Volvo Car USA, LLC (Volvo Car) is recalling certain 2020-2021 S90, 2020-2022 S60, V60, XC60, XC90, and 2022 V90 plug-in hybrid vehicles. The high-voltage battery may experience a short circuit within the battery module when the battery is fully charged and the vehicle is parked.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2022 V60CC, XC60, and XC90 vehicles. During steering gear assembly, double screws may have been assembled on top of each other, which can cause a screw to fall into the gearbox housing.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 S90L, 2020-2021 XC60, and XC90 vehicles. An improperly welded rotor and shaft may separate within the integrated brake system.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2020 V90, XC60, S60, V60, V60CC, S90, V90CC, S90L, and XC90 vehicles. The low-pressure fuel pump can blow a fuse and fail.
Volvo Car of N.A., LLC (Volvo Cars) is recalling certain 2018-2020 XC60 vehicles. The nuts that secure the front wipers may not have been sufficiently tightened, possibly causing the wipers to not function properly.
On July 28, 2026, while driving my 2020 Volvo XC60 T8 Polestar Engineered, the vehicle repeatedly displayed “Hybrid system failure – Service required,” together with the check-engine light and hybrid/battery warning indicators. The warning repeatedly reappeared while the vehicle was being driven. I brought the vehicle to an authorized Volvo dealer, North Point Volvo, on July 30, 2026. The dealer diagnosed a fault in high-voltage battery cell module “B” and documented that the module requires replacement. Repair Order #522934 states that the replacement parts are on order with “NO ESTIMATED TIME OF ARRIVAL.” The dealer advised me that the vehicle was mechanically safe to drive as long as I did not charge it. Because the hybrid-system failure warning repeatedly appeared while driving and the diagnosed fault involves the high-voltage traction battery, I did not consider continued operation appropriate. The vehicle remains unrepaired at the Volvo dealer. I am reporting this because the failure involves the high-voltage propulsion battery and occurred while driving. I am not aware of any crash, fire, injury, or loss of propulsion associated with my incident.
No injuries · No fire · No crash
While in service at Volvo Cars Clear Lake for Recall R103312/ Campaign 25V-179, three of four hybrid battery modules failed on installation, yet Volvo refuses to replace the entire battery. This is a covered warranty repair that has not been completed, and the car has been out of service for more than 100 days. During part of that time, it was being stored outdoors with the battery removed and the floor open to the ground.
No injuries · No fire · No crash
Recall identified over a year ago during Q1 2025. Manufacturer and dealer have failed to provide appropriate updates for the repair, and no ETA has been given for repair. The only direction received from manufacturer and dealer was to not plug in the vehicle until the recall is completed. So as it stands, I paid for a plug in hybrid vehicle I haven’t been able to plug it in for over a year as it has a flawed hybrid system that apparently can’t be repaired.
No injuries · No fire · No crash
The seal on my 2020 Volvo XC60 moonroof allowed water to leak under the floorboards. My car is only 6 years old. We had a lot of rain over a short period and I noticed the sound of water sloshing around under the floor. Nothing was wet inside the car. My Check Engine light came on as well. I took it to the Volvo service dept. They are now saying wires are corroded and that it will cost me over $11,000 to fix this problem. Again - my car is only 6 years old, and less than 70K miles. With my previous Volvo, that I had for 18 years, I never had this problem.
No injuries · No fire · No crash
Volvo has failed to repair or compensate me for the NHTSA Recall 25V-179. I received a notification of te recall in a letter dated May 14, 2025. I have repeatedly visited the local dealership as well as called Volvo Customer Care. Today, in a conversation with a Volvo Customer Care representative, I was told there is no timeline for the batteries to be replaced. I would like Volvo to rectify the issue by replacing my battery or car in a timely matter. Thank you for your help, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
No injuries · No fire · No crash