Nissan Titan Complaints (2017)

187 consumer complaints on file.

#11760557August 29, 2026
POWER TRAIN
The truck suddenly and without warning drops into an un-acceleratable 'limp mode' while traveling at highway speeds in active traffic, presenting an immediate rear-end collision hazard. Nissan acknowledges this is a Turbo Failure and replaced it in 2021 and 2023 and now the turbo, actuator and dpf have all failed in less than 10k miles since the 2023 repair and refuses to cover it under the 10yr/150k mile warranty extension for the turbo.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11759901August 27, 2026
ELECTRICAL SYSTEM, ENGINE, FUEL/PROPULSION SYSTEM
See attached document
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11753451July 29, 2026
FUEL/PROPULSION SYSTEM
My truck currently has approximately 112,000 miles. Recently, it suffered a high-pressure CP4 fuel pump failure that sent metal debris throughout the fuel system. The failure has been diagnosed by both an authorized Nissan dealership and an independent diesel repair facility. Both concluded that the fuel system has been contaminated and requires replacement of the high-pressure pump, injectors, fuel rails, fuel lines, and related components. I was driving down the road in Atlanta traffic and on a 2 lane road when my truck all of a sudden started to lose power and stop in the middle of the road. A car behind me had to slam on brakes to avoid running into the back of my truck. There was no warning lights or anything. I was able to push the truck to a nearby gas station to get it out of traffic.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11748060July 2, 2026
FUEL/PROPULSION SYSTEM
I have owned this vehicle since February 2025 and as of June 2026 the CP4 Fuel pump failed and causes the Cummings engine to shutdown and the vehicle is now immobile. According to recent research and diagnosis, the cost of repair will exceed the value of the vehicle which I am still paying on. It is my understanding that a class action lawsuit for this particular issue is in progress and Nissan is not taking ownership of the faulty part. I now have a vehicle I can’t drive and I own a farm. I used this vehicle for towing and hauling livestock and now this issue is affecting my business. Nissan needs to repair or replace my vehicle given the fact they used substandard parts.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11739896May 25, 2026
ENGINE
Engine is knocking at only 83k miles. No. 7 cylinder issue. Nissan won’t cover repairs even though they’re aware of the design flaw.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11734670April 29, 2026
ENGINE, FUEL/PROPULSION SYSTEM
I am submitting this complaint on behalf of the vehicle owner. On March 31, 2025 (136,962 miles), the vehicle was brought to Fred Anderson Nissan of [XXX] for Voluntary Emission Recall PD128 (NTB24-061), which required a new Particulate Matter Sensor and ECM reprogramming. One day later, the Check Engine Light illuminated. On April 2, 2025 (137,083 miles), the dealer diagnosed code P2002-00 (DPF Efficiency Below Specs). Repair Order #XXX states: "The new sensor that is now monitoring DPF is able to see this and is setting the code as designed." The dealer's own documentation confirms the fault code was triggered by the recall — not a pre-existing failure. The vehicle had no warning lights before the recall was performed. Nissan Consumer Affairs (Case #XXX) declined goodwill assistance citing mileage, without addressing the documented causal link between the recall and the fault code. The owner now faces a DPF replacement costing several thousand dollars as a direct result of complying with a manufacturer recall. Safety concern: A DPF in confirmed fault condition can trigger unexpected limp mode, including at highway speeds. If other PD128 recipients are experiencing the same recall-induced fault and cannot absorb the repair cost, those vehicles may be operating in a compromised condition. We request NHTSA investigate whether Recall PD128 is creating safety and repair liability for consumers who complied in good faith. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11714962February 2, 2026
ELECTRICAL SYSTEM
The contact owned a 2017 Nissan Titan. The contact stated that while driving at 40 MPH, the contact noticed smoke coming from the engine and pulled over to the right side of the road, exited the vehicle with his dog, and five minutes later, he noticed flames coming under the vehicle. No injuries were sustained. The fire department was notified and extinguished the fire. A fire department report was filed. A police report was filed. The vehicle was towed to the local vehicle lot. The vehicle was not diagnosed or repaired. The vehicle was destroyed. The contact was relating the failure to NHTSA Campaign Number: 19V495000 (ELECTRICAL SYSTEM) however the VIN was not included in the recall. The manufacturer was not notified of the failure. The failure mileage was 143,639.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11710541January 12, 2026
FUEL/PROPULSION SYSTEM, POWER TRAIN
At about 120,000 miles, my transmission started searching for gears shattering going in limp mode while in drive and then ultimately dying while on the highway. Also, my leaf springs are completely loose. You can just pull them out when you have the truck up on the lift.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11710061January 10, 2026
ENGINE
Premature turbocharger failure
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11700731November 21, 2025
ENGINE
I live in [XXX] . Went on vacation to visit our son outside of Nashville Tennessee. Vehicle had approximately 80,000 miles at the time. While driving in traffic and sitting still at lights and odor was coming in the cab. When I got home, I called the dealer about Catalytic converter failure possibly they told me that it was not covered that I should take it to a reputable exhaust repair shop. I took it to Callahan’s auto repair in Pontiac Michigan. They put it on the Hoist and came and told me it had a cracked exhaust manifold which the catalytic converter was attached to and that’s where the odor was coming from. When I purchased the vehicle, I have a lifetime drive caring warranty from infinity through the dealership. I called the dealership and talked to Service and they told me to bring it in while waiting for an appointment. I was due for an oil change and canceled it and looked on Google For problems with the 2017 V8 engine and found a nine page technical service report on the failure of that particular line of engine, I was never notified at any time that my engine was subject to failure, and it had been to the dealership within the last 30 days to have a new transmission pan put underneath the vehicle which Nissan paid 60% of on their own and I paid 40. Upon taking it to the dealership and leaving it, I have to pay $181 for them to analyze the problem they have verbally told me on the phone That my truck needs a new engine because there’s a lifetime warranty on the drivetrain. I don’t feel this problem should be covered under that this is a problem Nissan should put a brand new engine in my vehicle. I would like a response to this. My email is [XXX] . My telephone number is [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699717November 16, 2025
ENGINE
My vehicle lost power driving down the road while pulling my horse trailer. The engine began to vibrate and knock then shut down completely. I did not make it off the road entirely so the police had to assist with lights to ensure other motorists would avoid collision with me. The engine will not turn over, it makes a single click and is locked up completely.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11697422November 4, 2025
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM, ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:UREA INJECTION SYSTEM (DEF)
The contact owns a 2017 Nissan Titan. The contact stated that while driving at various speeds, there was an exhaust odor entering the cabin of the vehicle. The contact was forced to lower the windows to escape the foul odor. The contact stated that the failure occurred while the vehicle was performing the DEF (Diesel Exhaust Fluid) system operation. The vehicle was taken to a dealer, where the failure was related to the windshield cowl system not properly filtering the air. The contact was provided an estimate for the repair, and declined. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 30,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11689330September 24, 2025
AIR BAGS
The contact owns a 2017 Nissan Titan. The contact stated that while operating the vehicle, the air bag warning light continued to blink off and on. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The failure mileage was 223,215.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11688174September 18, 2025
ENGINE, TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
The contact owns a 2017 Nissan Titan. The contact stated that while driving at 65 MPH, the vehicle lost motive power. There was an abnormally loud sound coming from the engine. Additionally, the TPMS warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed with engine failure. The vehicle was not repaired. The manufacturer was contacted, and a case was opened. The failure mileage was approximately 80,100.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11681143August 17, 2025
ENGINE
V8 endurance engine has a known defect with scaring of cylinder 7 causing knocking in the engines and engines replacements. I purchased this Titan brand new in 2017. It required a brand new engine at 18,000 miles that was covered by the warranty. That engine developed another knock that required another engine replacement at 89,000 miles. Initially Nissan refused to cover as the truck was more than 5 years old even though the miles were well below 100,000 manufacturer warranty. I have found that these are bad engines that dealership is continue to install in these trucks even knowing that it could develop another knock. Other engine manufacturers refused to work on these engines due to this known defect. Nissan has thus far refused to recall this engine. The replacement cost is $18,000 without warranty.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11676712July 28, 2025
ENGINE
I was droving down the road with the cruise control set at 70MPH, when all of the sudden the engine lost power and stopped. It did not have a check engine light or anything on the dash to indicate that there was a problem. I coasted to the edge of the road where i attempted to restart the vehicle, but it would not even turn over. I had the vehicle towed to a repair shop where I was informed that they engine was locked solid. The mechanic suspects that they crankshaft is broken, but the entire engine will need to be replaced.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11670644July 1, 2025
ENGINE
Broken crankshaft
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11670062June 29, 2025
ENGINE
Spun rod bearing/broken crank shaft - major vibration, loss off power, dangerous
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11665318June 6, 2025
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM, POWER TRAIN
Purchased a used 2017 Nissan Titan XD Pro-4X 5.0L diesel on 3/8/25. Left the dealership and only made it ~10 miles down the road before the check engine light came on and there was a loud knocking noise. Immediately turned around and went back to the dealership. After diagnosing it I was told it was a fuel injector and that they were replacing it. Received the truck back ~3/20/25. This truck is not my daily driver but the few times I have attempted to drive it the check engine light keeps coming on and I'm getting a message about the REGEN. On 5/28/25 I had the truck towed to my local Nissan dealership. They diagnosed it and although there is still a code for the same injector coming up they said the issue is the wiring harness and quoted me $7000 to repair and it's not covered under my powertrain warranty. After research it seems like this is a common issue in 2017-2019 Nissan Titan 5.0L diesel trucks which will cause the crankshaft to break if not fixed. I am super frustrated that after less than 3 months of ownership I have an undrivable truck requiring thousands of dollars in repairs.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11663299May 27, 2025
UNKNOWN OR OTHER
Took my nissan titan xd into the tim dahle nissan to get my recall done and also my ac fixed since it was broken, let them know that i had a light turn on and then turn back off, they said that they would look at it. when messaging with the service advisor he had told me that the part that was issued for the recall could not be done because there was something already wrong with my truck. i had not had any problems previously when i took it in just weeks prior and it was never brought up when they looked at it before. they then told me i shouldn’t drive it very far because it is not safe, i just wanted to take it in for the recall part but they refused to do it for me even though it would help. i was very unhappy with how i was treated and how they denied me a part that should be put in regardless. but they had just told me it would be pointless to put it in.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Nissan Titan