BMW 535i Complaints

536 consumer complaints on file.

#11770616October 12, 2026
ENGINE
UKNOWN EXACT PROBLEM. 2013 BMW 535i with the same N55 motor with the [XXX] recall. Similar symptoms: Drivetrain malfunction and "camshaft stuck" code with loud metallic clanking in upper front of engine bay. Incident happened at rough 5-10mph pulling out of a parking lot just at 160,000 miles. Oil spilling everywhere and car was losing power. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11734928April 30, 2026
TIRES:SIDEWALL
Tire Size 245-40-19 - Car 2015 BMW 535 x-drive During a trip from [XXX] to [XXX] the the Continental ProContact SSR MOE tires on both the drivers and passinger side front developed sidewall bubbles. The tires had less than 3500 miles on them. The tires were purchase through the local BMW Dealer, A&L Motors, in Pennsylvania. I had a bubble develop on another Continental Pro Contact MOE a year ago but I wasn't worried about that due to the tire having over 35,000 miles. In XX years of car ownership I have never had an issue with a tire bubbling other than this. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11732394April 20, 2026
POWER TRAIN, ENGINE
ValveTronic motor and eccentric shaft is a very common issue that my specific car has. Affects the timing and makes a loud sound. Dangerous to drive in this condition.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721737March 3, 2026
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
The contact owned a 2011 BMW 535I. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed, however the vehicle failed to accelerate as intended. The contact stated that the accelerator pedal became stuck. No warning lights were illuminated. The contact stated that the vehicle accelerated into oncoming traffic. The contact's vehicle was crashed into by two oncoming vehicles. No warning light. The contact was taken to the local medical center, where the contact received multiple X-rays. In addition, the contact sustained bruises and pain to the left and right knees and to the middle of the chest. The contact stated that the pain in the chest was severe because of a pre-existing illness of male breast cancer. The vehicle was towed to a local tow yard. In addition, the vehicle was condemned as a total loss by the insurance company. A police report was filed. In addition, the contact was unsure of any injuries to the other drivers. The manufacturer was not made aware of the failure. The failure mileage was approximately 143,000
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11721523March 2, 2026
EXTERIOR LIGHTING, ELECTRICAL SYSTEM
This is a known and unaddressed issue. BMW headlight seals fail allowing condensation to build and erode electronics. Replacement costs exceed $15K and only OEM parts and BMW servicing are options. Many BMW repair shops refuse to do this work as it is overly complicated and expensive. This issue is well known and document and warrants compensation and/or recall.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11712401January 21, 2026
VEHICLE SPEED CONTROL, SERVICE BRAKES, ENGINE
The BMW, while turning at low speed into a parking space, suddenly accelerated and the braking system failed. Airbags deployed after multiple impacts with other vehicles and a fixed object, causing serious personal injury for the driver. The incident occurred on 01/16/2026. The vehicle is a total loss, has not yet been inspected, and is in storage. No warning lamps, messages or other issues were displayed or known prior to the failure. The vehicle was regularly maintained. The incident did not occur as a result of driver error or a medical issue.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11710365January 12, 2026
AIR BAGS
The contact owns a 2014 BMW 535i. The contact stated that while driving in stop-and-go traffic, she depressed the brake pedal, however crashed into the rear of the vehicle in front of her. The contact stated that all three air bags deployed; however, the front driver-side air bag failed to deploy properly. The contact stated that smoke came out from the air bag and failed to fully inflate, not protect the contact. Neither the contact nor the driver of the other vehicle sustained any injuries. A police report was filed. Due to the accident, the vehicle was towed to an independent mechanic, where the damage to the vehicle from the accident was repaired, and all air bags were replaced. The manufacturer was notified of the failure but offered no assistance. The vehicle was repaired. The failure mileage was approximately 129,000.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11700387November 19, 2025
ENGINE, ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
My 2013 BMW 535i (VIN [XXX] ) caught fire spontaneously while parked, turned off, and unoccupied on 11/18/2025 in Westbury, NY. A passerby saw smoke and called 911. Nassau County Police and the Westbury Fire Department responded. Firefighters informed me at the scene that the fire was mechanical in origin. The vehicle was completely off and had been parked for about 20 minutes. I was not in or near the car. The fire originated under the hood. This matches known fire patterns in BMW 5-series models from this generation involving electrical/engine components, even though my VIN shows no open recalls. The previous owner did not register the car, so any recall notices may not have reached them. The vehicle is a total loss. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11696232October 28, 2025
ENGINE, POWER TRAIN, FUEL/PROPULSION SYSTEM
BMW N63 Engine Powertrain Issues 2012 535i The N63 engine, utilized in various BMW models including the 2012 535i, has been subject to multiple customer complaints regarding premature timing chain wear and other powertrain-related issues. This led BMW to introduce a "Customer Care Package," detailed in Technical Service Bulletin (TSB) B110614, to address the concerns reported by multiple owners and noted by the National Highway Traffic Safety Administration (NHTSA) under ID Number 11016414. A primary cause of the issue is accelerated timing chain wear. The N63 engine's design features timing chains that are prone to stretching prematurely. This stretching can disrupt the precise timing of the engine's valves, leading to a cascade of problems. As a consequence, owners have reported a variety of symptoms, including the illumination of the "drivetrain malfunction" warning light, noticeable engine noise, excessive vibration, and potentially catastrophic engine failure. The "drivetrain malfunction" message, in particular, is a frequently cited indicator of this underlying powertrain problem. To address these widely reported issues, the N63 Customer Care Package was implemented. This service bulletin instructs authorized BMW technicians to perform a series of diagnostic tests. The main objective is to detect if the timing chains have stretched beyond acceptable tolerances. If excessive wear is confirmed, the TSB provides a detailed procedure for the necessary repairs. This often involves replacing the timing chains and related components to restore proper engine function. Beyond the core timing chain replacement, the Customer Care Package also includes several proactive and preventative measures. Technicians are instructed to check and potentially replace other components, such as fuel injectors and boost solenoids, which may have been impacted or contributed to the engine's performance issues. Furthermore, the service includes reprogramming the vehicle's software
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11686396September 10, 2025
ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM
The contact owns a 2015 BMW 535I. The contact stated that while driving at 30 MPH, the engine overheated. The engine temperature gauge was between 250 and 300 degrees. The contact linked the failure to NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System). The vehicle was taken to the local dealer and was diagnosed with a water pump connector failure. The vehicle was repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 70,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11682140August 21, 2025
AIR BAGS
The contact owns a 2011 BMW 535i. The contact stated that when pressing the accelerator pedal to drive from being idle at a red light, the driver's side air bag deployed out of the steering wheel without impact. The contact sustained burns to the left arm, right cheek, and chest area. The contact had suffered stomach issues due to inhaling the dust and fumes from the air bag. Medical attention was required. The vehicle was towed by AAA to an independent mechanic, where it was diagnosed that the horn module needed to be replaced; however, the part was not available. The vehicle was towed to another independent mechanic, where the vehicle remained for a month, and Liberty Mutual was to retrieve the vehicle and investigate the failure. The contact stated that the vehicle was not investigated to her knowledge, and the vehicle was returned without being repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 132,000.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11675261July 22, 2025
AIR BAGS, ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL
Heard a clicking noise behind the steering wheel for a few days then I’ll the sudden the horn stopped working and all the controls on the steering wheel stopped working. I’m a mechanic so I took apart the clock spring stealing wheel compartment to find all of the wire broken and very very brittle. Cause for concern due to airbag malfunction and is no longer connected properly!!!I’ve been hearing a clicking noise behind the steering wheel for a few days. Then, suddenly, the horn stopped working, and all the controls on the steering wheel stopped working as well. Since I’m a mechanic, I disassembled the clock spring and the steering wheel compartment to find that all the wires were broken and extremely brittle. This is concerning because it could cause an airbag malfunction, and the wires are no longer connected properly.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11672707July 11, 2025
POWER TRAIN
I believe using the manual shift mode for normal usage of optimal shifting in certain driving situations and gentle downshifting caused a malfunction in the functionality of the transmission that led to a complete transmission failure. I don’t believe it’s a mechanical issue or result of misuse. There were no warning signs. Only that every time the manual shift option was used, it would cause an error to occur that caused an automatic shifting issue that would reset if the vehicle was shut down and restarted.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11667152June 16, 2025
UNKNOWN OR OTHER
I purchased the BMW 535 and it continues to have drivetrain malfunction issues. This feels like a safety concern for several reasons. The first is that were not able to identify the issue, but I believe it has to do with the systems diagnostics being triggered or misfiring this is an unfortunateissue because wherever we are, we can get stuck randomly. Lastly, the car has an issue with Oberheu. Issue because wherever we are, we can get stuck randomly. Lastly, the car has a issue with overheating believe it has to do with the radial hose
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11666052June 10, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2013 BMW 535I. The contact stated while driving at various speeds, the engine was overheating. Additionally, the contact noticed an abnormal burning odor while driving, with smoke coming from underneath the hood while at a complete stop. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 200,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11662104May 20, 2025
STEERING
The contact owns a 2015 BMW 535I. The contact stated that upon starting the vehicle, a steering wheel image was displayed on the instrument panel. The computer then informed the contact to carefully drive the vehicle to a dealer for service. The contact stated that excessive force was needed to steer the vehicle during the failure. The vehicle was taken to the dealer where a diagnostic test was performed. The contact was informed that the electrical steering rack system was defective and needed to be replaced. The manufacturer was notified of the failure and referred the contact to the NHTSA to report the failure. The vehicle was not repaired. The failure mileage was approximately 88,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11651226March 28, 2025
ELECTRICAL SYSTEM, ENGINE, FUEL/PROPULSION SYSTEM
My car suddenly shut off when I came to a stop at a red light while on a busy state route. The information cluster then began to read “Fuel supply” and “Battery Discharge” My car would not turn back on and still has not turned back on since and it's been over a month now. According to the OBD results, the fuel pump and injectors were somehow seized and therefore have caused the car to become inoperable. I was forced to spend over $1000 just to get my car out of the police tow yard and towed to my home because I could not afford the cost of the repairs needed. The NHSTA website states that there is a recall on both the fuel system and the electrical system for my exact vehicle, but according to my Vin search results, there are 0 recalls. That doesn't make sense. I had just got my new inspection done maybe a month prior to my car breaking down.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11649879March 22, 2025
ELECTRICAL SYSTEM
The car was parked overnight. In the morning around dusk , it spontaneously caught fire.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11647235March 9, 2025
ENGINE
2014 BMW 535i Oil housing filter started leaking oil into serpentine belt causing the belt to shred and snap then was sucked into the crankshaft causing the motor to seize. Car was towed to bmw dealership and was diagnosed with catastrophic engine failure resulting in $28,000 estimate for engine replacement. Then vehicle was towed to licensed BMW repair facility and was repaired for $15,000 engine replacement.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11645545February 28, 2025
FUEL/PROPULSION SYSTEM
Consistent fuel pump error code 2AAF
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to BMW 535i