Toyota Tundra Complaints

6,958 consumer complaints on file.

#11699099November 13, 2025
ELECTRICAL SYSTEM
I’m writing to report a driver’s-door lock malfunction on my 2022 Toyota Tundra and to request goodwill assistance (reimbursement or no-charge repair). VIN: [XXX] Mileage: 38,575 miles Concern: The driver’s door does not lock/unlock using the key fob or interior switch. Manual locking still works. Other doors operate normally. Safety/security impact: The vehicle cannot be reliably secured and the condition may leave the vehicle vulnerable when parked. Troubleshooting performed: Verified other doors work; checked fuses; inspected door-to-body wiring boot; issue appears isolated to the driver-side door lock actuator/latch. Requested resolution: Goodwill coverage for diagnosis and repair (or reimbursement if I proceed with repair now), including parts and labor for the driver-door lock actuator/latch assembly. I’ve been satisfied with the vehicle and would appreciate Toyota’s help resolving this known-type issue just beyond the 3-year/36,000-mile basic warranty. Please open a case and advise next steps. I can provide service records, videos, and a dealer estimate upon request. Thank you for your assistance. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699063November 12, 2025
UNKNOWN OR OTHER
While driving today, the sunroof spontaneously exploded. It exploded up and outward. There were no other cars/trucks nearby. I have never heard anything hit the sunroof before either. The truck is 3 weeks old and has only 1800 miles on it.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11698545November 10, 2025
FUEL/PROPULSION SYSTEM
I had an independent service center diagnose the issue with my 2018 Toyota Tundra. My truck would not start so there was no safety concern, but if the fuel pump failed while driving then the safety concern rises. The electrical connection inside the fuel pump was melted. There was no warning signs of the issue, it just would not turn all the way over. I looked up that the 2018 Toyota Tundra w certain VIN #'s have a recall for the fuel pump, unfortunately my VIN # is not included.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698566November 10, 2025
ENGINE
October 6th 2025, I was leaving my place of work and started to here a slight banging/knocking sound, the vehicle lost instant power and I the engine quit running, I have taken the vehicle to the Toyota dealer and they have confirmed a internal bearing failure in the engine. The vehicle is not part of the engine recall but appears to be the same issue. The Toyota dealership has agreed that it is still with in the warranty period after review of there regional representative and agreed to replace the engine short block and rebuild the remaining engine components. I towed it to the dealer October 6th and have been given a rough timeline for repairs to be performed roughly around December based on the availability of parts.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698312November 8, 2025
STRUCTURE:BODY
The truck under frame is rusting a lot in spots near welds.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698337November 8, 2025
STRUCTURE:BODY, UNKNOWN OR OTHER
2000 toyota tundra SR5 4door 4.7 liter V8. Sunroof glass blew off on freeway at 65mph almost hit car behind me. No police report, no person injured. November 3, 2025.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698334November 8, 2025
ENGINE
Hybrid 2024 Toyota, was accelerating on freeway on ramp when I received a notification of hybrid system malfunction and engine shutdown notice, "pullover". I was not able to use either system as there was no charge on the hybrid system and the hybrid system was not functioning due to the error, and the engine was shutdown. I was put in a situation of having to coast in a location of high vehicle traffic and greater relative speed to the road shoulder until I could safely stop.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698264November 7, 2025
UNKNOWN OR OTHER
The headliner in the truck is falling down. It appears that this is happening to a lot of them due to some faulty velcro. Seam to ve a pretty wide spread issue and is definitely a sadety concern if this happens while driving.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698207November 7, 2025
POWER TRAIN, VEHICLE SPEED CONTROL, ENGINE
There is an interment issue where the vehicle fails to accelerate from a stop when accelerator is applied. This issue is present in my current vehicle and my previous 2023 tundra. I have brought up concerns to the dealer and manufacturer and am told every time that the concern cannot be duplicated, but I feel that it is going to lead to a crash not only for me but other owners
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697861November 6, 2025
FUEL SYSTEM, GASOLINE
The contact owns a 2018 Toyota Tundra. The contact stated that while her husband attempted to start the vehicle, the engine failed to turn over. The contact stated that there was no warning light illuminated. The contact stated that the vehicle was towed to a local dealer. The dealer diagnosed the vehicle and determined that the fuel module needed to be replaced. The vehicle was repaired. The manufacturer was not informed of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 20V012000 (Fuel System, Gasoline); however, the VIN was not included in the recall. The failure mileage was approximately 103,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698022November 6, 2025
ENGINE
Just asking for an investigation. Same engines in vehicle year 2023 gas only models have been recalled for safety because the engine locks up while driving causing a this safety issue. My model year is 2023 and is a hybrid but has not been added to the recall. The hybrid should be included in the recall as well since it is the exact same engine. This is a dangerous situation for me and my family as well as others I am on the road with.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697963November 6, 2025
ENGINE
Toyota has just extended the engine recall for debris left in it thru the 2024 year model for all non-hybrid Tundra vehicles. This recall makes no sense the Hybrid vehicles have the exact same engine and therefore have the exact same safety issue. The claim they are not being recalled because they can still be powered by the hybrid system, but this is false. If the engine seizes from this debris it will render the vehicle inoperable and cause a safety issue too. Those with the Hybrid who have experienced the failure confirm the vehicle becomes inoperable. When they take it to Toyota if still under warranty they are only offered a short block rebuild and not the long block and turbos as all non-hybrid receive under the recall. Please look into this issue and force Toyota to extend the recall to both Hybrid and Non-Hybrid as they both have the same engine and pose the same safety risk to the driver and other vehicles on the road.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697884November 6, 2025
ELECTRICAL SYSTEM
The HVAC climate control system in my 2025 Toyota Tundra Limited malfunctioned while the vehicle was idling. The air conditioning had been set to cool and was operating normally, but without any touch to the controls or any alert, the system switched from blowing cold air to blowing warm/hot air. This caused the cabin temperature to increase rapidly. Because there were no warning lights, notifications, or error messages, there was no indication that the air system had changed. The vehicle continued to show that A/C was on and functioning. The malfunction resulted in the cabin reaching a dangerously high temperature. This caused fatal heat injury to one animal and critical heat injury to another, both of which were inside the vehicle at the time. One is still undergoing medical treatment. This same type of HVAC issue has been reported by other 2024–2025 Toyota Tundra owners in multiple owner discussion groups, particularly related to the vehicle blowing warm air at idle or failing to maintain cabin temperature. This suggests a potential widespread defect, whether software-related or involving the A/C compressor control system. This presents a serious safety risk, especially for: Children Animals Disabled or elderly passengers Anyone unable to immediately exit the vehicle The vehicle remains in our possession and can be inspected. Service interactions with the Toyota dealership are documented and available. Immediate investigation is needed to determine the cause of this HVAC failure and whether a recall or TSB must be issued to prevent future injury or death.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697586November 5, 2025
TIRES, SUSPENSION, STEERING
The contact owns a 2023 Toyota Tundra. The contact purchased the vehicle in January 2023 and had several mechanical and tire related failures with the vehicle. The contact stated that the vehicle was not handling normally. The contact stated that that the steering wheel was constantly turning to the right and needed to manually be returned to center to remain in the intended lane. The contact stated that the failure occurred at various speeds. The contact stated that the vehicle was taken to the dealer however, the dealer was unable to duplicate the failure, and that the wear on the tires were normal. The contact stated that the wear was noticeable to the extent that the tread was almost worn on the passenger’s side front tire at 12,000 miles. The contact stated that the tires were the original equipment and were rated at 30,000 miles of service. The OEM tires were Falken Wild Peak A/T 3WA; Tire Size 265/60/R20 112H: DOT 1V40H. The manufacturer was informed of the failure. The contact replaced the original tires with Bridgestone Tires; Tire Size: 265/60/R20; DOT Number: 17XEDHT1. The contact stated that the dealer had mounted the tires and balanced and aligned the steering wheel. The contact stated that the steering failures with the vehicle steering to the right persisted. The contact checked the tires and had taken the vehicle to a tire dealer to check the alignment and the tire condition and was advised that the new tires were showing wear, and that the vehicle was not properly aligned. The vehicle was not repaired. The original dealer was contacted, and the contact was informed that no assistance would be provided. The contact also reported failures with the transmission and other vehicle systems, and had a case opened by the manufacturer. The failure mileage was approximately 27,142. The Bridgestone tire wear mileage was approximately 10,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696854October 31, 2025
LANE DEPARTURE: LANE KEEP: STEERING ASSIST
The contact owns a 2025 Toyota Tundra. The contact stated that while driving 20 - 70 MPH, the steering wheel independently merged onto a back road, pulling the vehicle off the road and onto main roads and highways, with the vehicle merging into the turning lane independently. No warning light was illuminated. A local dealer was contacted. The vehicle was taken to a dealer, where it was diagnosed, and it was determined that the vehicle was working as intended. The vehicle was not repaired. The contact stated that the failure had occurred on several occasions. The manufacturer was notified of the failure and determined not to buy back the vehicle due to the dealer stating that the vehicle was operating as designed. The approximate failure mileage was 35,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696648October 30, 2025
FUEL/PROPULSION SYSTEM
the fuel guage on the dashboard shows inccurate infroamtion. I filled up the tank and went out of city. Once I came back home, next morning it was showing full tank. I was unsure about the quantity left, i filled up the tank and it was almost 11Gallon missing but it was showing full even on the gas station. It was fixed after a while but again today, it shows the full tank on dashboard but I saw half last night. I seached up online and it shows so many other people having the same issue. They also put some solutions but none of them worked for 2023 tundra. This could be a great risk if you are on a long route and do not know how much fuel left .
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696530October 30, 2025
ENGINE, FUEL/PROPULSION SYSTEM, VEHICLE SPEED CONTROL
On Wednesday 10/21 at approximately 11:30pm I was traveling on the Clearview Expressway. While changing from the middle last to the left lane at 20mph due to a construction merge with some traffic. When trying to accelerate the truck lost all throttle power and my speed quickly dropped to 12mph before throttle response came back. No noticeable or harsh change of gear for this episode.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696529October 30, 2025
FUEL/PROPULSION SYSTEM, ENGINE, VEHICLE SPEED CONTROL
On Tuesday 10/21 at approximately 4:30pm I was on the Grand Central Parkway traveling about 50mph. When trying to accelerate the truck lost all throttle power and I quickly lost speed down to 40mph before throttle response came back. There was a noticeable change in gear upon throttle resuming.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696525October 30, 2025
FUEL/PROPULSION SYSTEM, VEHICLE SPEED CONTROL, ENGINE
On Saturday 10/18 I was traveling about 60mph on the Long Island Expressway at approximately 12:30pm when I went to accelerate to pass a vehicle. Immediately upon pressing the accelerator the truck lost all throttle power and I quickly lost speed down to 45mph before throttle response came back. The truck harshly went into gear once throttle power resumed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11696495October 30, 2025
SERVICE BRAKES
Toyota requires the ABS system to be recalibrated. The only way is by going to a Toyota dealership and having the technicians use the fancy expensive diagnostic tools and computer software. I got my brakes changed by a reputable shop. However, I did not know whether they knew this or not. Now my front passenger pad is always rubbing on the rotor. These issues may cause high fuel consumption, strain on the transmission and driveline components, and even the possibility of fire. It would be really helpful if Toyota built vehicles that can easily be maintained as well as less complicated systems requiring owners to pay dealership prices for maintenance that should allow the owner to address it or any mechanic shops.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Tundra