Ford F-450 Complaints

588 consumer complaints on file.

#10328946May 5, 2010
ELECTRICAL SYSTEM, FUEL SYSTEM, DIESEL, ENGINE AND ENGINE COOLING:EXHAUST SYSTEM, SUSPENSION:FRONT, POWER TRAIN:AUTOMATIC TRANSMISSION, ENGINE AND ENGINE COOLING:ENGINE, STEERING
INJECTORS TURBO EXHAUST AND ALOT MORE PROBLEMS, BEEN TOWED 6 TIMES BEEN TO THE DEALER OVER 30 TIMES WENT THROUGH LEMON LAW DIDN'T QUALIFY VEHICLE TO HEAVY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10328977May 5, 2010
FUEL SYSTEM, DIESEL
A FORD 6.0 DIESEL ENGINE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10328860May 4, 2010
FUEL SYSTEM, DIESEL
FORD F450 DIESEL DELAMINATING FUEL TANKS CAUSE THE VEHICLE TO STALL ON THE HIGHWAY CAUSING A SAFETY HAZARD. THE DELAMINATION CAUSES THE FUEL SYSTEM TO NOT WORK PROPERLY SUCH AS THE INJECTORS CAUSING THE VEHICLES TO LOOSE POWER AND STALL. IT HAS HAPPENED THREE TIMES TO ME WITHOUT WARNING. THE TANK IS BEING RE-COATED BUT AFTER DOING SOME INVESTIGATION ABOUT THE PROBLEM AND EVEN THE FORD SERVICE TECH SAID IT COULD HAPPEN AGAIN...AND MOST LIKELY WILL BECAUSE THE DIESEL FUEL IS INTERACTING WITH WHATEVER THEY PUT ON THE TANKS CAUSING IT TO ERODE. FORD WILL NOT COVER THIS. I HAVE FOUND INFORMATION SAYING IT SEEMS TO BE HAPPENING TO TANKS WITH THESE TWO IDENTIFICATION NUMBERS YC35-9K007-F8 AND 5C34-9K007-RA. I GUESS IF FORD ACKNOWLEDGED THIS THEY WOULD BE RESPONSIBLE FOR REPLACING THESE DEFECTIVE TANKS. BUT BY BLAMING THE DIESEL FUEL...THEY ARE NOT HELD RESPONSIBLE. HOWEVER IT DOESN'T HAPPEN ON OTHER TRUCKS SUCH AS DODGE, CHEVY, ETC. SOMETHING REALLY NEEDS TO BE DONE TO WARN OTHERS BEFORE SOMEONE STALLS AND CAUSES A WRECK. ALOT OF THESE TRUCKS ARE USED IN BUSINESS AND CARRY HEAVY LOADS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10328389May 2, 2010
FUEL SYSTEM, DIESEL
A FAULTY FUEL LINE ON A 2000 FORD F450 BRUSH FIRE TRUCK FAILED, SPRAYING DIESEL FUEL ONTO THE ENGINE, CAUSING A SMALL ENGINE FIRE, DURING AN EMERGENCY RESPONSE TO A FIRE. FIRE WAS QUICKLY CONTROLLED WITH ONBOARD AFFF/WATER MIXTURE. CALLED TO HAVE REPAIRED, MECHANIC CAME OUT TO STATION, AND REPLACED 2 STEEL FUEL LINES. MECHANIC STATED HE IS SURPRISED THESE FUEL LINES WERE NEVER RECALLED, HE HAD CHANGED HIS OUT FOR A SAME FAILURE WEEKS AGO. APPARENTLY, THE SUPPORT BRACKET, THAT CAME ON THE ORIGINAL LINES, THE RUBBER INSIDE THE BRACKET WEARS OUT, SO THE LINE RUBS AGAINST METAL AND WEAKENS IT. THE NEW REPLACEMENT LINES DO NOT COME WITH THIS LINE. APPARENTLY THIS IS A COMMON PROBLEM ACCORDING TO THE MECHANIC. OLD PART IS NOT AVAILABLE, MECHANIC THREW IT AWAY. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10325568April 13, 2010
FUEL SYSTEM, DIESEL
F450 STAKE BODY DUMP TRUCK STARTED HESITATING AT ALL SPEEDS. FOUND OUT THAT THE DIESEL FUEL GAS TANKS ARE DELAMINATING ON THE INSIDE AND CLOGGING THE FUEL SYSTEM. THIS REPAIR COSTS $2,400. A BIG TRUCK DRIVING DOWN THE ROAD THAT IS RUNNING FINE AND THEN ALL OF A SUDDENLY STARTS TO HESITATE IS EXTREMELY DANGEROUS. FORD TRUCKS SEEM TO BE THE ONLY ONES HAVING THIS PROBLEM. I FEEL FORD SHOULD BE REQUIRED TO RECALL THESE TRUCKS AND FIX THE PROBLEM FOR SAFETY PURPOSES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10324716April 9, 2010
UNKNOWN OR OTHER
I HAVE TWO AMBULANCES THAT ARE ON 2008 FORD CHASSIS'. BOTH AMBULANCES HAVE HAD MULTIPLE PROBLEMS AND HAVE BEEN IN THE SHOP SEVERAL TIMES. I HAVE SPOKEN WITH THE FOLKS AT FORD MOTOR COMPANY AND HAVE NOT HAD SATISFACTORY RESULTS. MY FEAR IS THAT ONE OF THESE UNITS WILL BE TRANSPORTING A CRITICAL PATIENT AND BREAK DOWN ENROUTE TO THE HOSPITAL LEADING TO THE DEATH OF THE PATIENT. AS A FIRE CHIEF I AM VERY CONCERNED ABOUT THIS. ANY ASSISTANCE WOULD BE APPRECIATED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10322808March 30, 2010
FUEL SYSTEM, DIESEL
THE COATING ON THE INTERIOR OF FORD DIESEL FUEL TANKS CORRODES AND COLLECTS AS SEDIMENT IN THE FUEL SYSTEM. THE SEDIMENT, COLLECTS AT THE BOTTON OF THE FUEL TANK AND IS SUCKED INTO THE FUEL SYSTEM. THE FUEL LINES BECOME FOULED, THE FUEL PUMPS BECOME CLOGGED AND REQUIRE REPLACEMENT. AS THE COATING CONTINUES TO DETERIORATE, THE ONLY RECOURSE IT TO CHANGE THE FUEL TANK, THE SENSORS, AND ENTIRE FUEL DELIVERY SYSTEM. WE HAVE HAD 3 FORD VEHICLES F SERIES EXPERIENCE THIS PROBLEM. IN THIS INSTANCE, THE TRUCK WAS RETURNED TO THE DEALER FOR REPAIR. AFTER SPENDING $1912.11 IN REMEDIES, THE FINAL RECOURSE WAS TO HAVE OUR OWN MECHANICS REPLACE THE FUEL SYTEM FROM THE TANK ITSELT UPTO AND INCLUDING THE FUEL PUMP. THIS WAS AN ADDITIONAL EXPENSE OF APPROXIMATELY $1000. WE ARE REPORTING THIS AS IT SEEMS TO BE A DEFECT IN ALL THE FORD DIESEL FUEL SYSTEMS. AS THE FUEL SYSTEMS BECOME CLOGGED, THE VEHICLES LOSE POWER WITHOUT WARNING AND CREATE A SAFETY ISSUE AND DRIVING HAZARD NOT ONLY TO THE VEHICLE OPERATOR BUT OTHER MOTORISTS. UPON COMPLAINTS TO THE DEALER, AND TO FORD, THE DEALER REFERRED US TO THE ODI WEBSITE TO FINAL A SAFETY COMPLAINT AS THIS HAS OCCURRED OVER AND OVER.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10322799March 30, 2010
FUEL SYSTEM, DIESEL
THE COATING ON THE INTERIOR OF FORD DIESEL FUEL TANKS CORRODES AND COLLECTS AS SEDIMENT IN THE FUEL SYSTEM. THE SEDIMENT, COLLECTS AT THE BOTTON OF THE FUEL TANK AND IS SUCKED INTO THE FUEL SYSTEM. THE FUEL LINES BECOME FOULED, THE FUEL PUMPS BECOME CLOGGED AND REQUIRE REPLACEMENT. AS THE COATING CONTINUES TO DETERIORATE, THE ONLY RECOURSE IT TO CHANGE THE FUEL TANK, THE SENSORS, AND ENTIRE FUEL DELIVERY SYSTEM. WE HAVE HAD 3 FORD VEHICLES F SERIES EXPERIENCE THIS PROBLEM. THE AVERAGE REPAIR IS APPROXIMATELY $2180 PER VEHICLE. WE ARE REPORTING THIS AS IT SEEMS TO BE A DEFECT IN ALL THE FORD DIESEL FUEL SYSTEMS. AS THE FUEL SYSTEMS BECOME CLOGGED, THE VEHICLES LOSE POWER WITHOUT WARNING AND CREATE A SAFETY ISSUE AND DRIVING HAZARD NOT ONLY TO THE VEHICLE OPERATOR BUT OTHER MOTORISTS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10322803March 30, 2010
FUEL SYSTEM, DIESEL
THE COATING ON THE INTERIOR OF FORD DIESEL FUEL TANKS CORRODES AND COLLECTS AS SEDIMENT IN THE FUEL SYSTEM. THE SEDIMENT, COLLECTS AT THE BOTTON OF THE FUEL TANK AND IS SUCKED INTO THE FUEL SYSTEM. IN THIS INCIDENT, THE FAILURE BEGAN WITH THE CHECK ENGINE LIGHT ILLUMINATING. THE DEALER, REPLACED THE SENSOR, THEN AT A SECOND TIME THE FUEL ELEMENT, AND FINALLY THE ENTIRE FUEL SYSTEM REQUIRED REPLACEMENT. THE FUEL LINES BECOME FOULED, THE FUEL PUMPS BECOME CLOGGED AND REQUIRE REPLACEMENT. AS THE COATING CONTINUES TO DETERIORATE, THE ONLY RECOURSE IT TO CHANGE THE FUEL TANK, THE SENSORS, AND ENTIRE FUEL DELIVERY SYSTEM. WE HAVE HAD 3 FORD VEHICLES F SERIES EXPERIENCE THIS PROBLEM. IN THIS CASE IN LESS THAN 18 MONTHS FROM DATE OF PURCHASE, THE FUEL ELEMENTS AND SENSORS REQUIRED REPLACEMENT WE ARE REPORTING THIS AS IT SEEMS TO BE A DEFECT IN ALL THE FORD DIESEL FUEL SYSTEMS. AS THE FUEL SYSTEMS BECOME CLOGGED, THE VEHICLES LOSE POWER WITHOUT WARNING AND CREATE A SAFETY ISSUE AND DRIVING HAZARD NOT ONLY TO THE VEHICLE OPERATOR BUT OTHER MOTORISTS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10321167March 20, 2010
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM, SERVICE BRAKES, HYDRAULIC, FUEL SYSTEM, DIESEL, POWER TRAIN:AUTOMATIC TRANSMISSION, UNKNOWN OR OTHER
DRIVING AS NORMAL ON FWY HEARD A LOUD NOISE THOUGHT I GOT A FLAT. STOPPED VEHICLE ON SHOULDER, BRAKING WAS DIFFICULT AND WHITE SMOKE WAS AROUND THE CAR. I GOT OUT AND DID NOT SEE ANY FLAT TIRES BUT I SAW SMOKE BETWEEN THE CAB AND BED OF THE TRUCK. I RAN BACK TO THE DRIVER DOOR AND SAW A SMALL FIRE ON THE FLOOR NEXT TO THE 4X4 SHIFTER FOR THE TRANSFER CASE. I IMMEDIATELY GRABBED MY 3 YEAR OLD DAUGHTER FROM HER CAR SEAT AS THE CAB FILLED WITH SMOKE AND RAN APPROXIMATELY 300 FEET AWAY AND TOLD MY DAUGHTER TO STAY. I JUMPED INTO THE BACK OF THE TRUCK GRABBED A LARGE FIRE EXTINGUISHER AND DISCHARGED IT INTO THE HOLE IN THE FLOORBOARD NEXT TO THE TRANSFER CASE IT WENT OUT AND IMMEDIATELY CAME STARTED UP AGAIN. I THEN CALLED 911. SOME PEOPLE STOPPED AND HELPED ME REMOVE A FEW POSSESSIONS FROM THE TRUCK BED. WITHIN 3 MINUTES THE TRUCK FIRE FLASHED AND WE ALL STOOD BACK AND VIDEO TAPED THE VEHICLE BURN TO THE GROUND. THE WITNESSES SAID WHAT APPEARED TO BE SOMETHING METAL CAME OFF OF MY TRUCK STRUCK THEIR CAR AND THE REASON THEY PULLED OVER IS BECAUSE THEY THOUGHT THEY HAD A FLAT BUT WHEN THEY LOOKED BACK THEY SAW FIRE UNDERNEATH MY TRUCK AND RAN TO HELP. THE FD ARRIVED THEY SHOT FOAM ON THE FIRE BUT IT CONTINUED TO GO OUT THEN START BACK IT TOOK THEM APPROXIMATELY 30 MIN TO EXTINGUISH. I AM VERY MECHANICAL AND BELIEVE MECHANICAL FAILURE IN THE EXHAUST CANNINSTERS THAT COLLECT THEN BURN HYDRO CARBON PARTICLES BEFORE THEY ARE RELEASED INTO THE CAT CONVERTER, SENT EXCESSIVE HEAT TO THE TRANSMISSION THEN THE TRANSFER CASE(DIRECTLY BELOW THE FUEL LINES), THUS MELTING THE FUEL LINES WHICH DRIPPED ON THE RED HOT TRANSFER CASE AND STARTED THE FIRE. THE VEHICLE WAS IN THE SHOP PREVIOUSLY UNDER A FORD RECALL FOR SHOOTING FLAMES OUT OF THE TAIL PIPES SO I ASSUME THEY MUST HAVE RESTRICTED THE FLAMES WHICH KEPT THE MORE HEAT INSIDE THE VEHICLE EXHAUST SYSTEM AND IS SERIOUSLY DANGEROUS! MY DAUGHTER AND I WOULD HAVE BEEN KILLED IF THE AIR BAGS HAD DEPLOYED OR AN ACCIDENT. *TR
Crash:
No
Fire:
Yes
Injuries:
2
Deaths:
0
#10319740March 16, 2010
FUEL SYSTEM, OTHER:FUEL INJECTION SYSTEM, ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER
LTR FWD FM (VA) RE DEFECT FUEL INJECTION AND AIR INDUCTION SYSTEM FOR A 2004 FORD F-450 MEDIUM DUTY TRUCK. *TGW THE CONSUMER STATED A FEW MONTHS AFTER PURCHASING THE TRUCK, HE BEGAN HAVING A RECURRING PROBLEM WITH THE TRUCK LOOSING POWER. THE CONSUMER BELIEVED THE PROBLEM WAS ASSOCIATED WITH THE FUEL INJECTION AND AIR INDUCTION SYSTEM FOR THE TURBO CHARGER. ON 4 OCCASIONS, WHILE DRIVING UP A MOUNTAIN, HE EXPERIENCED A SUDDEN LOSS OF POWER THAT WAS CAUSED BY THE TRUCK GOING FROM 65 MPH TO LESS THAN 10 MPH IN A MATTER OF SECONDS. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10319188March 12, 2010
FUEL SYSTEM, GASOLINE
TL*THE CONTACT OWNS A 2006 FORD 450. HE STATED THAT THE FUEL TANK HAD DELAMINATED, CAUSING SHARDS OF THE TANK TO BREAK OFF INTO THE FUEL LINE. THE VEHICLE WAS DIAGNOSED BY A LOCAL DEALER WHO CONFIRMED REPAIRS WOULD NEED TO BE MADE TO THE FUEL TANK, AT THE OWNER'S EXPENSE. THE CONTACT WAS CONCERNED WITH THE DEFECTIVE FUEL TANK AFFECTING THE FUEL INJECTORS AND THE MOTOR. REPAIRS WERE MADE TO THE VEHICLE BY THE OWNER AND AN INDEPENDENT MECHANIC. THE APPROXIMATE FAILURE MILEAGE WAS 135,000 AND THE CURRENT MILEAGE WAS 135,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10319261March 12, 2010
ENGINE AND ENGINE COOLING
TL * THE CONTACT OWNS A 2005 FORD F-450. WHILE DRIVING APPROXIMATELY 65-70 MPH ON NORMAL ROAD CONDITIONS, THE VEHICLE EXPELLED EXCESSIVE WHITE SMOKE FROM THE TAIL PIPE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON FOUR SEPARATE OCCASIONS FOR THE IDENTICAL FAILURES. THE FAILURE WAS CONTRIBUTED TO THE ENGINE IN WHICH THERE WERE FOUR REPLACEMENTS OF THE EXHAUST GAS RECIRCULATION COOLER AND THE TURBO DRAIN TUBE. IN ADDITION, THE INTAKE GASKETS, HIGH PRESSURE OIL PUMP, AND FUEL INJECTOR CONTROL MODULE WERE REPLACED. THE CONTACT STATED THAT THERE WERE OTHER ENGINE RELATED COMPONENTS REPLACED ON SEVERAL OCCASIONS. THE FAILURES WOULD OCCUR AT AN ESTIMATION BETWEEN EVERY 7,500 -12,000 MILES. THE FAILURE MILEAGE WAS 86,845 AND THE CURRENT MILEAGE WAS UNKNOWN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10317140March 5, 2010
FUEL SYSTEM, DIESEL
2004 FORD F-450 SUPER DUTY. TRUCK WAS RUNNING AS IF IT WAS RUNNING OUT OF FUEL, GOT TO A STOP LIGHT AND THE TRUCK STALLED. GOT THE TRUCK TO RESTART. THAT EVENING I HAD THE FUEL FILTERS CHANGED THINKING THAT WAS THE PROBLEM, THEN THE TRUCK RAN FINE. TWO DAYS LATER THE TRUCK DID THE SAME THING, AND I WAS DRIVING AT 25MPH, TRUCK WOULD NOT RUN ANY FASTER, THEN THE TRUCK STALLED IN THE MIDDLE OF A TWO LANE ROAD. THE TRUCK AT THIS TIME DID NOT RESTART. I HAD TO GET THE TRUCK TOWED. I GOT ADVICE FROM A MECHANIC AND HE DRAINED THE TANK AND HE FOUND SILVER FLAKES IN THE TANK. I CALLED UNIVERSAL FORD IN RICHMOND VIRGINIA AND THEY HAD IT TOWED THERE TO LOOK AT THE TRUCK, AND THE TECHNICIAN VERIFIED THAT THE TANK WAS CONTAMINATED FROM THE TANK DUE TO DELAMINATION OF THE INTERIOR OF THE TANK. FORD MOTOR COMPANY SAID THAT THE COST WAS $783.93 FOR PARTS AND $258.10 FOR LABOR, FOR A TOTAL OF $1042.03 AND FORD MOTOR WAS WILLING TO PAY ONLY $312.00. THIS IS ONLY FOR A TANK REPLACEMENT, NOT THE FILTERS, FUEL PUMP OR INJECTORS IF THESE PARTS ARE CONTAMINATED. I REFUSED THE SERVICE, ON THE FACT THAT THE SERVICE MANAGER SAID THAT THIS WILL PROBABLY HAPPEN AGAIN WITH THE NEW TANK AS WELL. I HAVE FOUND SOMEONE THAT CAN FIX MY TANK FOR LESS MONEY, BUT I WOULD LIKE RESULTS AND THIS NEEDS TO BE ADDRESSED BEFORE SOMEONE DOES GET KILLED, IF THEY HAVEN'T ALREADY. FORD IS SAYING TO MY KNOWLEDGE THAT THIS IS THE LOW-SULFUR DIESEL FUEL AND NOT THERE FUEL TANKS. I HAVE CONTACTED A LAWYER AND HE IS DEALING WITH OTHER CLIENTS WITH THE SAME ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10315711March 2, 2010
ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR
TL*THE CONTACT OWNS A 2006 FORD F450. WHILE DRIVING 25 MPH HE TRIED APPLY THE BRAKES AND THE VEHICLE BEGAN TO SLIDE TO THE LEFT AND HE ALMOST HIT A FEW VEHICLES. THE DRIVER STATED THAT HIS FRONT TIRES LOCKED UP. HE CONTACTED THE DEALER AND THEY SAID IT WAS DUE TO LOW VOLTAGE. THE DEALER THEN REPLACED HIS ALTERNATOR FOR $500.00. THE DRIVER STATED THAT THERE WAS ALSO SMOKE COMING FROM THE TIRES. THE FAILURE MILEAGE WAS 75,000. THE CURRENT MILEAGE WAS 76,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10314146February 25, 2010
FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY
TL*THE CONTACT OWNS A 2006 FORD F450. THE CONTACT STATED THAT THE MATERIAL IN THE FUEL TANK HAS DETACHED FROM THE INNER STRUCTURE OF THE TANK. THE MATERIAL WAS IN THE FUEL INJECTOR AND CAUSED THE VEHICLE TO STALL AND SHUT OFF INTERMITTENTLY WHILE DRIVING 65 MPH. THE CONTACT HAS TAKEN THE VEHICLE TO THE DEALER TO REPLACE THE FUEL TANK, FUEL PUMP, FUEL SENDER, FUEL FILTERS, AND THE FUEL INJECTORS. THE REPAIRS HAVE REMEDIED THE FAILURE. THE CONTACT STATED THAT THE VEHICLE COULD HAVE CAUSED A CRASH WHILE STALLING ON THE HIGHWAY. THE FAILURE MILEAGE WAS UNKNOWN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10314145February 25, 2010
FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY
TL*THE CONTACT OWNS A 2002 FORD F450. THE CONTACT STATED THAT THE MATERIAL IN THE FUEL TANK HAS DETACHED FROM THE INNER STRUCTURE OF THE TANK. THE MATERIAL WAS IN THE FUEL INJECTOR AND CAUSED THE VEHICLE TO STALL AND SHUTS OFF INTERMITTENTLY WHILE DRIVING 65 MPH. THE CONTACT HAS TAKEN THE VEHICLE TO THE DEALER TO REPLACE THE FUEL TANK, FUEL PUMP, FUEL SENDER, FUEL FILTERS, AND THE FUEL INJECTORS. THE REPAIRS HAVE REMEDIED THE FAILURE. THE CONTACT STATED THAT THE VEHICLE COULD HAVE CAUSED A CRASH TO OCCUR WHEN IT STALLED. THE FAILURE MILEAGE WAS UNKNOWN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10312971February 23, 2010
VEHICLE SPEED CONTROL
TL*THE CONTACT OWNS A 2008 FORD F450 SD. THE CONTACT STATED THAT AFTER THE VEHICLE WAS STARTED AND SHIFTED IN GEAR IT ATTEMPTED TO ACCELERATE. THE CONTACT APPLIED EXTREME PRESSURE TO THE BRAKE PEDAL IN ORDER TO STOP THE VEHICLE FROM LUNGING FORWARD. THE CONTACT STATED THAT HE HAD TO TURN THE VEHICLE OFF TWICE AND RESTART IT. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE FAILURE MILEAGE WAS 43,016. UPDATED 4/7/2010 *CN THE CONSUMER STATED HE WAS UNABLE TO STEER THE TRUCK AS WELL. UPDATED 05/05/10.*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10310966February 16, 2010
ENGINE AND ENGINE COOLING:ENGINE
TL*THE CONTACT OWNS A 2008 FORD F450SD. THE CONTACT STATED AS HE WAS DRIVING AT 40-65MPH THE ENGINE GOES INTO A SAFE MODE AND CUTS OFF. HE STATED THAT WHEN PARTS SUCH AS THE EGR VALVE AND FUEL PUMP FAIL THE ENGINE GOES INTO A SAFE MODE AND THE VEHICLE SHUTS DOWN. THE CONTACT HAD TO PULL OVER TO THE SIDE OF THE ROAD, RESTART THE ENGINE AND THEN DRIVE SLOWLY TO THE DEALER. THE DEALER HAS ALREADY REPLACE THE FUEL PUMP BUT THE EGR VALVE IS ON BACK ORDER DUE TO A HIGH DEMAND OF THIS FAILURE. THE FAILURE MILEAGE WAS 46,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10305367February 4, 2010
FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY
TL*THE CONTACT OWNS A 1999 FORD F450. THE CONTACT WAS DRIVING VARIOUS SPEEDS, THE VEHICLE WOULD SHUT DOWN WHILE DRIVING DUE TO THE DELAMINATED FUEL TANKS. EXCESSIVELY LARGE AMOUNTS OF SMOKE HAS BEEN SEEN IN THE ENGINE AREA OF THE VEHICLE. FORD ADVISED THE CONTACT THAT THEY ARE NOT RESPONSIBLE FOR THE FAILURE OR REPAIR. THE FAILURE AND CURRENT MILEAGES WERE UNAVAILABLE. UPDATED 04/05/10*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-450