Ford F-450 Complaints

588 consumer complaints on file.

#10872171June 2, 2016
ENGINE
WHILE TRANSPORTING A PATIENT TO THE HOSPITAL THE ENGINE ON OUR 2012 FORD AMBULANCE SUDDENLY AND WITHOUT WARNING DERATED. THIS CAUSED OUR AMBULANCE TO SLOW DRAMATICALLY AND DELAYED TRANSPORT TO THE HOSPITAL. WE BROUGHT THE AMBULANCE TO THE DEALER WHO STATED THE ENTIRE DEF SYSTEM WOULD NEED TO BE REPLACED AT A COST OF $5,000! I RESEARCHING THE INTERNET THIS IS NOT AN UNCOMMON PROBLEM. I CONTACTED THE REGIONAL MANAGER FOR FORD AND HAVE HAD NO RESPONSE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10871640May 31, 2016
ENGINE, FUEL/PROPULSION SYSTEM
THE HIGH PRESSURE FUEL PUMP FAILED. FORD CLAIMED THAT THIS WAS FROM CONTAMINATED FUEL. FORD HAS TWO FUEL FILTERS AND A WATER SEPARATOR. I PERSONALLY ADDED TWO ADDITIONAL FILTERS AND AN ADDITIONAL WATER SEPARATOR, FOR A TOTAL OF FOUR FILTERS AND TWO SEPARATORS. FORD ALSO HAS A WATER IN FUEL LIGHT THAT IS SUPPOSED TO ALERT THE DRIVER TO CONTAMINATION. AT NO TIME DID THIS LIGHT COME ON. IN SHORT, I BELIEVE FORD HAS A DEFECTIVE FUEL PUMP AND A DEFECTIVE FILTRATION AND WATER ALERTING SYSTEM. THIS TRUCK SHUTDOWN, WITH NO WARNING AT 70 MPH ON A LIMITED ACCESS HIGHWAY. FORD REFUSES TO ADDRESS THE PROBLEM AND CONTINUES TO BLAME THE OWNER. THIS IS A SAFETY ISSUE AND I WAS FORTUNATE THAT THERE WAS LIGHT TRAFFIC AND I WAS ABLE TO SAFELY STEER THE POWERLESS TRUCK TO THE SIDE OF THE ROAD. IN RESEARCHING THIS ISSUE, I'VE SEEN THAT THERE ARE NUMEROUS REPORTS OF THE SAME PROBLEM ON THE 6.7 LITER POWERSTROKE DIESEL ENGINE FROM 2011 ON.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10871367May 28, 2016
FUEL/PROPULSION SYSTEM
1/28/14- HPFP METAL SHAVINGS FOUND AFTER ENGINE POWER DOWN, ALL FUEL SYSTEM REPLACED. AFTER ONLY A FEW MONTHS (4/10/14) SAME THING. ON 4/25/16 SAME THING. NO WARRANT. FORD KNOWS THIS HAS BEEN ONGOING ISSUE, REFUSES TO WARRANTY WHILE OTHER MFG, IE VW DOES COVER SAME PART. I WOULD WELCOME CLASS ACTION SUIT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10870536May 24, 2016
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2008 FORD F-450 SD. THE CONTACT STATED THAT WHILE DRIVING AT 45 MPH, THE REAR DRIVER'S SIDE DOOR OPENED INDEPENDENTLY AS THE DOOR AJAR WARNING INDICATOR ILLUMINATED. THE CONTACT MANEUVERED TO THE SIDE OF THE ROAD. HOWEVER, THE DOOR FAILED TO LATCH IN A SECURED POSITION. AFTER NUMEROUS ATTEMPTS, THE DOOR LATCHED PROPERLY. THE FAILURE RECURRED TEN TIMES. IN ADDITION, THE SAME FAILURE OCCURRED WITH THE REAR PASSENGER SIDE DOOR ON A SEPARATE OCCASION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10863436May 5, 2016
STEERING, SUSPENSION, UNKNOWN OR OTHER
WHILE DRIVING DOWN A PARKWAY AT THE SPEED LIMIT, WE TRAVELED OVER SEVERAL BRIDGES AND ALL OF A SUDDEN AFTER HITTING A ROUGH SPOT IN THE ROAD AND OVER THE BRIDGES THE TRUCK BEGAN TO SHAKE VIOLENTLY AND WE HAD TO ALMOST COME TO A STOP TO HOLD IT IN THE ROAD. IT CONTINUED TO DO THIS ALMOST EVERY TIME WE HIT A BUMP IN THE ROAD. WE HAD JUST RECENTLY BOUGHT THIS TRUCK USED, I AM SCARED TO RIDE OR DRIVE THIS TRUCK ANYMORE, IT IS MY HUSBANDS AND HE DOES. WE PULL A HORSE TRAILER AT TIMES AND I AM SCARED TO DO SO BECAUSE IT PUTS OUR LIVES AS WELL AS OTHER MOTORISTS LIVES AND MY HORSES IN DANGER. THIS NEEDS TO BE RECALLED AND CORRECTED ASAP....HE PURCHASED SOME EXPENSIVE PART AND HAD IT PUT ON UNDER THE FRONT END AND IT HAS HELPED BUT LT STILL FEELS LIKE IT WILL START AT ANY MOMENT TO SHAKE WHEN YOU CROSS A BRIDGE OR HIT A POT HOLE, IT IS LIKE IT IS ON THE VERGE AND COULD START AT ANY MOMENT. IT DOES NOT DRIVE NORMAL!!!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10860944April 22, 2016
ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 2008 FORD F-450 SD. AFTER WATER WAS ADDED TO THE RADIATOR, THE CONTACT NOTICED THAT WATER LEAKED OUT OF THE HOSE. THE VEHICLE LEAKED RADIATOR FLUID FROM THE HOSE. IN ADDITION, THE EGR COOLER MALFUNCTIONED AND CAUSED THE AIR CONDITIONER TO OPERATE INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE EGR COOLER, RADIATOR, AND HOSES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS APPROXIMATELY 95,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10851336March 24, 2016
ENGINE
TL* THE CONTACT OWNED A 1995 FORD F-450 SD. THE CONTACT STATED THAT THE VEHICLE CAUGHT FIRE INDEPENDENTLY. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND FILED A REPORT. THERE WERE NO INJURIES. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS DESTROYED. THE VIN AND FAILURE MILEAGE WERE UNKNOWN.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10851181March 23, 2016
ENGINE, POWER TRAIN
CODE P2201 SETTING AND CAUSING TRUCK TO GO INTO LIMP MODE AND REDUCE POWER. VEHICLE IS USED A A BRUSHPUMPER FOR FIRE DEPARTMENT. HAS BEEN IN FOR REPAIRS TO DEALER 12 TIMES WITH NO REPAIR THAT HAS LASTED. CODE SETS WHEN IN MOTION, DE-RATES POWER AND HAS TO LIMP BACK TO SHOP. CANNOT BE USED TO FIGHT FIRES AT THIS TIME.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10825015February 9, 2016
FUEL/PROPULSION SYSTEM, STEERING
ENGINE WILL SHUT OFF WHILE DRIVING AND NOT RESTART OR JUST NOT START.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10822423January 26, 2016
AIR BAGS
I WAS IN AN ACCIDENT ON 7/6/2015. I RECEIVED BURNS ON BOTH HANDS AND LEFT FOREARM. I ALSO RECEIVED A TORN ROTATOR CUFF AND CHEST BRUISING FROM SEAT BELT. I DO NOT THINK THE AIRBAG SHOULD HAVE CAUSED BURNS TO MY SKIN. I WOULD LIKE TO KNOW IF THIS SHOULD HAVE OCCURRED.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10822431January 26, 2016
FUEL/PROPULSION SYSTEM
"DELAMINATION OF FUEL TANK" AFTER ONLY HAVING THE VEHICLE FOR SHORTLY OVER FOUR MONTHS, THE TRUCK WOULD NOT CRANK. THE TRUCK WAS PARKED ON A CITY STREET IN WASHINGTON, DC WHERE I RACKED UP 2 PARKING TICKETS. I HAD IT TOWED TO THE DEALER AND THEY SAID THAT THE TANK IS CORRODING. I'VE HAD ISSUES WITH THE TRUCK SINCE I PURCHASED IT. THE GAS GAUGE WOULD GO OUT PERIODICALLY ALONG WITH THE POWER. I CALLED THE DEALER AND HAD IT CHECKED OUT, AND THEY SAID THEY COULDN'T FIND ANY ISSUES. NOW THAT THE 90 DAY WARRANTY IS OVER, THE GOES OUT COMPLETELY IN 120 DAYS. IT TOOK THE DEALER A MONTH TO DELIVER THE TRUCK TO ME AFTER I PURCHASED IT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10821855January 23, 2016
ENGINE
WHILE DRIVING AT VARIOUS SPEEDS RECEIVE LOW FUEL PRESSURE / REDUCED ENGINE POWER WARNING. TRUCK ENTERS "LIMP HOME HOME" ALMOST IMMEDIATELY. REDUCED POWER AT HIGHWAY SPEED PUTS DRIVER/PASSENGERS IN HARM AS ONE CAN'T MAINTAIN SUFFICIENT SPEED TO SAFELY EXIT THE HIGHWAY. FORD WAS UNABLE TO DETERMINE ROOT CAUSE ON FOUR OCCASIONS. ON FINAL OCCURRENCE DEALER STATES FORD CORPORATE WANTS TO DISMANTLE FUEL SYSTEM TO DETERMINE IF FUEL CONTAMINATION IS PRESENT. FURTHER STATES IF CONTAMINATION IS FOUND REPAIR AND DISMANTLE ARE OUTSIDE OF WARRANTY AND OWNERS RESPONSIBILITY. ISSUE BEGAN WITH 10K MILES ON THE VEHICLE FINAL INCIDENT OCCURRED AT 18K MILES. TRADED FOR ANOTHER BRAND OUT OF CONCERN FOR PERSONAL SAFETY. FORDS LACK OF CONCERN AND BLATANT ATTEMPT TO PASS THE BLAME TO CONSUMERS AND FUEL SUPPLIERS HAS LOST THEM A CUSTOMER FOR LIFE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10821300January 20, 2016
FUEL/PROPULSION SYSTEM
I HAVE 2008 FORD F450 WITH 60 K MILES AND RADIATOR START LEAKING AT THE BOTTOM AND IT WAS BUILDING PREASSURE ON THE TOP OF ATIFREAZE BOX AND HEAT AIR STOPED WORKING AND FORD DEALER THAT I BOUGHT FROM DISNT COVER THE WARRANTY I PAID 1400$ TO GET PROBLEM FIXED AND IT SECOND RADIATOR THAT I CHANGED FROM MY POCKET !!!! I THINK FORD NEEDS TO DO SOMETHING WITH THAT IT SHOULD BE A RECALL FOR ALL 2008-2014 POWER STROKE DIESEL ENGINES
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10818765January 7, 2016
ENGINE
RADIATOR LEAK AT 43,000 FROM THE JOINT BETWEEN THE PLASTIC END CAP AND ALUMINUM CORE, DRIVER'S SIDE NEAR BUMPER. COST TO REPAIR ESTIMATED AT 1400-1800$ AT ONLY 7K MILES OUTSIDE OF FACTORY WARRANTY. VEHICLE IS USED DAILY WITHIN RECOMMENDED WEIGHT CAPACITIES TO MOVE MATERIALS AND TRAILERS, BUT FOLLOWS A VERY STRICT MAINTENANCE PROGRAM TO ENSURE LONG LIFE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10808462December 4, 2015
STEERING, SUSPENSION, UNKNOWN OR OTHER
DRIVING DOWN THE HIGHWAY IN THE RAIN TRUCK STARTED SHAKING COULD NOT HOLD STEERING WHEEL . TRUCK STARTED GOING SIDEWAYS ON HIGHWAY FROM SHAKING/ WOBBLE. TRUCK SHUTS OFF DRIVING DOWN THE ROAD WITH NO WARNING NO STEERING OR BRAKES TOWING EQUIPMENT. I HAVE HAD MY 1 YEAR OLD DAUGHTER IN TRUCK ALMOST IN A ACCIDENT 2 TIMES NOW FROM TRUCKS DEATH WOBBLE AND MOTOR SHUTTING OFF TOWING EQUIPMENT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10779531October 3, 2015
ELECTRONIC STABILITY CONTROL (ESC), ENGINE, UNKNOWN OR OTHER
I WAS DRIVING ALONG MY 2012 FORD F450SUPERDUTY TURBO DIESEL ALONG THE INTERSTATE 495 DC BELTWAY IN MARYLAND WITH MY SEVEN YEAR OLD SON IN THE BACK SEAT, WHEN A LCD IN THE MIDDLE OF THE SPEEDOMETER GAVE A WARNING WHICH READ "REDUCED POWER" AND COULD IMMEDIATELY FEEL A REDUCED RESPONSIVENESS OF THE TRUCK TO THE ACCELERATOR. A MOMENT LATER ANOTHER SIGN READ " CLEANING EXHAUST FILTER" WHICH DISAPPEARED ALMOST IMMEDIATELY. A MOMENT LATER A FINAL WARNING CAME UP WHICH READ" STOP AT A SAFE LOCATION. I BEARLY PULLED OVER TO A DANGEROUS SHOULDER WHEN MY TRUCK SHOT DOWN. AT THIS POINT I COULD NO LONGER MOVE MY TRUCK TO A SAFER LOCATION ON THE HIGHWAY SHOULDER. THE HIGHWAY ON WHICH MY TRUCK STALLED IS THE BUSIEST HIGHWAY IN MARYLAND. THE TRUCK STALLING LIKE THE WAY IT DID PUT MY LIFE, MY SONS LIFE AND THE LIVES OF OTHER MOTORISTS AT RISK AT MOMENT IT DID. WHILE I WAS SEARCHING ONLINE FOR WHAT MIGHT HAVE GONE WRONG WITH MY TRUCK, I CAME ACROSS AN ARTICLE ON WHICH AMBULANCES WERE RECALLED AND SENSORS IN THE EXHAUST WERE REPLACED TO FIX THE PROBLEM. ONE STRIKING SIMILARITY WAS THE FIVE AUDIBLE CHIME THE TRUCKS WERE EMITTING WHICH MY TRUCK ALSO EMITTED. I WAS NOT ABLE START THE TRUCK AT THAT STALL POINT SO I HAD IT TOWED TO A LOCAL DEALERSHIP.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10764446September 17, 2015
ENGINE, FUEL/PROPULSION SYSTEM
INVESTIGATION NEEDS TO BE DONE ON 2008 FORD F450SD 6.4L TRUCKS ON THE BOLTS THAT ARE USED IN THE ENGINE COMPARTMENT FOR THE EXHAUSTS. HAVE A BOLT THAT BROKE THAT IS NOW CAUSING A WHISTLING SOUND UNDER ACCELERATION AND EXHAUST FUMES TO ESCAPE. ON THE DRIVER SIDE FOUR OTHER BOLTS HAVE BROKEN OFF IN THE HEAD UNIT THAT WILL REQUIRE FOR THE ENGINE OR CAB TO BE REMOVED IN ORDER TO REPLACE THE BOLTS. THE REPAIR FACILITY MY TRUCK IS LOCATED HAS FOUR OTHER 6.4L FORD SUPER DUTY TRUCKS SITTING THEIR FOR THE SAME REPAIRS. SEEMS TO ME THERE IS AN ISSUE WITH THE TYPE OF STUDS AND BOLTS THE MANUFACTURER USED. RECALL NEEDS TO BE ISSUED TO FIX THIS ISSUE. THE OTHER TRUCKS WERE F250, F350, AND F450 SUPER DUTY 6.4L TURBO DIESEL. THE EXHAUST FUMES IS DEFINITELY A SAFETY HAZARD.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10763769September 15, 2015
ENGINE
FORD NEEDS TO ISSUE A RECALL FOR FAULTY BOLTS IN THE ENGINE COMPARTMENT. ONE BOLT BROKEN OFF ON THE PASSENGER SIDE THAT DEALS WITH THE EXHAUST CAUSING A WHISTLING SOUND UNDER ACCELERATION. FOUR BOLTS BROKE OFF ON THE DRIVER SIDE THAT GO INTO THE HEAD OF THE ENGINE BLOCK. IMPOSSIBLE TO GAIN ACCESS TO THESE BOLTS UNLESS YOU PULL THE ENGINE OUT IN ORDER TO REPLACE. FORD NEEDS TO HELD ACCOUNTABLE FOR THESE FAULTY HARDWARE AND REPLACE THIS AT NO COST TO THE OWNER OF THE VEHICLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10761226September 3, 2015
FUEL/PROPULSION SYSTEM
DELAMINATION OF DIESEL FUEL TANK. REQUIRING FUEL TANK, FUEL LINES,AND FILTERS REPLACED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10731225June 30, 2015
ENGINE
TL* THE CONTACT OWNS A 2008 FORD F-450 SD. THE CONTACT STATED WHILE DRIVING AT 65 MPH, THE THROTTLE CONTROL WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT STATED THAT THE ENGINE RPMS GAUGE STARTED TO FLUCTUATE ABNORMALLY AND THE EXHAUST SYSTEM STARTED TO SMOKE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THERE WAS AN ISSUE WITH THE ENGINE COOLANT TEMPERATURE AND ENGINE OIL TEMPERATURE. AS A RESULT, THE ENGINE COOLER, COOLANT, THERMOSTAT, AS WELL AS THE OIL AND OIL FILTERS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 68,000. UPDATED 09/02/15*LJ THE CONSUMER STATED THE TURBO BOOST BRAKE SYSTEM WAS SLOWLY LEAKING. UPDATED 12/7/2015*JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-450