Toyota Sienna Complaints (2003)

105 consumer complaints on file.

#11419267June 1, 2021
EQUIPMENT:ELECTRICAL
A plug-in battery charger failed. You may inspect it. It got hot and smoked, and I suppose was a fire hazard. The problem has not been confirmed nor inspected. There were no symptoms of the problem before the failure. - - - - I used the automotive charger to charge a battery after a light had been on overnight, discharging the battery. I removed the battery from the vehicle because the terminals might have been corroded. When I first put the charger on the battery it indicated full and did not start to recharge it, so I used jumper cables to charge the discharged battery from a good battery in my car and left the charger at 10 amps on the good battery at the same time so that battery would not become discharged. I left it to sit, figuring it would take several hours at that setting, and after about 5 minutes I saw smoke. Both 12v wires were hot and insulation burned or melted off. There is damage to the car where the wires rested on the painted plastic bumper and a plastic bit near the battery, and of course the charger is useless. I wrote to the manufacturer on March 28 to make them aware, and ask how to avoid it in the future, and ask if it can be repaired. I have not heard back. - - - - The user manual for this product is at http://manuals.harborfreight.com/manuals/60000-60999/60653.pdf The current year model of this product is at https://www.harborfreight.com/10250a-12v-manual-charger-with-engine-start-60581.html - - - - The charger is sold by Harbor Freight Tools under the Cen-Tech brand.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11140478October 15, 2018
AIR BAGS
TAKATA RECALL AIR BAGS FAILED TO DEPLOY IN A ROLL OVER ACCIDENT THAT INVOLVED IN CAR BEING AIRBORNE AND ROLLING OVER. CAR WAS TOTALED. NO AIRBAGS DEPLOYED, CAR WENT THROUGH 50 FOOT OF CORNFIELD AND LANDED ON THE ROOF. WINDOWS WERE ALL COLLAPSED DOOR RIPPED OFF ITS HINGES. I HAVE PICTURES ON MY PHONE I CAN PRINT AND GET TO YOU.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10872769June 6, 2016
SEATS
MVA - OTHER PARTY REAR-ENDED US AT 35-40 MILES/HR. WHILE WE WERE STOPPED AT A LIGHT. BOTH DRIVER AND PASSENGER FRONT SEAT BACKS BROKE. OUR VEHICLE WAS TOTALED , OTHER VEHICLE AIR BAGS DID NOT DEPLOY . APPEARED TO BE MINIMAL DAMAGE TO OTHER VEHICLE. PICTURES OF BOTH VEHICLES AVAILABLE
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10750339August 21, 2015
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2003 TOYOTA SIENNA. WHILE DRIVING APPROXIMATELY 45 MPH, AN ABNORMAL SQUEAKING SOUND EMITTED FROM THE REAR OF THE VEHICLE. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHERE IT WAS DIAGNOSED THAT SPARE TIRE CARRIER ASSEMBLY CABLE WAS CORRODED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 10V160000 (STRUCTURE); HOWEVER, THE RECALL PART NEEDED WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE FAILURE MILEAGE AND VIN WERE UNKNOWN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10563460February 7, 2014
VEHICLE SPEED CONTROL, FUEL SYSTEM, GASOLINE
THE TOYOTA SIENNA'S GAS PEDAL HAS BEEN AND REMAINS INTERMITTENTLY STICKY. IT TAKES SOME FOOT STOMPING TO DEPRESS THE GAS PEDAL IN ORDER TO ACCELERATE THE VEHICLE. TOYOTA DOES NOT BELIEVE THIS TO BE A MAJOR PROBLEM WHEN I QUESTIONED THEM A FEW YEARS AGO. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10505892April 11, 2013
STRUCTURE:BODY, VISIBILITY
THE REAR WINDOW AT DRIVER SIDE STARTED TO LOOSE ABOUT 6 MONTHS AGO. AT THE BEGINNING, IT MADE NOISE WHEN OPEN THE REAR WINDOW. SO WE KEPT IT CLOSED ALL THE TIME. BUT GRADUALLY, IT IS GETTING WORSE AND WORSE. NOW EVEN WITH THE WINDOW CLOSED, THE WINDOW STILL SHAKES AND MAKES NOISES, SOUNDS LIKE THE WINDOW GLASS WILL DROP AT TIME. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10495271January 30, 2013
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 2003 TOYOTA SIENNA. THE CONTACT STATED THAT WHILE SHIFTING INTO REVERSE, THE VEHICLE INDEPENDENTLY ACCELERATED AND CRASHED INTO ANOTHER VEHICLE. THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO A DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED BUT PROVIDED NO ASSISTANCE. THE FAILURE MILEAGE WAS 74,000. UPDATED 3/13/13 *CN THE CONSUMER STATED THE DEALER DID NOT FIND ANYTHING MECHANICALLY WRONG. THE VEHICLE WAS SOLD BACK TO THE DEALER. UPDATED 04/09/2013 *JS
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10464763July 9, 2012
SERVICE BRAKES
TL* THE CONTACT OWNS A 2003 TOYOTA SIENNA. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, SHE APPLIED THE BRAKE AND THE PEDAL WAS LOCKED. THE FAILURE RECURRED NUMEROUS TIMES AND THE ABS BRAKE LIGHT ILLUMINATED DURING THE FAILURE. ADDITIONALLY, THE WHEELS WOULD SEIZE AT TIMES, CAUSING THE VEHICLE TO SKID. THE VEHICLE WAS TAKEN TO A PERSONAL MECHANIC FOUR DIFFERENT TIMES FOR A DIAGNOSIS, HOWEVER THE FAILURE COULD NOT BE REPLICATED. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 75,000 AND THE CURRENT MILEAGE WAS 75,618.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10446393February 3, 2012
STRUCTURE:BODY, STRUCTURE:BODY:DOOR
JULY 31, 2009 THIS WAS THE STATE OF THE CAR: DRIVER SIDE DOOR MAKES A POPPING NOISE. AUTOMATIC PASSENGER SLIDING DOOR IS NOT SMOOTH WHEN OPENING. FEB 2, 2012: THE DRIVER SIDE POPPING NOISE HAS GOTTEN MUCH WORSE. THE PASSENGER SLIDING DOOR NO LONGER WORKS. *KB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10445773January 29, 2012
STRUCTURE:BODY
DRIVER AND FRONT PASSENGER DOOR STARTED MAKING LOUD CLICKING SOUNDS WHEN OPENING AND CLOSING DOORS BACK IN MAY OF LAST YEAR. THEN ABOUT 2 MONTHS AGO, THE FRONT PASSENGER DOOR WOULD NOT CLOSE FULLY AND WOULD ONLY OPEN UP A FEW INCHES. AFTER I WAS ABLE TO OPEN UP, I NOTICED THE DOOR WELD HAD SNAPPED AND BROKEN OFF (WHERE IT ATTACHES TO THE DOOR). I SEARCHED ONLINE AND FOUND OUT THIS IS A COMMON PROBLEM WITH SIENNAS AND THERE WAS A SERVICE BULLETIN FOR THIS PROBLEM, ALTHOUGH NOT FOR MY YEAR. FROM WHAT I'VE READ, DOOR WELDS ARE NOT SUPPOSE TO BREAK OFF ON DOOR AND THIS IS A SERIOUS DEFECT THAT TOYOTA SHOULD TAKE CARE OF. *TT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10445097January 24, 2012
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2003 TOYOTA SIENNA. THE CONTACT STATED THAT THE REAR DRIVER SIDE SLIDING DOOR WOULD NOT OPEN. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CONTACT ALSO STATED THAT THE VEHICLE EXPERIENCED A RECURRING FAILURE IN THE PAST IN WHICH BOTH REAR DOORS WOULD EXPERIENCE DIFFICULTY LOCKING. THE FAILURE MILEAGE WAS 140,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10444019January 17, 2012
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS 2003 TOYOTA SIENNA. THE CONTACT STATED THE INSTRUMENT PANEL ON THE VEHICLE DOES NOT WORK AND WHEN THE VEHICLE EXCEEDS 30-40 MPH, IT SLOWS DOWN AND THE ALL OF THE WARNING LIGHT ILLUMINATE. THE LOCAL MECHANIC REPLACED THE SENSORS FOR THE COMPUTER, BUT THAT DID NOT CORRECT THE PROBLEM. THE VEHICLE WAS NOT INSPECTED BY A DEALER. THE FAILURE MILEAGE WAS UNKNOWN, BUT THE CURRENT MILEAGE WAS 74,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10424013September 6, 2011
POWER TRAIN
SOME TIMES WHEN AT TRAFFIC LIGHTS THE ACCELERATOR PEDAL IS HARD TO PUSH(GO). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10421116August 23, 2011
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
TL* THE CONTACT OWNS A 2003 TOYOTA SIENNA. THE CONTACT STATED THE SLIDING REAR DOORS WERE DEFECTIVE. THE SLIDING DOORS WOULD NOT LATCH PROPERLY AND OCCASIONALLY THE REAR DOORS WOULD NOT OPEN OR CLOSE. THE MANUFACTURER WAS NOT NOTIFIED. THE DEALER WAS NOTIFIED, BUT DENIED ANY ASSISTANCE WITH REPAIRS TO THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 100,000 AND THE CURRENT MILEAGE WAS 150,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10416552August 1, 2011
TIRES
TL* THE CONTACT OWNS A 2003 TOYOTA SIENNA WITH TOYO EXTENSA TIRES, TIRE SIZE 215/65/15. THE CONTACT STATED THAT THE TIRE PRESSURE WARNING LAMP ILLUMINATED AND NOTICED THE REAR PASSENGER SIDE TIRE WAS FLAT. THE VEHICLE WAS TAKEN TO A MECHANIC WHO STATED THAT AN OBJECT PUNCTURED THE TIRE AND A PATCH WAS USED TO REMEDY THE FAILURE. THREE MONTHS LATER THE SAME TIRE WAS PUNCTURED AGAIN BY A SMALL ROCK. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE TIRE WAS REPLACED. THE FAILURE MILEAGE WAS 106,000 AND THE CURRENT MILEAGE WAS 108,800.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10381391February 10, 2011
LATCHES/LOCKS/LINKAGES
WE HAVE A 2003 TOYOTA SIENNA MINIVAN. THE DRIVERS SIDE AUTOMATIC DOOR NOW WILL NOT OPEN MANUALLY OR AUTOMATICALLY. I HAVE A DAUGHTER WHO IS HANDICAPPED AND THIS IS THE EASIEST DOOR TO PUT HER IN THE CAR, SO AS OF RIGHT NOW THE CAR THAT HOLDS HER WHEELCHAIR IS COMPLETELY USELESS TO US. TOYOTA HAS BEEN ABSOLUTELY NO HELP. THIS IS VERY DANGEROUS. WHAT IS SHE WAS IN THE CAR AN ACCIDENT OCCURRED AND WE COULD NOT GET HER OUT???? *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10381284February 9, 2011
VEHICLE SPEED CONTROL
TL*THE CONTACT OWNS A 2003 TOYOTA SIENNA. THE CONTACT WAS DRIVING WHEN THE VEHICLE SUDDENLY ACCELERATED. IT WENT THROUGH THE CONTACT'S GARAGE AND INTO THEIR LIVING ROOM. THE VEHICLE WAS DESTROYED. THERE WERE NO INJURIES. THE VIN WAS UNAVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE 112,000.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10378746January 26, 2011
STRUCTURE:FRAME AND MEMBERS
BOTH OF THE REAR DOORS IN MY TOYOTA SIENA WILL NOT OPEN FROM EITHER SIDE. TO GET OUT OF THE CAR IN AM EMERGENCY PEOPLE HAVE TO CLIMB OVER TO THE FRONT SEATS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10366761November 18, 2010
STRUCTURE:BODY:HATCHBACK/LIFTGATE, LATCHES/LOCKS/LINKAGES
THE HANDLE ON THE LIFT GATE FOR MY 2003 TOYOTA SIENNA BROKE OFF RIGHT IN MY HAND. THE GATE REMAINS LOCKED AND UNABLE TO OPEN IT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10357050September 22, 2010
STRUCTURE:BODY:DOOR, LATCHES/LOCKS/LINKAGES
BROKEN CABLE FOR SLIDING DOOR OF MY 2003 TOYOTA SIENNA. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Sienna