Volvo XC60 Complaints (2023)

51 consumer complaints on file.

#11755690August 8, 2026
BACK OVER PREVENTION: WARNINGS, FORWARD COLLISION AVOIDANCE: WARNINGS, UNKNOWN OR OTHER
Entire car audio does not work. Blinker click, collision warning, navigation etc. Volvo has blamed software but each update in the past 3 years has not fixed the issue. Driving a car where the entire audio system is not working reliably is a safety issue
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11754657August 4, 2026
VISIBILITY/WIPER
The contact owns a 2023 Volvo XC60. The contact stated that while driving in a rainstorm, the front windshield wiper arm was striking the top of the hood of the vehicle. Due to the failure, the windshield was not properly cleared of the rainwater, causing a visibility hazard. The contact stated that the hood was damaged by the wiper arm striking the hood. The vehicle was taken to the local dealer, who replaced the wiper blades, but the failure reoccurred. The vehicle was taken to the local mechanic, who replaced the wiper arm, but over time the failure reoccurred. The cause of the failure was not yet determined. The manufacturer was not contacted. The failure mileage was 17,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11749979July 13, 2026
LANE DEPARTURE: BLIND SPOT DETECTION, LANE DEPARTURE: WARNING, ELECTRICAL SYSTEM
Loss of all audible components after start up (Infotainment system has Android Auto 5.1.17 system installed); no turn signal sound, no back up or lane departure audible alert. This is dangerous because the system can fail to confirm whether the turn signal is on or whether there is hazardous condition outside. Had to perform a complete system reboot to resolve the issue. The reboot is hazardous during driving condition as it is a distraction to the driver. This is issue has been happening on a persistent basis since the latest software update, the system needs to be rebooted two to three times a week, sometimes during driving.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11749140July 8, 2026
ELECTRICAL SYSTEM, BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING, LANE DEPARTURE: WARNING
After Volvo’s software update 5.1.17 was installed, all sound in the vehicle including all warning alerts, turn signals, stereo, etc. have no sound. If you reboot the system it MIGHT work, but it reverts back to not working once it is parked. Does not show any alerts when you’re close to an object. I have serious concerns about any of my safety systems working properly.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11747232June 29, 2026
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
The backup camera system on this vehicle is ineffective and creates a significant safety hazard. Rather than providing a clear view of what is behind the vehicle, the camera is aimed downward, displaying primarily the ground immediately behind the rear bumper and only about two feet beyond it. As a result, it does not provide visibility of approaching vehicles, pedestrians, cyclists, or other obstacles behind the vehicle. This severely limits the camera's usefulness when backing out of parking spaces or driveways, where cross traffic and pedestrians are the primary safety concern. Because the display shows so little of the area behind the vehicle, drivers cannot rely on it to safely reverse. Believing this was a defect specific to my vehicle, I brought it to a Volvo dealership on two separate occasions. Each time, I was told that the camera was functioning as designed and that its viewing angle was normal. If this is indeed the intended design, then the backup camera system is fundamentally inadequate and presents an unnecessary safety risk.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740327May 27, 2026
UNKNOWN OR OTHER
I repeatedly lost propulsion or shut down while driving. The vehicle would not shift into Drive or Reverse and would not move, although displays and lights remained powered. This occurred three times in approximately two weeks. One event occurred at approximately 55 mph. I had to call the police for help. This after Hudson Valley Property Maintence the two previous stalls had been fixed. Dealer performed software update/reinstall and test drove vehicle approximately 30 miles, but the same failure returned and vehicle required towing. This is a repeated highway-speed safety defect. This vehicle is a safety hazard, and I am afraid for my life. The first two tow truck drivers were not able to get it on a flatbed without dragging it which we chose not to do. It took a third tow truck driver with special equipment to lift the car and tow it. This process took five hours on the hottest day and alone while other cars were coming at me at 60 mph. I had to call the police for help. There was no police report filed. Just a quote to dispatch to send officers to control a dangerous situation. The toe was through Volvo roadside assistance.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740173May 26, 2026
UNKNOWN OR OTHER
While driving on the highway my navagation, internet, gps stopped working. An error came up on the dash saying "SOS emergency call system fault" We were not sure what was happening with the vehicle or if was safe to drive. We made an appointment with a Volvo service center. Volvo service center stated we would need to pay to have this diagnosed because the vehicle has a rebuilt title. The dealership wanted approx $800 just to look at the vehicle. This issue is a known defect in the 2023 Volvo XC60 B5. It was already recalled once for this exact issue. This is an ongoing safety issue - losing our navigation in the middle of the highway as well as the vehicles ability to automatically phone emergency help when required.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11730164April 9, 2026
EXTERIOR LIGHTING:TURN SIGNAL
See attached document for complaint.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11729489April 6, 2026
ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
3rd time driving our Volvo on the road and having the automatic emergency brake engage too early or in this instance, with no vehicle in front of us. We have been dealing with issues related to the safety systems and error messages in our Volvo related to “blind spot”, “automatic emergency braking”, and sensor failures or errors since having our vehicle leased since 2023. It has been in the shop MULTIPLE times to have sensors replaced only for errors to come back. Our system current says to clean the front sensors even though there is no debris on them. We also experienced this errors while driving 2025 loaner models with our vehicle in for repairs. We feel unsafe in our vehicle and can’t rely on the safety systems. We have also experienced the entire auto system failing in our car multiple times. This leads to any sounds system including emergency warnings to turn signals from not producing ANY sounds.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726529March 23, 2026
SERVICE BRAKES
Occasionally, when I put the car in reverse, the brakes do not activate. The pedal feels stiff and hard to push. But then if I let off the brake pedal, and reapply the brakes, the problem goes away. This puts me and my passengers at risk of an accident. I have not shown the problem to a dealer yet as the problem is intermittent. I have not seen any warning signs about this problem. I have owned the car for about 6 months, since September of 2025 and have seen the problem about 8 or 10 times.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721350March 2, 2026
CHILD SEAT:HARNESS RETAINER/CHEST CLIP
The contact owns a Nuna Car Seat, Model Type: Pipa Aire RX, Manufactured Date: March 06, 2024. The car seat was installed in a 2023 Volvo XC60. The contact stated while unbuckling the child out of the car seat, the straps used to latch the harness were loose. After the initial failure, the contact inspected the car seat harnesses several times while strapping the child into the car seat; however, the failure persisted. The contact reached out to the manufacturer several times before the contact was able to reach a representative. Once the contact was able to reach a representative, the contact was advised to take a video of the failure while driving and submitting the information and the contact declined the suggestion because the vehicle was unsafe. The contact also reached out to the manufacturer through email and was given a ticket number. The contact reached out to the company where the car seat was purchased and was informed that the one-year car seat warranty had expired. The contact disputed the claim because the failure had occurred less than one year after the purchase. The car seat was not repaired or replaced. The VIN was not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11715541February 4, 2026
ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, FORWARD COLLISION AVOIDANCE: WARNINGS
System/Component Malfunction: Systemic failure of the onboard computer (Infotainment/Connectivity Module) and Advanced Driver Assistance Systems (ADAS), specifically the Collision Avoidance/Auto-Braking system, Rear-view Camera (FMVSS 111 non-compliance), and the 12V Battery management system. All components remain in the vehicle and are available for inspection. Safety Risk: The vehicle exhibits frequent "phantom braking" where the emergency collision avoidance system abruptly activates without obstacles present, creating an immediate risk of collisions. Additionally, the "hands-on steering wheel" sensor malfunctions, triggering emergency stopping procedures while driving. The backup camera intermittently fails (black screen), causing a total loss of rear visibility. These issues lead to unpredictable vehicle behavior in high-speed traffic. Confirmation & Inspection: These issues began to be reported to an authorized Volvo dealer within the first year of ownership (2022-2023). Most recently, a total vehicle failure occurred due to a drained 12V battery, which the dealer service department confirmed was caused by a known software module defect. Despite multiple "software updates" by the manufacturer, the safety-critical ADAS malfunctions (phantom braking) have recurred three times in the last week following the most recent dealer service.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11703728December 8, 2025
VISIBILITY/WIPER
On Wednesday December 3, 2025 the front windshield wipers stopped working on my wife's 2023 Volvo XC60. The stalk to control the wipers was operating as normal. It was able to spray the windshield wiper fluid and operate the rear window wiper as expected. This happened that day that we received unexpected lake effect snow in our area. We immediately scheduled an appointment at dealership we purchased the vehicle from and dropped it off on Friday December 5, 2025. A few moments ago we received a call from the service department that there is an internal service bulletin regarding this issue. They explained that there is a process where they have to go back and forth with Volvo to diagnose the issue. They could not estimate when the issue would be resolved or what was the cause. The dealership was out of loaners, so they gave us an option to either wait or drive the vehicle and hope we don't get caught in bad weather until they can identify what is wrong with the wipers. This puts us in a very unsafe vehicle with no recourse. The safety of my wife, myself, and our child are put at risk because of this issue. There was a message that stated that the wipers failed initially on 12-3-2025, but that message never appeared again. This in itself is a safety issue. What if someone was renting the same vehicle when this occurred. The rental car company wouldn't know and they could rent the vehicle to a drive who wouldn't know.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11703702December 8, 2025
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Received recall notice, the dealer did software upgrade to 3.7. but still having issues. Error message "Camera is temporarily unavailable". Reported to Volvo dealer who stated they are aware of the problem but cannot fix because they are waiting for new software, expected Q4 2025. Recall was not fixed
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11695645October 26, 2025
LANE DEPARTURE: BLIND SPOT DETECTION, BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Manufacturer: Volvo Car USA LLC | Initial Failure Mileage: 15,000 DEFECT DESCRIPTION: The Google built-in Infotainment Control Unit (ICU) and Audio Control Module (ACM) are repeatedly crashing/malfunctioning while driving. This system failure is a safety hazard because it simultaneously disables critical features: * SAFETY SYSTEM FAILURE: The Rear Cross Traffic Alert (RCTA) is disabled, creating a high risk of collision when reversing. * LOSS OF AUDITORY WARNINGS: All essential auditory cues, including the turn signal click and parking sensor sounds, are lost as the speakers go silent. * Distraction: The screen goes black/unresponsive, requiring a dangerous manual reboot while driving. REPAIR HISTORY: The defect has been confirmed and documented by an authorized Volvo dealer (O'Steen Volvo) on two prior warranty attempts (6/18/24 & 12/19/24) but remains uncorrected. The dealer has admitted they have "no way to fix this" permanently. Corporate (Volvo Customer Care) has been notified. This is a recurring, safety-critical manufacturing defect. Most recent issue was 10/25/205
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11694979October 22, 2025
ELECTRICAL SYSTEM, VISIBILITY/WIPER
There has been at least 5 incidences where the audio stopped working for the turn signals, navigation stopped, radio stopped and air conditioning stopped. The first 2-3 times the system reset itself. The 4th incident I was driving in torrential rain, the wiper auto sensor stopped and every warning light on the dashboard lit up. As the rain dissipated, the system seemed to clear itself. Today, on my way to the dealership, the turn signal audio stopped, navigation stopped, radio stopped. The service advisor verified the situation. His response, per Volvo instructions, tell the customer to reset the system once a month. There's no written instructions to resolve the problem. The service advisor admitted this is an ongoing problem and corporate is making no attempt to resolve it. Is Volvo waiting for a life threatening situation before addressing the problem. I can't rely upon the computer system to function properly. Volvo has a responsibility to its car owners for supposedly being one of the safest cars on the road. This vehicle is becoming unreliable. Thank you.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11694759October 21, 2025
SERVICE BRAKES, STEERING, UNKNOWN OR OTHER
Driving the car at under 20 mph making a left turn into my cul-de-sac which has an upward slope. Car system thought it would crash into the tree straight ahead and started emergency braking making loud noise and then the steering wheels locked. Ended up hitting the parked car in front of neighbors house due to brake and steering malfunction. Heard from other Volvo owners that this has been a problem. Even backing out of garage where there is no object behind the car the car emergency braking system engages causing whiplash. No longer feel safe driving this car.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11683386August 27, 2025
UNKNOWN OR OTHER
The "p" button on the car malfunctions. It does not always engage when pressed. After I pressed the "p" button, the car didn't go into park mode and started to roll forward. This put me in danger as well as pedestrians who may have been walking down the street in front of the car. I notified the dealer and they did nothing. There were NO warning signs. Because of the failure of the "p" button to function properly, my car rolled into a parking meter and caused in excess of $4,000 in damages.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11682052August 21, 2025
ELECTRICAL SYSTEM
We’ve owned a couple of the XC60s from the new generation. We have had many conversations with Volvo and the dealership but they have yet to rectify the issue. What it all boils down to, is that Volvo put an underperforming center console in its new generation of cars (2016-2025). The console does not have enough memory to process everything it’s doing. As a result it locks up and either freezes or shuts off. The problem is the console operates everything in the car. When it fails everything goes dark including the dash. The safety features turn off and you are essentially driving blind. We have had this issue on so many of our cars: 2018 XC60 which was replaced with a 2019 XC90 to avoid lemon law. The 2019 xc90 had the issues. We have been leasing and are stuck in this cycle because Volvo refuses to address the hardware issue. Instead we are forced to either drive a car with a dead brain or trade in for another Volvo. Volvo keeps thinking it can solve the issue with software updates but that’s not true. They need to do a RAM upgrade for these cars. We know we are not the only ones with these issues and the advice of “just reboot” or “don’t use the apps” or “don’t use the crash mitigation features” does not work. We specifically picked Volvo for safety but enough is enough. Our car is undriveable and from our sample size alone 6 out of 6 new generation cars have had this issue. The console shutting down sometimes takes out the virtual cockpit too. Meaning no speed is displayed, the car may try to mitigate crashes erratically, the heating and cooling will also not function. To put it plainly, the car turns into a flying brick. I feel very fortunate that this has not caused a crash yet.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11672120July 8, 2025
SERVICE BRAKES, WHEELS
Yesterday, while driving on highway, I received a tire pressure warning for all four tires. I filled all tires to the recommended 35psi. The warning went away. Today, after I parked my vehicle, I saw a “parking brake service required” message on my dash. The “park” indicator on my dash started flashing. Now, I’m worried about a brake failure. I only mentioned the tire pressure warning bc I’ve never had multiple error messages like this before.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volvo XC60