Ford · Model Report
Showing safety data for the 2004 model year only.
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
CERTAIN PICKUP TRUCKS, SPORT UTILITY VEHICLES AND VANS EQUIPPED WITH 6.0L DIESEL ENGINES MAY EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART.
CERTAIN LARIAT AND KING RANCH MODEL PICKUP TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." SOME TRUCKS WERE INADVERTENTLY EQUIPPED WITH AN INCORRECT LOAD RANGE TIRE. THIS WOULD RESULT IN INCORRECT TIRE LOAD RATINGS FOR THE STATED VEHICLE AXLE GROSS AXLE WEIGHT RATING. ALSO, THE TIRE MAY BE INFLATED ABOVE THE DOT LISTED INFLATION PRESSURE.
The contact owns a 2004 Ford F-350. The contact stated that while driving approximately 76 MPH with his wife in the front passenger seat, the vehicle shuddered uncontrollably and stalled. The contact and his wife were concerned for their safety. There was no warning light illuminated. The contact was able to regain control of the vehicle and pulled over to the side of the road. The vehicle failed to restart and was towed to the residence. The contact stated that as an independent mechanic, he used a code reader to retrieve diagnostic trouble codes for the fuel control module wiring harness failure. The contact related to the failure to NHTSA Campaign Number: 05V270000 (Electrical System). The contact stated that the fuel control module wiring harness failure had caused warning lights to fail to illuminate as needed. The dealer was notified of the failure and informed the contact that the vehicle had previously been repaired under the recall. The manufacturer was notified of the failure and informed the contact that an elbow vacuum tubing connector was previously replaced under the recall; however, the contact advised the manufacturer that the recall involved replacing the entire fuel control module wiring harness. The manufacturer informed the contact that the recall was already marked completed and no further repairs could be covered. The contact stated that the dealer and the manufacturer had failed to honor the recall repair. The vehicle was not repaired. The failure mileage was 190,019.
No injuries · No fire · No crash
While driving at 40-50 MPH the vehicle will lose power and then then stalls while moving leading to loss of power. The loss power of affects the power steering posing a direct threat for an auto collision due to the difficult in steering the moving vehicle into an emergency lane. Avoided several accidents with this truck. Once it is stalled it can take numerous times to restart the vehicle. This issue seems to occur more on slopes going up hill. This does not seem to occur as often going downhill or on areas with no incline. Currently vehicle has 126,931.8 miles on it. Regularly serviced and otherwise running fine.
No injuries · No fire · No crash
The contact owns a 2004 Ford F-350 equipped with Cooper Tires, Tire Line: Discover AT3, Tire size: 265/75/R16, DOT Number: UPWM1M11718M16L. The contact stated that while driving 65 MPH, the rear driver’s side tire had a sidewall blowout. The contact stated that all four tires had sidewall blowouts months apart. The tire blowouts had damaged the rims. The contact replaced the front driver’s, passenger’s, and rear driver’s side tire with the spare after each blowout. The dealer was made aware of the failure and replaced the rear passenger’s side tire. The manufacturer was made aware of the failure and the rear driver’s side rim, rear driver’s and front passenger’s side tire were sent to the manufacturer. The failure mileage was not available.
No injuries · No fire · No crash
MY TRUCK HAS MAJOR ENGINE DAMAGE BOUGHT IT AND THREE DAYS LATER THE EGR WENT OUT THEN NEXT THING YOU KNOW I GOT A BLOWN MOTOR
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2004 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE SUDDENLY LOSS MOTIVE POWER AND STALLED WITHOUT WARNING. THE CONTACT RESTARTED THE VEHICLE HOWEVER, THE FAILURE RECURRED. UPON INSPECTION, THE CONTACT DISCOVERED THE FUEL FILTER WAS COVERED WITH SILVER DEBRIS. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. AN UNKNOWN DEALER WAS CONTACTED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 332,000.
No injuries · No fire · No crash