Chevrolet Tahoe Complaints

950 consumer complaints on file.

#11725697March 19, 2026
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
My 2022 Chevrolet Tahoe has a recurring pattern of excessive oil consumption, smoke from the exhaust, repeated check engine light events, P0420 catalyst-efficiency faults, and repeated catalytic-converter-related repairs. At approximately 75,000 miles, the vehicle shut down on the freeway. At approximately 121,000 miles, the first catalytic converter failed. Chevrolet of Wesley Chapel documented P0420 and catalyst failure in November 2025, and GM service history reflects catalytic-converter replacements at 131,468 miles and approximately 141,082 miles. The vehicle also underwent major injector-related repair in early 2026. At 141,620 miles, Chevrolet of Wesley Chapel started an oil consumption test and stated in writing that oil consumption can lead to repeat failed converters and false oxygen sensor readings. Despite substantial repairs, the problem pattern continued. I am reporting this as a possible safety-related defect affecting engine operation, emissions-system failure, and drivability, and I am asking NHTSA to review whether this indicates a broader safety-related defect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725684March 19, 2026
POWER TRAIN
The contact owns a 2023 Chevrolet Tahoe. The contact stated that while driving 50 MPH, the transmission unexpectedly downshifted before the engine seized. The check engine warning light was illuminated, and the reverse(R) indicator was flashing. The contact was unable to restart the vehicle. The semi-truck behind the vehicle almost crashed into the rear of the vehicle. After several minutes, the contact was able to restart the vehicle; however, the failure reoccurred. The check engine warning light illuminated, and the reverse(R) indicator light was flashing. The contact was able to restart the vehicle and pulled over to the side of the road. The vehicle failed to accelerate 5 MPH. The contact drove back to the residence slowly. The contact arrived at the residence, and the vehicle failed to shift into reverse(R). The vehicle was towed to the dealer. The vehicle remained at the dealer unrepaired. The manufacturer was not notified of the failure. The failure mileage was approximately 70,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725417March 18, 2026
ENGINE
I was driving down I-5 at 75mph and the truck shut off while driving. Couldn’t get to start. Paid over $1k for a new battery cause dealership couldn’t replicate problem. Next day doing 75mph on freeway engine through a rod.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725272March 18, 2026
ENGINE
Total Engine Failure
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725181March 18, 2026
ENGINE AND ENGINE COOLING
The contact's wife owns a 2022 Chevrolet Tahoe. The contact stated that while driving approximately 50-60 MPH, several unknown warning lights illuminated. The driver pulled over to the side of the road. The vehicle failed to restart and was towed to the dealer, where it was diagnosed and determined that unknown engine valves had collapsed, and there was possible camshaft damage. The contact was advised that further diagnostic tests were required. The dealer informed the contact that a recall should be issued for the failure. The vehicle was not repaired. The manufacturer was notified of the failure, and the contact was referred to the dealer for assistance. The failure mileage was approximately 68,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11724933March 17, 2026
ENGINE
Driving down I495 in Mass when engine stopped with no warning or prior symptoms. My wife and 4 children (including 2 friends of our kids) were in the car. Luckily we were able to safely pull to the shoulder after coasting through a construction zone. If we hadn’t made it to a safe piece of shoulder chances are high that another vehicle would have hit our vehicle and hurt and killed us. These 6.2 engines are a serious safety hazard and I only hope my new engine proves to be reliable. Car was towed to dealer who diagnosed it as a seized motor. Car is a 2022 Chevy Tahoe with the problematic 6.2 engine. Engine had passed Chevrolet’s Pico test as per the 6.2 recall about 7,000 miles before it seized. Vehicle and engine dealer maintained with all required changes/maintenance. Engine seized/failed with no warning.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11724504March 15, 2026
ELECTRICAL SYSTEM, ENGINE, FUEL/PROPULSION SYSTEM
Since March of 2025 I have identified a critical safety defect with my vehicle. When driving and without warning, the vehicle unexpectedly shifts to neutral, experiences a loss of propulsion, and the engine shuts off. This has occurred multiple times in which I narrowly escaped collisions with other vehicles or objects. If this would occur at a high rate of speed, it would certainly result in serious accident including possible fatality. I have experienced three near-accident scenarios when I had children in the vehicle. I have worked with Classic Chevrolet in Sugar Land, Texas who has made six attempts at repair. They have each time found a different component attribute to an error code and replaced that part. After each visit they tell me that the car is fixed and safe to drive. They have never been able to provide a clear explanation as to why I am experience this reoccurring issue, but attribute it to a different part each time. Within 5 days to 2 months, the incident repeats. I have recent video of the incident that I can share. Chevrolet Customer Care has been minimized my concern and informs me that their Service staff has found the vehicle to be fully operational and safe to operate. I have spent over $6,000 in failed repairs. I do not feel safe operating this vehicle. That list of repairs includes: March 7, 2025 - battery replacement March 28, 2025 - DC/DC power converter April 22, 2025 - ECM updates January 8, 2026 - •Throttle body replacement •Serpentine belt replacement •Engine air filter replacement •Transmission fluid flush •Coolant fluid flush •Fuel injection cleaning •Hydrogen carbon cleaning service January 23, 2026 - power control module (recall) January 30, 2026 - rear differential system replacement March 10, 2026 - • Replacement of the high-pressure fuel pump • Replacement of the DC power supply converter • Hydrogen carbon cleaning service I can share all invoices. Chevy is NOT TAKING THIS MATTER SERIOUSLY. Please support
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11724284March 14, 2026
UNKNOWN OR OTHER
Pulled into a pharmacy, vehicle died and completely shut off while driving. 3400 miles, towed to dealership, March 5, 2026. Still no answer from dealership for why this happened and no loaner vehicle yet because they cannot confirm it's a warranty issue
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11724226March 13, 2026
ENGINE, ELECTRICAL SYSTEM
The vehicle shifted itself into neutral and shut off while driving. It happened twice in three days. The first time I was pulling into the driveway so I was able to put it in park and restart the car safely. The second time I was in the middle of traffic in Tampa and it shifted into neutral and shut off in the middle of the road. Luckily no cars hit me but again I had to apply the break , restart the car and put it back in drive. This was very scary and I had my kids with me. Earlier in the day I had been driving on 75 and if it had happened then it could have been a bad wreck. It shows there are no current recalls on my vehicle. No warning lights or messages appeared. Vehicle was purchased less than 30 days ago. I will contact the dealership to verify there are no open recalls just in case but again when I checked I found none.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11723551March 11, 2026
ENGINE AND ENGINE COOLING
The contact owns a 2021 Chevrolet Tahoe. The contact stated that the engine was consuming an excessive amount of oil, and there was an abnormal knocking sound coming from the engine. Additionally, the vehicle hesitated and failed to accelerate as needed, with blue smoke coming from the exhaust pipes. The check engine warning light was intermittently illuminated. The vehicle was taken to the dealer, who determined that there were metal shavings in the engine oil and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 51,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11723537March 11, 2026
POWER TRAIN, UNKNOWN OR OTHER
While driving down I35 South of wellington Ks in our new 2026 Chevy Tahoe we experienced a vehicle shift to neutral and no transmission correction available. Coasted to ditch saw “Service Transmission” notice and so turned off and on engine . Went to Derby Ks and Davis Moore Chevy in Wichita where staff removed the warning service notice on driver info and we continued to Molle Chevy in Blue Springs Mo. where they did diagnostic and only showed ambient air fault!! This is scary! We had no transmission and had to get off road safely! Please let public and our dealers know and recall all vehicles with this problem. We are afraid to drive this new 3,000 mile Chevy Tahoe.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11723473March 11, 2026
ENGINE
The vehicle motor goes out with no indication that anything’s going to happen. It does this a different stages of miles. Mine happened when I was passing someone on the high way. It just shut off
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11723305March 10, 2026
ENGINE
The contact owns a 2024 Chevrolet Tahoe. The contact stated that while driving at 76 MPH, the vehicle was driving abnormally rough. The RPM increased, and the message to shut-off engine and restart the vehicle was displayed. The contact stated that the failure occurred while the two minor children and their friends were inside the vehicle. The contact's daughter stated that the vehicle was in neutral after leaving the car wash. In addition, the failure occurred while driving on a busy two-lane highway. The vehicle was almost involved in a crash twice when the engine seized in the middle of the left lane. The contact stated that while attempting to drive the vehicle to the shoulder of the road, the engine seized. The contact stated that while attempting to start the vehicle, the vehicle failed to restart. The local Police assisted with traffic control. The vehicle was towed to the dealer; however, the failure was not duplicated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The dealer was informed that the Mobile App indicated a transmission and engine failure. The dealer informed the contact that because the engine seized, the engine needed to be replaced. The dealer informed the contact that there was no indication of what caused the engine to seize. The manufacturer was made aware of the failure but provided no assistance. The contact referenced an unknown recall with a similar description; however, the VIN was not associated with the unknown recall. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 16,988.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11723262March 10, 2026
FUEL/PROPULSION SYSTEM, POWER TRAIN
PICOSCOPE test passed on 2/3/2026 with mileage of 58061 at Everett Chevrolet, Benton, AR. On [XXX], while driving received an error code, no oil pressure and vehicle became disabled in the middle of the road. Tahoe was towed to Teeter Chevrolet in Malvern, AR. We were notified on Friday that the engine was bad and would need to be replaced. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11723103March 9, 2026
POWER TRAIN
Driving down the highway and I lost all the gears it went from driving speed then wouldn’t go over 30 mph. When I got pulled into a business on the side of the road then tried to restart it it then wouldn’t go into reverse. It was dangerous because there was cars behind me going the speed limit then my car just lost speed. No warnings it’s not throwing any codes. Looking on the internet it seems it’s the transmission or valve body
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11722698March 7, 2026
ELECTRICAL SYSTEM, ENGINE, FORWARD COLLISION AVOIDANCE: WARNINGS
My truck was driving perfect and I went to pull into a parking lot in Arkansas where I live in long story short it started acting funny trying to idle out and then I heard a knocking noise. It happened twice. Then my service ESV light come on next my motor light come on then my auto for a collision system failure light come on. It’s on the dash anyway my vehicle is not running around. It has hardly no power and I smell something under the hood from time to time burning it’s kinda like an electrical smell. I’m not sure. I’m not a mechanic. I’m a [XXX]. I’m a [XXX]!!! but I have to have a way back back-and-forth to work and I cannot drive this vehicle. I have been driving it to work and just straight to home and that’s only like a mile from the shop but I need a replacement vehicle I need to sell mine at wholesale value as you guys said you would that would be greatly appreciated. God bless you guys. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11722487March 6, 2026
ENGINE AND ENGINE COOLING
The contact owns a 2021 Chevrolet Tahoe. The contact stated that while driving at various speeds, the Forward Collision Avoidance message was intermittently displayed. The vehicle was taken to a dealer, where a computer module was replaced. While driving at various speeds, there was an intermittent knocking sound coming from the engine, with the check engine warning light illuminated. While driving at an undisclosed speed, the knocking sound became constant. The vehicle was driven to the dealer, and upon inspection, the mechanic discovered a bent engine rod inside the engine. The vehicle was diagnosed with engine failure, and the contact was provided an estimate for the repair. Upon investigation, the contact discovered the failure was associated with NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling). The manufacturer was initially notified of the failure through the dealer, and the contact was later informed that the manufacturer agreed to cover half the cost of an engine replacement. Upon calling the manufacturer directly, the contact was referred to the NHTSA Hotline to report the failure. The vehicle was not repaired and remained with the dealer. The failure mileage was approximately 72,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11722367March 5, 2026
ELECTRICAL SYSTEM
The sound in my entire truck goes in and out. Even my blinker signal does not make sound and I have to look down to ensure my blinker is on which could lead to an accident.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11722130March 4, 2026
ENGINE
While driving on the highway, the vehicle suddenly downshifted and shut down and would not restart. All lights appeared on the cluster and showed "conditions not correct for shift". Had to have vehicle towed from the side of the road and wasn't even able to shift into neutral.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721855March 3, 2026
ENGINE
Our vehicle passed their inspection required test for the engine recall and then at an intersection just died with absolutely no warning and wouldn’t even start again. Warning light for low engine oil came on. We were stuck and couldn’t even put the vehicle in neutral to be towed out of the intersection. Had to call a flat bed tow truck to load it and take to dealership where it was confirmed the engine failed!!! Police did show up at the scene to facilitate traffic and the loading of th vehicle
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Tahoe