Volvo Car USA, LLC (Volvo Car) is recalling certain 2021-2025 XC40, 2022 V90, 2022-2024 C40BEV, 2022-2025 S90, V90CC, XC60, 2023-2025 S60, V60, V60CC, XC90, and 2025 EC40, and EX40 vehicles. The rearview camera image may not display when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Volvo Car USA, LLC (Volvo Car) is recalling certain 2023 Volvo C40 BEV, 2025 EC40, 2023-2024 XC40 BEV, 2020-2026 XC90 PHEV, 2022-2026 XC60 PHEV, 2023-2025 S60 PHEV, 2024-2025 V60 PHEV, and 2025-2026 EX40 and 2025 S90 PHEV vehicles. In certain driving scenarios while coasting down a hill and using "B" mode or "One Pedal Drive," the vehicle may lose brake function.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021-2025 XC40, 2022 V90, 2022-2025 S90, V90CC, C40, XC60, 2023-2025 S60, V60, V60CC, XC90, and 2025 EC40 and EX40 vehicles. The rearview camera image may not display when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Volvo Car USA, LLC (Volvo Car) is recalling certain 2024 XC40 vehicles. A diagnostic error in the Central Electronic Module (CEM) software may cause the left rear turn signal indicator to not function.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2023 S60, V60CC, XC60, XC90, XC40, and C40 vehicles. A diagnostic trouble code (DTC) may be falsely detected for the emergency call system (e-call) and display "e-Call Service Required" in the driver information module (DIM).
Liquid intrusion in the center console from a routine cup holder spill penetrated unshielded wiring harnesses. This caused progressive electrical failures, including loss of engine power and power steering, failure of the SRS passenger airbag occupant sensor, 12V battery drain, and uncommanded movement of the power driver's seat while driving—which surged forward and pinned the driver against the steering wheel. Dealer repairs are approximately $5,000 to date with active hazards remaining
9/4/26: 2023 Volvo XC40 Recharge made an uncommanded collision-avoidance correction at a dead stop. No obstacle ahead, no driver input. No crash/injury. Two prior false alerts (8/25, 8/27). Reported to Volvo Cars Danvers 9/15/26; no finding.
No injuries · No fire · No crash
Sometimes when I start the car, the infotainment has no sound and I have to reboot it. This affects maps, blinkers, safety, anything using audio. When I reboot I lose access to all audio and video in the car. This happens a couple times a month. Sometimes I don’t notice it until I’m already under way.
No injuries · No fire · No crash
I was pulling into a parking space at very low speed and was in the final stage of positioning the vehicle in the parking space. I was intentionally controlling the vehicle’s movement by gradually lifting my foot from the brake pedal. Instead of continuing to move forward slowly as expected, the vehicle suddenly accelerated forward with substantial force and speed greater than would be expected from simply releasing the brake pedal, and crashed into a cement wall. I did not intentionally press the accelerator or attempt to accelerate the vehicle. The collision caused substantial damage to the vehicle. The repair estimate is $14,644.25. The vehicle was NOT in cruise control. The Volvo-installed rubber floor mats were securely attached to the factory retaining pegs on the floor and were not loose or displaced. The vehicle’s Forward Collision Avoidance system did not engage or provide an automatic braking intervention before the vehicle struck the cement wall. The airbag did not deploy. The seat belt did not lock into place during the crash. I am submitting this complaint because the vehicle was being maneuvered at extremely low speed during a parking maneuver and unexpectedly accelerated forward with sufficient force to cause a collision with a cement wall, and resulted in significant vehicle damage. I am concerned that this may represent a safety defect. I request that NHTSA investigate whether this incident is part of a broader pattern involving the 2023 Volvo XC40 B5 mild-hybrid, including accelerator/throttle system, brake system, transmission, electronic controls, sensors, software, or communication between these systems. And consider examination of the vehicle’s electronic data, including accelerator-pedal position, brake-pedal position, throttle commands, engine-control-module data, transmission commands, brake-control-module data, diagnostic trouble codes, freeze-frame/event data and relevant software versions immediately preceding the collision.
Vehicle is starting up in the middle of the night. Not plugged in. Not updating! Has occurred at least twice that I know of. Checking the app shows no remote start. No activity! I am concerned about fire danger! Checking the app the vehicle software has not been updated since June/26.
No injuries · No fire · No crash