the oil pan seal. My dealership wants over 1k to fix which I refuse to pay. This issue was created by poor engineering and craftsmanship on Fords end and the consumer should not have to pay to fix this known issue. I understand there is a fix that involves a 1-piece aluminum pan, as seen on many you tube videos. I'm requesting that Ford be held responsible for fixing this issue and not the consumer, who paid a lot of money for this truck. Any help in getting this resolved would be greatly appreciated.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674463July 18, 2025
ENGINE, VEHICLE SPEED CONTROL
The contact owns a 2015 Ford F-150. The contact stated that while driving 75 MPH, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. In addition, the check engine warning light illuminated, and the vehicle stalled. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The dealer was made aware of the failure; however, the contact was requested to pay a diagnostic fee. The contact stated that due to the persistent failure, the contact was fearful of driving the vehicle. The contact stated that the failure had occurred four times. The manufacturer was made aware of the failure, and a case was filed. The contact referenced an unknown recall; however, the VIN was not included in the recall. The contact was advised to contact the NNHTSA Hotline to report the failure. The failure mileage was approximately 80,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674510July 18, 2025
POWER TRAIN
The contact owns a 2018 Ford F-150. The contact stated that while starting the vehicle, there was an abnormally loud sound coming from the engine. The contact stated that several minutes later the vehicle functioned as intended. The check engine warning light was illuminated. The contact received notification of Technical Service Bulletin: 21B10. The vehicle was taken to the dealer where it was diagnosed that the cam phasers had failed and needed to be replaced. The vehicle was repaired; however, the failure recurred afterwards. The contact stated that an abnormally loud sound was coming from the engine with the check engine warning light illuminated. The vehicle was taken to another dealer where it was diagnosed with cam phaser failure. The repair was pending. The manufacturer was not contacted. The failure mileage was 87,560.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674523July 18, 2025
POWER TRAIN
Bought a 2019 ford f150 V6 3.5L Having issues with transmission slipping gears really hard! Even after warming up car then put in drive I accelerate maybe 3-5mph Due to speed bumps in neighborhood From gear 1 skips 2 and goes to 3rd gear hard and I have to be ready to break cause it kicks in to 3rd gear and speeds up. Even when on main road almost almost crashed into cars. Numerous times. It’s actually scary during with family in truck do to these issues. Also just that 40-45 mph 5-7 gear skip and slipping so much almost crashed!! . Pls investigate this issue people bye this brand due to thinking it’s a safe, spend so much money on this truck purchase then find out problems that has nothing to do with its customer. Just selling something just to stay in the 500 fortune company lvl And not caring bout the customer life and family when they purchase FORD PRODUCT. Just NOT RIGHT!! With out us customers your product is just sitting unsold sitting brand. Due what’s right by your customer and own up to doing the right thing. To all those other customers pls continue to be alert when driving, be safe..
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674527July 18, 2025
POWER TRAIN
Going 50mph+ down road and transmission downshifting to 1st gear and won't do anything for a whole minute then kicks back into 5-6th gear. Does it multiple times. Almost wrecked on busy interstate due to this happening. This recall needs to be extended to the 15-17 truck also with 6R80
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150