Ford Ecosport Complaints

1,865 consumer complaints on file.

#11669518June 26, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2021 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (ENGINE AND ENGINE COOLING); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11669129June 25, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2018 Ford EcoSport. The contact stated while driving at an undisclosed speed, the low oil pressure warning light illuminated, and the vehicle was shaking erratically. In addition, the contact noticed an abnormal rattling sound coming from the vehicle. The contact parked the vehicle and performed an inspection of the vehicle. The contact checked the oil level and noticed that the oil level was sufficient. The vehicle was towed to the residence. The contact inspected the oil level and noticed oil was leaking from the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was 57,350. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11669147June 25, 2025
ENGINE
My 2018 Ford EcoSport is subject to Safety Recall 23S64, concerning a defective oil pump belt and/or tensioner that can lead to engine failure. My VIN is listed in this recall. The engine has symptoms consistent with this recall, including performance loss, mechanical noise, and diagnostic codes such as P0014 (camshaft timing over-advanced), P0303 (cylinder misfire), and U0100 (lost communication with ECM/PCM). The vehicle is currently located at an authorized Ford dealership (Sunrise Ford of North Hollywood). However, the dealer has refused to perform the required diagnostic inspection unless I pay $1,084. This is a direct violation of federal law under 49 U.S.C. § 30120, which mandates that both diagnosis and remedy of safety-related recalls must be provided free of charge. I have also documented communication from the dealership and a written inspection from an independent licensed repair shop showing the engine is in as-found condition and that no repairs were attempted. I am seeking enforcement action to ensure that the recall is honored as required by law. Dealership: Sunrise Ford of North Hollywood Address: 5500 Lankershim Blvd, North Hollywood, CA 91601 Service Advisor Name: Bruno Rivero
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11669203June 25, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2020 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11668933June 24, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (ENGINE AND ENGINE COOLING); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11668712June 23, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (ENGINE AND ENGINE COOLING); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11668092June 20, 2025
ENGINE
I purchased this vehicle on [XXX] Serra Ford in Farmington Hills, MI. It was certified by the manufacturer Ford Motor Company. I was told they remedied all issues/recalls. On [XXX] I experienced loss of power and oil pressure. We immediately returned it to the dealer for evaluation and repair. On May 12th they informed me that the vehicle needed a new engine. On May 27th I was told that they were waiting on parts. I was told on June 9th that the engine had arrived and it would be about 10 days to repair. Finally on June 18th I was told that they would not be replacing my engine and that they are unable to fix the recall that was causing all these issue. I reached out to the dealership and was not provided details offering oil pressure level read off the diagnosys to ensure the vehicle is safe. The recall states that loss of power braking increases the risk of a crash. For the safety of my family, I am hoping to avoid that. Refusing to remedy the recall by the manufacturer is unacceptable. THe dealership selling a vehicle that is not safe is also unacceptable. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11668108June 20, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2020 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11668204June 20, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2018 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated while driving 65 MPH, the low oil pressure warning light was illuminated, and the vehicle stalled while driving off a ramp. The vehicle was towed to D & M Auto Service, where the contact was informed that it was a known failure, and the engine might be damaged. The vehicle was not diagnosed or repaired. An unknown dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 27,000. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11668243June 20, 2025
ENGINE
Oil pump tensioner failure still has not fix the recall on my vehicle since 12/23/2023 when it was issued. I had taken my vehicle in today for both recalls Ford only address the Half Shaft recall. But stated parts are not available on the oil pump tensioner. Being waiting for a remedy for year and a half. I can not claim lemon law in California with Ford hiding behind the recall issued. Ford should be forced to buy back vehicle or fix the recall.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11668000June 19, 2025
ENGINE
Transmission assembly
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11667344June 17, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2018 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at various speeds there was a clattering sound coming from the front end of the vehicle. The dealer was contacted and confirmed the remedy was not yet available. Another dealer was contacted, AutoNation Ford Bradenton, (5325 14th St W, Bradenton, FL 34207); who confirmed the information. The manufacturer was not made aware of the issue. The failure mileage was approximately 24,000. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11667514June 17, 2025
ENGINE, POWER TRAIN
What component or system failed or malfunctioned, and is it available for inspection upon request? The issue appears to be related to the powertrain system, specifically the belt tension or transmission shifting components. A “Powertrain Malfunction / Reduced Power” warning message appeared through the FordPass app, and I have also been experiencing jerking or hesitation when applying pressure to the gas pedal, particularly during gear shifts. The vehicle is available for inspection upon request. ⸻ How was your safety or the safety of others put at risk? The unexpected jerking and reduction in power while driving could pose a serious safety risk, especially when merging onto highways or changing lanes, where smooth acceleration is critical. This behavior could result in a loss of control or increase the likelihood of a rear-end collision in traffic. ⸻ Has the problem been reproduced or confirmed by a dealer or independent service center? An independent mechanic has reviewed the issue and suspects that it may be related to the previously reported belt tension recall, although my specific vehicle VIN was not included in that recall group. The mechanic observed the jerking and powertrain alert and recommended further inspection. ⸻ Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Not yet. I am currently in the process of filing this report and seeking guidance from the manufacturer to determine the next steps for inspection and resolution. ⸻ Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Yes. The “Powertrain Malfunction / Reduced Power” message appeared via the FordPass app. Prior to the alert, I had noticed intermittent jerking and hesitation during acceleration, which became more noticeable within the last few weeks leading up to the warning
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11667131June 16, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2021 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (ENGINE AND ENGINE COOLING); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666791June 13, 2025
ENGINE, FUEL/PROPULSION SYSTEM
THIS RECALL BEING UNABLE TO BE COMPLETED IS CAUSING DAMAGE TO MY ENGINE AND RESTRICTING MY DRIVING. I CAN NOT EVEN MAKE IT HOME FROM WORK WITH OUT THE CAR TRYING TO STOP, TEMP IS WAY UP AND OIL PREASSURE DROPS. ARIZONA'S HOT WEATHER INCREASES THIS ISSUE. PART WERE PROMISED FIRST QUARTER OF THIS YEAR.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666821June 13, 2025
ENGINE
The contact owns a 2020 Ford EcoSport. The contact stated while driving at an undisclosed speed, the vehicle lost motive power. In addition, the engine overheated and seized. No warning light was illuminated. The vehicle was taken to the dealer; however, the contact was informed that the vehicle needed to be completely cleaned out and detailed prior to being serviced. The vehicle was taken to an independent mechanic where it was diagnosed with several failures, and DTC: P0217, P0496, P04DB, P1825 and P1299 were retrieved. Additionally, the contact stated the engine had been replaced by the dealer in February 2023; however, the contact was informed that the warranty had since expired. The contact stated that four days after the repair, the check engine warning light had illuminated. The vehicle was taken back to the dealer; however, the failure was not duplicated. The contact stated that the vehicle had been taken back to the dealer several times due to the failures and the dealer reset the check engine warning light. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 64,444.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666508June 12, 2025
ENGINE
We noticed rattling and misfiring sounds from the motor but no warning indications on the dash. 2 days later when my wife was coming home the car started losing power and "died". Would not restart but no warning lights on dash. The app did send a notice about loss of pressure to turbo. Had my wife not been near someplace to pull into she would have been stranded in the road in a disabled vehicle. Traffic was backed up behind her while she was trying to get out of the road. Had the car "died" while she was on the interstate doing 70 it would have been COMPLETELY without power steering AND brakes. The car has ONLY been serviced by our local Ford dealer. So we had it towed there. This morning they are telling us it's a problem with the "integrated exhaust manifold" that allowed water into the cylinders and ruined the engine. Believe they called that a cracked block years ago? Something that shouldn't happen to a car with only 66K miles. They assured us it wasn't the oil pump from the recall. We just paid it off a couple months ago. Now it needs a new $6,300 motor. Not something senior citizens only a year from retirement can easily swing. There NEVER was ANY indication (warning lights, etc) or warning from the dealer after service of any problems. It seems that Ford has more problems with this motor than just the oil pump!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666316June 11, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2021 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V9055000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated while driving approximately 70 MPH, the vehicle stalled. There was no warning light illuminated. The contact was able to veer to the side of the road. The vehicle failed to restart and was towed to the dealer, where it was diagnosed that the engine had failed, and the failure was related to the recall. The dealer replaced the engine free of charge; however, the contact stated that she was concerned that the failure would reoccur. The vehicle was repaired temporarily. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure and denied the request to buy back the vehicle. The failure mileage was approximately 40,000. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666311June 11, 2025
ENGINE AND ENGINE COOLING, POWER TRAIN
The contact owns a 2021 Ford EcoSport. The contact received notifications of NHTSA Campaign Numbers: 23V905000 (Engine and Engine Cooling) and 25V126000 (Power Train); however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The contact stated that there was a loud thumping sound coming from the drive shaft while the transmission was changing gear. The contact stated that the oil level was checked, and the contact was informed that the engine had low oil pressure. There was no warning light illuminated. The dealer was contacted and stated that the vehicle would not be repaired until the part became defective. The manufacturer was not made aware of the issue. The failure mileage was approximately 71,000. VIN tool confirms parts not available for NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling). Parts distribution disconnect for NHTSA Campaign Number: 25V126000 (Power Train).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11665983June 10, 2025
POWER TRAIN
The contact owns a 2020 Ford Ecosport. The contact stated while driving at an undisclosed speed, the transmission hesitated to shift as intended, with a whining sound. No warning light was illuminated. The vehicle was taken to an independent mechanic; however, the failure was not duplicated. The vehicle was not diagnosed or repaired by the independent mechanic or the dealer. The manufacturer was made aware of the failure but provided no assistance. The contact referenced an unknown recall; however, the VIN was not included in the recall. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 107,130.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Ecosport