Lincoln Corsair Service Bulletins
306 manufacturer communications on file.
- September 20, 2023•Document ID: 10242858Service Bulletin/Repair InstructionsBACK OVER PREVENTION:SOFTWARE
- Mfr Comm. #:
- TSB 23-2292
- Date Added:
- September 26, 2023
- Manufacturer:
- LINCOLN
SummarySome 2023 Corsair vehicles equipped with a 2.5L plug-in hybrid electric vehicle (PHEV) engine built on or before 07-Sep-2023 may exhibit an illuminated powertrain malfunction (wrench) indicator with diagnostic trouble code (DTC) U1010 stored in the secondary on-board diagnostic module-B (SOBDMB). This concern typically happens after a plug-in charging event. This may be due to the software in the SOBDMB.
Associated Products (1)Associated Documents - September 14, 2023•Document ID: 10243535Service Bulletin/Repair InstructionsUNKNOWN OR OTHER; SERVICE BRAKES
- Mfr Comm. #:
- SSM 51923
- Date Added:
- October 4, 2023
- Manufacturer:
- LINCOLN
SummarySome 2020-2022 Escape and 2021-2022 Corsair vehicles may exhibit a condition where the brake service mode is inoperative using the Workshop Manual (WSM) routine and/or Parking Brake Limited Function-Service Required message displayed in the instrumental panel cluster (IPC) after opening the drivers door. This may be due to the software installed in the anti-lock brake system (ABS) module. To correct this condition, reprogram the ABS module to the latest software available. For claiming, use causal part number 2C219 and the applicable labor operations in Section 02 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (4)Associated Documents - September 7, 2023•Document ID: 10243482Service Bulletin/Repair InstructionsSTRUCTURE:BODY:HATCHBACK/LIFTGATE; STRUCTURE:BODY:HOOD; LATCHES/LOCKS/LINKAGES; STRUCTURE:BODY:DOOR
- Mfr Comm. #:
- SSM 51908
- Date Added:
- October 4, 2023
- Manufacturer:
- LINCOLN
SummarySome 2020-2023 Escape/Corsair vehicles may exhibit a door ajar warning indicator or higher than expected efforts to fully close doors. Verify the hood/liftgate are not open. Confirm all doors are fully closed and latches are fully engaged. Doors will not fully close when lightly letting go of the door or letting it swing closed from a short distance under its own weight. Push/pull effort must be applied to doors while closing to fully engage latch and turn off the ajar signal warning. If doors are still not fully latching closed, manually adjust door striker position to allow for proper alignment and engagement to the door latch. The door hang position may also need to be slightly adjusted to achieve the same effect. Refer to Workshop Manual (WSM), Section 501-03.
Associated Products (6)Associated Documents - September 4, 2023•Document ID: 10243479Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 51903
- Date Added:
- October 4, 2023
- Manufacturer:
- FORD
SummarySome 2021-2023 Ford and Lincoln vehicles may exhibit DTCs U2100 and/or U3002 stored in the cruise control module (CCM), side obstacle detection control module LH (SODL), side obstacle detection control module RH (SODR), side obstacle detection control module C (SODCMC) and/or side obstacle detection control module D (SODCMD) after a module replacement. DTC U2100 may set when the module has not been properly configured after replacement. DTC U3002 may set when the module has been configured with the incorrect VIN. To correct this condition, verify that the module storing the DTC has been installed following the applicable Workshop Manual (WSM) Removal and Installation procedure. If the DTC is still stored, download and run the Vehicle Identification Number (VIN) Write application found under Toolbox, Multi-Module tab in the Ford Diagnosis and Repair System (FDRS).
Associated Products (9)Associated Documents - August 31, 2023•Document ID: 10241962Service Bulletin/Repair InstructionsEQUIPMENT:APPLIANCE:TV/RADIO/SPEAKERS
- Mfr Comm. #:
- 23B27 S1
- Date Added:
- September 7, 2023
- Manufacturer:
- LINCOLN
SummaryCertain 2022 Model Year Corsair Equipped with Base Radio - Amplifier Replacement and Speaker Test Supplement 1
Associated Products (1)Associated Documents - August 31, 2023•Document ID: 10241953Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- 23B27
- Date Added:
- September 7, 2023
- Manufacturer:
- LINCOLN
SummaryCertain 2022 Model Year Corsair Equipped with Base Radio - Amplifier Replacement and Speaker Test
Associated Products (1)Associated Documents - August 30, 2023•Document ID: 10241546Service Bulletin/Repair InstructionsPOWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM); ELECTRICAL SYSTEM:SOFTWARE
- Mfr Comm. #:
- TSB 23-2275
- Date Added:
- September 1, 2023
- Manufacturer:
- FORD
SummarySome 2023 Escape/Corsair vehicles built on or before 25-May-2023 equipped with a 2.0L EcoBoost engine may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P0300 and/or P0316. This may be due to the software in the powertrain control module (PCM). To correct this condition, follow the Service Procedure to reprogram the PCM.
Associated Products (2)Associated Documents - August 30, 2023•Document ID: 10241545Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- TSB 23-2274
- Date Added:
- September 1, 2023
- Manufacturer:
- FORD
SummarySome 2022-2023 Bronco Sport/Escape vehicles equipped with a 1.5L engine and 2022-2023 Corsair vehicles equipped with a 2.5L engine, built on 01-Sep-2022 and through 06-Apr-2023, may exhibit a low coolant level with engine oil in the coolant and/or coolant in the engine oil. This may be caused by an internal oil cooler leak. To correct this condition, follow the Service Procedure to test and replace the oil cooler.
Associated Products (6)Associated Documents - August 7, 2023•Document ID: 10240726Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL
- Mfr Comm. #:
- SSM 51847
- Date Added:
- August 14, 2023
- Manufacturer:
- LINCOLN
SummarySome 2023 Corsair vehicles equipped with a 2.5L plug-in hybrid electric vehicle (PHEV) engine may exhibit an illuminated powertrain malfunction indicator (wrench) lamp with DTC U1010 stored in the secondary on-board diagnostic module-B (SOBDMB). This concern typically happens after a plug-in charging event. This condition does not affect vehicle durability and no additional diagnosis or service is required for this condition at this time. Inform customers that engineering is currently working on a solution for this condition that is expected in October 2023. Replacement or reprogramming of the SOBDMB is not recommended for this condition. Monitor OASIS for additional information and schedule service appointments for customers once the repair becomes available..
Associated Products (1)Associated Documents - August 2, 2023•Document ID: 10241627Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 51838
- Date Added:
- September 4, 2023
- Manufacturer:
- LINCOLN
SummaryIn various 2017-2023 Ford and Lincoln vehicles, customers may receive a message in the FordPass or LincolnWay App stating Feature Unavailable. Since this is a fleet vehicle, it cannot access the (SYNC Connect) FordPass or LincolnWay app through the TCU Embedded Modem. If this message appears, the vehicle may be equipped with a fleet telematics module. Replacement of the TCU or TCU related repairs will not prevent this message from appearing. Refer the customer to in app FordPass Guides or LincolnWay Concierge Teams to aid with fleet telematics removal. Open app, select Account > Help > CHAT or CALL option.
Associated Products (44)2023 Ford Bronco2023 Ford Bronco Sport2023 Ford Edge2023 Ford Escape2023 Ford Expedition2023 Ford Explorer2023 Ford F-1502023 Ford Maverick2023 Ford Mustang2023 Ford Ranger2023 Ford Transit2023 Lincoln Aviator2023 Lincoln Corsair2023 Lincoln Nautilus2023 Lincoln Navigator2022 Ford Bronco2022 Ford Bronco Sport2022 Ford Edge2022 Ford Escape2022 Ford Expedition+ 24 moreAssociated Documents - August 1, 2023•Document ID: 10240577Service Bulletin/Repair InstructionsPOWER TRAIN; UNKNOWN OR OTHER; EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
- Mfr Comm. #:
- SSM 51823
- Date Added:
- August 11, 2023
- Manufacturer:
- LINCOLN
SummarySome 2019-2023 Edge/Nautilus, 2020-2023 Escape/Corsair, 2021-2023 Bronco Sport, 2022-2023 Maverick vehicles equipped with all wheel drive (AWD) may exhibit chatter/shudder during low speed turning events. This may be due to fluid contamination in the rear drive unit (RDU). Drain and refill the RDU, refer to Workshop Manual Section (WSM) 205-02. Drive for 5 miles (8 km) in stop and go conditions with right and left turns and re-evaluate. If the issue is still present, continue with normal WSM diagnostics. For claiming, use base (4000) causal part.
Associated Products (17)2023 Ford Bronco Sport2023 Ford Edge2023 Ford Escape2023 Ford Maverick2023 Lincoln Corsair2023 Lincoln Nautilus2022 Ford Bronco Sport2022 Ford Edge2022 Ford Escape2022 Ford Maverick2022 Lincoln Corsair2022 Lincoln Nautilus2021 Ford Bronco Sport2021 Ford Edge2021 Ford Escape2021 Lincoln Corsair2021 Lincoln NautilusAssociated Documents - July 24, 2023•Document ID: 10239630Service Bulletin/Repair InstructionsSTEERING
- Mfr Comm. #:
- SSM 51812
- Date Added:
- July 25, 2023
- Manufacturer:
- FORD
SummarySome 2020-2022 Escape/Corsair, 2021-2022 Bronco Sport, and 2022 Maverick vehicles built on or before 23-Mar-2022 may exhibit a hard, stiff, and/or difficult to turn condition due to a lack of power steering assist during engine start-up with U3000 diagnostic trouble codes (DTCs) stored in the PSCM. Using the latest version of Ford Diagnosis and Repair System (FDRS) tool, select and run the PSCM - Reset the Power Steering Control Module (PSCM) application. After PSCM reset, perform an ignition cycle. Update the PSCM to the latest software level using FDRS tool. If the U3000 DTC returns, continue with diagnostics and repair direction using Workshop Manual (WSM), Section 211-02 > Power Steering > Diagnosis and Testing. For claiming, use causal part 3C529 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (7)Associated Documents - July 12, 2023•Document ID: 10239477Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 51783
- Date Added:
- July 18, 2023
- Manufacturer:
- FORD
SummarySome 2021-2023 Ford and Lincoln vehicles may exhibit a condition where the high voltage battery stops charging when connected to level 1 or level 2 chargers with an illuminated malfunction indicator lamp (MIL) and diagnostic trouble code (DTC) P2C94 stored in the secondary on-board diagnostic control module A (SOBDM). To restore charging capability, disconnect the off-board charging station charge handle from the vehicle charge port and reconnect. This condition does not affect vehicle durability and no additional diagnosis or service is required for this condition at this time. Inform customers that they can continue to drive the vehicle and engineering is currently working on a solution for this condition that is expected in August 2023. Replacement of the SOBDM will not resolve this condition. Monitor OASIS for additional information.
Associated Products (13)Associated Documents - July 6, 2023•Document ID: 10239098Service Bulletin/Repair InstructionsEQUIPMENT; BACK OVER PREVENTION: CAMERA SYSTEM
- Mfr Comm. #:
- SSM 51776
- Date Added:
- July 12, 2023
- Manufacturer:
- FORD
SummarySome 2021-2023 Mustang Mach-E/F-150, 2022-2023 Expedition/Navigator and 2023 Corsair vehicles may exhibit a Driver Monitoring Camera Blocked message and/or DTCs B115E:97, B15E1:97 and/or B15E2:97 stored in the driver status monitor camera module (CMR). These DTCs should be disregarded unless it is a DTC with a status byte 8F. Other status bytes should be disregarded as they may be caused by a camera obstruction such as driver position, aftermarket devices or dust on the camera. To clear the DTCs, remove anything obstructing the view of the camera and light emitting diodes (LEDs), place the steering wheel in the center position and close the driver door. Connect Ford Diagnosis and Repair System (FDRS) and clear the DTCs. Turn the ignition off and wait 10 seconds. Turn the ignition on and wait 1 minute. Perform the CMR self-test and reevaluate if DTCs persist.
Associated Products (8)Associated Documents - July 3, 2023•Document ID: 10238461Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM); ELECTRICAL SYSTEM:SOFTWARE
- Mfr Comm. #:
- SSM 51762
- Date Added:
- July 3, 2023
- Manufacturer:
- FORD
SummarySome 2021-2023 Ford and Lincoln vehicles equipped with SYNC 4 may exhibit the navigation feature in the center display screen only displaying imperial units and not being able to change to metric. This may be due to the software level of the SYNC module (APIM). This issue does not affect vehicle durability and no additional diagnosis or service is required for this condition at this time. Inform customers that engineering is currently working on a solution for this condition and will be released via Ford Power-Up software updates delivered over-the-air (OTA) expected in September 2023. Software will update automatically if vehicle connectivity is enabled in the vehicles settings. Schedule a service visit for customers who have disabled vehicle connectivity or who report that they did not receive the update in September 2023. Monitor OASIS for additional information.
Associated Products (17)2023 Ford Bronco2023 Ford Escape2023 Ford Expedition2023 Ford F-1502023 Ford Transit2023 Lincoln Corsair2023 Lincoln Nautilus2023 Lincoln Navigator2022 Ford Bronco2022 Ford Expedition2022 Ford F-1502022 Ford Transit2022 Lincoln Nautilus2022 Lincoln Navigator2021 Ford Bronco2021 Ford F-1502021 Lincoln NautilusAssociated Documents - June 16, 2023•Document ID: 10237977Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- SSM 51725
- Date Added:
- June 21, 2023
- Manufacturer:
- LINCOLN
SummarySome 2020-2023 Ford and Lincoln SYNC3 equipped vehicles may experience an inaccurate notification in the FordPass®/LincolnWay® app indicating Vehicle Has Entered Deep Sleep Mode. Vehicle Has Entered Deep Sleep Mode message is expected if the vehicle has not been started for 14 consecutive days, battery voltage is at/below 9.5 volts or the body control module (BCM) 12 volt battery state of charge (SoC) drops below 50%. If the vehicle is going into deep sleep outside these conditions, this may be due to the telematics control unit (TCU) software. To correct this condition, follow the Service Procedure to update the TCU to the latest software. For claiming, use causal part 14G229 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (29)2023 Ford Bronco Sport2023 Ford Explorer2023 Ford Maverick2023 Ford Ranger2023 Ford Transit Connect2023 Lincoln Aviator2022 Ford Bronco Sport2022 Ford Ecosport2022 Ford Escape2022 Ford Explorer2022 Ford Maverick2022 Ford Mustang2022 Ford Ranger2022 Ford Transit2022 Ford Transit Connect2022 Lincoln Aviator2022 Lincoln Corsair2021 Ford Bronco Sport2021 Ford Ecosport2021 Ford Escape+ 9 moreAssociated Documents - June 2, 2023•Document ID: 10237587Service Bulletin/Repair InstructionsELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL; ELECTRICAL SYSTEM:SOFTWARE
- Mfr Comm. #:
- SSM 51676
- Date Added:
- June 8, 2023
- Manufacturer:
- LINCOLN
SummarySome 2023 Corsair vehicles may exhibit a continuous memory diagnostic trouble code (CMDTC) U0100 stored in the audio front control module (ACM) and/or instrument panel cluster (IPC) after a self test is performed with Ford Diagnosis and Repair System (FDRS) scan tool. If the vehicle does not exhibit any observable symptoms, these DTCs can be ignored. If any observable symptoms are present, refer to normal Workshop Manual (WSM) diagnostics.
Associated Products (1)Associated Documents - May 23, 2023•Document ID: 10237335Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- SSM 51656
- Date Added:
- June 5, 2023
- Manufacturer:
- LINCOLN
SummarySome 2022-2023 F-150/Bronco/Expedition/Navigator/Escape/Corsair/Bronco Sport/Edge/Mustang vehicles built on 04-Sep-2022 and through 30-Dec-2022 may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTC) P0230 stored in the powertrain control module (PCM). The vehicle may also experience a no start or stall after start. This may be due to an internal PCM issue. If this DTC is present, verify the battery condition, then perform pin point test (PPT) KC of the Work Shop Manual (WSM), Section 310-01. If PPT KC leads to component replacement, start with replacing the PCM and then evaluate the vehicle. If the DTC returns, follow WSM, Section 310-01 PPT KC direction to address the issue.
Associated Products (14)Associated Documents - May 19, 2023•Document ID: 10236579Service Bulletin/Repair InstructionsLATCHES/LOCKS/LINKAGES
- Mfr Comm. #:
- TSB 23-2156
- Date Added:
- May 31, 2023
- Manufacturer:
- FORD
SummarySome 2020-2023 Escape/Corsair, 2021-2023 Bronco Sport and 2022-2023 Maverick vehicles may exhibit a condition where the door(s) do not open using the exterior door handle(s). This may be due to an enabled permanent engagement inertia lock within the exterior door handle, this condition occurs when the doors are closed or opened with excessive force. To correct this condition, follow the Service Procedure to properly disengage the permanent engagement inertia lock clip to allow the exterior door handle(s) to fully extend and open the door(s) from the exterior.
Associated Products (11)Associated Documents - May 10, 2023•Document ID: 10236335Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- SSM 51622
- Date Added:
- May 16, 2023
- Manufacturer:
- FORD
Summary2022-2023 Explorer/Aviator vehicles built on or after 28-May-2022, 2022-2023 Expedition/Navigator vehicles built on or after 08-Jun-2022 and 2022 Escape/Corsair vehicles built on or after 01-Jun-2022 are no longer equipped with a hands free liftgate system. The vehicle is not misbuilt. The addition of any parts is not a warrantable repair. Do not submit a claim for this condition.
Associated Products (10)Associated Documents