Volvo EX90 Complaints

73 consumer complaints on file.

#11741677June 2, 2026
UNKNOWN OR OTHER
Built-in navigation application has on multiple occasions stopped working and stating "searching for GPS". This causes a distraction and increases the chance of a crash because I now have to try to figure out what is going on while I was relying on the navigation to understand where I was going.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741674June 2, 2026
LANE DEPARTURE: BLIND SPOT DETECTION, BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING, BACK OVER PREVENTION: WARNINGS
Multiple times I have gotten a "Park assistance fault - book a service" message while driving and the parking sensors stop working. The issue temporarily resolves itself only to reoccurring several days later. Took to service and they replaced the car computer and said they could to replicate the issue after replacing the computer. Now a week later and the issue has re-occurred twice again.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740836May 29, 2026
ENGINE
The first issue occurred on 4/16/26. Car stopped mid-drive on a public road. No error or warning, just a jerk noise and stopped. This was around 7 in the evening and I am fortunate it was a not so busy road. Gives me nightmares thinking if me or my kids were driving on a freeway. Got towed to a dealership and the root cause was identified as the coolant being completely drained off because of a manufacturing defect with the radiator having a pin sized hole causing coolant to leak off. What was worse is that there was a known software bug, TJ 37300 that suppressed the low coolant message. I can't believe Volvo has released the car with a known safety issue. Got the car back on 5/11/26 and it was towed back on 5/16/26 for a similar issue. Awaiting root cause and resolution. Will report a separate case for that
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738406May 17, 2026
ELECTRICAL SYSTEM, SEAT BELTS, FUEL/PROPULSION SYSTEM
The vehicle has experienced repeated intermittent electrical-system-related failures since the start of the lease, which have remained unresolved despite eight months of formal engagement with Volvo and multiple service and software-related repair attempts by Volvo. Most recently, on May 15, 2026, while operating the vehicle in approximately 90°F Arizona temperatures, the vehicle displayed a “Limited Performance / Electrical System Temporarily Limited” warning message. Shortly afterward, the driver was temporarily unable to re-enter the vehicle, despite the exterior door handles deploying normally. Vehicle access was restored only after several minutes. The side view mirrors would not open. Driving for two minutes did not resolve this. After ten minutes of remaining parked the mirrors reconnected. This latest incident follows prior issues including: •Loss of charging capability during a long distance trip (which forced us to drive 50MPH on a 75MPH highway, putting our car and other drivers at risk.) •Multiple incidents involving loss of instrument displays while driving •Intermittent vehicle access and lock-related issues •Unexpected seatbelt tensioning while the vehicle was in motion Volvo previously indicated that software updates and related service efforts should address the issues. However, after the updates the vehicle continues to exhibit intermittent electrical-system-related problems affecting reliability and normal operation.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11736867May 10, 2026
VISIBILITY/WIPER
Under certain driving conditions, particularly when the sun is at a low or mid-angle (morning or late afternoon), direct sunlight entering through the windshield reflects off multiple interior surfaces and creates a significant glare effect within the driver’s field of view. The reflections originate from several interior components, including metallic or semi-polished trim surfaces on the dashboard and steering wheel, as well as the glossy plastic housing surrounding the Bowers & Wilkins center tweeter located on the dashboard. When sunlight strikes these surfaces at specific angles, the reflected light is directed back toward the driver’s eyes and onto the windshield area, producing intermittent bright glare spots. Safety Impact: This glare can cause temporary visual distraction and reduced forward visibility. In some cases, the reflected light is intense enough to momentarily obscure portions of the road view or draw the driver’s attention away from driving. The issue is angle-dependent and not constant, but it is repeatable under common sun positions and clear weather conditions. Assessment of Cause: The condition appears to be related to interior material selection and surface finishes that include reflective or semi-gloss components positioned within the driver’s forward field of view. The combination of windshield angle, dashboard geometry, and placement of polished trim elements contributes to a direct reflection path toward the driver. The Bowers & Wilkins center tweeter housing, in particular, appears to be constructed of a highly reflective plastic surface that amplifies this effect when exposed to direct sunlight. Similarly, metallic trim elements on the dashboard and steering wheel may lack sufficient matte finishing or anti-glare treatment to prevent specular reflection.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11731856April 17, 2026
UNKNOWN OR OTHER
My Volvo Ex90 was promised to have LIDAR capability. I found out that Volvo broke their relationship with the company that was promised to supply this capability to our vehicle and I would like compensation. Do you know who I would contact?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11731480April 15, 2026
ELECTRICAL SYSTEM
The contact owns a 2025 Volvo EX90. The contact stated that while the vehicle was parked, an over-the-air software update was attempted but failed. The vehicle locked during the update process and remained inoperable for approximately one hour after the update was completed. On a separate occasion, the vehicle failed to shift into gear while driving on the interstate. The message that the vehicle was not in gear was displayed. The download process took an extended period and after the update was completed the vehicle operated as intended. Additionally, the infotainment system turned black and was inoperable, while the instrument panel was dark, and caused the turn signal indicator and speedometer to become inoperable. The instrument panel was flashing. The vehicle was taken to the dealer where it was determined that the battery was in low power mode. The vehicle was not repaired but was manually updated by the dealer, bypassing the over-the-air process. The manufacturer was notified of the issue. The approximate failure mileage was 1,115.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727840March 29, 2026
EXTERIOR LIGHTING, ELECTRICAL SYSTEM
On November 28, 2025, my 2025 Volvo EX90 displayed a headlight warning message on the dashboard and the headlights failed to function properly while parked and after starting the engine. The defect temporarily resolved but recurred on December 5, 2025. A headlight defect that is not immediately apparent to the driver poses a serious safety risk before or during nighttime driving. The symptoms are consistent with NHTSA Safety Recall No. 25V-071 (Volvo internal reference R10298), which covers 2025 EX90 vehicles and involves unexpected headlight malfunction. I request that NHTSA investigate whether my vehicle's defect is related to Recall No. 25V-071 and whether the recall remedy has been properly implemented. If unrelated to Recall No. 25V-071, I request that NHTSA investigate this as a separate unreported safety defect. Other 2025 EX90 owners may be experiencing the same issue without reporting it. Volvo has contacted me directly on multiple occasions to schedule a central computer replacement on my vehicle. I understand this replacement is being offered to all 2025 EX90 owners. I request that NHTSA investigate whether this widespread hardware replacement is related to the safety defect I experienced and whether it should have been conducted as a formal safety recall. When brought in for repair on December 13, 2025, the service department advised parts were on indefinite backorder with no estimated delivery date. The vehicle remained at the service center for 47 days while Volvo was unable to supply the necessary parts. I request that NHTSA evaluate whether this represents an adequate response to a safety-critical defect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725544March 19, 2026
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
While driving the car the car will suddenly stop working, it will be unable to accelerate. When this happens a multitude of alerts display on the screen. The car is very dangerous to drive and I’m concerned someone may die if this car is not recalled for safety.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11724715March 16, 2026
ELECTRICAL SYSTEM
The contact owns a 2025 Volvo EX90. The contact stated that while using the house charger, the breaker tripped. The check connection message was displayed. The vehicle failed to charge at the residence. The vehicle was later taken to the local dealer, who was unable to charge the vehicle. The contact eventually used a standalone charging system to charge the vehicle. The vehicle was taken to another local dealer, Subaru of Melbourne Service Center (4340 W New Haven Ave, Melbourne, FL 32904); where it was diagnosed and determined that an unknown part needed to be replaced; however, the part was on backorder. The vehicle was repaired, but the failure recurred. The manufacturer was contacted, and a case was opened. The failure mileage was approximately 80.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11723637March 11, 2026
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
My car will not charge at my home power charger or any L1 or L2 AC based power system. It will only charge at higher price fast DC chargers which are limited and not at my house. This is apparently a commonly known flaw with this vehicle that has not been addressed and I am now waiting more than 20 days for a replacement part to be ready.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11723450March 10, 2026
ELECTRICAL SYSTEM
Was given a 'critical brake fault' warning on the dashboard. Car defaulted into neutral and I was not able to put it park, drive, reverse or even turn off the car (had to keep my foot on the brake until someone could help me push it onto a flat surface). Could not open the car doors from the outside, no resets would work, had to be towed to dealership. Car was left "running" at the dealership for over 24 hours.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11719658February 21, 2026
ELECTRICAL SYSTEM
Unable to charge the car, interrupted charging
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11716524February 8, 2026
UNKNOWN OR OTHER, LANE DEPARTURE: BLIND SPOT DETECTION
My Volvo EX90 has recurring software reliability problems affecting safety-related detection systems and hands-free operation features. These failures involve inconsistent or incorrect detection of vehicles and pedestrians and unpredictable loss of hands-free phone functionality. These issues create increased distraction and reduce confidence in driver-assistance safety features.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11716356February 6, 2026
SEATS
Our 2025 Volvo EX90 was delivered with the seat track covers missing for the second row captain's chairs. It took a few weeks for the dealer to order them and install them. Looking at other active listings it appears most of the 6-seat Volvo EX90s being offered for sale is missing the seat track covers. I believe this is a saftey issue as without the cover the seat tracks and wiring is exposed and likely increases the risk of injury to 2nd row passengers (feet getting caught in seat tracks or debris getting into seat tracks preventing them from working properly, etc). I have reported this to my local Volvo dealership and Volvo Customer Support. I believe they should issue a recall to ensure the seat track covers are installed before delivery and that all already-sold EX90 missing the seat track covers gets them installed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11716170February 6, 2026
UNKNOWN OR OTHER
The onboard charger (GHCA) has now failed to charge on any Level 2 (the most common kind) charger. The first time it failed was on December 15, 2025 and was replaced under warranty and released back to me on December 31, 2025. Then on February 4, 2026, it failed to charge on a Level 2 charger and was confirmed to have a second onboard charger failure. (Both failures confirmed by Volvo technicians.) Not being able to charge presents safety issues of being stranded and leaving the car completely in-operational. In addition to the GHCA failure, the dash that sits on top of the steering wheel has gone black/dark twice in the last 2 weeks. while driving, with no known reason. That dash houses the speedometer, the battery percentage indicator, my gear shifting indicators as well as other ancillary items such as a map and speed limit signs.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11715857February 5, 2026
ELECTRICAL SYSTEM
GHCA Failure that resulted in inability to charge the car.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11715733February 5, 2026
FUEL/PROPULSION SYSTEM
The GHCA failed while AC charging at home, and the vehicle made loud banging noises. AC charging is no longer possible, and a replacement part is still backordered with no ETA over three months later. A corporate case has been filed with Volvo and they are effectively unresponsive, only emailing me once a few weeks after the case was created, saying that they would promptly reply to any of my responses, but have not replied for almost a month after my immediate response.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11715705February 4, 2026
EXTERIOR LIGHTING
The instrument panel displays symbol for exterior lights malfunction and the vehicle status screen reports “1 serious issue detected – Headlight fault – Book a service”. The high and low beams appear to function normally on both sides of the car. The daytime running lights (white) around the headlight are only illuminated on the drivers side; the passenger side running lights are not working. This issue is intermittent. It first occurred within one day of ownership and has recurred about once per week since then. Service department stated in mid-December that this is a software issue that will be fixed in a future update, but there hasn’t been one and the issue still presents. Car software is currently version 1.4.15, and I believe has been since delivery.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11715700February 4, 2026
ELECTRICAL SYSTEM
While Level 2 charging at home from a NEMA 14-50 receptacle using the Volvo-supplied cable/adapter, charging stopped unexpectedly accompanied by a loud thunk. The central computer restarted and presented a profile setup routine as if the car was new. Stored settings were not retained. Repeated attempts to re-initiate charging resulted in ‘Charging fault’ notifications on the instrument panel and a solid red light on the charging port indicator. The car can no longer charge with AC power, but still charges with Level 3 DC equipment. Also, the car software doesn’t seem to recognize that there is a problem with the vehicle. It shows the status as ‘everything is OK’.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volvo EX90