Toyota Grand Highlander Complaints (2025)

66 consumer complaints on file.

#11760011August 27, 2026
SEATS, UNKNOWN OR OTHER
Load cabin wind noise. Service said it was the luggage bars on the roof. I removed the bars and the noise was the same. Came back to the shop on August 22, 2026 they looked and said the panoramic seal was lifting and leaking. Before buying the car we were told the prior issue with panoramic sunroofs leaking had been resolved. In addition the plastic handle that controls the middle seat broke off after using it three times.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11759845August 26, 2026
FUEL/PROPULSION SYSTEM
I have noticed on several separate occasions a strong gas odor coming from my 2025 Toyota Grand Highlander after I have completed a drive. This has been intermittent, however, yesterday on XXX, the gasoline odor was so strong after I parked my vehicle in my garage, that it quickly filled the garage with an overwhelming odor. My son urgently came to get me when he stepped into the garage and realized how strong the fumes were. We had to open the garage to air it out. I called the Larry Miller Peoria Toyota dealership immediately and had my vehicle inspected the following day on XXX. I was informed by the service advisor that Toyota receives numerous complaints daily about this very issue with the newer model Highlanders, Grand Highlanders, Tacomas, and 4Runners. I insisted that my vehicle be inspected. The report stated that they were unable to duplicate the condition. The report states that no leaks were found with the evap system. The report also states that whe outside temps are extremely high, fuel inside the tank expands and creates additional vapor. I was assured by the service team that the fuel tank is operating correctly, despite the overwhelming fuel vapors that are intermittently emitted. I have lived in [XXX] my entire life and I have never encountered this issue with any vehicle that I have owned. These fumes are toxic and I am very concerned about my family being exposed and our safety/wellbeing. I have installed a carbon monoxide monitor in my garage. I have also filed a formal complaint at the Corporate level within Toyota and am awaiting a response. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11759592August 25, 2026
ENGINE, POWER TRAIN, VEHICLE SPEED CONTROL
I continuously have issues accelerating from stop in my max hybrid. the issue is particularly worse when it is warm out. I press the gas and the RPMs drop really low and I barely move through the intersection for a few seconds. Once it finally registers after a number of seconds, the RPMs rev up over 4000. It is very dangerous trying to proceed through an intersection and the car basically stalls when I press the gas. It especially concerns me that I have my child in the car with me and I worry when it is going to act up. I know others have experienced this issue and there was a TSB for 2024 models that had this issue. I have a 2025 and experience this issue. I have had toyota look at it and they said they cant do the TSB since it's bot for my VIN. A solution needs to be found for the the safety of myself and others.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11759572August 25, 2026
UNKNOWN OR OTHER
I have over 30k miles on my car. Over the period that I’ve owned it there have been a few, roughly 6, occasions where I’m trying to change lanes from a stop into quick traffic and my car lags 1-3 seconds in response to me pressing the gas petal. It happens infrequently and is not the normal response. Other times the car responds as one would expect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11759369August 25, 2026
UNKNOWN OR OTHER
on 8/13/2026, I was driving alone on West I-80 right before Park City, Ut; I heard a loud pop and my panoramic sunroof exploded which was really scary. I was not using my sunroof at all, so the cover protected everything on the inside. At first I thought it was a flat tire, but no warning messages came onto the control panel. There were not immediate safety issues, so I was able to get to a Toyota Dealership to have it repaired. I did not hear any gravel or road debris flip up onto my sunroof, nor did I hear any under my tires when driving. My vehicle was inspected by a service technician at the Toyota Dealership and he just said it was probably caused by an outside influence.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11758770August 22, 2026
UNKNOWN OR OTHER
My wife was driving and a small rock passed through the front grill puncturing the radiator and causing her check engine light to come on. Within 5 minutes the coolant leaked out and the car was undrivable. We took it to Bredemann Toyota in Park Ridge who replaced it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11754788August 4, 2026
ENGINE, ELECTRICAL SYSTEM
Rodent damage to plant based wiring to Engine Harness A and valve vacuum hose. Cost $1700 and 2 repairs.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11753991July 31, 2026
STRUCTURE:BODY
Driving on highway and suddenly panoramic sunroof glass shattered spontaneously. It nearly caused us to crash into median due to the sudden extremely loud noise that sounded like a gunshot at close range and then the sound of glass shattering and hitting into sunroof shade and top of car. My 18 year old daughter was driving and it was extremely scary for her and myself. No nearby vehicles on either side of the road or near an overpass. We were fortunately near an exit and able to safely remove vehicle from road. I feel extremely lucky that no accident or injury occurred and credit my daughter's ability to stay calm and not panic at highway speed. To date, the car insurance company Travelers states it is not covered as there was no accident and dealership states it is not a warranty item (but they have escalated it to Toyota corporate for further review) and no one is willing to repair it so far (including stand alone glass companies!). But it will certainly be several thousand dollars in repairs. In the meantime I cannot drive my car when there is any chance of rain or really at highway speed. No warning prior, no history of any cracks or damage to sunroof prior. The car is just barely 1 year old.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11752775July 25, 2026
FUEL/PROPULSION SYSTEM
The component that was available for inspection was our gas tank. It provided a profuse smell of fumes coming out of the tank and/or exhaust. You could also see vapors coming out of the gas tank when driving. The fumes alone are extremely toxic and extreme levels. The safety of me, my two young children and husband is all at risk. The smell of the gas and the view of the vapors from the gas tank puts the vehicle at an extreme fire risk. The smell of the fumes out it at a toxic inhalant risk - especially having two young children. This has caused great fear within me and the safety of my children is at extreme risk. No. I have taken the vehicle to the dealer 2-3 times, advised each time there is no issue with the vehicle. However, the smell of the gasoline has happened 6-8 times since purchasing the vehicle in May 2025. The vehicle has only been inspected by the dealer. Unsure who else to bring it to. The first time it was towed because the smell of the gas was in the cabin of the vehicle and I did not feel safe having my two small children in it with the extreme gas smell. No, no warning lamps. No indicators. The first time it happened I was alone with my two small children and the only indicator was the vapors coming out of the tank that were visible, and the extreme smell of the gasoline when I would roll my window down.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11752130July 22, 2026
FUEL/PROPULSION SYSTEM, POWER TRAIN, VEHICLE SPEED CONTROL
After a complete stop at a stop sign there is hesitation/stalling when trying to accelerate. Sometimes the hesitation is several seconds and then the engine kicks in and lurches forward. Couple times this has been a safety issue as it happens when I’m trying to pull out on a busy road. The delay/hesitation has caused me to almost get hit a few times. There are no lights or warning messages when this happens. It happens a multiple times a week especially during hot weather when AC is on full (LO temp setting and maximum fan) and is usually during the first few minutes of operation usually at the same stop signs on my route to pickup my kids after the car has been sitting unused overnight. I also notice that the hybrid battery indicator is usually always at 3 bars. Dealership hasn’t been able to reproduce as it's a very specific scenario (not driving/in garage overnight and short drive). Instead they went and applied T-SB-0040-25 but this hesitation is still happening after the software update. This needs to be handled like a safety issue/recall worthy with a complete fix! Not just some drivability issue that only gets applied if we ask about specific T-SBs.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11750898July 16, 2026
POWER TRAIN
On occasion the car will not accelerate from a dead stop like it should. I think it’s turbo lag. There have been a few times I thought I was going be broadsided pulling out into traffic when normal acceleration would have been safe but with a dead pedal for a few seconds it was terrifying. I’ve brought this up to two different dealers and they say without being able to experience it there’s nothing they can do. Someone going to die because of this.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11750610July 15, 2026
ENGINE
This vehicle has just over 18,000 miles on it and is 14 months old. It has a manufacturer design defect that allows small stones or birds to hit and puncture the air conditioning condenser. It is a known defect and Toyota refuses to warranty their product, forcing the consumer to pay out of pocket $1,500-$1,700 for repairs. Oddly, the sister Lexus vehicle has a screen over the condenser to prevent this.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11750573July 15, 2026
VEHICLE SPEED CONTROL, POWER TRAIN, ENGINE
After coming to a complete stop at a stop sign or stop light, then trying to go, the vehicle will stall. It will not go when given gas. The first time it happened, I was at a busy intersection with oncoming traffic coming towards me with the pedal to the floor, nothing would happen for 5-10 seconds. It was terrifying. Thank god the car coming towards us went around in time. It then happened again in my neighborhood a week later. Thankfully that time I wasn’t in traffic. I have noted that it seems to happen when very hot outside (Florida July summer) and air is on full blast. Also seems to be happening only during the first trip of the day, within the first 5-10 minutes of said trip. The dealership has not been able to recreate this to see for themselves. I think it would have to be with them overnight and they start it/drive it for the first time that day. It has now happened a total of 3 times since I’ve been driving it (2.5 months). I have 3 children and very worried I will get t-boned one day when it stalls next. I love my car so much so it’s heartbreaking that I have to drive it in fear. No lights/warnings/messages when this happens.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11750413July 14, 2026
ELECTRICAL SYSTEM, ENGINE, FUEL/PROPULSION SYSTEM
Radiator issue summer of 2025, when in back to back traffic at low speeds my vehicle overheated at a stand still took vehicle in to dealership with no real answers. The following summer 2026 same scenario but the engine was smoking. Took into dealership and they stated the connection for the radiator fan was disconnected which meant it was not colling the engine. A month later the AC is blowing hot air when AC is set to the coolest setting, scheduled another appt with dealership likely another radiator issue. Fuel gauge inaccuracy. Manual states 17 gallon tank capacity but my car states empty and can only fill the tank with 14 to 15 gallons. Dealership had no help and stated it does that to protect the hybrid engine. Transmission shifting issues, in the summer hotter temperatures I notice at times the transmission has difficulty shifting in lower gears and really revs up the RPMs to shift sometimes. At times the the transmission shift is jerky or harsh when going speeds form 20- 40 mph.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11745743June 22, 2026
FORWARD COLLISION AVOIDANCE: WARNINGS, LANE DEPARTURE: BLIND SPOT DETECTION, BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Subject: Potential Safety Defect Report – Infotainment System Interference with Driver Assistance Systems This submission reports a potential safety-related software interaction issue involving infotainment startup processes and Toyota Safety Sense 3.0 (TSS 3.0). During startup conditions, infotainment system activity coincides with delayed or unavailable driver assistance alerts and camera system functionality. Observed Conditions: - Delay or suppression of collision warning alerts - Temporary loss of rear and surround-view camera feeds - System unresponsiveness during startup sequence Safety Concern: Potential reduction in driver situational awareness during low-speed maneuvering due to system prioritization conflicts. Request: Evaluation for potential systemic safety defect and determination of whether further investigation or corrective action is warranted.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741981June 4, 2026
ELECTRICAL SYSTEM
While I was driving using the screen for the GPS the screen become black just sound. The volume got stuck and no image was displayed. Try to use manual control on steering wheel and they didn’t respond neither. Is not the first time that the screen freezes glows black or just glitches.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741165May 31, 2026
VISIBILITY/WIPER
While driving on the highway, I heard an extremely loud noise followed by rush of wind. I was not under or near an overpass and there was nothing to indicate an impact by a foreign object. I arrived at my house 10 minutes after the incident and inspected my car. I determined the noise I experienced was the panoramic sunroof, of which the front panel spontaneously exploded while operating the vehicle. I could find no other damage to the car. The sunroof and internal shade cover were closed and not in use, nor was I trying to operate them. The sunroof had a large hole in the center directly under a luggage rail, and the glass around the hole was angled upwards. The small shards of tempered glass were contained on top of the sliding sunroof shade. There was no foreign object, damage to the soft interior sliding shade, or any dents/scratches on the roof. Had the sliding shade been open, the shards would have rained down on me and any passengers (none at time of incident). There were no vehicle warnings of any kind. I took it to the Toyota dealer who inspected the damage but refused to cover it under warranty. I filed an insurance claim with photos and it was approved for repair.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741014May 30, 2026
SERVICE BRAKES, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
Adaptive cruise control causes quicker wear on rotors. Had to have them replaced at 16,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11739910May 25, 2026
UNKNOWN OR OTHER
Component that failed: Sunroof How was safety at risk: I was driving my 2025 Grand Highlander on Sunday, [XXX} in the morning. While I was driving, my sunroof exploded, causing a loud noise and a blowout in the front part of the sunroof (pictures included). There was no debris on the road or any other reason for the sunroof to have exploded. This was extremely shocking and concerning - if we had not kept the sunroof shade closed, the glass from the sunroof would have fallen directly on myself and my wife as we were driving, potentially causing an extremely dangerous situation. The sunroof blew outward, NOT inward as would have been expected if something had hit it and caused it to shatter. I also found multiple forums where I discovered that this is a common problem: [XXX] [XXX] [XXX] The problem is widespread enough across models that there is an ongoing lawsuit regarding panoramic sunroofs: [XXX] The dealer and Toyota are claiming that it had to be an external source, but again, there was no debris in the area or any other reason to cause the blowout. The vehicle has been inspected by the manufacturer's field service technicians. It is currently still at the dealer, awaiting final decision on coverage for the blowout. There were no warnings. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11739850May 25, 2026
STEERING, LANE DEPARTURE: ASSIST
While driving my new Grand Highlander, I have experienced a serious and recurring safety issue. Even with lane assist turned off, the vehicle automatically steers to the right when I exit a regular highway — apparently misinterpreting the widening road as a lane shift. When this happens, the steering overrides my input and I am forced to pull the wheel hard to regain control and stay in my lane. This loss of steering control is dangerous and frightening, and I am formally reporting it as a significant safety concern that requires immediate attention.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Grand Highlander