Ford F-650 Service Bulletins (2026)
8 manufacturer communications on file.
- June 4, 2026•Document ID: 11033763Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- SSM 54899
- Date Added:
- June 9, 2026
- Manufacturer:
- FORD
SummarySome 2023-2026 F-53 Motorhome Chassis/F-59 Commercial Stripped Chassis and 2024-2026 F-650/F-750/E-Series vehicles equipped with a 6R140 transmission may be limited to 5th gear and reverse gear only. Additionally, the driver will be able to shift back to park. Diagnostic trouble codes (DTC) P2701, P2704, P0757, and/or P0733 may be stored in the powertrain control module (PCM). This may be due to PCM software being unable to command the transmission solenoid clutch actuators when the battery has a low state of charge (SOC) and/or the vehicle has been jump started. To restore proper transmission functionality, charge the battery as stated in the Workshop Manual (WSM), Section 414-01 Charging System > General Information. Cycle the ignition on then off and leave the vehicle off for 5 minutes to confirm the condition is no longer present. To prevent this issue from reoccurring, refer to the Owner's Manual > Storing Your Vehicle > Preparing Your Vehicle for Storage > 12V Battery. Replacement of transmission components will not resolve this condition.
Associated Products (7)Associated Documents - February 17, 2026•Document ID: 11029081Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- SSM 54592
- Date Added:
- February 27, 2026
- Manufacturer:
- FORD
SummaryFor 20172026 vehicles equipped with a 10R transmission, a revision to the Road Testing Vehicle procedure has been made in the WSM, located in Section 307-01 > Diagnosis and Testing. This updated procedure improves the diagnosis of customer reported transmission concerns and aids in locating the proper root cause. During diagnosis and testing, details regarding whether the condition is more prevalent when the vehicle is hot or cold, throttle percentage at the time of occurrence, vehicle speed, the specific shift involved, and whether the issue occurs during transmission engagements (N>R, N>D, R>D, or D>R) should be noted. Engineering requests including these detailed operating conditions that will significantly assist with root cause analysis. Diagnosis, testing, and repair should use established labor times outside this article.
Associated Products (43)2026 Ford Bronco2026 Ford Expedition2026 Ford Explorer2026 Ford F-1502026 Ford F-6502026 Ford Mustang2026 Ford Ranger2026 Lincoln Aviator2026 Lincoln Navigator2025 Ford Bronco2025 Ford Expedition2025 Ford Explorer2025 Ford F-1502025 Ford Mustang2025 Ford Ranger2025 Ford Transit2025 Lincoln Aviator2025 Lincoln Navigator2024 Ford Bronco2024 Ford Explorer+ 23 moreAssociated Documents - February 9, 2026•Document ID: 11028800Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- SSM 54559
- Date Added:
- February 12, 2026
- Manufacturer:
- FORD
SummarySome 2026 F-Super Duty and F-650/F-750 vehicles equipped with a 10R140 automatic transmission may exhibit fluid leakage from the transmission fluid pan area. Prior to performing any repairs, thoroughly clean the transmission fluid pan area to ensure accurate identification of the leak source. Before replacing the transmission fluid pan or gasket, verify the torque of the fluid pan bolts and stud bolts. If the torque is incorrect, tighten the pan bolts and stud bolts to the specified torque following the proper torque sequence in Workshop Manual (WSM), Section 307-01. After tightening, verify that the leak has been repaired. If the pan bolts and stud bolts are already torqued correctly, proceed with standard leak diagnosis. Should the diagnosis indicate that pan replacement is required, mark the area of the pan where the leak is present. This information will assist engineering with root cause analysis. For claiming, use causal part 7A194 and labor operation 7000E.
Associated Products (1)Associated Documents - January 5, 2026•Document ID: 11027852OtherPOWER TRAIN
- Mfr Comm. #:
- 25B65
- Date Added:
- January 28, 2026
- Manufacturer:
- FORD
SummaryCertain 2024-2026 Model Year F-650 - F-750 Medium-Duty Trucks equipped with 7.3L engine and 6R140 Transmission Reprogram the Powertrain Control Module
Associated Products (1)Associated Documents - December 22, 2025•Document ID: 11026871OtherPOWER TRAIN; ENGINE
- Mfr Comm. #:
- 25B65
- Date Added:
- December 30, 2025
- Manufacturer:
- FORD
SummaryCertain 2024-2026 Model Year F-650 - F-750 Medium-Duty Trucks equipped with 7.3L engine and 6R140 Transmission Reprogram the Powertrain Control Module
Associated Products (1)Associated Documents - October 29, 2025•Document ID: 11024900Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- SSM 54338
- Date Added:
- November 4, 2025
- Manufacturer:
- FORD
SummarySome 2021-2025 F-150 vehicles equipped with a 5.0L/5.2L engine, 2021-2025 F-Super Duty/F-53 Motorhome/F59 Commercial Stripped Chassis vehicles equipped with a 6.8L/7.3L engine and 2021-2026 E-Series/F-650/F-750 vehicles equipped with a 7.3L engine may exhibit a rattle/scraping noise upon startup that may remain after the engine is running. This may be due to the starter motor drive gear not retracting after starting. To correct this condition, inspect the starter motor drive gear and shaft. If the starter motor drive gear slides back and forth by hand and/or shows signs of scoring or damage, replace the starter motor following Workshop Manual (WSM), Section 303-06 Starting System > Removal and Installation > Starter.
Associated Products (18)Associated Documents - October 27, 2025•Document ID: 11024523Service Bulletin/Repair InstructionsPOWER TRAIN; ELECTRICAL SYSTEM
- Mfr Comm. #:
- TSB 25-2515
- Date Added:
- October 28, 2025
- Manufacturer:
- FORD
SummarySome of the vehicles listed in the Model statement above may exhibit an incorrectly illuminated MIL with DTC P0384 stored in the powertrain control module (PCM). This may be due to the calibration in the PCM. This condition does not affect vehicle drivability or durability.
Associated Products (1)Associated Documents - September 1, 2025•Document ID: 11022905OtherELECTRICAL SYSTEM; UNKNOWN OR OTHER
- Mfr Comm. #:
- SSM 54190
- Date Added:
- September 8, 2025
- Manufacturer:
- FORD
SummaryIf the vehicle is built with minor feature code "(IEPAA) - LESS CELLPHONE INTERFACE SYSTM", the vehicle is not misbuilt. Do not submit a claim for this condition. To confirm a vehicle is built with a certain minor feature code, review the build information by double-clicking the vehicle identification number (VIN) in the upper left corner in the Professional Technician System (PTS).
Associated Products (2)Associated Documents