Chrysler Aspen Complaints

444 consumer complaints on file.

#10498564February 19, 2013
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2007 CHRYSLER ASPEN 4X4. THE CONTACT STATED THAT WHENEVER REFUELING, GASOLINE FUEL WOULD SPRAY OUT OF THE FILLER NECK HAPHAZARDLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO ADVISED THAT THE FAILURE WAS CONTRIBUTED TO THE FUEL TANK INLET VALVE. THE VEHICLE WAS SCHEDULED FOR REPAIRS. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 77,000. THE VIN WAS UNAVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10496416February 5, 2013
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2007 CHRYSLER ASPEN. THE CONTACT STATED THAT GASOLINE SPILLED TO THE GROUND WHENEVER THE FUEL TANK WAS FILLED. THE FAILURE WAS EXPERIENCED SEVERAL TIMES. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO HAVE A DIAGNOSTIC PERFORMED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 100,000 AND THE CURRENT MILEAGE WAS 110,000. THE VIN WAS NOT AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10494667January 25, 2013
FUEL/PROPULSION SYSTEM
VEHICLE HAS BEEN OVERFLOWING GAS AT THE END OF FILLUP. THE PUMP SHUTS OFF AS IT SHOULD, BUT THEN GAS OVERFLOWS OUT. WE ARE NOT TOPPING OFF - THIS HAPPENS WITH THE FIRST SHUTOFF OF THE GAS PUMP. THIS AT FIRST HAPPEN PERIODICALLY, BUT NOW HAPPENS EVERY TIME, NO MATTER WHERE I AM FILLING UP. I AM NOT OVER FILLING THE VEHICLE BY ANY MEANS, IN FACT I CAN SLOW THE PUMP DOWN TO A DRIBBLE AND IT WILL STILL "BURP" OUT FUEL ALL OVER THE SIDE OF THE VEHICLE AND LEAVING A LARGE PUDDLE OF GAS ON THE GROUND. THIS IS A HUGE SAFETY ISSUE AND NEEDS TO BE DELT WITH BY CHRYSLER. I HAVE TALKED TO OTHERS PERSONALLY THAT HAVE THE SAME ISSUE AND HAVE READ THAT MANY MANY OTHERS ARE HAVING THIS SAME ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10493338January 17, 2013
FUEL/PROPULSION SYSTEM
WHEN FILLING GAS TANK FUEL SPILLS OUT ALL OVER THE GROUND ( ABOUT A QUART+) WHEN FULL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10493171January 16, 2013
FUEL/PROPULSION SYSTEM
WHILE REFUELING FUEL WILL DISCHARGE OUT OF FILLER TUBE WHEN TANK GETS NEAR FULL, THIS WILL HAPPEN IF THE AUTO SHUT OFF IS USED OR IF IT IS OPERATED MANUALLY. THE FUEL WILL SPRAY UP TO 3' AWAY FROM VEHICLE AND COVER ANYTHING IN GENERAL AREA. THIS HAPPENS EVERY TIME VEHICLE IS REFUELED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10492861January 14, 2013
FUEL/PROPULSION SYSTEM
SIGNIFICANT FUEL SPIT-BACK OCCURS UPON EVERY REFUELING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10491659January 7, 2013
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2007 CHRYSLER ASPEN. THE CONTACT STATED THAT WHILE REFUELING, FUEL EJECTED FROM THE VEHICLE. THE CONTACT ALSO STATED THAT THE CHECK ENGINE LIGHT ILLUMINATES INTERMITTENTLY. THE VEHICLE WAS NOT TAKEN TO A MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 65,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10491541January 5, 2013
FUEL/PROPULSION SYSTEM
WHEN FUELING MY 2008 ASPEN IS COMPLETE IT DOES NOT SHUT-OFF AND GAS SPEWS OUT ALL OVER THE CAR, MYSELF, AND EVERYTHING ELSE. THIS STARTED ABOUT A YEAR AGO AND THEN QUIT, IT HAS SINCE STARTED UP AGAIN WITH A VENGEANCE OF AN EXPLOSION OF GASOLINE. I FIRST THOUGHT IT WAS THE PUMP, BUT I HAVE GONE TO MANY DIFFERENT STATIONS AND THERE SAME THING OCCURS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10490694January 2, 2013
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 2007 CHRYSLER ASPEN 4X4. THE CONTACT STATED THAT WHILE REFUELING, THE FILLER TUBE INLET CHECK VALVE FAILED, CAUSING FUEL TO BE PROJECTED ONTO THE VEHICLE AND THE CONTACT. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE FUEL TANK FILLER TUBE INLET CHECK VALVE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 70,000. ..UPDATED 01/30/13 *BF UPDATED 2/4/2013 *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10489135December 18, 2012
FUEL/PROPULSION SYSTEM
STARTING AT AROUND 85,000 MILES OR SO DURING FILLING OF THE GAS TANK, JUST BEFORE THE FUEL HANDLE SHUT OFF ENGAGES, AN ENORMOUS AMOUNT OF FUEL LITERALLY GUSHES BACK FROM THE FUEL TANK, SOAKING THE PERSON FILLING THE VEHICLE AND THE GROUND WITH WHAT APPEARS TO BE BETWEEN A HALF GALLON TO A GALLON OF FUEL. WE HAVE TRIED MANY DIFFERENT GAS STATIONS, MANUALLY FILLING UP THE TANK, AND EVEN NOT COMPLETELY FILLING UP THE TANK ALL WITH THE SAME RESULT - ALOT OF GAS DUMPING BACK OUT ONTO PEOPLE, THE TRUCK, AND THE GROUND. GIVEN THAT GASOLINE IS EXTREMELY FLAMMABLE, AND THAT IT HAS BEEN PROVEN THAT SPARKS FROM STATIC ELECTRICITY AND CELL PHONES CAN EASILY IGNITE VAPORS, THIS IS A VERY DANGEROUS SITUATION. MANY PEOPLE COMPLAIN OF THE SAME ISSUE WITH MANY CHRYSLER PRODUCTS (JEEP, DURANGO, AND ASPEN, MAINLY), AND CHRYSLER HAS INSTITUTED A RECALL ON VERY VERY LIMITED VEHICLES FOR THIS PROBLEM. I BELIEVE THAT ALL OF THE 2007 ASPENS AND DURANGOS, AND POSSIBLY EVEN MORE VEHICLES, SHOULD BE RECALLED TO FIX THIS PROBLEM. THE ONLY WAY TO FIX THE ISSUE IS TO REPLACE THE ENTIRE GAS TANK, WHICH IS COST PROHIBITIVE FOR MANY PEOPLE. I AM SURPRISED THAT THERE HASN'T BEEN ANY SERIOUS FIRES AND/OR FATALITIES DUE TO THIS ISSUE. DO WE REALLY NEED TO WAIT FOR SOMEONE TO BE SERIOUSLY HURT OR DIE BEFORE TAKING ACTION? NO OTHER CAR MANUFACTURERS SEEM TO BE HAVING THIS PROBLEM WITH AS MUCH REGULARITY AS CHRYSLER HAS. GIVEN THE TRAGIC EVENTS THAT HAVE UNFOLDED OVER THE PAST SEVERAL DAYS THE LAST THING I WANT TO HEAR ABOUT OR EXPERIENCE IS MORE CHILDREN KILLED OR SERIOUSLY INJURED FROM A WELL KNOWN AND DOCUMENTED PROBLEM. PLEASE TAKE A VERY SERIOUS LOOK INTO THIS, AND SINCE I AM LUCKY ENOUGH TO HAVE THE ABILITY TO PAY FOR A NEW GAS TANK I WOULD BE MORE THAN HAPPY TO GIVE YOU THE OLD ONE TO VERIFY THE ISSUE. PLEASE TAKE ACTION BEFORE ITS TOO LATE! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10487729December 7, 2012
ELECTRICAL SYSTEM, EXTERIOR LIGHTING
TURN SIGNALS FUNCTION INTERMITTENTLY WHEN ACTIVATED. RIGHT SIGNAL SEEMS TO WORK OKAY WHEN ACTIVATED BUT RIGHT SIGNAL LIGHT ALSO COMES ON WHEN STALK IS PUSHED DOWN TO INDICATE A LEFT TURN. TRYING TO INDICATE A LEFT TURN CAN ALSO RESULT IN NO SIGNAL LIGHT AT ALL. THIS CAN CONFUSE OTHER DRIVERS AND HAS RESULTED IN SEVERAL NEAR MISSES ON LANE CHANGES AND AT INTERSECTIONS WHEN TURNING LEFT. SEEMS TO BE AFFECTED BY COLD TEMPERATURES AND AT THE PRESENT TIME GOES AWAY AFTER CAR IS WARMED FOR 15-20 MINUTES. CHRYSLER FORUMS HAVE INDICATED THIS TO BE A PROBLEM ON ASPENS. NO RECALLS ISSUED YET. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10477157September 26, 2012
FUEL/PROPULSION SYSTEM
UPON PICKING UP THE VEHICLE FROM THE REPAIR SHOP, I WENT TO GET GAS. WHILE FUELING THE TANK SPITS BACK FUEL AND ALSO DISENGAGES THE DISPENSING OF FUEL. I'VE TRIED DIFFERENT GAS STATIONS AND HAVE THE SAME ISSUE EACH TIME. FUEL FILLER NECK WAS REPLACED ALONG WITH THE FUEL TANK. THIS IS A SERIOUS SAFETY ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10470773August 15, 2012
FUEL/PROPULSION SYSTEM
BOUGHT MY 2007 CHRYSLER ASPEN WENT TO FILL IT UP WITH GAS, TANK WAS JUST ABOUT FULL WHEN AN EXCESSIVE AMOUNT OF GAS SHOT OUT OF THE FILLER NECK ALL OVER MY HUSBAND AND MYSELF. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10460069May 30, 2012
STEERING
TL* THE CONTACT OWNS A 2007 CHRYSLER ASPEN. WHILE DRIVING APPROXIMATELY 5 MPH, THE CONTACT DROVE OVER A PUDDLE OF WATER AND THE STEERING BECAME DIFFICULT TO MANEUVER. AFTER STOPPING THE VEHICLE BRIEFLY THE STEERING FUNCTION RESET INDEPENDENTLY. THE FAILURE RECURRED FOUR TIMES. THE CONTACT, WHO WAS A CERTIFIED MECHANIC, WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NEITHER REPAIRED NOR TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION OR REPAIRS. THE APPROXIMATE FAILURE MILEAGE WAS 32,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10459124May 21, 2012
FUEL/PROPULSION SYSTEM
AS WITH MANY OTHERS, I TOO HAVE HAD THE PROBLEM WITH GAS SPITTING OUT OF THE TANK WHEN FUELING MY 2007 CHRYSLER ASPEN. THIS HAS OCCURRED REPEATEDLY OVER THE PAST YEAR AND A HALF NO MATTER WHAT PRECAUTIONS I HAVE TRIED (STOPPING REPEATEDLY, ADJUSTING THE POSITION OF THE NOZZEL, ETC..). IT'S DANGEROUS, HARMFUL TO SKIN/CLOTHING/SHOES, COSTLY AND DOWNRIGHT EMBARRASSING. AFTER READING ON THE INTERNET HOW COMMON OF AN ISSUE THIS IS, I CANNOT BELIEVE THAT CHRYSLER HAS NOT STOOD UP AND TAKEN ACTION ON THIS - OBVIOUSLY THEY ARE NOT LOOKING TO BUILD BRAND LOYALTY! *TT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10457818May 8, 2012
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2009 CHRYSLER ASPEN. THE CONTACT STATED THAT THE TRIP COMPUTER MALFUNCTIONED. THE CONTACT TOOK THE VEHICLE TO A DEALER AND THE DEALER REPLACED THE TRIP COMPUTER. TWO WEEKS AFTER THE REPAIR, THE TRIP COMPUTER ILLUMINATED RED AND MALFUNCTIONED. THE TRIP COMPUTER ALSO CAUSED THE BATTERY TO DIE. THE CONTACT CALLED THE MANUFACTURER AND THE MANUFACTURER SUGGESTED TAKING THE VEHICLE BACK TO THE DEALER. THE CONTACT DID NOT TAKE THE VEHICLE BACK TO THE DEALER. THE FAILURE MILEAGE WAS 56,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10457442May 4, 2012
FUEL SYSTEM, GASOLINE
GASOLINE DISCHARGED (APPROXIMATELY 1/4 GALLON) OUT OF FUEL FILLER AFTER GASOLINE FILLER NOZZLE SHUTS OFF AT FILL-UP WHEN TANK REACHES CAPACITY. THIS HAPPENS AT ALL GAS PUMPS, NOT A SPECIFIC STATION. MANY ATTENDANTS AT GAS STATIONS HAVE STATED THAT THIS IS A SAFETY CONCERN AS FUEL GETS ON THE GROUND AND ON THE PERSON FUELING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10455676April 18, 2012
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
EVERY TIME WE FILL UP OUR GAS TANK WHEN THE GAS PUMP SHUTS OFF THERE IS GUSH OF GAS THAT IS SPIT BACK OUT OF THE TANK. WHEN IT FIRST OCCURRED I WAS DRENCHED WITH GAS. THIS IS NOT SAFE AND WHEN THE DEALER CHECKED OUT THE ISSUE THEY SAID THE PROBLEM WAS WITH THE FILLER ASSEMBLY AND WOULD COST $800 TO FIX. THIS IS UNACCEPTABLE AND AS I WRITE THIS TODAY THERE ARE 15 OTHER COMPLAINTS WITH THE SAME CAR AND SAME PROBLEM. I ALSO HAVE GAS STATION ATTENDANTS IN NJ TELL ME THEY HAVE THIS HAPPEN ALL THE TIME WITH CHRYSLER CARS MAINLY ASPEN, WRANGLERS AND LIBERTY. EVEN THE DEALER SAYS THIS IS A COMMON PROBLEM. CHRYSLER NEEDS TO ISSUE A RECALL FOR THIS PROBLEM. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10455485April 17, 2012
FUEL SYSTEM, GASOLINE
THE CAR HAS BEEN GUSHING GAS OUT OUT OF THE FILLER TUBE EVERY TIME IT IS FILLED FOR SEVERAL MONTHS. THEN THE FUEL PUMP COMPLETELY FAILED AND HAD TO BE REPLACED ON 02/13/12 AT A COST OF $1137.34. THEN ON 02/28 THE ENGINE LIGHT CAME ON REQUIRING AN NEW EVAPORATIVE EMISSIONS SYTEM ECIM SWITCH HAD TO BE REPLACED AT A COST OF $178.17. THE CAR STILL GUSHES GASOLINE OUT AT EVERY FILL UP AND WE ARE STILL WAITING FOR A FIX FROM THE DEALER ON THIS ISSUE. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10450437March 6, 2012
FUEL SYSTEM, GASOLINE
JUST PURCHASED A USED 2007 CHRYSLER ASPEN. WHEN FUELING TO FILL, GAS PUMP SHUTS OFF, THEN LARGE AMOUNT OF GAS OVERFLOWS OUT, SPLASHING SKIN, CLOTHING, GAS CAP AND PAVEMENT. ADDITIONAL GAS GOES ON HAND WHEN CLOSING GAS CAP. SEEMS LIKE THIS IS A FIRE HAZARD, NOT TO MENTION ENVIRONMENTAL HAZARD. NOT "TOPPING OFF", JUST ALLOWING PUMP TO SHUT OFF, WHICH IT DOES. THE GAS ONLY OVERFLOWS OUT AFTER THE PUMP SHUTS OFF. THIS HAS HAPPENED AT MULTIPLE STATIONS AND WAS EXTRA CAREFUL NOT TO PUT THE NOZZLE IN TOO FAR. HAVE SEEN LOTS OF COMPLAINTS ABOUT THIS HERE. WHY IS THERE NO OFFICIAL RECALL? *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chrysler Aspen