Ford · Model Report
Showing safety data for the 1991 model year only.
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE. VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000. CERTAIN 1991 THROUGHT 2002 FORD EXPLORER CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER CERTAIN 1991 THROUGH 2001 RANGER CERTAIN 1999 THROUGH 2001 EXPEDITION CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES CERTAIN 1991 THROUGH 1994 BRONCO NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.
TIRE DESCRIPTION: FIRESTONE WILDERNESS AT, SIZE P235/75R15, PRODUCED AT THE DECATUR, ILLINOIS TIRE PLANT AND ALL FIRESTONE RADIAL ATX AND RADIAL ATX II TIRES, SIZE P235/75R15. OPERATION OF THESE TIRES AT LOW INFLATION PRESSURES, HIGH SPEED, AND IN HOT WEATHER, CAN CONTRIBUTE TO SEPARATION OF THE TIRE TREAD.
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH FACTORY INSTALLED SUNROOF. THE SUNROOF GLASS PANEL ASSEMBLY CAN SEPARATE WHILE THE VEHICLE IS MOVING DUE TO INCORRECT HINGE ENGAGEMENT. THIS WAS CAUSED BY IMPROPER SUNROOF INSTALLATION OF THE GLASS PANEL.
THE STUDS WHICH ATTACH THE BRAKE MASTER CYLINDER TO THE POWER BRAKE VACUUM BOOSTER ASSEMBLY CAN DEVELOP STRESS CORROSION CRACKING AFTER BEING OPERATED FOR AN EXTENDED PERIOD OF TIME IN THE SOUTHERN CALIFORNIA LOCATION.
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES. THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH FEDERAL REGULATION 573. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. THE CAMPAIGN WILL REINFORCE THE BRACKET ATTACHMENTS OF THE REAR LIFTGATE GAS ASSIST CYLINDERS WHICH COULD PULL AWAY FROM THE INSIDE OF THE LIFTGATE.
The component that malfunctioned was the abs sensor. It is not available for inspection. I was driving going around 45 in traffic and the drivers side rear brake locked up and spun me out of control and caused me to collide with another vehicle. I only lightly pressed the brakes and it happened suddenly and unexpectedly. It was not inspected before it was towed after the accident. There were no warning lamps.
TL* THE CONTACT OWNS A 1991 FORD EXPLORER. WHILE DRIVING 15 MPH WITH ANOTHER PASSENGER, THE SEAT BELTS DISENGAGED AND CAUSED THE PASSENGER SEAT TO OVERTURN BETWEEN THE SEATS. THE PASSENGER WAS NOT INJURED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 91,000.
No injuries · No fire · No crash
ON JUNE 4TH MY DAUGHTER AND I WERE DRIVING EAST BOUND ON 62ND AND OVER-HILL IN LOS ANGELES CA. SHORTLY AFTER 12:00PM. WHEN SUDDENLY THE FORD EXPLORER WAS ENGULFED IN FLAMES. MY DAUGHTER AND I WERE ORDERED TO EXIT THE VEHICLE. I WAS NEVER NOTIFIED OF A RECALL. DUE TO INVESTIGATION ON MY OWN I HAVE RECEIVED A RECALL NUMBER. IT IS 96S35. I HAVE ATTEMPTED TO RESOLVE THIS MATTER WITH FORD HOWEVER I JUST RECEIVED A LETTER FROM THEM REFUSING TO ASSIST ME. MY DAUGHTER AND I COULD HAVE BEEN BURNED ALIVE. I WOULD LIKE TO KNOW IF YOU COULD ASSIST ME. THE VEHICLE HAS SINCE BEEN DESTROYED. I ONLY HAVE IN MY POSSESSION THE PICTURE, AND A FIRE REPORT. *TR
I PURCHASED TWO MICHELIN LTX MS2 235/75R15 TIRES FROM TIRE RACK.COM, E732381. THEY WERE DELIVERED SEPTEMBER 15, 2011 WITH AN INCORRECTLY COMPLETED OMB CONTROL NO. 2127-0050 TIRE REGISTRATION CARD. THE CARD LISTED THE BRAND AS BF GOODRICH AND THE TIRE IDENTIFICATION NUMBERS AS BETJMX912711. THE TIRES I RECEIVED ARE MICHELIN B3DDDVOX2511 ACCORDING TO THE TIRE SIDEWALLS. I CONTACTED TIRE RACK'S CUSTOMER SERVICE DEPARTMENT. THEY ADVISED THAT THERE SYSTEM SHOWED THAT I WAS SENT MICHELIN B3DDDVOX2511 TIRES AND THAT IT WAS NOT THEIR RESPONSIBILITY TO CORRECTLY COMPLETE THE TIRE REGISTRATION CARD. DOES THIS COMPLY WITH DOT REGULATIONS REGARDING TIRE RETAILER'S CONDUCT REGARDING TIRE RECALL REGISTRATION? *TR
No injuries · No fire · No crash
UNIROYAL TIRE SIDE WALL CRACKS LT 235 75R15 - NO FAILURE - JUST CRACK. ALL 4 OF MY TIRES HAD A SIDE WALL CRACK THE ENTIRE DIAMETER OF THE TIRE ABOUT 3 INCHES DOWN ON THE SIDE WALL . I NOTICED THE CRACK ON THE INSIDE AS WELL SO IT APPEARS THE TIRES HAD SOME ISSUE. I HAD NEVER APPLIED TIRE FOAM CLEANER(ARMOR ALL TIREFOAM PRIOR ) BUT ONE TIME THIS LAST WEEK I DID APPLY SOME AND FOUND THE CRACK. LOOKING UNDER THE 1991 FORD EXPLORER 4X4 I DID SEE THE SAME ISSUE ON THE INSIDE OF A FRONT TIRE AS WELL...I NEVER APPLIED ANY ARMOR ALL TYPE CLEANER ON THE INSIDE EITHER. UNIROYAL FACTORY PHONE SUPPORT BLAMED ME OF APPLYING TIRE CLEANER WHICH RUINS TIRES AND SO DID THE WALMART TIRE STORE STAFF . I NEVER APPLIED ANYTHING AS THIS IS AN OLDER VEHICLE WHICH AND NO PR OR SHOW APPEAL. WALMART REPLACED ALL 4 TIRES ON 10-25-09 BUT THE TIRE PRESSURE WAS NOT 35 PSI ITS WAS AROUND 43 ACCORDING TO MY GAGE..THE TIRES ARE RATED FOR 50PSI. WALMART CHARGED THE PROBLEM TO MY WARRANTY AND THEN WANTED TO CHARGE AGAIN FOR A NEW WARRANTY. THIS WAS A TIRE FACTORY PROBLEM AS BOTH SIDE OF THE TIRES HAD A CRACK NOT A FIELD ROAD HAZARD ISSUE. KINGMAN AZ HAS TEMP RANGES FROM 110 IN JULY TO 9 DEGREES IN WINTER...THIS MAY BE FACTOR. *TR
No injuries · No fire · No crash