Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2013-2017 Audi A5 Cabriolet, A5 Sedan and Audi Q5 vehicles, 2012-2015 Audi A6 vehicles and 2013-2016 Audi A4 Sedan and A4 allroad vehicles. These vehicles, equipped with 2.0l Turbo FSI engines, have an electric coolant pump that can either become blocked with debris from the cooling system causing it to overheat or can short-circuit from moisture within the pump.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2013-2016 Audi A5 Coupe, A5 Cabriolet, A4 Sedan, A4 Allroad and Q5 vehicles. Contact corrosion within the electrical connector for the auxiliary heater may cause the heater wires to overheat or melt.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2013-2017 Audi Q5 and 2013-2017 Audi Q7 vehicles. These gasoline-powered vehicles have a fuel pump flange that may crack, allowing fuel to leak.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2011-2017 Audi Q5 vehicles. The sunroof drainage system may allow water to soak into the foam surrounding the side head air bag inflator canister resulting in the corrosion of the canister. If this happens, the corrosion can weaken the canister and the inflator could fracture without air bag deployment, propelling fragments into the passenger compartment, striking and causing serious injury to vehicle occupants.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2013-2017 Audi A5, A5 Cabriolet and Q5 vehicles, 2013-2016 Audi Allroad and Audi A4 vehicles and 2012-2015 Audi A6 vehicles. These vehicles, equipped with 2.0l Turbo FSI engines, have an electric coolant pump that can be blocked with debris from the cooling system, resulting in the pump overheating.
My Q5 has a defective subframe. The system is defective because plastic coverings on the subframes of Audi Q5s and SQ5s trap moisture and other elements, causing the subframe to rust, rot, and corrode undetected, which creates a dangerous safety hazard, the existence and extent of which is concealed by the plastic coverings. This results in a myriad of negative consequences for the Class Vehicles and their safe and reliable operation. The defect, which can only be discovered after removing the plastic covering on the vehicles’ steel subframe, leaves an affected Audi vulnerable to “structural instability.”
No injuries · No fire · No crash
The rear sub frame has completely rusted through, on both driver and passenger sides. This makes the vehicle extremely unsafe to drive. It is a 2014 q5 with 160k miles. There is a hole on the bottom of the frame on both sides due to a poorly designed cover that traps salt and other road debris leading to premature failure.
No injuries · No fire · No crash
Post fix EDR cooler failure causing coolant fluid loss " enough complaints =pressure on Audi Reference EA189 emissions fix Subject: Goodwill Assistance Request – 2014 Q5 TDI EGR Cooler – VIN [XXX] Audi Customer Experience Team, I am writing to request goodwill assistance for my 2014 Audi Q5 TDI, VIN [XXX] , with 105,000 miles. Vehicle Issue The car is losing engine coolant with no external leaks. Symptoms are consistent with a failed EGR cooler: low coolant warnings every few weeks, white smoke on cold starts, and no puddles or visible leaks. This is a documented failure mode on the 3.0L TDI V6 engine, especially after the emissions modification. Warranty Background - Original in-service date: [XXX] - Emissions modification completed: 2018 - Current mileage: 105,000 I understand the EGR cooler is a covered component under the TDI Extended Emissions Warranty as an emissions-related part. While the 10-year time provision from the in-service date expired [XXX], I am well under the 120,000-mile limit. The 4 years/48k miles from the 2018 modification also places the failure directly within the spirit of the extended coverage. Basis for Goodwill Request The EPA-approved emissions modification increased EGR duty cycles and thermal stress on the cooler. This failure is a direct consequence of that modification. Repair quotes from Audi dealers are $1,200-$2,000 due to the labor involved to access the cooler in the V of the engine. The vehicle has been maintained with VW 507.00 specification oil and has no aftermarket modifications. I intend to keep the vehicle long-term if repaired. Request I respectfully request Audi cover the diagnosis and replacement of the EGR cooler under goodwill. I am happy to have the work performed at an authorized Audi dealer in Houston. I appreciate your consideration and can provide service records or additional photos if needed. I can be reached at [XXX] or this email. Thank you INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)
No injuries · No fire · No crash
Severe corrosion of the rear subframe crossmember on a 2014 Audi Q5 Premium Plus, purchased with 65,464 miles. Two independent inspections in South Carolina confirmed structural failure. Audi of Greenville, an authorized Audi dealership, marked the condition as VERY DANGEROUS on the service invoice and quoted $4,711.52 for subframe replacement. They were unable to perform a wheel alignment due to the severity of the corrosion. Yoder's Automotive in Westminster, SC independently confirmed the subframe was rusted beyond repair on both sides. Fist-sized holes have corroded through the structural metal on both sides of the subframe. The vehicle has plastic stone guard covers bolted over the subframe from the factory. These covers trapped road salt and moisture against unpainted mild steel, accelerating concealed corrosion that was invisible until the covers were removed during inspection. The vehicle is undriveable and has not been driven since the defect was discovered in approximately March 2026. This defect pattern is documented in at least 16 prior NHTSA complaints for Audi Q5 models spanning model years 2010 through 2018. Audi has revised the subframe part number at least five times (8R0505235F through 8R0505235N) but has issued zero recalls and zero consumer notifications.
No injuries · No fire · No crash
This vintage 2014 Audi A5 has a well known serious rust perforation issue with the rear subframe. The corrosion / rust through of two major holes, approx 3 inches in diameter, causing structural failure of the sub frame. This is a major saftey concern with these cars from model year 2009 thru 2017. The only remedy is replacement of the sub frame under Audi's 12 year rust perforation warranty or good will.
No injuries · No fire · No crash