Hyundai Ioniq 5 Complaints

1,350 consumer complaints on file.

#11527874June 20, 2023
ELECTRICAL SYSTEM, POWER TRAIN
The vehicle completely lost power and there was 207 miles left to the charge. The message displayed on the driver's screen read "12V battery voltage low. Stop safely" I had no other choice than to stop since the car suddenly had zero power. The car was towed to Hyundai dealership on 2/15/23 and I have yet to have the vehicle repaired. Hyundai keeps informing me that the part is on order and delayed. I have been waiting a long time for a defective vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11527797June 19, 2023
ENGINE, POWER TRAIN
EV goes into power limited mode when on interstate when going ~50 miles while driving 70mph or more. Happened each of my 3 times on interstate of about that distance. First time was Sat 4/29 while in eco mode with 70% battery and 82°F outside, 1 hr drive 50+ miles. Second time was in normal mode Friday 5/12, 55% battery 72°F outside 1 hr drive 50+ miles. Third time was in normal mode and it happened after 42 miles. I scheduled a service after the first incident but they were only able to take it on 5/31. When this happens you lose ability to accelerate and have to coast to the side of road and let it sit for 10+ minutes to clear and then can resume, I would take surface roads after it occurred. Impacts safety for self and others, as it drastically slows without brake lights causing a high chance of being rear ended. The last incident was close to it. As it was getting worse I stopped driving on interstate with it. Car has been at the dealership's service department since 5/31. They were able to easily reproduce once they finally got to it. They diagnosed a bit and then consulted design engineers. Diagnosed on and off for a couple weeks and have finally decided to replace the drive motor. Part received Friday 6/16, to be installed tomorrow 6/20. We'll see if that addresses.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11527794June 19, 2023
ELECTRICAL SYSTEM, ENGINE, POWER TRAIN
Car literally DIED while driving. Went from normal speed to 12mph to 6mph to dead. ICCU failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11527776June 19, 2023
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
The charging system in the 2023 Ioniq 5 has multiple issues with connectivity and charging above a certain threshold. When charging at home using an electrician certified install by Merit and a county approved installation and Emporia EVSE 48A charger, the car prompts with a message that reads "Electric Vehicle Charge Alarm was processed. Your vehicle is not charging because of a connection failure. Possible reasons include: blackout, payment incompletion, charging stop button enabled." This has only recently started happening with the temperature in the closed garage reaching above 80F. The only way to rectify is to charge below 40A and this same issue is being reported by other Ioniq 5 owners via online forums as well. As it relates to DC fast charging at public infrastructure, the Ioniq 5 has a reliability problem with connectivity to the CCS1 ports that are used with Electrify America stations. The common denominator appears to be the charging port of the Ioniq 5.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11527772June 19, 2023
VEHICLE SPEED CONTROL, LANE DEPARTURE: ASSIST, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
While driving on the interstate my 2023 Ioniq 5 SEL RWD experienced a failure with the front radar system stating that it was blocked. In reality there was nothing physically blocking the system which was verified on multiple pullovers to check the front of the vehicle. This caused the critical forward safety functions, HDA system, lane change assist functions, regeneration system, and smart cruise control to all be disabled. The car is available for inspection upon request and I have video of the car displaying the fault messages during the trip as it happened on multiple occasions.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11527771June 19, 2023
ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
- EV Fuse blown My Hyundai Ioniq5 EV electrical system stopped function on March 25th, 9 month after we purchased this EV, on a busy highway. It took Hyundai dealer 8 weeks to fix this issue. Due to the fix report, some fuse was blown. - Automatic Emergency Braking engaged On Jun 16th, when driving on HW 90 west bound, road was clean. No vehicle in front of me. The "Automatic Emergency Braking " was engaged. This could be very dangerous if the highway was busy.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11527751June 19, 2023
SERVICE BRAKES, ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
This is an electric vehicle that features “iPedal” driving, what Hyundai refers to as one-pedal driving. The main safety issue is that when you decelerate using one pedal, which is a fairly aggressive deceleration, the brake lights do not come on unless you lift your foot entirely from the accelerator or apply the brake pedal (which one would rarely do in iPedal mode). Hyundai needs to rethink their concept of operations for how their brake lights should operate. People are at risk of getting rear-ended. I didn’t realize this was how the vehicle operated until I was almost rear-ended today. Please push them to fix this issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11527747June 19, 2023
ELECTRICAL SYSTEM, POWER TRAIN
Failed EV drive system. Error messages of electrical problems and shortly went complete dead. 12 volt battery was dead and won't charge. Car was towed to Ideal Hyundai in Fredrick MD. Dealer reported failed ICCU and parts for repair are on back order. Fortunately the failure occurred when pulling away from parking. If I had been at highway speed it could have been disastrous.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11527720June 19, 2023
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
We purchased our 2023 Ioniq5 approximately 7 months ago. We saw an article in the newspaper about the 2022 Ioniq losing power while driving. That has happened to us 3 times in the last several months so it is not strictly the 2022 model. One time was particularly scary as I was entering a busy freeway the car lost power and as much as I pushed on the pedal I could not go more than 20mph. This happened for about 15-30 seconds then finally accelerated. My husband said he has experienced the same problem with this vehicle on 3 different occasions. Thank you.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11527692June 19, 2023
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
I received a warning on my dashboard while driving "Check electric vehicle system". A few minutes later I received the message "Stop vehicle and check power supply". My car would not go faster than 20 MPH, and I had it towed to the dealership. They said it was an ICCU issue and the part was on nationwide backorder. My car has been at the dealership for 41 days.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11527682June 19, 2023
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
2023 Hyundai Ioniq 5 (SEL, AWD) has bad ICCU (intergrated charging control unit). Will only charge at DC chargers reliably, level 2 or level 1 chargers will only work intermittently. Has been in the shop 2 weeks with no estimated repair date as the ICCU is on backorder. This issue is affecting a lot of Hyundai/KIA/Genesis customers who's vehicles share the same platform. The dealer won't even say where I am in line to receive the ICCU vs. everyone else in North America. This is really unacceptable for a car I paid almost $60,000 for.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11527664June 19, 2023
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
On 24 May 2023, I heard a "pop" sound when starting my Ioniq5 and immediately received warnings directing me to stop the vehicle and check the battery system. The car was taken to the dealer on the same day and is still out of service. The dealer notified me that the problem is due to an "ICCU" issue and that parts are backordered and they do not have an estimated date for the receipt of parts or repair.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11527596June 18, 2023
VEHICLE SPEED CONTROL
Accelerator failed to engage on two occasions. 5/18/2023: First while driving on highway at 70MPH. Car slowed down gradually and I pulled onto shoulder. 5/19/2023: Again the next day driving 35 MPH. Pulled off road onto private driveway. On both occasions I turned car off and back on and it resumed normally. Fortunately no accident or traffic problem. I brought car to the dealer (Country Hyundai Northampton) to be checked and they could not find a problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11527547June 17, 2023
ELECTRICAL SYSTEM, ENGINE, POWER TRAIN
Called an ICCU failure. It's the control unit that charges the 12V battery from the high voltage battery. The unit fails blowing the high voltage fuse. Failure of this component causes the vehicle to all but shut down, even while driving. This is known by Hyundai. Others have said this happens at about 12 months and 10,000 miles. My car was 53/54weeks old and had 9,300 miles. This failure of this part may have also caused my AC to stop working. As pressure sensor on the 12V system that was working before the component failed was not working when I received the car back, resulting in another lengthy repair. I had about 0.7 miles warning, a yellow check EV system lit up, then the whole dash lit up saying to pull over immediately. The ICCU was replaced by Hyundai with the "2023 spec" version.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11527539June 17, 2023
ELECTRICAL SYSTEM, POWER TRAIN
The power gave out on the car and Hyundai refuses to fix it. They said a part needs to ship over and they give very little updates.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11527198June 15, 2023
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
Charging randomly stops before completion
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11526875June 13, 2023
ELECTRICAL SYSTEM
Was driving on the highway and got a warning to check electric system, then it asked to pull over due to battery failure. The car's 12V battery died and it wouldn't turn on. Had AAA replace battery, and then drove it to the dealership. The power gave out close to the service center and the car moved really slowly. It took the service center to diagnose the issue as ICCU failure. It's been 4 weeks and there is no ETA on the part.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11525932June 7, 2023
ELECTRICAL SYSTEM
The charging port on the electric vehicle appears to have poor cooling as the port frequently overheats when connected to any level 2 charger that is within the vehicle's approved specs. I've measured it going as high as 200 degrees F before the car stops accepting a charge, and even after that the port will remain piping hot until it is physically unplugged. This is quite dangerous as I mostly charge at night and am asleep when it happens in my garage. A quick search online shows that hundreds of Ioniq5 owners are having the same issue. Hyundai released a technical service bulletin(23-EV-003H), so I can take it into a dealer for a software update that will fix the issue. However, that update only succeeds in restricting how much current the car will accept in order to keep the temperature within safe levels. This means that the car I purchased cannot function safely as advertised.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11525379June 5, 2023
ENGINE
What component or system failed or malfunctioned: Rear electric motor. Specifically the "engine oil pump" that is used to cool the rear motor. The pump does not respond to MCU commands and does not cool the motor. This causes the motor to overheat after about an hour of highway driving causing the motor to provide VERY limited power. How was your safety or the safety of others put at risk: When the above happens the car experiences a delayed throttle, and very little power to accelerate. This occurs while traveling on a highway where you may need to pass, but no longer have the power to do so safely. Has the problem been reproduced or confirmed by a dealer or independent service center: Dealer took the car in and did not properly attempt to reproduce the issue. Then stated that if the car does not produce a DTC then there is no issue. The dealer has since refused to accept the car again. This has been reproduced here: https://www.ioniqforum.com/threads/rear-motor-not-operating-45-min-after-charge.46007/ Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others: No, I have just started the process of reaching out to the manufacture, and if this fails I will be using my states lemon laws. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear: No this issue does not appear to throw any codes, lights, or messages. The dash shows the rear engine producing no power, and the throttle will only show half when pressed to the floor.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11525054June 2, 2023
ELECTRICAL SYSTEM
This is a rampant problem with my car as I have seen hundreds of the same reports throughout the many Ioniq 5 forums I am on. 4/22/23 my car died leaving me stranded. Apparently, the early revisions of the car I bought in March 2022 has a problem where the ICCU and inline fuse will go out over time leaving the car useless and frankly a hazard as I had to immediately pull over when the error message popped up. The issue IMHO should be a recall at this point. It has been sitting at a dealership awaiting the back ordered parts and Hyundai corporate denies that this is an ongoing problem even though I can see all the evidence widespread on the internet. Currently in the process of contacting a lawyer about a lemon law/class action lawsuit.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Hyundai Ioniq 5