Hyundai Santa Fe Sport Complaints

1,199 consumer complaints on file.

#11749084July 8, 2026
FUEL/PROPULSION SYSTEM, ENGINE
After a recall repair (Campaign 9C2) was performed on my vehicle, it developed a hesitation and lack of acceleration issue that did not exist before the repair. The vehicle exhibits rough or delayed gear shifting, a noticeable lack of power/acceleration, and behavior that feels like the engine is not receiving adequate fuel. This occurs both during cold start and after the vehicle has been driven and is fully warm. I returned the vehicle to the dealership (Wallace Hyundai), where the service advisor personally test drove the car with me and confirmed he could feel the hesitation firsthand. Despite this, the dealership stated no issue was found and advised warming the car up for 1-3 minutes before driving as a workaround. I tested this exact recommendation, and the issue returned even after the vehicle was fully warmed and had already been driven. Hyundai Motor America's National Consumer Affairs department has stated this is "under review" but has also described the hesitation as "normal" cold-start behavior related to catalyst warm-up. This does not match what I am experiencing, since the issue also occurs when the vehicle is already warm, and their own dealership's advisor confirmed the problem exists. I have also noticed a decrease in fuel efficiency (MPG) since the software update associated with this recall. This issue directly affects the safe operation of the vehicle — specifically the ability to accelerate reliably, including in situations like merging onto highways or pulling into traffic, where a lack of power could result in a collision. I do not consider the vehicle safe to drive in its current condition.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11749195July 8, 2026
SERVICE BRAKES, ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL
I am reporting a severe safety failure on my 2014 Hyundai Santa Fe Sport that perfectly matches the safety defect described in Recall 21V-303 / Campaign 205. This happened even though I had the dealer perform the official recall fuse fix back in 2024. The problem started after I left the car parked for about 3 to 4 hours. When I came back, I heard a motor (not the motor) loudly running under the hood even though the ignition was completely off. It stayed on even after starting and turning the car off. The battery in the vehicle had drained so bad it was deemed bad when hooked up to a tester at the auto parts store. After getting a new battery and trying to drive the car, the electrical system went haywire. The dashboard lit up with every brake warning light on, the speedometer stopped working, miles to empty being erratic, and the exterior rear brake lights kept flickering erratically after the car was turned off. The steering was acting abnormal and unnatural, not crisp and easy to turn as usual. There were absolutely no warning lights or symptoms before I parked the vehicle. I had it towed to my local Hyundai dealership, and their diagnostic scan confirmed major brake and chassis issues, specifically code C2402 for an ABS Pump Motor Circuit Malfunction and codes C1200, C1203, and C1206 for a loss of wheel speed data. The vehicle has not been inspected by police or insurance representatives, but it is currently sitting at the dealership waiting for a resolution from a Hyundai customer care case manager. The 2024 recall remedy only involved dropping the fuse amperage to mitigate fire intensity; it did not replace the module housing or prevent the internal brake fluid leak from eventually destroying the system. The defect has seemingly now fully manifested, knocking out primary braking indicators and power steering assist, presenting an ongoing safety and fire hazard while driving and parked.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11748333July 5, 2026
ENGINE
The car has 90,000 miles on it and uses excessive oil, not leaking. It uses at least one quart per 1000 miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11748225July 3, 2026
ENGINE
On March 20, 2026, while driving, my 2014 Hyundai Santa Fe Sport (VIN: [XXX]) equipped with a Theta II 2.4L GDI engine, the car experienced a catastrophic, sudden loss of motive power. The engine suffered a total mechanical failure/seizure, creating an immediate highway safety hazard. This vehicle is part of the "In re: Hyundai and Kia Engine Litigation II" settlement population due to known factory manufacturing defects where residual metal debris blocks oil flow to the connecting rod bearings. Hyundai Corporate has issued a blanket refusal to honor the lifetime safety warranty extension, using an unverified allegation of "outside influence" to avoid executing the mandatory engine replacement protocols required under NHTSA Campaign T3G. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11747934July 2, 2026
ENGINE
Drive train, head gasket, burned valve, leaking
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11747757July 1, 2026
ENGINE
The engine (2016 Hyundai Santa Fe 2.0L/2.4L Theta II GDI engine) suffered a catastrophic internal mechanical failure, specifically related to the known connecting rod bearing defect. The vehicle is currently un-driveable and is located at Serra Hyundai in Trussville, AL. The vehicle and its failed engine are available for inspection upon request. The engine suddenly failed and lost all power while driving at highway speeds in active traffic. I was forced to coast a dead vehicle across multiple lanes of traffic to the shoulder without any acceleration capability. Yes. The vehicle experienced a complete failure, cannot be restarted, and is currently parked at an authorized Hyundai dealership The vehicle is currently at an authorized Hyundai dealership awaiting a formal corporate inspection and evaluation for engine replacement approval. It has not been inspected by police or insurance. There were no long-term warning lamps, messages, or symptoms prior to the incident. The vehicle was operating normally until the exact moment of the failure, when the engine suddenly began knocking loudly, lost power, and stalled within seconds.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11747266June 29, 2026
ENGINE
Issue was first identified in September 2024 when a rattling noise prompted inspection, and the engine was found to be significantly low on oil. Excessive engine oil consumption was confirmed with failure during manufacturer testing. Vehicle emits occasional burning oil smell when idling after 10 miles+ driving. Vehicle failed a 1,000-mile oil consumption test following a “Dynamic Engine Clean” performed by a certified independent mechanic, with documented oil loss of approximately 2 quarts. Vehicle subsequently failed a dealer-administered oil consumption test, with documented oil loss of approximately 2.3 quarts within 1,000 miles. Engine oil levels have dropped to critically low levels between checks despite active monitoring and maintenance. This condition presents a risk of engine seizure, sudden loss of power while driving, and potential engine compartment fire due to oil consumption or leakage. The issue has been reproduced and documented by both an independent mechanic and a Hyundai dealership. Despite confirmed excessive oil consumption, the manufacturer has delayed corrective action and has required repeated oil consumption testing and engine cleaning procedures rather than proceeding with repair. This condition appears consistent with known defects associated with Hyundai Theta II engines.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746986June 28, 2026
ENGINE
On 4/25/2026 I lost power on business freeway an orange light flash on along with whining noise I had to steer to right side shoulder for safety. Had it towed to dealership on 4/27/2026 they informed me 3 days later on 4/30/2026 that my car overheated. My car never overheated no smell of coolant nor no steam from the car when I exit to shoulder and turn car off. Retrieved manual from glove compartment it stated it had went into limp model. This has been a constantly nightmare my family could have been planning a funeral. These car manufacturers needs to be held accountable for their vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11747002June 28, 2026
STEERING, SERVICE BRAKES, ELECTRICAL SYSTEM
FHW Garage used car dealer [XXX], sold this Hyundai Santa fe 2015 knowing the vehicle is defective. It Stalls and stops in the middle of the road in High Traffic. This Hyundai Santa Fe 2015 Lock up the Steering Wheel, Lock up the breaks, Lock up the gas. it Stalls and stops without Warning then after it freeze and stop it flashes all of the Warning Lights on the dash board. FHW Garage is Falsely Advertising this vehicle in Excellent Condition. Its Advertised on Craigs List, and [XXX]. I was almost in a Serious Accident. [XXX] keeps getting his people in the workshop to Machanically Rig the Vehicle to run and drive until someone gets killed when this vehicle is in a terrible Accident. The Gas Cap dont screw on properly. Fhw Garage [XXX] sold me this Vehicle with full knowlege of the Mechanical Defects, and refuses to give my money back. I paid $5,400 Cash plus traded my car. The Hyundai Santa fe was $6,900. Deceptive Practices Fraud, and Title Jumping. FHW still have the two cars after I purchased them. I would like to see FHW Dealer License Suspended or Revoked. Give my money back and return my car. I will be filing a complaint Affidavit with the FLHSMV. [XXX] lied on the Bill of Sales how much I paid and he put $900 in his pocket. I will also file a complaint to FHW [XXX]. For defrauding me, Misrepresentation saying the Vehicle is in Excellent Condition when its Mechanically Defective, and Dangerous should not be on the road to kill someone. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746944June 27, 2026
ENGINE
ID # 11746004. I accidentally entered the wrong incident date on my original submission. The correct date of the incident is June 17, 2026. Please update my file to reflect this correct timeline.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746439June 25, 2026
SERVICE BRAKES
: "Vehicle is currently grounded at Rowe Hyundai Westbrook in Westbrook, Maine. Dealer confirms HECU has an active electrical short matching Recall 205 (Campaign 21V303000) but refuses to replace the safety defect because it lacks an external fluid leak. The vehicle is unsafe to drive due to fire risk and brake hazard, and the manufacturer's agent is refusing the federal remedy."
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746463June 25, 2026
ENGINE, POWER TRAIN
Campaign 9C2 was installed on this vehicle and the now the vehicle is a danger to drive. My wife refuses to drive it as it bucks and jerks as well as the gas mileage has decreased from 35 highway to 28 highway. The fuel trims are way off on cold starts and the transmission now searches for the correct gear. Shifting back and forth. Just a slight touch of the accelerator and the car seems to jump forward which makes stop and go driving almost impossible.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746272June 24, 2026
STEERING
Steering column sensor issue reported by Hyundai dealership. This has happened a several times before causing the steering wheel to “lock up” when driving making it very hard to turn my wheel. I have had to pull over, stop, and turn off the car and then back on again, which resets it, and I’m able to drive as normal, until it happens again. This most recent time, 6/2026, I was able to take it in to a dealership when the warning lights were on. He did a recalibration, however, later when driving, the same issue arose at high speeds, on the fwy, causing me to exit and pull over. * I noted 2- 3 warning lights came on during the malfunction.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746004June 23, 2026
ENGINE
The engine failed completely and is currently available for inspection at my residence. While traveling on a family vacation at highway speeds, the engine suffered a catastrophic connecting-rod bearing failure and seized. This caused an immediate loss of motive power, braking assistance, and steering control, nearly resulting in a fatal multi-car collision with my child in the vehicle. Warning lights illuminated on the dashboard during the failure as a sudden metallic knocking sound occurred and the engine died. The vehicle became completely disabled and had to be limped off the highway and towed. The VIN has a completed Campaign 953 from September 2019 qualifying it for the Lifetime Warranty Extension under the Theta II settlement.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11745648June 22, 2026
ENGINE
After driving the vehicle around all day, I parked it and turned it off and then it set on fire.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11745691June 22, 2026
UNKNOWN OR OTHER
What component or system failed or malfunctioned, and is it available for inspection upon request? Multiple systems have failed sequentially — engine (replaced at ~84,000 miles), catalytic converter (replaced post engine replacement), and transmission (currently stalling, pending replacement authorization from Hyundai Corporate). The vehicle is available for inspection upon request. How was your safety or the safety of others put at risk? The vehicle stalls during the first few miles of every drive before stabilizing. This creates an immediate risk of accident on public roads, particularly at intersections, highway on-ramps, and in traffic. Despite this known safety hazard, the dealership returned the vehicle to me unrepaired on June 22, 2026, and deemed it safe to drive. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. Fort Mill Hyundai (805 Gold Hill Road, Fort Mill, SC 29708) has confirmed they can physically feel the stalling issue but stated they do not have sufficient data to submit to Hyundai Corporate for transmission replacement authorization. An independent mechanic also previously confirmed the engine issue that the dealership initially dismissed. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Yes. Fort Mill Hyundai, an authorized Hyundai dealership, has inspected the vehicle multiple times over several years. The dealership is actively coordinating with Hyundai Motor America Corporate regarding the transmission replacement. Invoice reference: [XXX], dated June 22, 2026. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Yes. Check engine and brake warning lights first appeared at approximately 64,000 miles. These lights recurred repeatedly every ~1,000 miles despite multiple dealership visits. Subsequent symptoms included engine hesitation and loss of power, fol INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INF
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11745727June 22, 2026
ENGINE, UNKNOWN OR OTHER
The vehicle is a 2016 Hyundai Santa Fe Sport. It had previously been included in an engine-fire-related recall/service campaign, and Hyundai replaced the engine between approximately October 2024 and January 2025 at about 113,000 miles. About 10,000 miles and 14 months later, the vehicle developed engine/performance problems. A Hyundai dealership service center performed about $6,500 in repairs, including installation of a new transmission, and represented that the engine and transmission had a lifetime guarantee. One day after the vehicle was returned from the dealership, the engine compartment caught fire while the vehicle was being driven. The fire rapidly escalated, the vehicle exploded/burned, and the vehicle was destroyed down to the frame. The occupants escaped, but the incident created an immediate risk of serious injury or death. The failed component appears to involve the engine, engine compartment, fuel/oil/electrical systems, transmission-related repair area, or another drivetrain component. The vehicle remains may be available for inspection depending on insurance/tow/storage status. The vehicle had recently been repaired and inspected by a Hyundai dealership service center. This incident raises concern that the recall-related engine-fire risk, replacement engine, recent dealership repairs, transmission installation, or related components may have failed and created a serious fire hazard.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11745132June 18, 2026
ENGINE
My 2017 Hyundai Santa Fe sport has never had any issues until last Friday when I took my car to the dealership for regular maintenance (oil change, tire rotation) as I always do. They also performed a software update for recall campaign 9C2. Every day since, when first starting the car after it’s been resting for a while, I’ve experienced a jerky transmission and rough shifting for a first couple minutes of driving. Hyundai has acknowledged they are aware of this issue related to the campaign and the dealership said they’ve had many customers complaining of the same problem following the recall update. However, Hyundai has offered no resolution, other than recommending the car warm up for 13 minutes after starting. Hyundai needs to correct the issue they caused, as my car was perfectly fine before it was serviced and now it’s not performing properly.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11744684June 17, 2026
ENGINE AND ENGINE COOLING
The contact owns a 2018 Hyundai Santa Fe Sport. While the contact’s daughter was driving approximately 10 MPH, the vehicle started bucking and shaking abnormally. The warning light indicating that the oil level was low had flashed on the screen. The driver pulled over to the side of the road and waited for the contact to arrive on scene. The contact inspected the vehicle and became aware that the oil level was extremely low. The contact added oil to the engine, and the dipstick failed to indicate the oil level until there was a quart full. The vehicle was taken to a certified mechanic, who diagnosed the vehicle with engine failure and referred the contact to the dealer. While attempting to drive the vehicle at approximately 20 MPH with the hazard light flashing on the highway, the vehicle lost drive power. The contact was able to coast to the side of the road and waited for the vehicle to be towed. The vehicle was towed to the dealer, but the vehicle was not diagnosed or repaired. The contact stated that the failure had occurred after consistent oil changes, and the next oil change was not due for 11 days. The manufacturer was not made aware of the failure. The failure mileage was approximately 75,314.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11743935June 13, 2026
UNKNOWN OR OTHER
The vehicle stooped running while driving and will not start, available for inspection upon request. The vehicle or component has not been inspected by the manufacturer, police, insurance representatives or others. There were no warning lamps, messages or other symptoms of the problem prior to the failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Hyundai Santa Fe Sport