Volvo S60 Complaints

1,272 consumer complaints on file.

#10661751January 29, 2015
ENGINE AND ENGINE COOLING
2004 VOLVO S60R, EXPERIENCE TOTAL ENGINE SHUTDOWN AT APPROXIMATELY 30 MPH THE VEHICLE JUST QUIT RUNNING. CW A DIAGNOSTIC INVESTIGATION BY THE DEALER, CONFIRMED THE FUEL PRESSURE SENSOR WAS AT FAULT. THE SENSOR WAS REPLACED AT A COST OF $ 420.69. THE CONSUMER INQUIRED ABOUT A RECALL. HOWEVER, HE WAS INFORMED HIS VEHICLE WAS NOT INCLUDED IN RECALL # 07V226000. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10679737January 29, 2015
SERVICE BRAKES
THIS REPORT CONCERNS THE FAILURE OF THE PARKING BRAKE ASSEMBLY ON MID 2000S VOLVO SEDANS AND SPECIFICALLY, A 2006 VOLVO S60, 2.5T. SPECIFICALLY, A DE-LAMINATION OF THE PARKING BRAKE SHOE ASSEMBLY, WHICH RESULTS IN A TENDENCY FOR A METAL COMPONENT OF THE SHOE ASSEMBLY TO DISLODGE AND JAM BETWEEN THE BRAKE PAD AND ROTOR, RESULTING IN THE BRAKE SUDDENLY LOCKING UP WITH NO WARNING. WHILE THE EVENT GIVING RISE TO THIS REPORT OCCURRED AT APPROXIMATELY 20MPH, AT HIGH SPEEDS, A BRAKE JAM EVENT OF THIS NATURE COULD RESULT IN SERIOUS INJURY OR DEATH. THE ONSET OF THE DE-LAMINATION OF THE PARKING BRAKE SHOE ASSEMBLY OCCURS WITH NO WARNING, OTHER THAN A MILD BUMPING NOISE WHEN THE VEHICLE IS PLACED INTO REVERSE OR DRIVE AT LOW SPEEDS. UPON INQUIRY TO SEVERAL VOLVO-SPECIFIC REPAIR SHOPS, AS WELL AS MULTIPLE REPORTS ON ONLINE VOLVO-SPECIFIC FORUMS, THIS PROBLEM IS KNOWN TO BE A RELATIVELY COMMON ISSUE AFTER APPROXIMATELY 4-8 YEARS OF NORMAL WEAR AND/OR 50,000-100,000 MILES OF USE ON THE EMERGENCY BRAKE SHOES. HOWEVER THERE IS NO SERVICE BULLETIN ISSUED BY VOLVO AS TO THIS PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10679079January 27, 2015
ENGINE AND ENGINE COOLING
TL*THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THE CHECK ENGINE LIGHT ILLUMINATED AND THE ENGINE SEIZED. THE FAILURE HAD RECURRED SEVERAL TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CONTACT STATED THAT THE VEHICLE WAS EXHIBITING THE SAME FAILURES AS LISTED IN RECALL NHTSA CAMPAIGN NUMBER: 07V226000 (ENGINE AND ENGINE COOLING). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 187,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10677090January 21, 2015
ENGINE, STEERING, SERVICE BRAKES
THE 2.4L 2004 VOLVO S60 EXPERIENCES ERRATIC BEHAVIOR AND ENGINE FAILURE WHEN OPERATING MULTIPLE CONCURRENT ELECTRICAL SYSTEMS. WHEN THESE SYSTEMS (OPERATED WITHIN SPECIFIED GUIDELINES) ARE USED CONCURRENTLY THEY CAUSE THE FOLLOWING CONDITIONS: ENGINE FAILURE, LOSS OF POWER STEERING, LOSS OF BRAKES. THE FOLLOWING IS A LIST OF ELECTRICAL CHANNELS THAT HAVE BEEN USED TO TRIGGER THE ENGINE FAILURE: BRAKES, INDICATOR LIGHTS (RIGHT OR LEFT) HEATED SEATS (X2) FRONT WINDSHIELD DEFROST MULTIPLE S60 MODEL OWNERS HAVE REPORTED HAVING EXPERIENCED THIS SAME ENGINE FAILURE WHICH CANNOT BE DETECTED BY THE MANUFACTURES DIAGNOSTICS TEST. WHEN TESTED THE BATTERY, ALTERNATOR AND COMPUTER ALL PRESENT POSITIVE READ-OUTS. HTTP://REPAIRPAL.COM/REPLACED-MAP-SENOR-AND-MAF-AIRFLOW-ENGINE-LIGHT-BACK-ON-HESITATE-STILL-CUT-OFF-321 HTTP://COMMUNITY.CARTALK.COM/DISCUSSION/2290017/VOLVO-S60-ENGINE-CUTS-OFF-WHILE-TURNING HTTPS://ANSWERS.YAHOO.COM/QUESTION/INDEX?QID=20110502120739AA0TJSR THIS IS A SERIOUS CONDITION THAT COULD RESULT IN A COLLISION OR EVEN DEATH. A RECALL ON THIS MODEL IS BEING IMMEDIATELY REQUESTED. THANK YOU, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10677125January 21, 2015
AIR BAGS
TL* THE CONTACT OWNS A 2006 VOLVO S60. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE BECAME INVOLVED IN A CRASH WITH ANOTHER VEHICLE AND THE AIR BAG WARNING LIGHT ILLUMINATED. THE CONTACT HEARD A LOUD BANG AND A BURNING ODOR EMITTED FROM THE AIR BAG. HOWEVER, THE AIR BAG DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.
Crash:
Yes
Fire:
Yes
Injuries:
0
Deaths:
0
#10676782January 20, 2015
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2003 VOLVO S60. THE CONTACT STATED THAT THE ENTIRE INSTRUMENT PANEL GRADUALLY BECAME INOPERABLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE INSTRUMENT PANEL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 90,000. UPDATED 4/20/15*CN
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10681259January 7, 2015
STEERING
I AM WRITING ABOUT WHAT MAY BE DESIGN FLAW WITH THE VOLVO S60R THAT HAS ME VERY CONCERNED. MY FRONT TIRES RUB ON THE BODY IN THE WHEEL WELL WHEN I TURN SHARPLY INTO A PARKING SPACE. I DON'T THINK IT SHOULD DO THAT BUT I'VE BEEN TOLD IT'S "NORMAL" AND THE CAR "SETTLES" AS IT GETS OLDER. SEVERAL OTHER VOLVO S60 OWNERS HAVE THIS SAME PROBLEM WHERE THE TIRES RUB ON THE BODY. PLEASE LOOK INTO THIS. I BELIEVE IT WILL CAUSE SERIOUS CONSEQUENCES IN AN EMERGENCY SITUATION AND IT'S WEARING DOWN THE EDGE OF THE TIRES PREMATURELY, WHICH MAY ALSO BE DANGEROUS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10670683January 7, 2015
ENGINE
TL-THE CONTACT OWNS A 2012 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE LOW OIL WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE FOUR QUARTS OF OIL WERE EMPTIED BUT THE FAILURE WAS UNDETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 47,100. DJR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10668747December 29, 2014
SEATS, ELECTRICAL SYSTEM
DRIVER'S SIDE SEAT STARTED SMOKING WITHIN A FEW SECONDS OF STARTING THE VEHICLE WHILE BACKING OUT OF PARKING PLACE. SEAT HEATER WAS ON. IMMEDIATELY STOPPED AND TURNED OFF SEAT HEATER AND SMOKING STOPPED. QUARTER SIZE HOLE WAS BURNED INTO THE LEATHER SEAT BOTTOM ON THE DRIVER'S SIDE OUTSIDE PANEL. TOOK IT TO DARRELL WALTRIP VOLVO/SUBARU IN FRANKLIN, TN, AND THEY SAID IT WAS THE SEAT HEATER AND TOOK THE FUSE OUT. SAID IT WASN'T COVERED UNDER WARRANTY AND NO RECALL OUT. HOPE NO ONE HAS THIS PROBLEM DRIVING DOWN THE INTERSTATE. BEST REGARDS AND THANKS FOR ALL YOUR HARD WORK, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10668912December 29, 2014
FUEL SYSTEM, GASOLINE
I HAVE A GAS/FUME SMELL COMING FROM MY CAR ,I CAN SMELL THE FUMES WHEN I STAND NEXT TO VEHICLE. DO YOU KNOW WHAT I SHOULD CHECK OR ANY RECALLS FOR THIS VEHICLE. THANK YOU *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10668444December 27, 2014
POWER TRAIN
IN 2008, AT ABOUT 93K MILES, THE TRANSMISSION ON MY 2001 VOLVO S60 FAILED WHILE I WAS DRIVING ON A MAIN THOROUGHFARE. FORTUNATELY, I WAS ABLE TO AVOID BEING IN AN ACCIDENT. I HAD A VOLVO DEALER INSTALL A NEW VOLVO TRANSMISSION. IN 2014, AT ABOUT 123K MILES (OR ABOUT 30K MILES ON THE NEW TRANSMISSION), THE SECOND TRANSMISSION FAILED WHILE I WAS DRIVING ON A LOCAL STREET. AGAIN, I WAS ABLE TO AVOID AN ACCIDENT. A SEARCH OF THE NHTSA DATABASE AND OTHER ONLINE SOURCES SHOWED THAT THERE HAVE BEEN NUMEROUS EARLY TRANSMISSION FAILURES WITH VOLVOS LIKE MINE. VOLVO OF NORTH AMERICA REFUSED TO DO ANYTHING TO HELP FIX THE FAULTY TRANSMISSION DESPITE INFORMATION THAT THERE IS A PROBLEM WITH THE TRANSMISSION THEY HAVE BEEN USING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10667635December 22, 2014
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE PARKED, THE VEHICLE WAS LEAKING A LARGE AMOUNT OF FUEL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 97,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10667039December 18, 2014
ENGINE, ELECTRICAL SYSTEM
WHILE DRIVING APPROXIMATELY 70MPH IN HEAVY TRAFFIC, IN UNFAMILIAR AREA AND DARK, THE CAR EXPERIENCED COMPLETE SHUTDOWN OF ELECTRICAL AND MECHANICAL POWER. THE SHUTDOWN WAS INSTANTANEOUS WITHOUT ANY PRIOR WARNING THAT A CATASTROPHIC FAILURE WAS LOOMING. THE DRIVER WAS WITHOUT ALL LIGHTING, POWER ASSIST BRAKES OR STEERING. THIS ISSUE WAS GREATLY COMPLICATED BY NOT BEING SUFFICIENTLY VISIBLE TO OTHER DRIVERS, PROMPTING SEVERAL LAST MOMENT EVASIVE MANEUVERS WHILE EXITING THE ACTIVE LANES. INITIALLY, THE CAR DID NOT RESPOND TO ATTEMPTS TO START OR TO GET LIGHTS TO ILLUMINATE. AFTER APPROXIMATELY 3 MINUTES, THE CAR STARTED AND OPERATED NORMALLY. EVERYTHING HAD APPEARED TO RESET, AS IF CAR HAD BATTERY DISCONNECTED AFTER SERVICE. THIS APPEARS TO ME AS A REPEAT OF THE COMPLAINT FILED ON THE 2007 VOLVO S60 DATED 7-2-2014, WHERE THE OWNER REPORTED ?COMPLETE AND TOTAL ELECTRICAL FAILURE? FOUR TIMES IN ABOUT A YEAR. VOLVO WAS NOTIFIED THE NEXT MORNING OF THIS NEW EXAMPLE OF THEIR HORRIFYING SAFETY ISSUE. I WAS INSTRUCTED TO TAKE IT TO THE LOCAL VOLVO SERVICE DEPARTMENT WHERE THE ISSUE COULD BE DIAGNOSED. THE CAR WAS TAKEN TO THE DEALER AND I GAVE THE SERVICE ADVISER REFERENCE NUMBERS FOR BOTH THE CONVERSATION I HAD WITH VOLVO AND THE NHTSA FOR THE COMPLAINTS I FILED. ADDITIONALLY, THEY WERE GIVEN THE INFORMATION ON THE PRIOR COMPLAINT DESCRIBING THE SAME ISSUE. AFTER 1 DAY IN SERVICE DEPARTMENT, PROBLEM CANNOT BE DIAGNOSED. OTHER THAN AN ISSUE WITH CODE/CODES, RELATING TO FUEL PRESSURE, THERE IS NO IMMEDIATE INDICATION OF WHAT MAY HAVE CAUSED THIS INSTANTANEOUS COMPLETE ENGINE AND ELECTRICAL FAILURE. CURRENTLY, THE TECHNICIAN IS EMAIL CORRESPONDING WITH ?PEOPLE IN NJ? TO TELL HIM ?WHAT THEY WANT HIM TO DO? OUR CAR HAS 99K MILES AT TIME OF FAILURE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10664766December 17, 2014
ENGINE
TL* THE CONTACT OWNS A 2007 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 70 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS STARTED AND FUNCTIONED AS NORMAL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 99,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10664629December 16, 2014
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2001 VOLVO S60. THE CONTACT STATED THAT FUEL WAS SEEPING FROM THE TANK NEAR THE PUMP AND ONTO THE GROUND. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 180,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10663718December 11, 2014
AIR BAGS, ELECTRICAL SYSTEM, EXTERIOR LIGHTING
DRIVING CAR LIGHTS ON DASH BOARD WENT COMPLETELY OFF. TOOK IT TO SHOP THEY TAP IT AND DASH CAME ON AGAIN, CHANGE FUSE . LIGHTS WENT OFF AGAIN AND STAYED OFF. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10662665December 7, 2014
SERVICE BRAKES, ENGINE, FUEL/PROPULSION SYSTEM
THE CAR HAD DIFFICULTY IN STARTING ALL OF A SUDDEN. IT APPEARED TO BE AN ELECTRONIC IGNITION PROBLEM. AFTER A FEW STARTS, WARNING SIGNALS STARTED COMING ON. FIRST WAS "ENGINE UNDER PERFORMANCE" AND THEN IT WAS "BREAK FAILURE". THE CAR WAS STOPPED AND TOWED TO VOLVO DEALER. THE DEALER INDICATED THAT THE CAR'S FUEL PUMP / LINES WERE DESIGNED AND INSTALLED OUTSIDE THE WEATHER SHIELDED HOUSING. THE SALT USED FOR SNOW MELTING CORRODES THESE LINES AND SEVERAL CARS SHOW UP WITH THIS ISSUE.SO THEY REPLACED THEM AND MOVED THEM TO WITHIN THE WEATHER PROTECTED AREA. SEARCHING THE INTERNET, I FOUND SEVERAL VOLVO CARS OF THIS ERA HAVE THIS PROBLEM AND SEVERAL OCCURRED WHILE DRIVING - BOTH LOSS OF SPEED AND BREAK FAILURE. MY CAR WAS WELL MAINTAINED, REGULAR OIL CHANGES WITH THE SYNTHETIC OIL AND MAINTAINED BY VOLVO DEALER OR SPECIALIST. I ALSO USE THE RECOMMENDED 91 OR 93 OCTANE GAS, SO IT CANNOT BE ATTRIBUTED TO LAX MAINTENANCE OR LESSER QUALITY FUEL. THE ONLINE FORUMS SEEM TO HAVE ALL KINDS OF DIAGNOSTICS FOR THIS PROBLEM. IF IT WAS A DESIGN FAULT AT MANUFACTURER, AS ADVISED BY THE VOLVO DEALER, I WOULD THINK IT WOULD SHOULD BE INVESTIGATED FOR RECALL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10661589December 2, 2014
ENGINE
TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING 5 MPH, THE ENGINE STALLED.THE PROBLEM RECURRED NUMEROUS OF TIMES. THE VEHICLE WAS NOT TAKEN TO A DEALER NOR INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10658686November 17, 2014
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2013 VOLVO S60. THE CONTACT STATED THAT SOMEONE WAS ABLE TO KICK IN THE SIDE COLLISION PROTECTION BAR ON THE DRIVER SIDE DOOR. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE PROTECTION BAR NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 16,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10654041November 10, 2014
FUEL SYSTEM, GASOLINE
MY CAR WAS DYING ON THE HIGHWAY OR ON A REGULAR STREET ROAD. ENDED UP BEING THE FUEL PRESSURE SENSOR WHICH IS ON THE RECALL LIST BUT DIDN'T COME UP FOR MY VIN. I WAS DEALING WITH THIS FOR 6 MONTHS OR SO AND IT WAS VERY DANGEROUS. I DON'T UNDERSTAND WHY MY CAR ISN'T ON THE RECALL LIST. ANY HELP IS APPRECIATED. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volvo S60