Volvo S40 Complaints

491 consumer complaints on file.

#10313282February 23, 2010
ENGINE AND ENGINE COOLING:COOLING SYSTEM, VEHICLE SPEED CONTROL
UNINTENDED ACCELERATION OCCURRED WITH CAR IN DRIVE. CAR BEGAN TO ACCELERATE SLOWLY INCREASING SPEED WITH FOOT OFF ACCELERATOR. PULLED UP ON ACCELERATOR WITH NO RESULTS. PUT CAR INTO NEUTRAL AND RPM INCREASED TO 6000 RPM THEN BACK TO 750 IDLE SPEED. BACK INTO DRIVE AND ENGINE ACCELERATED AGAIN. ENGINE SHUT OFF VIA KEY THEN IT WOULDN'T START AGAIN. CRANKED BUT WOULD NOT TURN OVER. DEALER REPLACED ECT BECAUSE OF FAILURE OF PART. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10312587February 22, 2010
ELECTRICAL SYSTEM:IGNITION:SWITCH
I PARKED THE 2007 S40 VOLVO AND CAN'T REMOVE THE KEY FROM THE IGNITION SWITCH. THE CAR IS IN PARK, BRAKE ON, ALL NECESSARY CHECKS ARE CHECKED. STILL CAN'T GET THE KEY TO RELEASE, HAD TO TURN IT SEVERAL TIMES (30 MINUTES) RIGHT TO LEFT UNTIL I HEARD A CLICK AND THE KEY CAME OUT. I HAVE SEEM POST ON THE INTERNET ABOUT THIS AND THAT IS HOW I FIGURED OUT HOW TO GET MY KEY AND LOCK THE DOORS. I CALLED VOLVO AND THE RESPONSE WAS GO TO THE DEALER AND YOU ARE OUT OF WARRANTY?! THE KEY WILL NOT GO PAST THE I POSITION. I DON'T MIND PAYING TO GET IT FIXED BUT ACCORDING TO THE VOLVO MAKERS IT IS ISOLATED AND NOT KNOWN HOW TO FIX. I BEG TO DIFFER BASED ON TALKING TO OTHER OWNERS AND THE INFO ON THE WEB. PLEASE ASSIST AS MUCH AS POSSIBLE OR A DIRECTION TO GET RESOLUTION. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10312385February 20, 2010
SERVICE BRAKES, ELECTRIC
I DROVE INTO A HOTEL PARKING GARAGE , CAME INTO MY SPOT AND THE CAR ACCELERATED AND WENT INTO A WALL. I SHUT THE ENGINE OFF TO PREVENT MY WHOLE CAR GOING THRU THE WALL. JUST THE FRONT OF THE CAR WENT INTO THE WALL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10312216February 19, 2010
SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM
TL*THE CONTACT OWNS A 2001 VOLVO S40. WHENEVER THE VEHICLE WAS COLD, THE BRAKES WOULD NOT WORK UNLESS THE PEDAL WAS ENGAGED 6 TIMES. THE DEALER STATED THAT THE BRAKE VACUUM NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS 63,000. THE CURRENT MILEAGE WAS 74,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10310851February 16, 2010
SERVICE BRAKES, HYDRAULIC
I AM WRITING TO OFFICIALLY INFORM YOU OF A PROBLEM THAT CONTINUES TO NEED TO BE REPLACED ON MY 2004 S40. I HAVE OWED THE CAR SINCE 2006 AND AM ABOUT TO BRING IT IN FOR THE FORTH (4) TIME TO HAVE THE HYDRAULIC BRAKE VALVE PUMP AND HOSES REPLACED. ONLY THIS TIME IT IS NOT UNDER WARRANTY BECAUSE I HAVE 65K MILES ON THE CAR. SO I HAVE TO PAY FOR THIS UNWILLINGLY. THE BRAKES LOCK AND THE CAR CONTINUES TO SLIDE. I HAVE HAD ONE MINI-FENDER BENDER DUE TO THIS ISSUE, BUT MY INSURANCE WON'T ACKNOWLEDGE THAT IT WAS BECAUSE OF THE CAR. SINCE I HAVE EXPERIENCED THIS SO MANY TIMES, I KNOW WHEN THE PROBLEM ARISES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10308462February 10, 2010
EXTERIOR LIGHTING
TURN SIGNALS WILL STOP WORKING INTERMITTENTLY. WHEN IT HAPPENS NEITHER LH NOR LH TURN SIGNAL WILL ILLUMINATE AND NEITHER EXTERIOR BULB NOR DASH INDICATOR WILL ILLUMINATE. TURNING ON THE HAZARD LIGHTS WILL JUMP START THE TURN SIGNALS TO WORK AGAIN. TURN SIGNAL RELAY (UNDER DASH NEAR DRIVER KICK PANEL) HAS BEEN REPLACED WITH NO IMPROVEMENT. USED TO ONLY HAPPEN ON VERY HOT DAYS. NOW HAPPENS REGARDLESS THE AMBIENT TEMP. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10308527February 10, 2010
VEHICLE SPEED CONTROL
I'D LIKE TO REPORT UNINTENDED ACCELERATION IN MY VOLVO S40. IT STARTED LAST SUMMER AND OCCURRED SPORADICALLY UNTIL WINTER AND HAS NOT OCCURRED SINCE THEN. NO REPAIRS WERE MADE DURING THIS TIME AND I HAVE NOT TAKEN IT TO THE DEALER. SEVERAL TIMES LAST SUMMER I EXPERIENCED SUDDEN ACCELERATION THAT REQUIRED EXTRA HARD BREAKING TO MAKE THE CAR COME TO A COMPLETE STOP. THE CAR SEEMED TO BE GIVING ITSELF GAS EVEN WHILE I WAS BRAKING TO COME TO A STOP, REQUIRING THAT I PRESS THE BRAKE EXTRA HARD. THIS PROBLEMS SOUNDS SIMILAR TO WHAT WE ARE HEARING IN THE NEWS ABOUT TOYOTAS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10307236February 7, 2010
ELECTRICAL SYSTEM
WHEN DRIVING MY CAR, HE START GOING FASTER WITHOUT PRESSING A GAS PEDAL WHEN I PRESS THE BRAKE THE CAR TURN OFF, I PUT THE GEAR CHANGING ON PARK AND START THE CAR AGAIN, THE RPM START GOING CRAZY, THE CAR HAVE ONLY 30000 MILES. *TW
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10298521January 6, 2010
SERVICE BRAKES, HYDRAULIC
I BOUGHT A 2001 VOLVO S40 IN JUNE 2009. I NOTICED RIGHT AWAY THAT THE BRAKES DIDN'T SEEM TO WORK PROPERLY, AS THE STOPPING DISTANCE WAS FAR TOO LONG. THEY ASSURED ME THE BRAKES WERE BRAND NEW. AFTER DRIVING IT A FEW WEEKS, I BECAME VERY NERVOUS ABOUT THE BRAKES BECAUSE I HAD COME CLOSE TO REAR ENDING SEVERAL PEOPLE. I BROUGHT IT BACK TO THE DEALER WHERE I PURCHASED IT AND ASKED THEM TO DOUBLE CHECK THE BRAKES. THEY DID SO AND STATED THAT THEY WERE FINE. SO, I DROVE EXTRA CAUTIOUSLY FROM THEN ON. UNFORTUNATELY, THEY NEVER GAVE ME ANY DOCUMENTATION AND I NEVER ASKED FOR IT. THEY JUST CHECKED THE BRAKES AND SENT ME ON MY WAY, REASSURING ME THERE WAS NOT A PROBLEM. HOWEVER, ON DECEMBER 28TH, 2009, THE BRAKES FAILED WHEN COMING TO AN INTERSECTION. I WAS JUST BEGINNING TO SLOW DOWN (NOT EVEN TRYING TO STOP YET) AND THE BRAKE WOULD NOT GO DOWN FURTHER. I TOOK MY FOOT OFF THE BRAKE, AND IT DID NOT RELEASE. I AGAIN TRIED TO PUSH DOWN THE PEDAL, AND IT DID NOT GO DOWN. I REAR ENDED THE CAR IN FRONT OF ME. I LOOKED ONLINE AND FOUND THAT SEVERAL PEOPLE WITH MY SAME YEAR AND MODEL HAD THE SAME PROBLEMS, BOTH WITH THE STOPPING DISTANCE AND THE BRAKE FAILURE. THE NEXT MORNING, I TOOK MY CAR TO THE VOLVO DEALER IN INDIANAPOLIS. THEY INSPECTED THE BRAKES AND FOUND NOTHING WRONG. THEY ALSO VERIFIED THAT THE RECALLED VACUUM PUMP HAD ALREADY BEEN REPLACED. FROM THERE I TOOK MY CAR TO THE BODY SHOP FOR AN ESTIMATE OF THE DAMAGE FROM THE ACCIDENT, WHICH WAS $2,2604.96. UPON LEAVING THE BODY SHOP, I BRAKED AT A YELLOW LIGHT, AND ONCE AGAIN, MY BRAKES WOULD NOT GO DOWN AND I WENT THROUGH THE INTERSECTION. I HAD MY CAR TOWED BACK TO THE VOLVO DEALER. I MADE A CLAIM WITH VOLVO COMPANY, WHO HAD SOMEONE LOOK AT IT AND SAID THE VACUUM PUMP AND PRESSURE VALVE NEEDED TO BE REPLACED, WHICH WOULD COST APPROXIMATELY $750. I ASKED FOR AN ESTIMATED TRADE-IN VALUE AFTER THE CAR WAS COMPLETELY FIXED. THEY STATED THAT THEY. *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10298168January 4, 2010
SERVICE BRAKES, HYDRAULIC
TL*THE CONTACT OWNS A 2001 VOLVO S40. WHENEVER THE VEHICLE WAS PARKED LONGER THAN 2 HOURS THE CONTACT NOTICED THAT THE BRAKES FAILED TO OPERATE. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER AND THERE WERE NO PRIOR WARNINGS. THE CURRENT MILEAGE WAS 112,131 AND THE FAILURE MILEAGE WAS AT 88000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10295636December 14, 2009
ENGINE AND ENGINE COOLING:ENGINE
TL* THE CONTACT OWNS A 2004 VOLVO S40. WHILE DRIVING 50 MPH THE CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT CONTROL PANEL, AND THEN THE VEHICLE STALLED. AFTER A PERIOD OF WAITING SHE WAS ABLE TO RESTART THE VEHICLE. THE VOLVO MANUFACTURER WAS NOTIFIED, BUT NO ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 48,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10294882December 8, 2009
ENGINE AND ENGINE COOLING:ENGINE
ENGINE FAILURE. CAR STALLED WHILE DRIVING ON HIGHWAY. CAR WAS TOWED TO WYNN VOLVO. WAS TOLD THAT THE BELTS BROKE, LEADING TO THE BREAKAGE OF THE TIMING BELT, LOCATED INSIDE THE ENGINE, RESULTING IN MAJOR DAMAGE TO THE ENGINE. WAS GIVEN A QUOTE OF $5600 TO REPAIR. THE CAR HAS 63000 MILES AND THE MANUAL DOES SAY THAT THE BELTS NEED TO BE REPLACE AT 125 THOUSAND MILES. THE SERVICES SUGGESTED PRIOR TO THIS DOES NOT INCLUDE ANY OF THE BELTS BEING REPLACED. I BELIEVE THAT THIS SHOULD BE A RECALL OR ATLEAST CONSIDERED IN THE SERVICES AND NOW. IF THIS IS CONSIDERED, I WOULD HOPE THAT THIS WOULD WARRANT VOLVO TO REPAIR MY CAR AT NO COST TO MYSELF. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10291072November 5, 2009
SERVICE BRAKES, HYDRAULIC
NEW 2009 VOLVO S40 SEDAN BRAKE FIRE 1. VEHICLE WAS DRIVEN 3 MILES FROM A HIGH SCHOOL PARKING LOT TO THE OWNER'S HOME. 2. THERE WAS A FIRE BETWEEN THE BRAKE PAD AND THE ROTOR IN THE REAR PASSENGER SIDE WHEEL WELL. 3. THE ROTOR, BRAKE CALIPER AND BRAKE PADS WERE REPLACED. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10288666October 16, 2009
VEHICLE SPEED CONTROL
UNINTENDED ACCELERATION ON MY 2000 VOLVO S40. ACCELERATING IN TRAFFIC WITHOUT PRESSING PEDAL. MUST PRESS BRAKE HARD TO STOP. CONTINUES TO REV HIGH. THIS HAS HAPPENED TWICE IN THE LAST MONTH. AFTER THE FIRST TIME, MY SERVICE SHOP REPLACED THE IDLE AIR CONTROL VALVE BUT IT OCCURRED AGAIN ABOUT A WEEK AND A HALF AFTER THAT. SERVICE TECHNICIAN HAS INDICATED HE CANNOT POTENTIALLY DIAGNOSE UNLESS IT IS OCCURRING WHEN HE CAN DRIVE AND LOOK AT IT. IT IS A SERIOUS RISK FOR CRASH OR INJURY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10284231September 16, 2009
SERVICE BRAKES, HYDRAULIC, AIR BAGS:FRONTAL
THE EVENT LEADING UP TO THE FAILURE IS SIMPLY A DEFECTIVE PART AFTER SOME USAGE DUE TO A POOR WELDING JOB AT MANUFACTURE. VOLVO HAS ONLY RECALLED ONE VEHICLE TO MY KNOWLEDGE BUT THEY NEEDED TO RECALL ALL VEHICLES DURING THAT YEAR. THE FAILURE IS THE CAR HAS A HARD TIME STOPPING WHEN THE BRAKES ARE APPLIED THE CARE CONTINUES TO MOVE AND ROUGH ENGINE IDLE. THE PARTS THAT WERE REPLACED WERE THE VACUUM PUMP AND VALVE AT BRAKE BOOSTER, HOSES, LINES AND FITTINGS. REPAIR COST $840. THE AIR BAG LIGHT HAS CONTINUED TO COME ON/OFF SINCE THE PURCHASE OF THE CAR. IT IS DEFECTIVE. THE DRIVERS SIDE SIPS BAG NEEDS REPLACING TOTAL COST $801. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10281474August 23, 2009
SERVICE BRAKES, ELECTRIC
I HAVE A 2001 VOLVO S40 WITH BRAKE PROBLEMS. IN THE MORNINGS WHEN I GET IN MY CAR AND BACK UP I HAVE TO ALMOST STAND UP ON THE BRAKES TO STOP MY CAR. I HAVE ALMOST WENT OUT IN FRONT OF OTHERS CARS BECAUSE MY BRAKES WILL NOT HARDLY STOP. THIS OCCURS DAILY. IF MY CAR SITS FOR A FEW HOURS IT DOES IT ALL OVER AGAIN. THIS TO ME IS A SAFTY ISSUE BECAUSE ONE DAY THEY ARE NOT GOING TO STOP AND I'LL HAVE A WRECK. I HAVE TWO SMALL CHILDREN IN MY CAR. I THOUGHT VOLVO WAS SUPPOSE TO BE ONE OF THE SAFEST CARSS ONE THE ROAD BUT SOMEONE DIDN'T DO ENOUGH RESEARCH. I HAVE BUMPED MY HUSBANDS TRUCK TWICE BECAUSE OF THIS PROBLEM. AND I HAVE ALSO HAD TO USE THE E-BRAKE TO STOP MORE THAN ONCE. SOME ONE NEEDS TO BE HELD RESPONSIBLE FOR THIS PROBLEM. MY CAR ONLY HAS 110,000 MILES ONE IT. I HAD A 1993 VOLVO 850 BEFORE THIS ONE AND IT HAD 207,000 MILES ON IT WHEN IT WAS WRECKED AND I NEVER HAD ANY PROBLEMS WITH IT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10281475August 23, 2009
POWER TRAIN
I HAVE A 2001 VOLVO S40. AT ABOUT 90,000 MILES THE GEAR SHIFT BUTTON BROKE. NOW YOU CAN CHANGE THE GEARS WITH OUT PRESSING THE BRAKE PEDAL. I HAVE SMALL CHILDREN SO I HAVE TO KEEP MY CAR LOCKED AT ALL TIMES WHEN I'M NOT IN IT. IF THEY WERE TO BE IN IT THEY COULD PULL IT OUT OF PARK WITH NO PROBLEM AND THE CAR WOULD START TO ROLL. I AM VERY CONCERNED ABOUT THE PROBLEM BECAUSE I'M SURE I'M NOT THE ONLY ONE WHO HAS HAD THIS PROBLEM AND IT IS A SAFETY ISSUE. THE SHIFTER ON THE INTERNET IS OVER $250.00 TO FIX IT THEN YOU HAVE TO PAY TO HAVE IT PUT IN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10280687August 17, 2009
WHEELS
LUGNUTS CAME LOOSE ON RIGHT FRONT WHEEL, CAR IS ALWAYS SERVICED HERE AND WE ALWAYS HAND TORQUE LUG NUTS. ODD THIN IS THIS IS THE 2ND 2000 VOLVO S40 WE HAVE SEEN DO THIS AND I ASSUME MANY ARE NOT REPORTED AND CONSIDERED INSTALLER ERROR. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10276396July 11, 2009
ELECTRICAL SYSTEM, SUSPENSION, SUSPENSION:FRONT, POWER TRAIN:AUTOMATIC TRANSMISSION
FRONT END SUSPENSION ISN'T RIGHT,PULLS WHEN DRIVING AND THERE IS A KNOCKING ITEMS NHTSA 10016415 AND 630879. CHECK ENGINE HAS ALWAYS BEEN ON 10003441. THERE IS A CLUNKING NOISE WHEN SHIFTING 10003398. THERE WAS NEVER AN ACCIDENT THESE ARE JUST ONGOING THINGS AND THE SUSPENSION MAY CAUSE AN ACCIDENT AND CHECK ENGINE LIGHT IS HARD TO GET PASSED FOR INSPECTION IN NC. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10272563June 1, 2009
ELECTRICAL SYSTEM
SEVERAL TIMES I TOOK MY VOLVO S40 TO THE DEALERSHIP BEFORE MY WARRANTY EXPIRED ON THE PROBLEM WITH STARTING MY CAR. WHEN INSERTING THE KEY IN THE IGNITION NOTHING WORKED. NOW THE WARRANTY IS EXPIRED (59,000 MILES) AND NO ONE AT THE VOLVO DEALERSHIP "RECALLS" OUR MANY CONVERSATIONS! AFTER TRYING TO START IT SEVERAL TIMES AND CALLING A TOW TRUCK FOR A JUMP, STILL NOTHING. IT DISPLAYED THE MESSAGE "BRAKE FAILURE STOP CAR SAFELY", "ANTI-SKID SYSTEM FAILURE", "REDUCED ENGINE PERFORMANCE", "POWER STEERING FAILURE", SBS AIRBAG FAILURE". THE CAR STOPPED, I COULD NOT RESTART THE ENGINE AND THE MESSAGES KEPT REPEATING IN RANDOM ORDER. THE CAR WILL BE TOWED TO VOLVO AND THEY WILL SEE WHAT'S GOING ON! I HAVE READ THIS SAME COMPLAINT IN MANY DIFFERENT VOLVO FORUMS. YOU WOULD THING THERE WOULD BE A RECALL ON WHATEVER THIS PROBLEM IS. I FOUND OUT THAT FORD MADE THIS PARTICULAR YEAR! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volvo S40