Volvo S40 Complaints

491 consumer complaints on file.

#10512425May 16, 2013
ELECTRICAL SYSTEM
I WAS IN THE INTERSECTION READY TO MAKE A TURN WHEN THE CAR SUDDENLY STALLED ALL THE DASH DISPLAY LIGHTS WENT OUT ALL GAUGES STOPPED WORKING AND THE WINDSHIELD WIPERS WOULD NOT GO OFF WHEN I TRIED TO RESTART THE CAR THE DASH SUDDENLY DISPLAYED BRAKE FAILURE PULL OVER SAFELY, AND IMMOBILIZER CHECK MANUAL AND THE CAR WOULD NOT START IT HAD TO BE PUSHED ACROSS THE INTERSECTION AND IT HAS BEEN SITTING IN A PARKING LOT SINCE THEN WAITING TO BE TOWED THIS HAS HAPPENED ON 3 DIFFERENT OCCASIONS SINCE I BOUGHT THE VEHICLE THIS PROBLEM NEEDS TO BE FIXED AT COMPANY EXPENSE EACH TIME I HAVE BEEN FORTUNATE ENOUGH TO BE IN A PARKING LOT OR A PUBLIC STREET BUT ON THE LAST INCIDENT I WOULD'VE BEEN ON THE FREEWAY. I HOPE SOME ONE WILL CALL OR CONTACT ME TO RECTIFY THIS ISSUE I LOVE THE VOLVO BRAND BUT GOING THROUGH THIS MAKE NOT WANT TO CONTINUE ON WITH ANY OTHER MODEL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10509612April 25, 2013
SERVICE BRAKES, ENGINE
I WAS STOPPED AT A RED LIGHT BEHIND SEVERAL CARS. THE LIGHT TURNED GREEN AND I TOOK MY FOOT OFF THE BRAKE, BUT DID NOT PUT MY FOOT ON THE ACCELERATOR. THE CAR ENGINE REVVED UP AND LURCHED FORWARD DESPITE ME ATTEMPTING TO BRAKE HEAVILY. THE BRAKES WOULD NOT FULLY DECOMPRESS CAUSING ME TO REAR END THE VEHICLE IN FRONT OF ME. I PURCHASED THE CAR USED WITH 134,100 MILES. I NOTICED ABOUT 5 MONTHS AFTER PURCHASE THAT THE ENGINE WOULD REV AND THE RPM'S WOULD REMAIN HIGH WITHOUT PRESSING ON THE ACCELERATOR AND THE CAR WILL MOVE APPROXIMATELY 10-15 MPH WITHOUT PRESSING ON THE ACCELERATOR. WHEN ROADS ARE WET OR WHEN IT HAS BEEN RAINING, THE CAR IS DIFFICULT IN BRAKING AND THE BRAKES OFTEN "FREEZE" WHERE THE BRAKE PEDAL CANNOT BE DEPRESSED. BRAKES WERE REPLACED, BUT THE ISSUE PERSISTS. ALSO, AT TIMES, THE CAR ENGINE CONTINUES TO REV WHEN PRESSING ON THE BRAKES. LASTLY, THE ENGINE LIGHT CAME ON, IT WAS INDICATED VIA A DIAGNOSTIC TEST THAT THERE WAS A MISFIRE WITH ONE OF THE SPARK PLUG COILS. ALL SPARK PLUGS AND COILS/IGNITION COILS WERE REPLACED, ENGINE LIGHT PERSISTED. AT THE TIME THE TEMP SENSOR AND THE THERMOSTAT WAS REPLACED AS THE IGNITION COILS AND SPARK PLUGS DID NOT ALLEVIATE THE ISSUE. WHEN A FOLLOWING DIAGNOSTIC TEST WAS PERFORMED INDICATED THAT THE COOLANT TEMP SENSOR HAS LOW VOLTAGE. SOMETIMES THE CAR ENGINE WILL TURN, BUT THE CAR WILL NOT FULLY TURN ON AND I NEED TO WAIT ABOUT 10 MINUTES (OR UNTIL THE FAN TURNS OFF) BEFORE BEING ABLE TO ATTEMPT TO START THE CAR. DUE TO THE ISSUES WITH THE CAR, THE CAR CANNOT GET AN INSPECTION STICKER, AND IT DOES NOT SEEM SAFE TO DRIVE. DUE TO MASSACHUSETTS CAR LAWS, WE CANNOT SELL THE CAR DUE TO LEMON LAW AND THE CAR IS WORTH MORE THAN SCRAPING. WE ALSO HAD A BROKEN AXEL AND COIL THAT WERE REPLACED AFTER HITTING A POTHOLE. *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10509079April 22, 2013
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2006 VOLVO S40. THE CONTACT STATED WHENEVER THE AIR CONDITIONER WAS ACTIVATED, HOT AIR EMITTED THROUGHOUT THE VENTS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS. THE TECHNICIAN STATED THAT THE FAILURE WAS CONTRIBUTED TO THE AIR COMPRESSOR. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 55,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10509003April 21, 2013
ENGINE, WHEELS
MY CAR VIBRATES WHENEVER I REACH 60 MPH AND CONTINUES TO VIBRATES IF I TRY TO ACCELERATE BUT STOPS WHEN I DECELERATE. I WAS TOLD IT COULD BE A BALANCE PROBLEM BUT WHY WOULD THE WHOLE CAR VIBRATE? I WAS ALSO TOLD IT MAY BE WORN OR OLD MOTOR MOUNTS, WHICH I BELIEVE THAT MORE THAN IT BEING A BALANCE PROBLEM. I JUST NEED TO KNOW FOR CERTAIN SO I KNOW WHAT TO HAVE REPLACED AND HOW MUCH I MAY HAVE TO SPEND. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10505181April 1, 2013
VEHICLE SPEED CONTROL
WHILE DRIVING ON THE HIGHWAY I SET CRUISE CONTROL TO 65. WITHIN SECONDS I FELT AS IF I WERE GOING VERY FAST AND I HAD ACCELERATED TO NEAR 90 MPH. I TURNED CRUISE CONTROL OFF, STEPPED ON THE BRAKE AND WHEN I LET OFF THE BRAKE THE CAR BEGAN TO ACCELERATE AGAIN. AFTER THE SECOND TIME STEPPING ON THE BRAKE THE PROBLEM CEASED. THE SAME TYPE OF INCIDENT OCCURRED AGAIN, ONLY THIS TIME CRUISE CONTROL WAS NOT INVOLVED. STOPPED AT A RED LIGHT, I STEPPED ON THE ACCELERATOR TO MAKE A RIGHT HAND TURN, THE RPMS IMMEDIATELY JUMPED AND MY CAR ACCELERATED VERY QUICKLY. I STEPPED ON THE BRAKE AND AFTER A FEW SECONDS THE ISSUE RESOLVED ITSELF. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10503691March 19, 2013
ELECTRICAL SYSTEM
THIS CAR HAS DEVELOPED AN ELECTRICAL PROBLEM WHERE THE DASH LIGHTS START FLICKERING ON AND OFF DISPLAYING VARIOUS FAILURES ON THE DASHBOARD DISPLAY, LIKE IMMOBILIZER FAILURE AND CRASH MODE AND VARIOUS OTHER WARNINGS. AT THE SAME TIME, THE RADIO CUTS OUT AND AN AUDIBLE "CLICKING" IS HEARD UNDERNEATH THE DASH BOARD. ON SEVERAL OCCASIONS THE VEHICLE HAS STALLED OUT COMPLETELY WHILE DRIVING CAUSING A DANGEROUS DRIVING CONDITION AND I HAVE HAD TO COAST TO THE SIDE OF THE ROAD WITHOUT POWER STEERING OR POWER BRAKES. SOMETIMES THE VEHICLE WILL START BACK UP, OTHER TIMES IT SIMPLY WON'T CLICK OR TURN OVER AT ALL. I FEAR AN INCIDENT WHERE THE STEERING COLUMN WILL LOCK AUTOMATICALLY WHEN THE VEHICLE DIES, AS THE STEERING COLUMN IS UNLOCKED BY THE IMMOBILIZER KEY FOB TO INITIALLY START THE CAR. IF THIS WERE TO OCCUR I FEAR THIS COULD CREATE AN UNSAFE CONDITION FOR THE OCCUPANTS OF THE VEHICLE AND OTHERS MOTORISTS OR PEDESTRIANS. I HAVE JUST HAD TWO NEW REMOTES PROGRAMMED TO THE VEHICLE AND THIS PROCEDURE WAS PERFORMED AT WEISS BRENTWOOD VOLVO IN ST. LOUIS MISSOURI. I HAVE OWNED THIS VEHICLE FOR ONE WEEK PRIOR TO TAKING THIS CAR TO WEISS VOLVO WITHOUT ISSUE AND THIS PROBLEM ONLY AROSE SINCE THIS SERVICE WAS PERFORMED AT WEISS VOLVO. THE PREVIOUS OWNER TOLD ME THIS PROBLEM DID NOT EXIST PRIOR TO THE SALE OF THE VEHICLE. *TR .... UPDATED 08/05/14 *BF
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10496925February 8, 2013
ELECTRICAL SYSTEM
I RETURNED TO MY CAR AND FOUND THAT I COULD NOT TURN THE IGNITION SWITCH AND AS A RESULT OF THE SECURITY SYSTEM MY CAR WAS TOTALLY INOPERATIVE. THE CAR HAD TO BE TOWED TO THE NEAREST DEALER, WHERE IT WAS DIAGNOSED WITH A BROKEN IGNITION SWITCH, SPECIFICALLY THE DEVICE THAT READS THE CHIP IN THE KEY HAS FAILED AND WILL NOT ACCEPT ANY KEY. CURRENTLY THE CAR HAS BEEN SITTING AT THE DEALER FOR OVER 4 WEEKS. BECAUSE THE KEYS AND SWITCHES ARE MATCHED WE CANNOT GET AN AFTER-MARKET REPLACEMENT SWITCH. FURTHER, THE PARTS ARE BACK ORDERED AT THE DEALER, BACK ORDERED AT VOLVO NORTH AMERICA, BACK ORDERED AT VOLVO IN SWEDEN, AND THEY CANNOT EVEN GET ME A DATE WHEN THE PART MIGHT BE AVAILABLE. AS AN RELIABILITY ENGINEER, THE IGNITION SWITCH FAILURE WOULD BE CLASSIFIED AS A CRITICALITY 1, SINGLE POINT FAILURE, IN OTHER WORDS IT RESULTS IN LOSS OF VEHICLE. THERE IS NO INDICATION OF PENDING FAILURE, AND NO WAY TO MITIGATE THE PROBLEM IF IT OCCURS. YOU ARE STRANDED WHERE EVER THE CAR WAS LAST PARKED. AND WORSE, IN THIS CONDITION THE CAR HAS NO RESALE VALUE, EXCEPT MAYBE AT A "CHOP SHOP", SO I CANNOT EVEN TRADE IT IN FOR A NEW CAR. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10490922January 3, 2013
SUSPENSION
WHILE DRIVING THE RIGHT FRONT AND RIGHT REAR COIL SPRINGS BROKE AND THE FRONT COIL SPRING DAMAGED THE TIRE. DEALER STOCKS THESE EXPENSIVE SPRINGS (BOTH FRONT AND REAR) IN LARGER THAN NORMAL AMOUNTS DUE TO INCIDENCES OF BREAKAGE. I FEEL THAT THIS WAS AN EARLY FAILURE FOR THIS TYPE AND AGE OF VEHICLE AND SHOULD IT HAVE BEEN A A HIGHER SPEED THE INCIDENT COULD HAVE BEEN SEVERE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10485192November 19, 2012
AIR BAGS
TL* THE CONTACT OWNS A 2004 VOLVO S40. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED WITHOUT WARNING. THE DEALER WAS CONTACTED AND ADVISED HIM THAT THE OCCUPANT WEIGHT SENSOR MAY HAVE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED HIM A 10 PERCENT COUPON. THE FAILURE MILEAGE WAS APPROXIMATELY 95,000. THE CURRENT MILEAGE WAS APPROXIMATELY 110,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10480672October 16, 2012
VISIBILITY:SUN/MOON ROOF ASSEMBLY
I WAS DRIVING DOWN THE HIGHWAY WHEN THERE WAS A LOUD BOOM IN MY CAR THAT SOUNDED LIKE A GUNSHOT. GLASS THEN CAME DOWN ON AND AROUND ME IN MY CAR. I PULLED OVER AS QUICKLY AS POSSIBLE. IT LOOKS LIKE THE GLASS FROM MY SUNROOF CAME UP AND OUT OF MY CAR. IT DID NOT APPEAR AS IF ANYTHING HIT IT. THERE IS A LARGE GAPING HOLE IN MY SUNROOF. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10479401October 9, 2012
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 2000 VOLVO S40. THE CONTACT STATED THAT WHILE TRAVELING 30 MPH THE VEHICLE'S SPEED ERRONEOUSLY INCREASED TO 55 MPH. THE CONTACT FIRMLY DEPRESSED THE BRAKE PEDAL TO STOP THE VEHICLE. THE CONTACT MERGED TO THE SIDE OF THE ROAD TO RESTART THE VEHICLE. THE VEHICLE THEN FUNCTIONED AS NORMAL. THE VEHICLE WAS TAKEN TO A MECHANIC WHERE IT WAS FOUND THAT THE COOLANT TEMPERATURE SENSOR HAD FAILED. THE VEHICLE WAS REPAIRED. THE FAILURE RECURRED SEVERAL TIMES AFTER THE REPAIR. THE FAILURE MILEAGE WAS 95,000 AND THE CURRENT MILEAGE WAS 96,828. UPDATED 11/13/12 *CN THE IDLE CONTROL VALVE AS REPLACED TO CORRECT THE PROBLEM. HOWEVER, THE CONSUMER CONTINUED TO EXPERIENCE PROBLEMS. UPDATED 11/19/12
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10479236October 8, 2012
ELECTRICAL SYSTEM
DRIVING IN RAIN, BRAKE FAILURE MESSAGE BEGAN FLASHING ON DASH, THEN AIRBAG FAILURE. SLOWED TO A STOP AND TURNED OFF CAR, TURNED BACK ON AND DROVE SLOWLY HOME. MESSAGES CONTINUED TO FLASH. DROVE TO SERVICE CENTER AND MESSAGES WERE NO LONGER FLASHING , MECHANIC SAID IT WOULD NEED TO BE ACTIVE TO FIND PROBLEM. SAME SCENARIO MANY TIMES SINCE AND THE PROBLEM HAS BECOME WORSE, DRIVING DOWN HIGHWAY AND MESSAGES APPEAR THEN ALL GAUGES ON PANEL FAIL AND GO TO ZERO, WINDOWS FAIL, BLINKERS, BRAKE LIGHTS FAIL, ENTIRE INSTRUMENT PANEL WENT DARK. BACK TO MECHANIC, HE DROVE IT SAME THING HAPPENED THEN STOPPED BEFORE RETURNING TO SHOP SO COULD NOT DIAGNOSE.EXTREMELY DANGEROUS AS SEVERAL TIMES DRIVING IN RAIN AND IN HIGH TRAFFIC AREAS AND ON FREEWAYS WITH HIGH SPEEDS AND THEN IN CONSTRUCTION ZONES BUMPER TO BUMPER WITH NO BRAKE LIGHTS OR ABILITY TO USE TURN SIGNALS. HAS BEEN OUT FOR FIVE TO THIRTY MINUTES AT A TIME THEN APPEARING TO WORK AGAIN BEFORE REPEATING THE SAME FAILURE PROBLEM. NEVER ANY WARNING, IT JUST HAPPENS SUDDENLY. TO MECHANIC AGAIN, CODES READ AND PRINTED OUT PAGES OF SIGNAL FAILURES, NONE ACTIVE AT TIME SO UNABLE TO DETERMINE PROBLEM. CHECK ENGINE LIGHT HAS ALSO APPEARED AND WHEN CHECKED NOTHING ACTIVE FOUND AT TIME OTHER THAN PAGES OF SIGNAL FAILURES IN SYSTEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10468802August 1, 2012
ENGINE
TL* THE CONTACT OWNS A 2001 VOLVO S40. THE CONTACT WAS DRIVING 35 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE ENGINE RPMS INCREASED EXCESSIVELY AS THE VEHICLE STALLED A SECOND TIME. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 107,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10463577June 29, 2012
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 2003 VOLVO S40. THE CONTACT STATED THAT WHILE SITTING AT A TRAFFIC STOP, THE VEHICLE ACCELERATED ABNORMALLY. THE CONTACT HAD HIS FOOT ON THE BRAKE PEDAL AND THEN HAD TO SHIFT INTO NEUTRAL TO GET THE VEHICLE TO SLOW DOWN. THE CONTACT PULLED THE VEHICLE OVER, SHUT OFF AND TRIED TO RESTART THE ENGINE BUT IT FAILED. THE VEHICLE WAS TOWED TO A DEALER FOR INSPECTION BUT THE CAUSE OF THE FAILURE WAS UNKNOWN. THE MANUFACTURER WAS NOTIFIED AND THEY INFORMED THE CONTACT THAT THERE WERE NO RECALLS FOR THE FAILURE. THE FAILURE MILEAGE WAS 94,000. THE VIN WAS UNAVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10460439June 4, 2012
ELECTRICAL SYSTEM
WHILE DRIVING ON THE HIGHWAY MY CAR BEGAN TO SHOW SIGNS OF AN ELECTRICAL PROBLEM. DIFFERENT WARNINGS WERE COMING UP ON THE CONTROL PANEL, ALERTING ME TO BRAKE FLUID LOW, AS WELL AS MY CURRENT MILEAGE DISAPPEARING. WHEN I PULLED OFF THE HIGHWAY, SHUT THE CAR OFF, AND REMOVED THE KEY THE WINDSHIELD WIPERS CONTINUED TO RUN. THE DISPLAY MESSAGES INCLUDING "BRAKE FAILURE, STOP CAR SAFELY" AND "IMMOBILIZER SEE MANUAL." THE BRAKES ARE FINE, BECAUSE THEY WORKED WHEN STOPPING THE CAR AND WORK WHILE THIS MESSAGE IS DISPLAYED. I BELIEVE THIS WAS AN ELECTRICAL PROBLEM, AS I WAS DRIVING THE CAR EARLIER IN THE DAY AND NO ISSUES WERE ARISING. WHEN I TRIED TO RESTART THE CAR IT WOULD BE START SAYING TO SEE THE "IMMOBILIZER SEE MANUAL" AND WOULD NOT RECOGNIZE THE PROBLEM. THE CAR IS NOW STUCK IN A PARKING LOT UNTIL IT CAN BE TOWED TO A DEALER. I WOULD APPRECIATE THIS MATTER BEING INVESTIGATED AND RECALLED IF POSSIBLE, AS THIS IS NOT THE FIRST TIME THE CAR HAS NOT RECOGNIZED THE KEY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10459079May 21, 2012
SEAT BELTS
TL* THE CONTACT OWNS A 2005 VOLVO S40. THE CONTACT STATED THE SEAT BELT RETRACTOR IN THE REAR HAS FAILED. THE VEHICLE WAS TAKEN TO A MECHANIC SHOP WHO INSPECTED THE FAILURE AND STATED THE SEAT BELT RETRACTOR ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 106,103.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10457440May 4, 2012
SERVICE BRAKES, HYDRAULIC
IT WAS CLOSE TO 9PM. I HAD EXITED THE FREEWAY TO STOP IN A PARKING LOT TO CHECK DIRECTIONS. I HAD BEEN DRIVING FOR ABOUT AN HOUR, SO I GOT OUT TO WALK AROUND AND BUY A CUP OF COFFEE. I CAME BACK A FEW MINUTES LATER AND DROVE OUT OF THE LOT. THE ON RAMP WAS ABOUT 200 YARDS AWAY AND THERE WAS A RED LIGHT AT THE INTERSECTION, SO I WAS ONLY MOVING AT AROUND 20MPH. I WAS THE ONLY CAR IN MY LANE, SO ABOUT 100 FEET AWAY FROM THE INTERSECTION I PRESSED DOWN ON MY BRAKE PEDAL, BUT THE FOR SOME REASON IT THE CAR KEPT ROLLING. I TRIED AGAIN, BUT THE BRAKES WERE NO HELP AS I KEPT ROLLING. FRANTICALLY, I STOMPED HARD, FLOORED THE BRAKES, AND MY CAR STARTED TO SLOW DOWN A LITTLE, BUT THAT TIME IT WAS TOO LATE. I TRIED TO TURN TO THE RIGHT TO AVOID THE FLOW OF TRAFFIC, BUT AN INSTANT LATER I HAD HIT AN ONCOMING CAR. I DON'T KNOW WHAT WENT WRONG. I AM PRETTY GOOD AT MAINTAINING THE CAR AND IT HAD BEEN SERVICED AT THE VOLVO DEALER FAIRLY RECENTLY. IT'S ONLY GARAGED ABOUT HALF THE TIME, BUT I LIVE IN SOUTHERN CALIFORNIA SO IT'S NEVER BEEN EXPOSED TO AN EXTREME CLIMATE OR ANYTHING. THERE WAS A THUNDERSTORM THAT MORNING, AND THE ROADS WERE VERY WET EARLIER IN THE DAY, BUT THE STORM BROKE AROUND NOON: 7 OR 8 HOURS BEFORE I LEFT HOME THAT NIGHT. BY THAT TIME ALL OF THE ROADS HAD DRIED. *TR
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10455940April 20, 2012
ENGINE AND ENGINE COOLING
FIRST OCCURRENCE ABOUT 87000 MILES WAS TRAVELING ON FREEWAY WHEN CAR STALLED. STARTED IT BACK UP AND CHECK ENGINE LIGHT CAME ON. TOOK VEHICLE TO DEALER AND THEY INSTALLED NEW SPARK PLUG AND WIRES. STALLED AGAIN AT ABOUT 89000 MILES AND WAS TOLD TO BRING BACK WHEN CHECK ENGINE LIGHT CAME BACK ON. CHECK ENGINE LIGHT CAME ON AGAIN AND TOOK VEHICLE IN ON SATURDAY BUT STORE WAS REMODELING AND COULDN'T GET ME IN. TOOK CAR IN FOR 90000 MILE SERVICE AND CHECK ENGINE LIGHT WAS ON. WAS TOLD THAT SPARK PLUGS WERE INSTALLED. I INFORMED THEM I HAD SPARK PLUGS AND WIRES INSTALLED THE LAST SERVICE AND THAT THIS STALLING OF MY VEHICLE IS DANGEROUS. WAS TOLD THAT AFTER THE SPARK PLUGS WERE INSTALLED IT CLEARED THE CHECK ENGINE LIGHT AND THAT I WOULD HAVE TO BRING THE CAR IN AGAIN WHEN THE CHECK ENGINE LIGHT WAS ON. DEALERSHIP HAS BEEN OF NO HELP WITH THIS ISSUE. LOOKED ONLINE FOR PEOPLE WITH SIMILAR PROBLEMS AND IT POINTS TO RECALL #08V033000. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10454823April 11, 2012
ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 2005 VOLVO S40. THE CONTACT STATED THAT THE ENGINE TRAP FLAME BOX WAS LEAKING OIL AND EXHIBITED A WHISTLING NOISE WHEN THE ENGINE WAS STARTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT THAT THE ENGINE FLAME TRAP BOX WAS PREVIOUSLY REPLACED UNDER THE WARRANTY AND WOULD NOT BE REPLACED AGAIN. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 100,000 AND THE CURRENT MILEAGE WAS 121,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10453439March 29, 2012
ELECTRICAL SYSTEM
WHILST DRIVING, THE INSTRUMENTS ON THE INSTRUMENT CLUSTER DROPPED TO ZERO AND THE WARNING LIGHTS STARTED FLASHING. AFTER SHUTTING DOWN THE CAR, AND THEN RESTARTING, THE FAULT CLEARED. EVER SINCE, THE ELECTRIC WINDOWS AND DOOR LOCKS HAVE WORKED ONLY INTERMITTENTLY. VOLVO DIAGNOSED THE PROBLEM TO THE A-PILLAR CONNECTORS, WHICH THEY SAID WERE OLD, AND NEWER ONES HAD BEEN MADE. VOLVO WILL NOT PAY FOR THE REPLACEMENT SINCE THE CAR'S WARRANTY HAS EXPIRED. AFTER DOING SOME RESEARCH, I FOUND OUT THAT VOLVO HAD ISSUED A SERVICE BULLETIN ADDRESSING THE A-PILLAR CONNECTORS, AND I ALSO FOUND QUITE A FEW VOLVO OWNERS THAT EXPERIENCED THE SAME PROBLEM.VOLVO KNOWS THEY HAVE DEFECTIVE A-PILLAR CONNECTORS IN SOME OF THEIR CARS, WHY HAS A RECALL NOT BEEN ISSUED?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volvo S40