American Suzuki is recalling certain model year 2007 XL-7 vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; and manufactured June 13, 2006, through December 22, 2006. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
SUZUKI IS RECALLING CERTAIN MODEL YEAR MODEL YEAR 2006 GRAND VITARA AND MODEL YEAR 2005-2006 XL-7 VEHICLES. THE TENSION ADJUSTER PULLEY FOR THE DRIVE BELT THAT OPERATES THE POWER STEERING PUMP AND AIR CONDITIONER COMPRESSOR (IF EQUIPPED) HAS AN OUTER PORTION THAT IS MADE OF PLASTIC. REPEATED HEAT STRESS CAN CAUSE THE PLASTIC MATERIAL TO DETERIORATE AND PIECES OF THE PULLEY CAN BREAK OFF.
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, "WINDSHIELD MOUNTING." AN INCORRECT PRIMER MAY HAVE BEEN USED WHEN INSTALLING THE WINDSHIELD.
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 16-INCH WHEELS, THE FRONT BRAKE DISCS MAY BREAK UNDER SEVERE DRIVING CONDITIONS. THE BREAKAGE CAN OCCUR IN CONDITIONS WHERE THE VEHICLE IS DRIVEN ON A REGULAR BASIS ON EXTREMELY STEEP PAVED DOWN-SLOPES WHILE CONTINUOUSLY APPLYING THE BRAKES.
ON CERTAIN SPORT UTILITY VEHICLES, THE ACCELERATOR CABLE CASING CAP THAT IS ATTACHED TO THE VEHICLE FIREWALL CAN CRACK DUE TO EXTENDED EXPOSURE TO FORCES FROM THE ACCELERATOR CABLE AND INSUFFICIENT LONG-TERM DURABILITY OF THE PLASTIC CASING CAP. IF THE CASING CAP BECOMES CRACKED, MOVEMENT OF THE INNER ACCELERATOR CABLE THROUGH THE CAP CAN CAUSE THE INNER ACCELERATOR CABLE TO BECOME FRAYED.
On my Suzuki XL-7, I have 2 recalls: 1. Fuel pump 2. Windshield clamp. I'm trying to find a dealer to repair the recalls? Can you provide to me any Phoenix area dealer that can fix these two recalls? Thanks.
No injuries · No fire · No crash
I have this airbag light on problem stated below. It seems it should be a safety recall. Possible solution for Airbag light on Seat Sensor Ok, I'm going to ask a couple of questions and hope that [XXX] or someone with knowledge chimes in. I originally had this problem in my wife's car a couple of months ago, airbag light on, clock flashing after going over a bump with my 240lb ass in the passenger seat. We got home, turned the car off, restarted it and it went through the power-up self test I guess and the fault cleared itself. The other day it started up again, no bump but still had the fat guy in the seat. I noticed that I only saw this issue referring to 2004 model xl7s. I've looked and haven't seen 2003s, or 2005s. The TSB for this issue ONLY refers to 2004 models and says that this is the updated part number 86605-53JA1. If you look at this site that has them in stock: [XXX] It says that part fits 2004-2006. I found the published date for the TSB somewhere online as 12/2004 so they apparently knew the problem early, made an update/change and moved on. Probably changing the design sometime mid-year 04? I don't like the idea of spending $1400 for a part. So, I checked [XXX] and found a nice passenger seat from a 2005 locally for about $75 in a boneyard. Does anyone have any advice why swapping in a 2005 seat (or just the base if the color is wrong, whatever) is a bad idea? Does anyone know if there has to be any special dealer magic/ calibration/ etc done if I put this in myself? I haven't yet had the time to pull the seat out of the car, flip it over and check things out. But I'm not super hopeful that I can fix whatever this sensor is since nobody else has posted anything in the last 13 years. Thanks for your interest. VIN [XXX] For reference, Here's the text from the TSB And there is no recall information at Home | National Highway Traffic Safety Admin INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
No injuries · No fire · No crash
The contact owns a 2008 Suzuki XL7. The contact stated that when the vehicle was started, the contact was unable to deactivate the alarm. Additionally, other unknown electrical system functions failed to operate as needed. There was no warning light illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 139,000.
No injuries · No fire · No crash
The contact owns a 2007 Suzuki XL7. The contact stated that the vehicle was taken to the dealer after she discovered that the VIN was included in NHTSA Campaign Number: 12V597000 (Fuel System, Gasoline). The contact stated that after the vehicle was retrieved from the dealer and the recall was presumably completed, the vehicle was driven to the residence and parked. The contact then stated on the same day while driving at an undisclosed speed, there was an abnormal fuel odor throughout the cabin of the vehicle before the vehicle stalled. The vehicle was towed back to the residence. The contact then notified the dealer of the failure, but the contact was denied service. The vehicle was towed to an independent mechanic to be diagnosed. The contact was informed that the crank shaft position sensor was faulty. The contact stated that she previously had the vehicle diagnosed by a different independent mechanic and was informed that the engine was not getting fuel when the vehicle was started. The contact was informed that the fuel pump module assembly needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed that the recall was completed, and further repairs would be at the expense of the owner. The failure mileage was approximately 215,000.
No injuries · No fire · No crash
Heating Cooling system stopped working. Can not change from heat to cool or from vent to floor to defrost Mechanics can not find issue
No injuries · No fire · No crash