Volvo S60 Complaints

1,272 consumer complaints on file.

#11090018April 25, 2018
EXTERIOR LIGHTING
THE PASSENGER SIDE LIGHT WORKS INTERMITTENTLY THIS HAS BEEN A SLIGHT ISSUE SINCE 2006 WHEN I HAVE HAD NEW LIGHTS INSTALLED ON A REGULAR BASIS. DESPITE ME GOING TO THE DEALER FOR OVER THE LAST 11 YEARS OR SO IT IS ONLY GETTING MORE FREQUENT IN AGE. IT IS NOT THE BULB BUT THE WIRING IN THE VEHICLE THAT IS FAULTY. THIS CAN BE DANGEROUS ESPECIALLY WHEN COMBINED WITH THE FOG THAT THE LIGHTS HAVE PUT ON THE GLASS OVER THE YEARS. I HAVE PAID TO HAVE THE FOG REMOVED TWICE AND THE WIRING HARNESS CHECKED. AFTER LIVING IN 5 DIFFERENT STATES I SEE THIS IN ALMOST EVERY S60 IN THE MID 2000 ALWAYS ONE HEAD LIGHT OUT. IT WILL COME BACK ON WHEN YOU ENCOUNTER A BUMP SO IT IS A MISSED CONNECTION AT SOME POINT IN THE WIRE HARNESS. THIS CREATES SUCH LIMITED VISION IN NIGHT AND I AM CONSTANTLY GETTING HONKED AT. I HAVE PULLED OVER AND JIGGLED THE WIRES WHICH WILL ALLOW THE LIGHT TO WORK UNTIL YOU TURN A CORNER, HIT A BUMP OR IT JUST FADES. I BELIEVE THE HEADLAMPS SHOULD ALL BE REPLACED AND THE WIRING FIXED THIS IS SUCH AN ISSUE IN THE EVENINGS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11089975April 24, 2018
ELECTRICAL SYSTEM, ENGINE
CAR DID NOT INDICATE LOW OIL PRESSURE AT ANY TIME. ENGINE SEIZED AND STALLED ON FREEWAY CREATING DRIVING HAZZARD. CAR WAS IN MOTION AT APPROX. 65 MPL, STARTED SHAKING AS IF A TIRE HAD BLOWN. CAR STARTED TO SMELL LIKE BUNED OIL, STALLED AND WOULD NOT RESTART. THE ONLY ALERT THAT CAME ON WAS THE LOW BATTERY ICON AFTER THE MOTOR SEIZED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11089768April 23, 2018
UNKNOWN OR OTHER
ECO FRIENDLY SOY BASED MATERIALS USED FOR WIRING ATTRACTS RODENTS AND RESULTS IN MODERATE TO SEVERE DAMAGE. HAD MY CAR "EATEN" BY SQUIRRELS TWICE IN 3 MONTHS, THE FIRST TIME THE DAMAGE WAS AROUND $300, THE SECOND $2500! I HAVE NO GUARANTEE THAT THIS WONT HAPPEN AGAIN, IN FACT IT LIKELY WILL BECAUSE THE WIRE CASING IS STILL SOY BASED!!!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11089213April 21, 2018
ELECTRICAL SYSTEM
THE HEATER/AIR CONDITIONER BLOWER FAN DOES NOT WORK. THIS IS NOT A BLOWN FUSE, YET A POSSIBLE BLOWN RESISTOR AND/OR FAILED BLOWER MOTOR. THIS VEHICLE IS 5 YEARS OLD AND HAS 72K MILES; I CANNOT GET HEAT OR AIR CONDITIONING DUE TO THIS ISSUE; WINDOWS ARE FOGGED OFTEN, WHICH REPRESENTS A HAZARDOUS/SAFETY ISSUE. REPLACEMENT OF THE HEATER BLOWER MOTOR AND/OR RESISTOR REQUIRES THE REMOVAL OF THE DASHBOARD AND INSTRUMENT CLUSTER. THIS SHOULD NOT HAPPEN ON ANY 5 YEAR OLD VEHICLE, MUCH LESS A VOLVO. THE REPAIR IS EITHER VERY COSTLY, AT LEAST $700 TO $1100 OR TIME CONSUMING IF I DO IT MYSELF. THAT IS SEVERAL CAR PAYMENTS WORTH FOR A PART THAT SHOULD NOT HAVE FAILED. I HAVE OWNED TWO OLDER VOLVOS (1972, 1986) AND THIS PART NEVER FAILED--AND IF IT DID, THE ACCESS WAS MUCH EASIER (BEHIND THE GLOVEBOX).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11088658April 17, 2018
ENGINE
TL* THE CONTACT OWNS A 2012 VOLVO S60. THE CONTACT STATED THAT THE ENGINE SEIZED WITHOUT WARNING WHILE DRIVING 45 MPH. THE VEHICLE WAS TOWED TO MCGRATH VOLVO CARS BARRINGTON (300 MN HOUGH ST, BARRINGTON, IL) WHERE IT WAS DIAGNOSED THAT THE ENGINE FAILED DUE TO THE OIL BEING FOUR QUARTS LOW. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 13V592000 (ENGINE AND ENGINE COOLING) AS A POSSIBLE CAUSE OF THE FAILURE. THE FAILURE MILEAGE WAS 125,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11085130April 15, 2018
WHEELS, TIRES
I WAS SOLD THIS CAR BY VOLVO OF NORTH MIAMI ON 4/11/18. I HAD TO TAKE THE CAR FOR SERVICE ON 4/13 DUE TO OTHER REPAIRS THEY DID NOT TAKE CARE OF UNDER WARRANTY TO GUNTHER VOLVO , DELRAY BEACH , FLORIDA. I WAS TOLD I SHOULD HAVE NEVER BEEN ALLOWED TO DRIVE THE CAR OFF THE LOT DUE TO THE CONDITION OF THE TIRES THAT WERE EXTREMELY DANGEROUS AND COULD HAVE CAUSED A SERIOUS ACCIDENT AND AFFECTED OTHERS. I WAS TOLD BY RICKY MENENDEZ WHO SOLD THE CAR THAT ALL THERE CARS ARE INSPECTED THOROUGHLY BEFORE BEING SOLD.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11079753March 16, 2018
AIR BAGS, ELECTRICAL SYSTEM, SEATS
SERVICE LIGHTS SCROLL IN SPORADIC MOTION FLIPPING THROUGH CONSTANT ALERTS, CHECK ENGINE LIGHT, AIR BAG LIGHT, CONSTANT ELECTRICAL PROBLEMS GOING ON, FUEL DOOR WONT OPEN, BOTH FRONT SEATS HAVE ELECTRICAL PROBLEMS, OBVIOUS BURN THRU ON PASSENGER SIDE INDICATES ITS BEEN OVERHEATED AND DANGEROUS. EVERYTIME I'VE TAKEN IT IN THE SHOP THEY SAY THERE ARE NO RECALLS - YET PLENTY OF COMPLAINTS OVER FIRES WITH SEATS. CAN'T USED HEATED SEATS AT ALL. ENGINE SEEMS TO REMAIN INCONSISTENT IN SPEED, DASHBOARD LIGHTS GO COMPLETELY OUT AND THE ELECTRICAL ISSUES AFFECT BACK BRAKE LIGHTS. THE ELECTRICAL ISSUES BOUNCE IN CYCLES TO WHERE NO ONE CAN DETECT THE PROBLEMS. CHECK ENGINE LINE CONTINUES TO HAVE TO BE RESET AND SERVICE LIGHTS CONTINUALLY SEND SCROLLED WARNING TO PULL OVER. ALREADY HAD VEHICLE TOWED AND CAN'T TRUST VEHICLE WILL START. ALWAYS A WIRING ISSUE INVOLVED. THE CAR IS IN THE SHOP NOW AGAIN. 3/16/18 (SAME ISSUES)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11075638March 1, 2018
ENGINE
VOLVO HAS AN INTERNAL SERVICE RECALL FOR THEIR ENGINE OIL SENSORS. THE INFORMATION CAN BE FOUND HERE: THEY HAVE STATED THAT THEY FIXED THE SENSOR IN MY VEHICLE; HOWEVER, I STILL EXPERIENCED THE EXACT PROBLEM DESCRIBED IN THE SERVICE RECALL. MY CAR SHOWED 0 ENGINE OIL LIGHT READINGS, BUT MY ENGINE SEIZED UP IN THE MIDDLE OF THE INTERSTATE. HAD OTHER VEHICLES BEEN AROUND, I WOULD HAVE SURELY BEEN IN AN ACCIDENT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11073999February 21, 2018
UNKNOWN OR OTHER
SPONTANEOUS EXPLOSION OF OVERHEAD SUNROOF WHILE DRIVING. CAR WAS PURCHASED NEW IN SEPTEMBER 2017 AND ONLY HAS 10,000 MILES OF IT. THE SUNROOF HAD NO SCRATCH, DENTS, OR CHIPS - DEFINITELY NO REASON TO SUGGEST THAT IT MAY LITERALLY EXPLODE OUTWARD OVER MY HEAD WHILE DRIVING DOWN THE INTERSTATE. AT THE TIME OF THE INCIDENT I WAS ACTUALLY ON THE PHONE WITH MY MOM AND THE EXPLOSION WAS SO LOUD THAT SHE THOUGHT I HAD WRECKED MY VEHICLE DOWN AN EMBANKMENT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11067193February 6, 2018
STEERING
BD44 SRS AIR BAG TRIM HAS BECOME LOOSE ON THE BACK OF THE STEERING WHEEL RESULTING IN A SHARP HARD PLASTIC BEING EXPOSED RESULTING IN THE DRIVER CUTTING HIS FINGER ( DRAWING BLOOD) WHILE DRIVING ON THE HIGHWAY. SIGNIFICANTLY DISTRACTED THE DRIVER AS HE REMOVED ONE HAND FROM THE WHEEL IN RESPONSE TOM THE CUT. APPARENTLY THE GLUE FOR THE TRIM IS INADEQUATE TO KEEP IT SAFELY SECURED.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11064892January 25, 2018
SEATS
HEATED SEAT SHORTED WHEN TURNED ON ON DRIVERS SIDE AND BURNED ME WHILE DRIVING.
Crash:
No
Fire:
Yes
Injuries:
1
Deaths:
0
#11064240January 22, 2018
SERVICE BRAKES
THIS IS AN ADDITIONAL COMPLAINT REGARDING THE SAME VEHICLE BRAKE PROBLEM FILED UNDER NHTSA SAFETY ISSUE ID 10979689. ON 15 DEC THE SAME VOLVO FAILED TO STOP AT A RED LIGHT ON A CITY STREET IN DRY PAVEMENT CONDITIONS. THE ONLY WAY TO STOP THE VEHICLE WHILE TRAVELING AT APPROXIMATELY 35 MPH WAS BY CONTINUING TO HOLD THE BRAKE PEDAL ALL THE WAY DOWN AND THEN SLAMMING THE GEARSHIFT FROM DRIVE INTO PARK. THE VEHICLE WAS SUBSEQUENTLY TOWED BACK TO THE LOCAL DEALER. WHEN THIS VEHICLE WAS AT THE DEALER THEY DRAINED THE BRAKE LINES AND CHANGED THE MASTER BRAKE CYLINDER BASED ON THIS FIX REPORTEDLY WORKING ON ANOTHER S60 WITH THE SAME PROBLEM ACCORDING TO VOLVO TECH SUPPORT. AFTER EIGHT MONTHS THE BRAKES FAILED AGAIN. VOLVO HAS A BRAKING PROBLEM ON THESE VEHICLES AND DOES NOT NO THE CAUSE NOR THE CORRECTIVE ACRION.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11063666January 19, 2018
ENGINE
AT AROUND 51,000 MILES, THE OIL PRESSURE LIGHT BLINKED. WE CHECKED THE OIL AND FOUND THAT WE HAD TO ADD 5 QUARTS ON 11/5/2017. VOLVO ADDED ANOTHER QUART ON 12/26/2017. WE ARE CONCERNED ABOUT THE OIL USAGE AND SAFETY, AND ARE KEEPING IN CONTACT WITH OUR VOLVO DEALER TO SEE IF THIS CONTINUES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11062096January 11, 2018
STEERING
THE METAL TRIMMING ON THE STEERING WHEEL IS FRAYED. IT CUTS MY HANDS WHEN THE STEERING WHEEL TURNS.
Crash:
No
Fire:
No
Injuries:
4
Deaths:
0
#11061411January 9, 2018
ENGINE, FUEL/PROPULSION SYSTEM, UNKNOWN OR OTHER
EXCESSIVE OIL CONSUMPTION - BURNING OR CONSUMING AT LEAST 5 QUARTS OF OIL EVERY 2K-3K MILES, BETWEEN OIL CHANGES. OUR ONLY NOTICE IS WHEN OIL IS BELOW 5-QUART RANGE, WHEN WE RECEIVE A DASH WARNING NOTING TO STOP ENGINE. CAR HOLDS 7.25 QUARTS OF SYNTHETIC OIL. WELL KNOW DOCUMENTED THROUGHOUT THE WEB AND KNOWN TO VOLVO MECHANICS, ALTHOUGH MORE RECOGNIZED WITH 2011-2012 S60. STOP ENGINE NOTICE RECEIVED WHEN STARTING CAR. FORTUNATELY ABLE TO UBER TO AUTO SUPPLY AND ADD 5QUARTS TO DRIVE HOME. OCCURRED ON TWO OCCASIONS, WHEREIN THE SECOND INSTANCE WE RESEARCHED, REACHED OUT TO VOLVO MECHANICS AND IN THE PROCESS OF CONTACTING DEALER AND VOLVO FOR FOLLOW-UP. IT APPEARS THAT SEVERAL INSTANCES HAVE RESULTED IN ENGINE FAILURE AND/OR $5K OR MORE IN PERSONAL COST TO FIX PISTON/VALUE ISSUE OR REPLACE ENGINE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11057798December 31, 2017
UNKNOWN OR OTHER
WHILE DRIVING DOWN THE FREEWAY, THE SUNROOF OF THE CAR SPONTANEOUSLY EXPLODED RAINING BROKEN GLASS INTO THE CAR. THERE WAS NOTHING ABOVE THE CAR AT THE TIME THE SUNROOF EXPLODED (I.E. AN OVERPASS WHERE SOMETHING COULD HAVE FALLEN) NOR WERE THERE OTHER VEHICLES NEAR BY THAT COULD HAVE KICKED A ROCK OR OTHER OBJECT THAT COULD HAVE BROKEN THE GLASS. FURTHER, AFTER PULLING OFF THE ROAD TO EXAMINE THE DAMAGE, THE GLASS HAD EXPLODED OUTWARD, AWAY FROM THE CAR RATHER THAN INWARD, AS WOULD BE EXPECTED IF SOMETHING LIKE A ROCK HAD HIT THE GLASS AND BROKEN IT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11057659December 30, 2017
STEERING
A METAL SILVER PIECE ON STEERING HAS A SHARP EDGE THAT RESULTED IN A CUT ON FINGER WHILE DRIVING. THE VEHICLE WAS IN MOTION AND TURNING.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11055128December 17, 2017
UNKNOWN OR OTHER
BACK DOOR ON DRIVERSIDE WILL NOT LATCH SOMETHING ELECTRICAL IS GOING ON I HAD TO TIE THE DOOR UP JUST TO DRIVE ANYWHERE
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11047380November 20, 2017
ENGINE, POWER TRAIN
WITH LESS THAN 50,000 MILES ON IT, MY S60 JUST COMPLETELY STOPPED WORKING ON MY WAY TO WORK. WHILE PULLING OUT OF MY DEVELOPMENT, THE ENTIRE ENGINE, POWER STEERING - EVERYTHING SHUT DOWN. I HAD TO COAST INTO A TURNING LANE TO PUT ON MY FLASHERS. I HAD NOT GONE MORE THAN 3 MINUTES FROM MY HOUSE. AFTER VOLVO HAD IT FOR A FEW DAYS THEY TOLD ME THAT THE ALTERNATOR BELT HAD JUMPED OFF, HITTING THE ALTERNATOR, FRAYING THE BELT. THIS THEN RESULTED IN THE BELT WRAPPING AROUND ANOTHER PART OF THE ENGINE IMPACTING THE DRIVE BELT. THIS RESULTED IN DAMAGE TO THE DRIVE BELT, ALTERNATOR, 1/3 OF MY ENGINE AND MY CYLINDER BLOCK. VOLVO IS BLAMING THIS ON A FAULTY BELT TENSIONER, YET THEY ARE MAKING ME PAY FOR PART OF THE REPAIR WHICH IS A TOTAL COST OF $6,000. THIS IS CLEARLY A DEFECTIVE PART - EITHER IT WAS INSTALLED INCORRECTLY OR IT WAS NOT PROPERLY BUILT AS A BELT DOES NOT JUST "JUMP". I WAS LUCKY THAT I HAD NOT YET GOTTEN ONTO THE HIGHWAY OR I WOULD HAVE BEEN INJURED ALONG WITH OTHER PEOPLE IF NOT WORSE. THIS IS A HUGE SAFETY CONCERN AND VOLVO DOES NOT SEEM TO WANT TO ADMIT COMPLETE FAILURE HERE. THIS CAR HAS BEEN SERVICED REGULARLY AND AT THE SAME DEALERSHIP.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11043656November 6, 2017
FUEL/PROPULSION SYSTEM
FUEL LEAK FIRE HAZARD WON'T PASS INSPECTION. GAS SMELL. CAR LEAKING WHILE PARKED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volvo S60