ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 16-INCH WHEELS, THE FRONT BRAKE DISCS MAY BREAK UNDER SEVERE DRIVING CONDITIONS. THE BREAKAGE CAN OCCUR IN CONDITIONS WHERE THE VEHICLE IS DRIVEN ON A REGULAR BASIS ON EXTREMELY STEEP PAVED DOWN-SLOPES WHILE CONTINUOUSLY APPLYING THE BRAKES.
ON CERTAIN SPORT UTILITY VEHICLES, THE ACCELERATOR CABLE CASING CAP THAT IS ATTACHED TO THE VEHICLE FIREWALL CAN CRACK DUE TO EXTENDED EXPOSURE TO FORCES FROM THE ACCELERATOR CABLE AND INSUFFICIENT LONG-TERM DURABILITY OF THE PLASTIC CASING CAP. IF THE CASING CAP BECOMES CRACKED, MOVEMENT OF THE INNER ACCELERATOR CABLE THROUGH THE CAP CAN CAUSE THE INNER ACCELERATOR CABLE TO BECOME FRAYED.
THIS 2002 SUZUKI XL7 LIMITED STARTED TO HAVE TOUCHY STEERING AT 55 MPH AND UP. IT IS SO SENSITIVE THAT IT CAN EVEN CHANGE LANES. WHEN THE STEERING ACTS UP THE WHOLE VEHICLE VIBRATES. I HAD NEW TIRES AND ALIGNMENT AND CHECKED FOR ANY SLACK IN ANYTHING UNDER THE VEHICLE AND IT CHECKED OUT GOOD. I HAVE CHECKED ON THE INTERNET AND FOUND THAT SEVERAL PEOPLE HAVE HAD THE SAME PROBLEM. SOME OF THE PEOPLE SPENT HUNDREDS OF DOLLARS AND STILL HAVE THE SAME PROBLEM. I THINK THAT IT IS DANGEROUS TO DRIVE AND OTHER PEOPLE NEED TO KNOW ABOUT THE PROBLEM. *TR
No injuries · No fire · No crash
AC COMPRESSOR WENT OUT TWICE IN MY 2002 SUZUKI XL-7. ONCE IN AUGUST 2009 AND AGAIN IN MAY 2012. I HAD TO HAVE IT REPLACED TWICE BECAUSE IT WAS A PRETTY HOT SUMMER. IT ASSUME IF THE CAR LAST ANOTHER FEW YEARS, I WILL HAVE TO REPLACE IT AGAIN. HOW ANNOYING! ALSO, AFTER THE SUMMER MONTHS, DURING THE WINTER MONTHS WHEN I NEED TO TURN ON THE HEAT, THE SERVICE ENGINE LIGHT COMES ON. I GOT THIS TESTED AND IT HAD TO DO WITH THE AC COMPRESSOR. THIS MAKES SENSE BECAUSE THE XL-7 COMPRESSOR IS DUAL. IT'S RUNS AC AND HEAT. POWER STEERING HAS BEEN LEAKING FOR THE PAST YEAR. I WOULD ADD POWER STEERING FLUID EVERY TWO WEEKS OR SO. BUT NOW IT'S PROGRESSIVELY GOTTEN WORSE. I HAVE TO ADD FLUID EVERY OTHER DAY. FRONT AND BACK BUMPER IS DISPLAYING CORROSION. IT LOOKS LIKE THE METAL HINGES THAT HOLD UP THE BUMPERS ARE WEARING AND YOU CAN SEE IT. THIS CAR WAS NOT BUILT TO LAST. I FORESEE MANY MORE ISSUES. *TR
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2002 SUZUKI XL7. THE CONTACT STATED THAT THE VEHICLE WOULD PULL TO THE RIGHT ABNORMALLY WHEN DRIVING AT ANY SPEED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC AND THE FAILURE WAS LOCATED AS THE FRONT CROSS MEMBER BEING BROKEN DUE TO DEFECTIVE MATERIAL. THE FAILURE CAUSED THE ENGINE TO LEAN TO THE RIGHT. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 137,000 AND THE CURRENT MILEAGE WAS 141,000.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2002 SUZUKI XL7. WHILE DRIVING APPROXIMATELY 55 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED AND THE VEHICLE ABNORMALLY ACCELERATED. THE BRAKES WERE ENGAGED AND THE VEHICLE SLOWED DOWN WITH A LOUD GRINDING NOISE. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM AND THEY ADVISED THE VEHICLE BE TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO WAS UNABLE TO DUPLICATE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS UNAVAILABLE.
No injuries · No fire · No crash
CONDENSATION FROM VEHICLES AIR CONDITIONING DRIPS ONTO THE INSULATION AROUND BRAKE LINE THAT IS SUPPOSED TO PROTECT BRAKE LINE FROM EXHAUST MANIFOLD HEAT. LIVING IN TEXAS THE VEHICLE RARELY IS TURNED ON WITHOUT THE AIR CONDITIONING. THE CONTINUED SATURATION, DRYING AND VIBRATION OF NORMAL DAY TO DAY USE CAUSED A LEAK IN ONE OF THE TWO BRAKE LINES LEADING TO THE REAR OF THE VEHICLE. THIS WAS DISCOVERED AFTER OWNER REPORTED SPONGY FEELING AND LOSS OF BRAKE HOLDING STRENGTH WHILE IN STOPPED POSITION. UPON FURTHER INSPECTION IT WAS NOTICED BOTH BRAKE LINES BEHIND PROTECTIVE INSULATION HAS SEVER OXIDATION CLOSEST TO THE ENDS THAT ARE ATTACHED TO AN ADAPTER. FIX THAT I EMPLOYED WAS TO BYPASS THE EXTENSION THAT RAN FROM THE TOP OF THE ENGINE DOWN THE PASSENGER SIDE, ENTERED THE INSULATED EXTENSION AND THEN ENTERED THE ADAPTER THEN INTO THE REAR BRAKE LINES. I WAS ABLE TO BYPASS ALL THE UNNEEDED JOINTS WITH 2 48 BRAKE LINES AND 2 COUPLINGS BOUGHT FROM LOCAL AUTO PARTS AND REROUTED LINE FROM DRIVER SIDE DOWN ACROSS REAR SIDE OF UNDERCARRIAGE THEN DIRECTLY INTO REAR BRAKE LINE. THE A/C NO LONGER DRIPS ONTO THE BRAKE LINE.
No injuries · No fire · No crash