Toyota Grand Highlander Complaints

314 consumer complaints on file.

#11752231July 22, 2026
POWER TRAIN
I own a 2024 Toyota Grand Highlander Platinum Hybrid MAX with approximately 34,000 miles. The vehicle has experienced repeated delayed or absent acceleration from a complete stop, creating a serious risk when entering traffic. Before the most recent repair, I reported intermittent hesitation to the Toyota dealer. On Sunday, July 12, 2026, shortly after startup, the vehicle hesitated twice within the first half mile. At the second stop sign, I attempted a left turn into traffic and applied approximately 30% accelerator pedal. The engine was running, but the vehicle only crept forward at idle-level power for approximately three seconds. There was no noticeable increase in engine RPM and no warning lights. Normal power then returned. On July 15, 2026, the Toyota dealer performed TSB T-SB-0017-24 and updated the engine-control software for hesitation during acceleration. After that repair, the same loss-of-acceleration condition happened again while my wife was leaving a parking lot. She was stopped at a stop sign, making a right turn into traffic on a slight uphill grade, when the vehicle failed to provide normal acceleration. This was substantially similar to the earlier incident and occurred after the software update intended to correct the problem. The repeated failure to respond to accelerator input from a stop creates a collision risk because the vehicle can begin entering traffic without providing the expected power. I am requesting that NHTSA investigate whether this is a broader safety defect affecting the Grand Highlander Hybrid MAX and whether the existing software repair is effective.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11752130July 22, 2026
FUEL/PROPULSION SYSTEM, POWER TRAIN, VEHICLE SPEED CONTROL
After a complete stop at a stop sign there is hesitation/stalling when trying to accelerate. Sometimes the hesitation is several seconds and then the engine kicks in and lurches forward. Couple times this has been a safety issue as it happens when I’m trying to pull out on a busy road. The delay/hesitation has caused me to almost get hit a few times. There are no lights or warning messages when this happens. It happens a multiple times a week especially during hot weather when AC is on full (LO temp setting and maximum fan) and is usually during the first few minutes of operation usually at the same stop signs on my route to pickup my kids after the car has been sitting unused overnight. I also notice that the hybrid battery indicator is usually always at 3 bars. Dealership hasn’t been able to reproduce as it's a very specific scenario (not driving/in garage overnight and short drive). Instead they went and applied T-SB-0040-25 but this hesitation is still happening after the software update. This needs to be handled like a safety issue/recall worthy with a complete fix! Not just some drivability issue that only gets applied if we ask about specific T-SBs.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11752112July 22, 2026
STRUCTURE:BODY:HOOD
My 2026 Toyota Grand Highlander exhibits abnormal fluttering/vibration of the hood at speeds above approximately 25 mph. I have identified that this is the same defect documented in Toyota's own Technical Service Bulletin T-SB-0111-24 (issued December 4, 2024), which addresses this condition on 2024 model year Grand Highlander and Grand Highlander Hybrid vehicles, with the same complaint widely reported by 2025 model year owners as well. Despite this being a known, documented Toyota defect for three consecutive model years, I have been unable to get it resolved through Toyota's official channels: I contacted Toyota's PATT Lab (Parts and Technical Assistance) regarding the vibration under Dealership Task Number DC261970283. PATT Lab informed me that other 2026 model year vehicles exhibit the same condition, characterized it as "intended behavior," and closed the task without applying the known TSB remedy. I was directed to Toyota Brand Engagement for further assistance. This was opened as Case Number 260722000822. Toyota Brand Engagement stated they are not mechanics and that the issue must be resolved at the dealership level, but has provided no directive or authorization to the dealership to perform the known TSB repair. As a result, I am caught in a loop between Toyota corporate departments, none of which will authorize or perform the fix that Toyota's own engineering team has already documented and issued a bulletin for. My vehicle has a known manufacturing/design defect that Toyota has acknowledged in writing for prior model years, yet I am being told simultaneously that it is "normal" and that it's a dealership matter — while no dealership has been given authorization to apply the remedy. Requested Action: I am requesting that Toyota Motor Sales, USA be required to apply the existing Technical Service Bulletin remedy (or its 2026 model year equivalent) to my vehicle at no cost, consistent with how this defect has already been addressed for 2024 and 2025 mod
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11750959July 16, 2026
VISIBILITY/WIPER
I haven’t had no accident in my car
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11750898July 16, 2026
POWER TRAIN
On occasion the car will not accelerate from a dead stop like it should. I think it’s turbo lag. There have been a few times I thought I was going be broadsided pulling out into traffic when normal acceleration would have been safe but with a dead pedal for a few seconds it was terrifying. I’ve brought this up to two different dealers and they say without being able to experience it there’s nothing they can do. Someone going to die because of this.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11750786July 16, 2026
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
I've had consistent issues with the vehicle accelerating and shifting. These include sluggish acceleration, loss of power and sputtering when we've come to a complete stop and starting to move again. We've almost been hit by other vehicles at least over 20 times because the vehicle has failed to accelerate when pulling into a roadway. The car hesitates during acceleration regardless of how much I push the gas. Once it starts to go, it feels as though the car can't shift from 1st to 2nd gear, The RPMs get extremely high while the car is going 25-40 mph and remain there for a few seconds up to ~20 seconds. I am fearful of getting t-boned when my car hesitates while turning at an intersection, going through an intersection or pulling out from a parking lot. I have been stuck in several intersections when traffic was coming toward me, but thankfully those cars had patience and avoided us. I've also found that this issue always happens when the hybrid battery shows that it only has a charge of 3 bars. It seems that the engine, transmission and hybrid battery don't know how to communicate when the battery charge gets that low. This has been happening since Dec 2023 when I bought the vehicle and the dealer has never been able to duplicate or find any error code, they are refusing to fix a known issue when many others are experiencing the same issue. There are Toyota Technical Service Bulletins (TSBs) out there regarding this problem but my dealer told me they won't do anything as it could label my vehicle a lemon. This is creating an unnecessary safety risk for me and my family.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11750610July 15, 2026
ENGINE
This vehicle has just over 18,000 miles on it and is 14 months old. It has a manufacturer design defect that allows small stones or birds to hit and puncture the air conditioning condenser. It is a known defect and Toyota refuses to warranty their product, forcing the consumer to pay out of pocket $1,500-$1,700 for repairs. Oddly, the sister Lexus vehicle has a screen over the condenser to prevent this.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11750573July 15, 2026
VEHICLE SPEED CONTROL, POWER TRAIN, ENGINE
After coming to a complete stop at a stop sign or stop light, then trying to go, the vehicle will stall. It will not go when given gas. The first time it happened, I was at a busy intersection with oncoming traffic coming towards me with the pedal to the floor, nothing would happen for 5-10 seconds. It was terrifying. Thank god the car coming towards us went around in time. It then happened again in my neighborhood a week later. Thankfully that time I wasn’t in traffic. I have noted that it seems to happen when very hot outside (Florida July summer) and air is on full blast. Also seems to be happening only during the first trip of the day, within the first 5-10 minutes of said trip. The dealership has not been able to recreate this to see for themselves. I think it would have to be with them overnight and they start it/drive it for the first time that day. It has now happened a total of 3 times since I’ve been driving it (2.5 months). I have 3 children and very worried I will get t-boned one day when it stalls next. I love my car so much so it’s heartbreaking that I have to drive it in fear. No lights/warnings/messages when this happens.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11750413July 14, 2026
ELECTRICAL SYSTEM, ENGINE, FUEL/PROPULSION SYSTEM
Radiator issue summer of 2025, when in back to back traffic at low speeds my vehicle overheated at a stand still took vehicle in to dealership with no real answers. The following summer 2026 same scenario but the engine was smoking. Took into dealership and they stated the connection for the radiator fan was disconnected which meant it was not colling the engine. A month later the AC is blowing hot air when AC is set to the coolest setting, scheduled another appt with dealership likely another radiator issue. Fuel gauge inaccuracy. Manual states 17 gallon tank capacity but my car states empty and can only fill the tank with 14 to 15 gallons. Dealership had no help and stated it does that to protect the hybrid engine. Transmission shifting issues, in the summer hotter temperatures I notice at times the transmission has difficulty shifting in lower gears and really revs up the RPMs to shift sometimes. At times the the transmission shift is jerky or harsh when going speeds form 20- 40 mph.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11748006July 2, 2026
SEATS
The passenger-side second-row bench seat (60 percent section of the 60/40 split) has a defective seat track/latch assembly that fails in both directions: it seizes completely when it should slide, and it failed to stay latched while the vehicle was in motion. The seat saw almost no use for the first 34 months of ownership (third row kept folded). Within two weeks of its first regular use (XXX, approx. 45,700 miles), it seized completely and could not be moved in either direction. An authorized Toyota dealership in Placerville, CA disassembled the seat and documented in writing that the seat track was twisted and rubbing against the seat frame. The dealer straightened the track rather than replacing it and stated on the invoice that if the seat stopped moving again, both seat tracks should be replaced and the seat frame itself may need replacement or adjustment. After that repair, in approximately mid-June 2026, the bench slid FORWARD on its own as my wife braked for a stoplight, the track failed to remain latched with the vehicle in motion. Two rear-facing infant car seats are installed on this bench, and our toddlers reach the third row through this seat. On XXX (approx. 46,416 miles, 33 days and about 700 miles after the repair), the seat seized again. The vehicle is currently at a second authorized Toyota dealership in [XXX] for diagnosis and is available for inspection upon request. Safety risk: a second-row seat that does not remain latched cannot properly restrain occupants or anchored child restraints during hard braking or a crash, and a seized seat blocks third-row access and egress for children, including in an emergency. There were no warning lamps or prior symptoms before either failure. Note: NHTSA recall 26V128 covers 2021-2024 Highlander second-row seats that fail to lock; this Grand Highlander is not included in that campaign but exhibits a similar failure to remain latched. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11747691July 1, 2026
FUEL/PROPULSION SYSTEM, VEHICLE SPEED CONTROL
On a recent road trip I experience loss of acceleration twice. I was at a stop sign making a left hand turn. I step on the accelerator it start forward but then stop suddenly leaving me in the 1st lane of on coming traffic. I smashed on the accelerator several time before the vehicle finally responded. I took the vehicle to the dealer on 6/30 told the dealer what had happen along with my google findings acceleration hesitation and sudden lurching in the Toyota Grand Highlander Hybrid MAX Technical Service Bulletins (TSBs), including T-SB-0017-24. The dealer could not duplicate or find any error code, they are refusing to fix a known issue. They are creating an unnecessary safety risk for me and my family.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11747635July 1, 2026
UNKNOWN OR OTHER
Driving down the highway and the sunroof exploded
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11747505June 30, 2026
ENGINE
Component: Automatic transmission, 2026 Toyota Grand Highlander Hybrid MAX Platinum AWD. Available for inspection. Purchased new 11/21/2025 at zero miles. Beginning ~2000 miles (est Feb 2026), intermittent transmission malfunction during acceleration: transmission holds gears at elevated RPMs beyond expected shift point, then shifts harshly or shudders violently. Documentation began 6/1/2026; current odometer 8936 miles. Occurs from 22–64 mph, most commonly 30–44 mph, in Normal and Sport modes, after cold starts, extended driving, and brief stops. RPMs typically hang at 3500–4000 before shifting. Documented incidents over the last month: June 1, 2026, 3:20 PM: Approximately 1 min after cold start, turned right at a light to 33 mph. Violent shake and abnormally loud acceleration during gear change. June 2, 2026, 3:00 PM: Turning right and accelerating after driving approximately 1 min, transmission revved high; had to release throttle to force the shift. June 11, 2026, 4:40 PM: After cold start, driving up a small incline about .4 miles away, transmission revved high and delayed shift at 35–45 mph. June 12, 2026, 3:17 PM: After 17 minutes of driving, accelerating from a cloverleaf around 25 mph to 64 mph, revved at 4000 June 19, 2026, 3:00 PM: After 2 hours of driving and a 5 min stop, turning right out of a shopping center, transmission hung up three consecutive times at 35–40 mph, RPMs at 3500–4000. June 20, 2026, 11:17 AM: Accelerating off a cloverleaf at 57 mph. RPMs hung at 4000 before shifting. June 30, 2026, 10:23 AM: Pulling out of neighborhood after backing out of driveway. RPM hang at approximately 22 mph, then again at 43 mph Safety risk: Unexpected RPM surge and violent gear change during acceleration on highway on-ramps, cloverleaf merges, and intersections creates unpredictable vehicle response at speed, presenting collision risk to driver and surrounding vehicles Dealer/service: Not confirmed by dealer. Assessed at ~6000 miles with no issues found
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746510June 25, 2026
ENGINE, ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
While driving my 2024 Toyota Grand Highlander Hybrid AWD at highway speed with only 16,755 miles on the vehicle, multiple warning messages suddenly appeared, including warnings related to the engine, hybrid system, AWD system, and other vehicle functions. The vehicle instructed me to pull over immediately and significantly reduced power output, making it difficult to maintain highway speed and safely maneuver through traffic. I was able to reach the shoulder and had the vehicle towed to a Toyota dealership. The dealer diagnosed a punctured radiator caused by a rock or similar road debris that allegedly passed through the front grille and struck the radiator. The dealer confirmed that coolant loss from the puncture triggered the vehicle's protective reduced-power mode. This failure created a significant safety risk. A sudden loss of power while traveling at highway speed increases the risk of rear-end collisions and other accidents, particularly in heavy traffic where drivers may not expect a vehicle to rapidly decelerate. There were no warning lights, messages, leaks, drivability concerns, or other symptoms before the incident. All warnings appeared suddenly at the time of failure. Toyota has declined warranty coverage, classifying the damage as a road hazard. However, I believe this may indicate a design defect. I have identified numerous reports from other GH owners describing nearly identical failures involving rocks penetrating the radiator through the front grille, often at relatively low mileage. These reports suggest the radiator may be inadequately protected from ordinary roadway debris. My concern is not simply radiator damage, but that a small piece of road debris encountered during normal driving can disable a critical component and cause the vehicle to enter a severe reduced-power mode at highway speed. I request that NHTSA investigate whether the front grille and radiator protection design of the Grand Highlander creates an unreasonable safety risk
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11745922June 23, 2026
POWER TRAIN, ENGINE
Vehicle: 2024 Toyota Grand Highlander Hybrid Max The vehicle intermittently experiences a severe hesitation and shudder during acceleration from approximately 0-40 mph. The condition occurs only under specific circumstances: -The vehicle has been parked long enough for the engine, transmission, and related systems to cool to ambient air temperature. -The vehicle is started and driven shortly thereafter. -Engine oil and transmission temperatures are below approximately 160°F. -The air conditioning system is operating at maximum cooling with Eco Air Mode enabled. -The hybrid battery indicator displays approximately three bars of charge. When these precise conditions are present, the vehicle may hesitate, shudder, and fail to respond normally to accelerator pedal input during acceleration. Even with the accelerator pedal fully depressed, repeatedly, there is a noticeable delay in power delivery and vehicle acceleration. This creates a situation where the vehicle does not accelerate as expected when entering traffic or attempting to increase speed. The vehicle has previously received Toyota Technical Service Bulletin T-SB-0017-24; however, the condition continues to occur intermittently. No warning lights, diagnostic messages, or system faults are displayed when the event occurs. The condition typically occurs only once during the initial drive cycle after a cold start and has not been observed after the vehicle reaches normal operating temperature. The issue is most common in the warmer months and has never been encountered at freezing or below temperatures.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11745755June 22, 2026
UNKNOWN OR OTHER
Bought the vehicle in October 2025 everything was going fine. I went away for a few days came back and the A/C was not working. I took it to the dealership where I purchased it and was told outside influence and they refused to repair unless I pay $1900. I have bumper to bumper coverage for 5 years, My point is for a SUV that is costing over $50,000. If the condenser is such a sensitive piece of equipment it shouldn't not be placed in front of the vehicle unprotected. This is a design flaw because the SUV is made to be driven on the highway.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11745743June 22, 2026
FORWARD COLLISION AVOIDANCE: WARNINGS, LANE DEPARTURE: BLIND SPOT DETECTION, BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Subject: Potential Safety Defect Report – Infotainment System Interference with Driver Assistance Systems This submission reports a potential safety-related software interaction issue involving infotainment startup processes and Toyota Safety Sense 3.0 (TSS 3.0). During startup conditions, infotainment system activity coincides with delayed or unavailable driver assistance alerts and camera system functionality. Observed Conditions: - Delay or suppression of collision warning alerts - Temporary loss of rear and surround-view camera feeds - System unresponsiveness during startup sequence Safety Concern: Potential reduction in driver situational awareness during low-speed maneuvering due to system prioritization conflicts. Request: Evaluation for potential systemic safety defect and determination of whether further investigation or corrective action is warranted.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11745206June 19, 2026
POWER TRAIN
A couple of days ago, I was driving when my Toyota Grand Highlander started displaying a series of alerts. These alerts included "Hybrid system malfunction" "All Wheel Drive malfunction," "Check engine. See dealer," and finally something akin to "Find a safe place to pull over and turn off vehicle." Until these alerts appeared, back-to-back-to-back, there were no indications that there was anything wrong with the car. We were fortunate enough to be both close to home and close to a dealership when this happened and were able to bring the car in right away. If we were in a high traffic situation, or, conversely, in a very rural area (specifically in winter, not an unlikely happening for us), having the car's drive system suddenly fail out of nowhere could have been very dangerous. As I said, we were able to get the car to the dealer soon after. The dealership informed us that the car has a coolant system perforation, more than likely from a rock penetrating the grill. The coolant than leaked, causing the hybrid system/other failures the car noted. I have since done some research on this issue and have found, to my dismay and disappointment, that this isn't an uncommon issue with the Grand Highlander and the Highlander. There are many instances of people on social media saying a similar issue happened with their cars - one other person's dealership quoted them the exact same amount of the repair that our dealership did. In fact, this is such a common issue that there is apparently already an established workaround: other owners have ordered aluminum mesh from third party vendors and have zip-tied it to their grills in order to keep the rocks out. This is an absurd thing to have to do. Consumers should not, in the year 2026, have to drive down the road with concern that a loose pebble will put their car out of commission. Cars should be able to withstand this very common occurrence without taking substantial damage. This seems like a design flaw.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741981June 4, 2026
ELECTRICAL SYSTEM
While I was driving using the screen for the GPS the screen become black just sound. The volume got stuck and no image was displayed. Try to use manual control on steering wheel and they didn’t respond neither. Is not the first time that the screen freezes glows black or just glitches.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741165May 31, 2026
VISIBILITY/WIPER
While driving on the highway, I heard an extremely loud noise followed by rush of wind. I was not under or near an overpass and there was nothing to indicate an impact by a foreign object. I arrived at my house 10 minutes after the incident and inspected my car. I determined the noise I experienced was the panoramic sunroof, of which the front panel spontaneously exploded while operating the vehicle. I could find no other damage to the car. The sunroof and internal shade cover were closed and not in use, nor was I trying to operate them. The sunroof had a large hole in the center directly under a luggage rail, and the glass around the hole was angled upwards. The small shards of tempered glass were contained on top of the sliding sunroof shade. There was no foreign object, damage to the soft interior sliding shade, or any dents/scratches on the roof. Had the sliding shade been open, the shards would have rained down on me and any passengers (none at time of incident). There were no vehicle warnings of any kind. I took it to the Toyota dealer who inspected the damage but refused to cover it under warranty. I filed an insurance claim with photos and it was approved for repair.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Grand Highlander