Ford · Model Report
Showing safety data for the 2002 model year only.
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.
ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH 7.3L DIESEL ENGINES, THE CAMSHAFT POSITION SENSOR LOCATED ON THE ENGINE OF THE VEHICLE MAY FUNCTION INTERMITTENTLY, POSSIBLY RESULTING IN AN ENGINE STALL.
CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
We were just driving when the truck started smoking and the brakes wouldn’t work. After a few minutes the truck completely caught on fire.
The frame at the leaf spring hangars has cracked apart at only 131,000 miles on the truck. This issue is becoming more and more common over the years it seems and comparable age trucks from other manufacturers are having this issue for the same age.
No injuries · No fire · No crash
[XXX] tire on driver's rear began to have significant vibration while towing 16,000 lb. fifth-wheel RV. Stopped and visually/tactilely determined unusual wear pattern so went to commercial tire shop in Pahrump, NV. Their inspection determined tread separation rendering the tire unusable so we replaced it with a different brand. This is the second of three tires installed at the same time that have suffered tread separation failure. The first was in July 2023 and was not reported to NHTSA, but when two more tires failed at the same time, I decided to report. Because this type of failure does not produce TPMS warnings, it could have been a catastrophic failure that might have resulted in damage to our vehicles and/or a crash with significant injury to us or other motorists. With three failures from the same batch of tires on our vehicle, I believe there is a serious problem with this batch of tires and they should be recalled. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
No injuries · No fire · No crash
[XXX] tire on passenger’s rear began to have significant vibration while towing 16,000 lb. fifth-wheel RV. Stopped and visually/tactilely determined unusual wear pattern so went to commercial tire shop in Pahrump, NV. Their inspection determined tread separation rendering the tire unusable so we replaced it with a different brand. This is the third of three tires installed at the same time that have suffered tread separation failure. The first was in July 2023 and was not reported to NHTSA, but when two more tires failed at the same time, I decided to report. Because this type of failure does not produce TPMS warnings, it could have been a catastrophic failure that might have resulted in damage to our vehicles and/or a crash with significant injury to us or other motorists. With three failures from the same batch of tires on our vehicle, I believe there is a serious problem with this batch of tires and they should be recalled. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
No injuries · No fire · No crash
there has been intense rust and corrosion in the roof seams and welds. This has led to water leaks and damage to the interior of the vehicle. The integrity of the roof has been compromised, and I am concerned about the possibility of roof crush should there be an accident. Not to mention the mold, rot and damage to the interior and electrical systems I have already suffered due to the defect. On February 3, 2023, I contacted the Ford Motors helpline and spoke to [XXX] (direct phone # [XXX] ext [XXX]) to discuss the issue.[XXX] created a request for a buyback and assigned a case number of [XXX]. She also requested that I send photos to [XXX] and visit the local Ford dealership so they could assess the vehicle and share the information with her. I was able to make an apt for Feb 6,2023 @ 10:50 with [XXX] @ Envision ford of Oxnard. When I arrived for the assessment, [XXX] did one walk around the vehicle (he did not inspect the roof at all) and then said he couldn’t help me as he this was a Ford issue, and they were a franchise. I contacted [XXX] with follow up from that meeting, as well as photos of the vehicle. About two weeks after this apt. [XXX] said the case was closed. I am extremely disappointed with how this case was handled, especially considering the significant investment I made in purchasing and maintaining it my vehicle. When I made the original investment I was told that the engine would last up to a million miles…but never imagined the body would be worthless at the 300,00 mark. There is so much damage to the roof that I currently keep my vehicle parked instead of using it. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
No injuries · No fire · No crash