BMW 535i Complaints

536 consumer complaints on file.

#10825160February 9, 2016
FUEL/PROPULSION SYSTEM
DRIVING ON THE HIGHWAY, ENGINE STOPS. FIRST WARNING "ENGINE MALFUNCTION, REDUCED POWER. BUT IT HAD ALREADY STOPPED. AFTER NARROWING MISSING TRAFFIC PARKED IN BREAKDOWN LANE. NEXT WARNING FUEL PUMP FAILURE. CAR WOULD NOT RE-START FOR AN HOUR UNTIL TOW TRUCK ARRIVED. HAD TO BE TOWED TO BMW DEALER. DEALER REPORTS LOW PRESSURE FUEL PUMP. ENGINE DIED AGAIN AT DEALERS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10819750January 12, 2016
FUEL/PROPULSION SYSTEM
YELLOW ENGINE LIGHT CAME ON, WAS TESTED AND NOTHING WAS FOUND. IT STARTED USING MORE GAS THAN USUAL AND LONG-CRANKS STARTING THE ENGINE AND SHAKING AFTER THE ENGINE STARTED. THE DIAGNOSIS WAS ALL 6 FUEL INJECTORS NEEDED REPLACEMENT AS THEY WERE LEAKING GASOLINE, THEY ALL FAILED AT 73,000 MILES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10816489December 28, 2015
FUEL/PROPULSION SYSTEM
THE CAR SUDDENLY DISPLAYED A WARNING SAYING THE FUEL PUMP MALFUNCTION AND GAVE A NOTICE THAT ENGINE MAY SHUTDOWN IMMEDIATELY AND TO PULL TO A SIDE. WE COMPLIED - THOUGH IT MAY HAVE BEEN PRETTY DANGEROUS IF WE WERE ON HIGHWAYS OR IN TRAFFIC. TRIED TO START AGAIN, THE SAME ISSUE. GOT IT TOED TO THE BMW DEALERSHIP. THE DEALER DIAGNOSED THE ISSUE TO BE THE HIGH PRESSURE INJECTION PUMP AND TOLD US IT IS NOT COVERED. WE CALLED BMW AND THEY TOLD IT IS NOW COVERED AS IT HAS AN EXTENDED WARRANTY. WE TELL THE DEALER AND THE DEALER TELLS US IT IS COVERED BUT ANOTHER PART EDK PF IS NOW NOT COVERED AS IT DID SHOW FAULT CODES THAT WERE EARLIER THAN THE FUEL PUMP FAULT CODES. MY ISSUE IS IF THE FUEL PUMP AND EDK WORK HAND-IN-HAND, WON'T THE TWO TO BE COVERED BY BMW? WHY IT SHOULD MATTER, WHICH DID SHOW FAULT CODES FIRST? INFACT THIS IS PRETTY DANGEROUS SITUATION AND I WISH BMW RECALLS AND CHECKS ALL VEHICLES AND FIX ALL THE PARTS THAT ARE AFFECTED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10795085November 20, 2015
ENGINE
TL* THE CONTACT OWNS A 2008 BMW MODEL 535I. WHILE DRIVING 50 MPH, AN UNKNOWN WARNING LIGHT ILLUMINATED AND INDICATED THAT THE VEHICLE WAS OVERHEATING. IN ADDITION, THE VEHICLE STALLED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V521000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 101,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10786525October 27, 2015
WHEELS
RUBBER SEPARATING AND SIDEWALL BUBBLES AT 15K -30K MILES. VEHICLE IS ADULT DRIVEN ON PAVED ROADS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10780795October 8, 2015
SERVICE BRAKES
AT A SPEED OF 40-60 MPH WHEN I BRAKE MY CAR SHAKES REALLY BAD. I HAVE TAKEN TO ADVANTAGE BMW IN CLEAR LAKE, TX TWICE. THE FIRST TIME THEY CHANGED THE BRAKES. THE SECOND TIME I HAD A BUBBLE IN MY TIRE AND GOT IT REPLACED ALONG WITH A BALANCE AND ALIGNMENT. I DRIVE ON THE HWY. 5 DAYS A WEEK AND EVERY TIME I PRESS ON MY BRAKE MY CAR SHAKES. EVEN AFTER THE NEW TIRE, BALANCE AND ALIGNMENT IT STILL SHAKES WHEN I APPLY MY BRAKES. I FEEL A HARD VIBRATION WHEN BRAKING AND A SQUEAKING WHEN BACKING UP. I TOOK MY CAR TO THE DEALERSHIP OCTOBER 2 AND 5 MONTHS PRIOR TO THAT FOR THE SAME THING. IT IS NOT FIXED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10780037October 6, 2015
ENGINE
TL* THE CONTACT OWNS A 2009 BMW 535I. WHILE DRIVING 50 MPH, THE VEHICLE DECELERATED AND THE REDUCE ENGINE POWER WARNING MESSAGE ILLUMINATED. THE VEHICLE WAS MERGED TO THE SIDE OF THE ROAD, WHERE IT WAS TURNED OFF AND RESUMED NORMAL OPERATION AFTER RESTARTING THE ENGINE. THE CONTACT MENTIONED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER A MANUFACTURER'S CUSTOMER SERVICE RECALL; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS NOT TAKEN BACK TO THE DEALER NOR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 70,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10780083October 6, 2015
TIRES:SIDEWALL
TL* THE CONTACT OWNS A 2014 BMW 535I. WHILE DRIVING 55 MPH, THE SIDEWALLS OF THE TIRES RUPTURED AND CAUSED NUMEROUS FLATS. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE TIRE INFORMATION WAS NOT PROVIDED. THE FAILURE MILEAGE WAS 16,200.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10764570September 17, 2015
ENGINE
WHILE DRIVING "ENGINE FAILURE, REDUCE POWER" LIGHT CAME ON, POWER ON ENGINE REDUCED BUT DRIVABLE. WHEN CAR SHUT DOWN AND RESTARTED LIGHT GOES OFF BUT IF STEPPING ON THE GAS HARD THE LIGHT COMES BACK WITH ENGINE HAVING REDUCED POWER. THIS WAS REPAIRED TWICE, LAST BY BMW ON 7/29/13, THEY REPLACED VANS SOLENOIDS (INTAKE AND EXHAUST) AND REPROGRAMED THE TRANSMISSION. AT THAT TIME THEY TOLD ME IF THE PROBLEM RETURNS THE TRANSMISSION MAY NEED TO BE REPLACED. READING THROUGH FORUMS AND THE WEB I CAME UPON MANY COMPLAINTS FOR THE SAME PROBLEM IN WHICH DEALERS STATED DIFFERENT ROOT CAUSES, MANY SOLUTIONS PROPOSED BUT OFTEN PROBLEM RETURNS. I BELIEVE THIS IS DESIGN FLAW WITH THIS CAR AND SHOULD BE INVESTIGATED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10764681September 17, 2015
POWER TRAIN
DRIVE TRAIN MALFUNCTION LIGHT COMES ON FROM TIME TO TIME. MESSAGE: "DIRVETRAIN MALFUNCTION; MAXIMUM OUTPUT NOT AVAILABLE." LOSS OF POWER. TOLD BY DEALER SERVICE DEPARTMENT (OTTO'S BMW) TO STOP CAR AND TURN IT ON AGAIN. IT RUNS JUST FINE AFTER THIS IS DONE. BUT INTERMITTENT LOSS OF POWER WHILE DRIVING ON THE HIGHWAY IS VERY VERY DANGEROUS. I CALLED THE STATE TROOPER THE FIRST TIME THIS HAPPENED (IN 2012 WHEN THE CAR WAS PRACTICALLY NEW, HAVING LESS THAN 20,000 MILES) TO PROVIDE COVER.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10762750September 10, 2015
FUEL/PROPULSION SYSTEM
FUEL FLOATER IS BROKEN, THEREFORE I HAVE NO IDEA HOW MUCH FUEL IS IN THE TANK.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10749602August 18, 2015
UNKNOWN OR OTHER, ENGINE
STARTED ENGINE, CHECK ENGINE LIGHT CAME ON. THIS HAS HAPPENED ABOUT 6 TIMES BEFORE IN THE LAST 2 YEARS. EACH TIME IT WAS RELATED TO FUEL CAP/O2 SENSOR.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10748081August 12, 2015
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2011 BMW 535I. THE CONTACT RECEIVED A NOTIFICATION FOR AN EXTENDED WARRANTY ISSUED FOR THE FUEL PUMP. THE CONTACT HAD NOT EXPERIENCED ANY FAILURES RELATED TO THE FUEL PUMP; HOWEVER, THE CONTACT WAS CONCERNED THAT IF THE FAILURE OCCURRED IT COULD LEAD TO A SERIOUS INJURY OR DEATH. THE MANUFACTURER WOULD NOT REPLACE THE FUEL PUMP UNTIL A FAILURE OCCURRED. THE FAILURE MILEAGE WAS 85,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10744057July 27, 2015
ENGINE
I WAS DRIVING MY VEHICLE NORTHBOUND ON THE KENNEDY EXPRESSWAY (I-90) BETWEEN MONTROSE AND LAWRENCE EXIT HERE IN CHICAGO WHEN MY CAR STALLED THE MIDDLE OF A VERY BUSY HIGHWAY. I ATTEMPTED TO RESTART IT WITH REDUCED POWER THAT ALLOWED ME TO DRIVE MY VEHICLE TO THE SHOULDERS BUT IT WAS A SCARY EXPERIENCE NONETHELESS WITH HIGH SPEED CARS AND TRUCKS PASSING BY YOU. IT WAS DETERMINED THAT IT WAS A FUEL PUMP ISSUE RELATING TO AN EXISTING RECALL/CLASS ACTION LAWSUIT. ANYWAY, THE CAR WAS NEVER FULLY FIXED; I MEAN I HAD AT SEVERAL INSTANCES OF CAR STALLING AGAIN AND AGAIN. I REPEATEDLY COMPLAINT TO THE MANUFACTURER AND THE CAR DEALER LETTING THEM KNOW THAT I FEEL THERES A SYSTEMIC ISSUE WITH THE VEHICLE. EVERY TIME I BROUGHT IT FOR REPAIRS IT WAS A DIFFERENT REASON WHY THE ENGINE FAILURE KEEPS LIGHTING UP AND THE CAR STALLING. IN THE BEGINNING THEY WERE COVERING THE REPAIRS UNDER WARRANTY BUT AS SOON AS THE ORIGINAL WARRANTY EXPIRED I WAS ON THE HOOK FOR HUNDREDS SOMETIMES THOUSANDS OF DOLLARS IN REPAIRS. I COMPLAINED THAT THERE WAS A CLASS ACTION LAWSUIT ON THIS VEHICLE AND PART OF THE SETTLEMENT WAS TO EXTEND THE ENGINE WARRANTY TO 10 YEARS BUT THEY NEVER COVERED IT UNDER THIS EXTENDED WARRANTY SIMPLY BY STATING THAT THE ISSUE WAS NOT RELATED TO WHATS COVERED BY THE WARRANTY. IVE FINALLY GIVEN UP DISPUTING WITH THEM AND SOLD THE CAR THIS MONTH AND IVE DISPUTED WITH MY CREDIT CARD THE REPAIR COSTS SINCE THE ISSUE WAS NEVER FIXED. BMW IS COVERING UP THAT THERES AN ISSUE WITH THIS MODEL OF THEIR CAR AND HAVE BEEN DODGING WARRANTY CLAIMS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10721768May 27, 2015
FUEL/PROPULSION SYSTEM
VEHICLE SHUTTERS AND MISFIRES WHEN AUTOMATIC TRANSMISSION DOWNSHIFTS WHILE ATTEMPTING TO ACCELERATE AT CRUISING SPEEDS. ENGINE LIGHT COMES ON AND HAS REDUCED POWER UNTIL VEHICLE IS RESTARTED. MAJOR SAFETY CONCERN WHEN ATTEMPTING TO MERGE ONTO HIGHWAY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10712818April 25, 2015
EXTERIOR LIGHTING
THE HEAD LIGHT WIRING HAS FLAKED OFF AND CAUSED A SHORTAGE IN MY HEADLIGHTS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10712247April 22, 2015
FUEL/PROPULSION SYSTEM
I WAS DRIVING ON THE HIGHWAY AND ALL OF A SUDDEN WHEN I TRIED TO SWITCH LANES, THE CAR JUST MADE A BIG FUMBLE AND ALMOST STALLED. THE TRAFFIC BEHIND NEARLY BECAME FATAL AS THE CAR DID NOT ACCELERATE AND I WAS VERY LUCK TO HAVE PULLED BACK WITH THE PASSING CAR BARELY HITTING MY MIRROR. I HAVE TAKEN THIS CAR TO THE DEALER ON MANY OCCASIONS AND THEY HAVE CHANGED OUT ALL THE INJECTORS AND STILL THE CAR IS HAVING THIS PROBLEM. EVERY TIME I GO TO THE DEALER THEY KEEP CHANGING THE FUEL INJECTORS OR RECALIBRATING THEM. A SIMPLE GOOGLE SEARCH WILL SHOW THAT THIS IS AN ON GOING ISSUE WITH THESE CARS AND BMW OF NORTH AMERICA DOES NOT WANT TO DO ANYTHING ABOUT IT. EVEN THOUGH THIS WAS REPORTED BEFORE THE END OF THE MANUFACTURER'S WARRANTY AND STILL ONGOING, THEY REFUSE TO COVER THE REPAIRS. THIS IS ABSURD AND THEY SHOULD BE HELD RESPONSIBLE AS MY FAMILY AND MY LIFE IS IN DANGER EVERY TIME WE TAKE TO ANY ROAD WITH THIS CAR. WE ARE NOT IN A FINANCIAL POSITION TO AFFORD REPAIRS AS IT IS VERY EXPENSIVE AND UNFORTUNATELY WE ARE FORCED TO TAKE A RISK EVERY TIME WE HAVE SOMEWHERE TO GO. MY PREGNANT WIFE AND MY SELF HAS MISSED ALMOST 20 TIMES WHERE ANOTHER CAR COULD HAVE HIT US. I FEAR ONE OF THESE DAYS WE WILL NOT BE SO LUCKY . PLEASE HELP. *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10705056April 10, 2015
ENGINE
WHILE DRIVING AT 45 MPH, YELLOW WARNING LIGHT INDICATING THE CAR WAS OVERHEATING CAME ON. A FEW SECONDS LATER THE LIGHT TURNED RED AND INDICATED TO STOP THE VEHICLE AND SHUT THE ENGINE OFF. VEHICLE LOST ALL POWER AND I CAME TO A STOP. IT WAS TOWED TO THE SHOP AND I WAS INFORMED THAT THE WATER PUMP AND THERMOSTAT NEEDED TO BE REPLACED ADDING THAT IT WAS A COMMON FAILURE IN THE BMW. VEHICLE HAD RECENTLY BEEN SERVICED AT BMW DEALER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10703251April 2, 2015
ENGINE
VEHICLE LOSS POWER WHILE DRIVING ON HWY AND IDLE ROUGH. AND CHECK ENGINE LIGHT CAME ON. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10695051March 18, 2015
AIR BAGS, SEAT BELTS, SEATS
2008 BMW 5-SERIES VEHICLES HAVE THE SAME ISSUE AS RECALLED 2004 - 2006 BMW 5-SERIES VEHICLES IN REGARDS TO THE FRONT PASSENGER SEAT OCCUPANT DETECTION MAT MALFUNCTIONING. THE SEAT OCCUPANCY MAT IS FAULTY ON 2007 & 2008 MODELS AS WELL. THE CONSEQUENCE IS THAT THE PASSENGER AIR BAG WILL NOT DEPLOY EVEN IN THE EVENT OF A SEVERE CRASH. WHY WERE 2007 & 2008 BMWS NOT RECALLED ALREADY...?!?!? WHAT IS BEING DONE TO RECALL 2007 & 2008 BMW MODELS THAT USE THE SAME PARTS AS 2004 - 2006 MODELS...?!?!? *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to BMW 535i