Hood latch assembly corrodes making it impossible to open hood or service the vehicle.
No injuries · No fire · No crash
My SUV has a had the check engine light on from a failed battery cell for my 2021 grey Volvo XC60 recharge (VIN [XXX]). I have been without the electric functionality (to charge the hybrid car or use electric power) since mid December and waiting on a warranty part since Dec. 23, 2025. I have been told April 2026 and then August 2026 for this warranty issue that both the dealership and Volvo corporate have agreed is under warranty and needs replaced to make the car functional as intended. They claim the part as been backordered for the entire 8 months. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
No injuries · No fire · No crash
After backing up out of a parking space, the side mirror on the drivers side moves to an unpredictable position and does not return to its original position. This is potentially dangerous because the driver is not aware of this change in position, and when changing lanes may rely on mirror that is in a faulty position. This appears to be some sort of flaw in the logic that tilts the mirror down when backing up and returns to original position when the car is put back in drive. Regardless of whether I turn this feature on or off, the same malfunction occurs.
No injuries · No fire · No crash
The entire right ride of the car just stopped working. Back right door became permanently locked and could not open from outside or inside. When hitting lock/unlock buttons on key fob i) front passenger door would not lock/unlock and ii) right side mirror would not fold in/out. Blind spot monitor and TPMS said they needed service. Left side of car was fine and worked. Car would start normally. I checked all relevant fuses and none were blown. Then all of a sudden it all started working again. My fear is that in the heat of summer what if all doors became locked somehow and i did not have the key fob with the manual key? I have 2 children
No injuries · No fire · No crash
An intermittent electrical failure occurred to my wife causing my 2021 Volvo XC60 to stop and then later go into limp mode while driving. The service light went on immediately and was very startling to her and made it difficult for the drivers following as the car speed was significantly reduced/ I suspect limp mode though it was not on the dashboard. When I called Volvo and then brought the car in... it is a known issue to Volvo. They purposively produce a vehicle that is known for sunroof leaks which knowingly leads to electrical issues exposing their customers to harm. Volvo (Geely) inspected the car, found the electrical issues from the front interior to the battery compartment that had water over an inch deep. the VGM (Vehicle Gateway Module) was replaced and reloaded, all connectors were separate/dried and several had to be cut/spliced and rewired due to corrosion damage. Carpets were removed, the gasket was replaced, the front and rear sun roof drains were cleaned out. Aside from the safety concern the shrinking of the rubber gasket caused the issue. Not funny, but Volvo/Geely states that the repair now has a lifetime warranty after I was charged over $4,000 USD. The vehicle is only about 5 years old!!
No injuries · No fire · No crash