Ram 3500 Complaints (2022)

187 consumer complaints on file.

#11529858June 30, 2023
POWER TRAIN
K1 snap ring failure as described in TSB 21-002-23. Vehicle was towed to dealer and diagnosis confirmed. No issues prior to sudden transmission failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11529677June 29, 2023
POWER TRAIN
Transmission failure, would not go into gear, heard loud banging under the truck
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11529509June 29, 2023
POWER TRAIN, ELECTRICAL SYSTEM
The contact owns a 2022 Ram 3500. The contact received notifications of the NHTSA Campaign Number: 22V835000 (Power Train) and 23V060000 (Electrical System) however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated the Urgent Important recall and the Contact the Dealer Immediately message was displayed on the instrument panel on June 29, 2023. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was 15,000. Parts distribution disconnect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11529284June 28, 2023
POWER TRAIN
The contact owns a 2022 Ram 3500. The contact stated that while hauling a 14,000 lbs. load at approximately 70 MPH, there was a loud explosion underneath the vehicle. The vehicle suddenly came to a halt as if the transmission had failed. The vehicle was hesitating while shifting gear, especially while switching lanes. The contact was able to coast to the side of the roadway and had the vehicle towed to the dealer. The dealer informed the contact that the K1 clutch pack had failed. The contact related the failure to NHTSA ID Number: 21-002-23 (Power Train, Exterior Lighting) however, the dealer had not checked the K2 portion of the repair which implied that the vehicle may not have had a complete repair. The manufacturer was made aware of the failure. The approximate failure mileage was 20,667.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11529057June 27, 2023
POWER TRAIN, POWER TRAIN:AUTOMATIC TRANSMISSION
While driving my new Ram truck towing our camper on I 95 around the DC area, I heard and felt a pop noise and our transmission failed. My truck only has 3000 miles on it. I’m discovering that Ram is aware of this issue and won’t make it a recall.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11528483June 23, 2023
POWER TRAIN, VEHICLE SPEED CONTROL, SERVICE BRAKES
Without warning the transmission failed. Along with loss of power, when the tranny failed, the ability to use the exhaust brake also fails. The ability to manually downshift fails. I was on steep winding roads in North Idaho (Elk River) when this occurred with three passengers aboard. Once I was able to stop, I was on a steep uphill grade with no forward gears or shoulder to pull over on. I had to coast in neutral back down the mountain to an appropriate site to get off the road. All of this with no forward or reverse gears. The vehicle was towed to a dealership where it was determined to have the K-1 snap ring failure in the Aisin transmission. This problem is common enough that parts to repair the transmission are on back order with no definitive eta available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11528093June 21, 2023
POWER TRAIN
This is a new vehicle with 747 miles on the odometer. A critical transmission failure occured while towing in traffic. We lost all ability to move forward. A Ram dealer has the truck now and is reporting it is the Aisin transmission that failed. An internal snap ring is the issue. They also told us this problem is happening to hundreds of customers across the country
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11527544June 17, 2023
POWER TRAIN, POWER TRAIN:AUTOMATIC TRANSMISSION
On our 1st day of our 10 day vacation heading East on Hwy 26 to Crescent, OR. At Government Camp going up in elevation, our 2022 Dodge Ram Diesal 3500 4x4, stopped going. We were pulling a 32' 5th wheel at about 14,000 #. We pulled off the road and put it into park, let it sit then tried to put it into drive again and it would not go. The transmission rattled and made all kinds of noise. THERE WERE NO INDICATIONS ON THE DASH OF ANY ISSUES! We put it into park and called 911 to assist in a tow truck. We had to wait for about 1 1/2 hours for the truck. An officer came up behind the trailer as we were on a curve and blindspot. We were on the white line!!!!!!! The tow truck had to pull us (because of the 5th wheel) to the snow park parking lot. Tow truck driver had to line us up then we had to unhook the trailer so he could take it to a Dodge Dealer. We spent the night in the trailer until the next day when we had to hire another tow truck from where we lived to come pick us up and take us back home. This excursion set us up for 2 individual companies, ugh! the 1st one only went back to Boring, OR and the truck sat there until the next day to be taken to Grasham Dodge. Gresham did not have the manpower to assess the situation and or fix the problem so from Gresham Dodge had to take it to Dick Hannah in Vancouver, WA only to then be taken across the street to Dick Hannah Jeep in the overflow area. Not secured and we found the passenger window open when we went to get the rest of our stuff. Have a service team manager, Austin, from Dick Hannah CJDR to have contact with regarding our truck. I heard there is no recall on the transmissions yet but from going on to the forums and seeing all of the other Dodge Ram owners, there should be. All of this should be completely covered by Dodge even the towing as if this had not occurred, we wouldn't be in debt of $4,566.53. We lost our first vacation and probably for the rest of the summer as we had numerous ones set up. Thank you
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11526585June 12, 2023
POWER TRAIN
The contact owns a 2022 Ram 3500. The contact stated while driving approximately 42 MPH, the vehicle lost motive power. There were no warning lights illuminated. The vehicle was towed to the local dealer where it was diagnosed that the snap ring had detached. The vehicle was not repaired due to parts being on backorder. The manufacturer was contacted but no additional assistance was provided. The failure mileage was approximately 10,562.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11526305June 9, 2023
POWER TRAIN
Truck fails to properly accelerate when pulling out into traffic. There is a massive delay from pedal push to the truck moving. It is such a common issue there are devices that go between the pedal and computer to solve it. It voids the warranty though. I have almost been hit 4 times due the acceleration hesitation.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11523739May 24, 2023
POWER TRAIN
Brand new 2022 ram 3500 dually, 2300 miles 330 into towing trailer 18k trailer transmission blew. Loud clunk will only move in reverse. Left me and family stranded on side of busy freeway. No tow truck could handle truck and trailer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11522996May 20, 2023
POWER TRAIN
K1 snap ring failure in the transmission. Lost gears 1-4. Truck was stuck in the middle of the road unable to move, blocking traffic and causing safety concerns. Vehicle is currently at the dealer awaiting replacement parts. There was no warning. The check engine light and service 4wd light came on as soon as the failure occurred.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11522940May 19, 2023
POWER TRAIN
Transmission failure at 2145miles while driving with check engine light truck inspected by ram dealer service and confirmed that it was the transmission that failed and they had multiple Vehicles with the same issue in the 2022 model
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11522234May 16, 2023
SERVICE BRAKES
The brake and accelerator pedals are not aligned well. It is very easy for your foot to slip between the two when moving from the accelerator to the brake. The offset heights and distance of travel result in your foot slipping in-between them. This prevents the vehicle from stopping and can cause an accident. It seems like the accelerator pedal should be further forward than the brake pedal. I don't have this issue with any other vehicles I have driven. I'm 6' with a size 11 boot. My entire boot slips between these pedals easily.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11522230May 16, 2023
ELECTRICAL SYSTEM
The contact owns a 2022 Ram 3500. The contact stated that after he purchased the vehicle, he was unable to retrieve the vehicle. The contact stated that he was then informed of NHTSA Campaign Number: 23V06000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue and provided a case number. The contact had not experienced a failure. Parts distribution disconnect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11521993May 15, 2023
ELECTRICAL SYSTEM
RAM 13A Recall. Due to the fire risk, I was unable to park my truck at work. I ordered the parts from a RAM Dealer and installed following the instructions in the 13A Recall provided by NHTSA (https://static.nhtsa.gov/odi/rcl/2023/RCRIT-23V060-7126.pdf). I submitted a request for re-imbursement to the manufacturer showing pictures of the part being replaced, and a copy of the parts invoiced. The Manufacter has refused to re-imburse the replacement cost. US Customer Care Thu, May 11, 4:00 PM (4 days ago) to me Dear [XXX], Thank you for allowing Ram Customer Care an opportunity to address your concern. Our primary focus is your satisfaction. Upon thorough review and consideration, we regret to inform you that your request for reimbursement has been denied due to the following reason/s : • Insufficient document/s (no repair order). self installation is not reimbursable as per corporate resources policy guidelines. • The repairs were not completed at a certified RAM dealership As much as quality service is our concern, please be informed that there are certain guidelines and qualifications that we need to meet in order to grant your request. Thank you for your utmost understanding. We look forward to your continued business with us, and we appreciate you reaching out to us today. Sincerely, [XXX] Ram Customer Care ref:_00Dj01qsDF._5003Z1ZGNHy:ref INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11521839May 13, 2023
UNKNOWN OR OTHER, FUEL/PROPULSION SYSTEM, ENGINE
hello, on the truck, a review was opened, they took the truck to the dealership, they didn’t even give us anything in return, since they were in california themselves from new york for another 2 weeks, they waited in line, they said to replace the transmission and something light to do, more than a month has passed, the costs will grow hotel trailer work we don’t know what to do, they don’t pick up the phone by the truck, they take 80 thousand each and the attitude is terrible
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11521805May 13, 2023
UNKNOWN OR OTHER, ELECTRICAL SYSTEM
I have contacted Stellantis several times and was assigned case number 86112892 and was told someone would contact me within 24-48 hours, but no one has contacted me since I called on May 8, 2023. I can't park or drive this vehicle anywhere without causing possible damage to someone's personal property or my own and I only have this vehicle to drive.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11521357May 10, 2023
POWER TRAIN, ELECTRICAL SYSTEM
The contact owns a 2022 Ram 3500. The contact received notifications of NHTSA Campaign Numbers: 23V060000 (Electrical System) and 22V835000 (Power Train) however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11521048May 8, 2023
UNKNOWN OR OTHER
I parked the truck in my driver, turned it off and seen smoke under the hood. Opened the hood and there was a fire next to what I believe is a coil pak. Tried to put it out with a fire extinguisher but it didn't help. It then engulfed into flames, blowing air bags, and busting out windows.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0

← Back to Ram 3500