Volvo XC40 Complaints

218 consumer complaints on file.

#11508568February 22, 2023
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL, SERVICE BRAKES, HYDRAULIC, AIR BAGS
The contact owns a 2022 Volvo XC40. The contact stated while dropping off her niece at school, the vehicle was at a complete stop with the brake pedal depressed; however, the vehicle accelerated unintendedly and drove over the pavement. The brake pedal was depressed but failed to respond. The vehicle crashed into the wall of the school and crashed into the school fence. The curtain air bags were deployed; however, the front driver's side air bag failed to deploy. The contact sustained pain in the right shoulder. The contact received medical assistance the following day. A police report was filed. The vehicle was towed to a tow lot. The manufacturer was notified of the failure and referred the contact to a Volvo Collision Center. The Volvo Collision Center took the vehicle to their location and informed the contact that they were awaiting a Volvo engineer to diagnose the vehicle. The vehicle was not diagnosed nor repaired. The failure mileage was approximately 7,000.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11504901February 1, 2023
AIR BAGS:SENSOR:OCCUPANT CLASSIFICATION:FRONT PASSENGER
The contact owns a 2019 Volvo XC40. The contact stated while driving at various speeds, while his wife was seated in the passenger’s side front seat using an orthopedic back support, the air bag warning light illuminated. The contact stated that while not using the back support, the air bag sensor worked as designed. The contact stated that his wife used the back support due to physical issues and had used the lumbar support cushion to ease pain. The contact drove the vehicle to a dealer who advised that the only way to stop the sensor from being deactivated by the lumbar cushion was deactivating the sensor which was illegal. The manufacturer had been informed of the failure. The vehicle was not repaired. The failure mileage was approximately 26,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11499437December 29, 2022
VEHICLE SPEED CONTROL, ELECTRICAL SYSTEM
When backing the vehicle out of a parking space on Wednesday, December 21, 2022, the vehicle lurched and moved very slowly. The center HUD displayed the message, "Slow Down. The Vehicle will reduce speed. Propulsion system failure." The vehicle was towed to the Volvo certified dealer in Roanoke VA. The technician "reset" the error code and released the vehicle to me. The dealership could not tell me if the vehicle was safe to drive. I called the dealership multiple times, and they stated the problem was being investigated by Volvo corporate. Still, no one can tell me if and the conditions the vehicle will begin its automatic deceleration protocol. I have a second report now from the dealership that the error must occur twice for them to investigate it more thoroughly. I feel fortunate that this occurred in a parking lot, and not while travelling at any speed in heavy traffic. Volvo online forums have been reporting this error since at least August 2022. https://www.xc40forum.com/threads/propulsion-system-failure.5150/ This is the second response from the dealership after I called today for progress: "–based on your DTC codes it appears you are referencing TJ-36309, CMA BEV IHFA Internal Processor Failure. At this time the concern has only occurred 1 time and has not returned after following the TJ. A software fix is still under development to prevent misdetection of these DTCs, as you stated. This TJ was only released last month, VCUSA is working towards a solution. However, if the codes return it signals further fault tracing is needed and we will have to evaluate the situation if it happens." This does not sound safe, and I thank you all for reading.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11498747December 24, 2022
SERVICE BRAKES
The vehicle has approximately 16,000 miles on it. It began to shudder in the front end when the brakes were applied at any speed. I contacted the dealer, Parkway Volvo of Wilmington, NC concerning the problem and was told that the vehicle had just gone out of warranty. On December 16, 2022, I took the vehicle to Derhams Alignment and Auto Repair, Wilmington NC to have the problem diagnosed. They found that the discs of the disc brakes on all four wheels were warped. They recommended replacement of these to repair the problem. Following this I took the car to Parkway Volvo on December 19, 2022, for a second opinion. Parkway came back with the same diagnosis and recommended that the discs be turned to straighten out the surface. I had this done at a cost of $420, and it repaired the problem. There is no reason that a vehicle with 16,000 miles should have warped discs unless it is abused, which this one has not been. I believe that the brake discs are made from inferior steel. I have been driving Volvos for over 20 years and the discs last well over 100,000 miles without an issue. I believe that Volvo is no longer using Swedish steel and instead importing the discs. The Volvo dealer made a number of excuses for the reason for the warping, one being that we have not used the car enough and/or that the electronic emergency brake warps the back discs if the car is parked to long. The car is garaged and parked on a level surface, without the emergency brake on. Also, this does not explain the front disc warping. I do not think that any of their excuses are reasonable, and I believe that Volvo should replace the discs with properly manufactured and safe ones without a charge. I am unable to find the receipt from Derhams Alignment at the moment, but would be glad to get a duplicate and submit it if you need it. Sincerely, Craig A. Wenger
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11498762December 24, 2022
SERVICE BRAKES
Earlier today I submitted a complaint, NHTSA Tracking Number 11498747. Would it be possible to send this back to me as I would prefer to modify it? Please do not post it now. Thanks, Craig Wenger [email protected] 910-471-7653
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11496420December 7, 2022
UNKNOWN OR OTHER
We were notified by email of a computer update to our 2023 Volvo XC40 Recharge (it stated it would automatically download the update then ask us to initiate the installation). The next day I was charging the car. The car is programmed for 1 pedal driving. After disconnecting the charger, I got into the car, put my foot on the brake, and placed the car in reverse. When I released the brake, the car just took off in reverse. It should not have moved until I pushed on the accelerator. I am theorizing that the car was either in the middle of the download or had just finished the download portion of the update. This problem persisted after I put the car in Drive. I drove about 2 blocks and parked the car. After about 10 minutes I put the car in Drive and it returned to the 1 pedal drive mode and the computer screen in the car showed a message that the update was ready for installation. The car drove normally for 20 miles to our house. We installed the update after arriving home. My wife drove the car the following morning. She experienced no further problems.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11495845December 2, 2022
VISIBILITY/WIPER, STRUCTURE:BODY, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
Had a cracked windshield, Volvo replaced with OEM. Another pin head size rock chip resulted in another cracked windshield. Google search will reveal the Windshield on the XC40 Volvo crack with the lightest contact. The glass has a defect and the crack interferes with driver visibility and driver assist functions
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11495468November 30, 2022
UNKNOWN OR OTHER
The GPS continues to stop working, it states it is "searching for GPS". It has been to the dealership three different times for this software malfunction with no resolution.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11489366October 15, 2022
STRUCTURE:BODY
See accompanying letter.Cracked panoramic sun roof, with no evidence convincing stone damage, people with similar issues , involving same model.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11487120September 29, 2022
AIR BAGS
Air Bags did not deploy when car hit another vehicle that failed to stop and DUI. Volvo was traveling at 35MPH and vehicle hit was traveling 35+. Vehicle is available for inspection at this time. Driver experiencing bodily injuries (neck, shoulders, back, ribs, and legs, etc. as well as affects of a concussion. I am not sure who to contact to inspect the vehicle. Please call me at 951-973-3035 or email me with who can help me with this. No warning prior to failure.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11484154September 12, 2022
UNKNOWN OR OTHER
1. What component: The doughnut spare tire is too small for my car 2. How was safety put at risk?: Since May 2022 I have had two flat tires. Both times I placed the spare on the car to drive it to repair. Both times the car, with the spare installed, could not travel faster than 8 MPH without the car shuttering and the traction system turning on and off as well as the low tire pressure staying on. 3. Has the problem been reproduced or confirmed?: No the dealer doesn't seem interest in helping with this. 4. Have the vehicle component been inspected by manufacturer, etc?: NO 5. Were there waring lamps?: See number two above.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11481319August 26, 2022
ELECTRICAL SYSTEM
The electrical system on my car apparently failed, which rendered the car unable to start and drive. Park Place Volvo claims that there is water, that penetrated the seals, from underneath the car. Although there were no visible signs of water, Volvo claims that the rain caused this issue. Volvo has refused to honor a warranty for the alleged defective seals, and sent my car to its collision center.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11478229August 8, 2022
UNKNOWN OR OTHER
Vehicle systems, navigation, entertainment, heating, a/c, defrosting are dependent on Internet connection. The Internet connection shows connection, but no systems are available. Vehicle is operable, but driver distraction increases 10 or 20 fold trying to do simple tasks such as defrost windshield. Rather than being available upfront, so to speak, items are hidden in layers of menus. Unlike other vehicles in which voice command is an internal function, on the Volvo this is an Internet function, rather like Amazon Alexa. This is an accident waiting to happen. To restart system requires exiting and locking/unlocking Vehicle. Dealer said fixed with software update. Update did not fix.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11477876August 5, 2022
UNKNOWN OR OTHER
Right (passenger side) rear window failed at highway speeds. Window shattered spreading small pieces of glass throughout car interior. No projectiles found in the debris, and no other vehicles were around when window shattered.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11476749July 31, 2022
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, LANE DEPARTURE: BLIND SPOT DETECTION, LANE DEPARTURE: WARNING
*We're experiencing constant phantom braking (sometimes multiple times within a day) with our vehicle on local roads as well as highways. Usually this occurs when we're approaching a vehicle in a turn lane, slowing down. Our blindspot sideview mirror lights light up when there is nothing present, even when we're in the outside lane against the curb - we have video to document this. The vehicle has also spontaneously turned off and then back on while in drive, in a turn lane. In addition, the dashboard and media center lighting sporadically dims down, making it difficult to see in bright light situations. *Whenever the phantom braking engages, it makes us vulnerable to being rear-ended. We're very lucky that this hasn't happened so far. The phantom side view mirror lights have created some panic situations where we didn't see a vehicle in the lane beside us and started to change lanes but swerved back into the lane we were in due to seeing the lights go on. Not being able to see the dashboard due to dimming of the lighting within poses obvious risks and spontaneous shut-down of the vehicle while in drive in a turn lane also makes us prone to being rear-ended. *The vehicle has been in service at Volvo of Naples, Florida for a combined time of about 30 days. The dealership put on 900+ miles on our car and claimed that they couldn't recreate the phantom braking or lighting situation. *We didn't experience any obvious issues with the car prior to the phantom braking, etc. We found that adaptive cruise control wasn't working but the dealership told us that our car doesn't have adaptive cruise control which seemed odd to us. We were under the impression that all cars at this level had adaptive cruise control. We're not sure whether to take them at their word.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11476431July 28, 2022
AIR BAGS
Driver was stuck on ice pulling into a driveway, car got traction and driver thought they were on the brake but was on the gas. The vehicle ran into the garage going 9.9 mph (we have the EDR) and the steering wheel airbag and knee airbags deployed. The knee airbag caused a significant compound fracture of the lower tibia and fibula. Accident happened on 1/20 and orthopedics tried to repair using bone grafts, rods and screws. She has been non weight bearing since then and now on 7/27 it has been recommended to amputate the lower leg.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11475403July 22, 2022
FUEL/PROPULSION SYSTEM
Very frequently (4-5 times a week) the charging cable will not release from the vehicle. Pushing release button resolves to flashing yellow, red, or green lights, but does not release. Sometimes will release from console, but not always. Locking and unlocking the vehicle, repeating all the above several times will eventually release the cable. This may be related to the erratic charging process where the car may or may not charge after being driven or left overnight. Dashboard may show initializing, or show that it is not charging when it is charging, or vice versa. Dealer stated could not duplicate, but software update would fix it. No code, no problem as they say in Sweden. Driving the 15 minutes home from the dealer resulted in the car failing to charge, and the cable refusing to release. This problem has been duplicated using a home Chargepoint charging system cable, and the supplied Volvo charging cable on two different 50amp outlets in the garage. The inability to remove the charging cable quickly in an emergency may lead to serious or even fatal consequences. A quick Google search shows that this is a known problem. There are other erratic system problems in the vehicle which by themselves may not be serious or fatal, but lead to increased driver distraction which could be serious or fatal.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11475194July 21, 2022
UNKNOWN OR OTHER, BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING
Backup camera fails intermittently at least a dozen times, error message "camera unavailable". Camera icon disappears from dash. Took to dealer. No code, no problem. Backed up and worked, did not understand intermittently?! Asked tech to report to Volvo, got push back. I advised I was reporting as safety failure to SaferCar and they report to Volvo. Suspect was not reported to Volvo. When camera fails other rear safety systems are inoperable.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11471863June 30, 2022
SERVICE BRAKES
The contact called on behalf of the mother who owns a 2021 Volvo CX40. The contact stated that the mother was driving approximately 25 MPH, when the brake inadvertently stopped the vehicle and the seatbelt tighten the driver into the seat. There was anti-lock brake light illuminated and a message about accident avoidance city safety. The vehicle was diagnosed at a local dealer with an unknown recall failure. The vehicle was repaired and software updated; however, the failure reoccurred while driving approximately 55 MPH. The vehicle was taken to the dealer again for a computer module update; however, failure reoccurred. The contact also experienced the same failure with the vehicle while driving. The manufacturer was notified of the failure. The approximate failure mileage was 5,250
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11471456June 28, 2022
LANE DEPARTURE: BLIND SPOT DETECTION
Blind Spot monitoring indicates a vehicle is in the blind spot area when no other vehicle is actually present. It has also failed to warn that a vehicle is actually in the blind spot when one was. On some occasions it just starts blinking erratically. I believe this is happening primarily on the driver side but I an not sure that it is not an issue on the passenger side as well. The date provided below of the incident represents the most recent time this event has happened but note it has happened multiple times. The photo provided shows the warning indicator lit but no vehicle in the area. I have additional phots if you would like them please just let me know.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volvo XC40